2005 GMC Sierra 2500

AFTER PUTTING THE VEHICLE IN PARK AND PROCEEDING DOWN MY DRIVEWAY, THE ABS LIGHTS BEGAN FLASHING AND CHIMING ON THE DASH. I PUSHED THE BRAKE PEDAL AND IT WENT TO THE FLOOR. I STOPPED THE VEHICLE WITH THE EMERGENCY BRAKE. I GOT OUT OF THE VEHICLE AND NOTICED BRAKE FLUID DRIPPING UNDERNEATH THE TRUCK. I CRAWLED UNDER THE TRUCK AND FOUND THE LEFT REAR BRAKE LINE HAD CORRODED THROUGH JUST ABOVE THE FUEL TANK. I CALLED THE DEALER AND HE STATED THIS IS A KNOWN DEFECT FROM GM. HE SAID I NEEDED ALL BRAKE LINES REPLACED AND GM'S NEW PARTS HAD AN EXTRA COATING TO PREVENT CORROSION. IT COST ME $1100. THIS TYPE OF FAILURE SEEMS WAY TOO SOON FOR A TRUCK WITH 38,000 MILES. *TR

STARTED THE TRUCK AND APPLIED THE BRAKES TO SHIFT INTO GEAR AND THE BRAKE PEDAL WENT TO THE FLOOR. AFTER SEVERAL TIMES PRESSING THE PEDAL THERE WAS NO BRAKES AT ALL. THE TRUCK WAS TOWED TO THE DEALER WHERE I WAS INFORMED ALL THE BRAKE LINE WERE RUSTED AND NEEDED TO BE REPLACED AT A COST OF $1,300.00. THE TRUCK ONLY HAD 35,000 MILES ON IT. IF I HAD BEEN DRIVING, I AM SURE THIS WOULD HAVE LIKELY CAUSED A SERIOUS ACCIDENT. *TR

DRIVING THROUGH AN INTERSECTION AT 40 WHEN A ANOTHER VEHICLE MADE A LEFT TURN IN FRONT OF ME . I APPLIED MY BRAKES AND PEDAL WENT TO THE FLOOR . I SWERVED AND AVOIDED THE ON COMING VEHICLE . THE REAR HARD STEEL BRAKE LINE ABOVE THE FUEL TANK BURST DUE TO CORROSION . NO WARNING NO FLUID OR BRAKE LIGHT JUST A CATASTROPHE FAILURE OF LINE. UPON INSPECTION LINE IS NOT CORRODED ON THE FRAME RAIL BEFORE THE FUEL TANK JUST BEHIND THE TANK. *TR

THE 2005 GMC 2500HD FWD (WELL MAINTAINED AND OILED TO PREVENT CORROSION) EXPERIENCED A FAILURE WHILE TOWING MY 24' PURSUIT FISHING BOAT (7200 LBS.) HOME FROM STURGEON POINT MARINA TO HAMBURG, NY 14075 (APPROXIMATELY 10 MILES) WITH "MINIMAL" STOPPING CAPABILITY AS THE DOT 3 BRAKE FLUID WAS BEING EXPELLED. I HAD TO FEATURE THE THROTTLE TO NEGOTIATE STOPPING SENARIOS WITHOUT ISSUE. AS OF 8/20/12, THIS VEHICLE IS WITH FUCCILLO CHEVROLET, INC. (GRAND ISLAND, NY) FOR OVERHAUL OF ENTIRE BRAKING SYSTEM; INCLUDING FUEL LINES. THE CERTIFIED TECHNICIAN SUGGESTED THE ENTIRE BRAKE LINES SYSTEM BE REPLACED ALONG WITH THE FUEL LINES DUE TO EXTREME CORROSION. ALL THIS WORK IS BEING PERFORMED SINCE THE EXCELLENT CONDITION OF THE VEHICLE.THE ESTIMATE FOR THIS WORK IS APPROXIMATELY $2250 TO REPLACE ALL LINES (BRAKE / GAS) AFFECTED BY SEVERE CORROSION. THIS CONDITION IS A RESULT OF POOR MATERIAL SELECTION NOT CAPABLE OF WITHSTANDING NORMAL WINTER CONDITIONS FOUND IN THE NORTHEAST. THE SAME STANDARDS SHOULD BE USED AS SELECTING EXHAUST SYSTEM MATERIAL. BRAKES CAN KILL YOU....EXHAUST SYSTEMS CAN NOT! FINAL NOTE: TRUCK DRIVEN 50 MILES PER WEEK TO WORK (10 MILES EACH DAY). DURING WINTER MONTHS, THE RESIDUAL SALT IS RINSED AS REQUIRED ON A WEEKLY BASIS (OR SOONER) TO PREVENT CORROSION. THIS TRUCK PRIOR TO WINTER DRIVING HAS HAD OIL APPLIED TO THE UNDERFRAME, APPARENTLY, THE BRAKE / FUEL LINE WHERE NOT ADEQUATELY TREATED. *TR