IllustrationI HAVE HAD THE LOWER STEERING ARM REPLACED THREE TIMES DUE TO A BAD BUSHING. ONCE UNDER WARRANTY & TWICE I HAD TO PAY FOR IT WHICH IS OVER $300.00 EACH TIME. THIS IS NOT AN UNCOMMON PROBLEM WITH THE CHEVROLET & GMC TRUCKS. THIS IS ONLY NOTICEABLE WHILE IN MOTION.
2005 GMC Sierra 3500
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sierra 3500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
50–25K
625–50K
550–75K
675–100K
0100–150K
0150K+
22 reports with mileage · 2 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports0 injury reports
Steering complaints
5 reportsTL* THE CONTACT OWNS A 2005 GMC SIERRA 3500. WHILE DRIVING AT AN UNKNOWN SPEED, THE SPEEDOMETER BECAME INOPERABLE AND AN ABNORMAL NOISE EMITTED FROM THE STEERING WHEEL. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 62,250.
STEERING HYDRULIC ASSIST CONNECTIONS AT BOOSTER CONSTANTLY LEAK FROM DAY ONE. THEY HAVE BEEN REPLACED AND STILL LEAK. WHICH IN TURN CAUSE A DECREASE IN BRAKE PRESSURE. *TR
TL* THE CONTACT OWNED A 2005 GMC 3500 TRUCK. THE CONTACT STATED THAT THE VEHICLE WAS PARKED OUTSIDE HIS HOME WITH THE ENGINE SHUT OFF. WHILE INSIDE THE HOME, HE HEARD AN UNUSUALLY LOUD EXPLOSION. UPON FURTHER INSPECTION, THE VEHICLE WAS COMPLETELY ENGULFED IN FLAMES. THE FIRE WAS EXTINGUISHED AND THE DEALER WAS CONTACTED ACCORDI…
Read full complaint
TL* THE CONTACT OWNED A 2005 GMC 3500 TRUCK. THE CONTACT STATED THAT THE VEHICLE WAS PARKED OUTSIDE HIS HOME WITH THE ENGINE SHUT OFF. WHILE INSIDE THE HOME, HE HEARD AN UNUSUALLY LOUD EXPLOSION. UPON FURTHER INSPECTION, THE VEHICLE WAS COMPLETELY ENGULFED IN FLAMES. THE FIRE WAS EXTINGUISHED AND THE DEALER WAS CONTACTED ACCORDINGLY. THE DEALER STATED THAT THEY WOULD FURTHER INVESTIGATE FAILURE AND HAVE FAILED TO DO SO. THE CONTACT WAS ABLE TO LOCATE A RECALL FOR HER YEAR, MAKE AND MODEL DESCRIBING THE POTENTIAL FOR A VEHICLE FIRE BUT WAS UNAWARE IF HER VEHICLE WAS INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 30,000. ACCORDING TO THE FIRE REPORT, THE FIRE WAS MOST LIKELY CAUSED BY A POWER STEERING FLUID LEAK IN THE LEFT FRONT ENGINE COMPARTMENT AT THE POWER STEERING FLUID LINES OR LINE CONNECTION. UPDATED 05/17/10. *JB
EXITED THE INTERSTATE AND WHILE ROUNDING A CORNER WHEN I STARTED BRAKING AT LOW RPM THE STEERING LOCKED UP AND THE BRAKE PEDAL WAS JUMPING UNDER MY FOOT. FINALLY GOT VEHICLE STOPPED BUT THE PROBLEM CONTINUED AS I MADE MY WAY HOME. *TR
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.