NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
19 reportsClear category filterMileage unknown · Sep 9, 2026
EngineFuel/propulsion SystemPower Train
Lifters and camshaft failure, loud clanking, & sudden power loss on the 6.2 motor are the first noticeable signs. Instantly when everything happened check engine light, cruise control, & stabilizer lights flashed. The sudden loss of power forced the vehicle to suddenly slow down forcing my camper into the truck. I was hauling a…
Read full complaint
Lifters and camshaft failure, loud clanking, & sudden power loss on the 6.2 motor are the first noticeable signs. Instantly when everything happened check engine light, cruise control, & stabilizer lights flashed. The sudden loss of power forced the vehicle to suddenly slow down forcing my camper into the truck. I was hauling a within weight standerd camper but had difficulty bringing both the truck with the camper to a safe stop. There were no early signs or signal prior to sudden cautostrophic engine failure & all service records have been completed by a GM certified service dealer.
NHTSA ODI #11763115
Mileage unknown · Aug 10, 2026
EngineFuel/propulsion SystemPower Train
Was traveling home and started losing power going up a hill on XXX. The truck was surging, the check engine light came on and an audible warning of no (low?) oil pressure. The truck shut off on a busy interstate highway and barely got onto the shoulder. The tow truck driver had to lay on the ground with part of his body in the l…
Read full complaint
Was traveling home and started losing power going up a hill on XXX. The truck was surging, the check engine light came on and an audible warning of no (low?) oil pressure. The truck shut off on a busy interstate highway and barely got onto the shoulder. The tow truck driver had to lay on the ground with part of his body in the lane of travel to place "skids" under the rear tires because there is no way to place this vehicle in neutral for a tow without a special GM tool. When I contacted Harry Robinson GMC service center in [XXX], they told me that it was no longer a safety recall because the truck had passed diagnostics and new, high viscosity oil was put in the truck XXX. The GMC app says code P0016 which is the dreaded 6.2L camshaft to crankshaft alignment that accompanies engine component failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11755885
Mileage unknown · Jul 22, 2026
EngineFuel/propulsion SystemPower Train
I was driving on the highway when the vehicle started to make clinking noises. The vehicle started to lose power as I accelerated it would feel like something was pulling me in the opposite direction and the knocking noise would get louder. Ultimately, I had the vehicle towed to a dealership. This vehicle passed the L87 recall n…
Read full complaint
I was driving on the highway when the vehicle started to make clinking noises. The vehicle started to lose power as I accelerated it would feel like something was pulling me in the opposite direction and the knocking noise would get louder. Ultimately, I had the vehicle towed to a dealership. This vehicle passed the L87 recall not too long ago, and the vehicle is barely used.
NHTSA ODI #11752276
Mileage unknown · Jun 14, 2026
EngineFuel/propulsion SystemPower Train
My truck engine has failed due to metal shavings in the oil related to the L87 engine recall, and the failure occurred after GM had replaced the truck’s oil as part of the recall remedy. The recall remedy did not prevent the failure of the engine.
NHTSA ODI #11743967
Mileage unknown · Jun 14, 2026
EngineFuel/propulsion SystemPower Train
My truck engine has failed due to metal shavings in the oil related to the L87 engine recall, and the failure occurred after GM had replaced the truck’s oil as part of the recall remedy. The recall remedy did not prevent the failure of the engine.
NHTSA ODI #11743965
Mileage unknown · Jun 1, 2026
EngineFuel/propulsion SystemPower Train
The vehicle received the official N252494001 recall oil remedy on 06/27/2025 at 15,438 miles (but suffered catastrophic engine failure and loss of propulsion at 33,661 miles on 05/30/2026).
NHTSA ODI #11741282
Mileage unknown · May 8, 2026
EngineFuel/propulsion SystemVehicle Speed Control
I passed the recall inspection on 12/17/2025 and the higher viscosity oil was put into my vehicle. On 12/25/2025 my vehicle's engine shut off while I was traveling on the highway (I-25). The vehicle went into to neutral and I had to pull over to the side of the highway without power. The vehicle started again and as I was mergin…
Read full complaint
I passed the recall inspection on 12/17/2025 and the higher viscosity oil was put into my vehicle. On 12/25/2025 my vehicle's engine shut off while I was traveling on the highway (I-25). The vehicle went into to neutral and I had to pull over to the side of the highway without power. The vehicle started again and as I was merging onto the highway it shut down again. The truck started again and I was able to drive it home. There were no codes found when I took it in for service on 12/26/2025. On 01/24/2026 I was driving on the highway (US-40) and I had complete engine failure. I had to get my vehicle towed to the service center and a new motor was installed. On March 27th the vehicle's engine shut off again while driving on the highway (US-191). There were no codes or check engine lights on this time either. The service records state that the starter mount stud was loose.
NHTSA ODI #11736670
Mileage unknown · Dec 15, 2025
EngineFuel/propulsion System
My truck completely stalled and had to be restarted. I took it to the dealership to have it resolved. They wouldn’t look at the truck without a recall notice. Now there is a recall notice for my exact issue. I took it to be repaired by them but now they are saying that there is nothing wrong with the vehicle and are refusing to …
Read full complaint
My truck completely stalled and had to be restarted. I took it to the dealership to have it resolved. They wouldn’t look at the truck without a recall notice. Now there is a recall notice for my exact issue. I took it to be repaired by them but now they are saying that there is nothing wrong with the vehicle and are refusing to do anything about it stalling. They specifically said that I will have to stall and potentially get in a car wreck before they will repair the damaged engine. I have been very disappointed in this entire situation and would like to avoid driving a car that may end up crashing due to a preventable problem.
NHTSA ODI #11705177
Mileage unknown · Dec 15, 2025
EngineFuel/propulsion System
12/7/2025 8:48 AM Engine lost propulsion while driving 35mph enroute to residence. The engine cut off and at the same time we saw a cloud of blue smoke trailing the vehicle. The engine refired and propulsion resumed. I immediately looked at the dash display for an indicator light resulting from the lack of propulsion. There were…
Read full complaint
12/7/2025 8:48 AM Engine lost propulsion while driving 35mph enroute to residence. The engine cut off and at the same time we saw a cloud of blue smoke trailing the vehicle. The engine refired and propulsion resumed. I immediately looked at the dash display for an indicator light resulting from the lack of propulsion. There were no unusual indicator lights or messages but the tachometer needle dropped about an inch and went back up again rapidly. The engine had resumed running. This loss of propulsion and resumption occurred two more times while my foot was off the accelerator. After the third incident the vehicle seemed to be running normally. I stated we had only about two miles to get home and I hope we make it. The next day I called DeLuz service department to notify them of the incident. I left a message but my call was not returned. I updated service staff of the new incident when I dropped the vehicle off for a previously scheduled appointment on 12/11/25.
NHTSA ODI #11705173
Mileage unknown · Dec 11, 2025
EngineFuel/propulsion System
While driving my 2024 GMC Sierra Denali Ultimate on the highway, the engine suddenly failed without warning. The truck shut off completely while I was traveling at highway speed. I was fortunate to be able to safely maneuver to the shoulder, but the sudden loss of power created a serious risk of a collision with surrounding traf…
Read full complaint
While driving my 2024 GMC Sierra Denali Ultimate on the highway, the engine suddenly failed without warning. The truck shut off completely while I was traveling at highway speed. I was fortunate to be able to safely maneuver to the shoulder, but the sudden loss of power created a serious risk of a collision with surrounding traffic. The failure appears to involve the engine or engine control system. The vehicle engine is currently available for inspection upon request. Prior to the incident, there were no warning lights, messages, or unusual symptoms. The shutdown occurred abruptly with no prior indication of a problem. This vehicle previously received the NS25249400 safety recall repair on August 12, 2025, and it reportedly passed all required checks at that time.
NHTSA ODI #11704431
NHTSA investigations
4EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration