Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 43 of 468 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 204 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 91 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports2 fire reports1 injury reports
What owners actually said
468 reports
103,000 miles · Jun 8, 2026
Engine
The contact owns a 2023 GMC Sierra 1500. The contact stated that while driving at 15 MPH, the vehicle stalled. There was no warning light illuminated. The vehicle was towed to the dealer, where it was serviced, but the failure persisted. The vehicle was taken to another dealer, where it was diagnosed with engine failure. No …
Read full complaint
The contact owns a 2023 GMC Sierra 1500. The contact stated that while driving at 15 MPH, the vehicle stalled. There was no warning light illuminated. The vehicle was towed to the dealer, where it was serviced, but the failure persisted. The vehicle was taken to another dealer, where it was diagnosed with engine failure. No further information was available. The manufacturer was not made aware of the failure. The failure mileage was approximately 103,000.
NHTSA ODI #11742795
Mileage unknown · Jun 7, 2026
Power Train
The transmission control module failed. The dealer said a I a high voltage alarm signal code. This was the diagnostic inform received from the dealership service department. Primary]: MDIAG : MISC. VEHICLE DIAGNOSIS. CHECK ENGINE LIGHT ILLUMINATED AND GETTING MESSAGE FOR SERVICE TRANSMISSION, UNABLE TO SHIFT. PLEASE CHECK AND A…
Read full complaint
The transmission control module failed. The dealer said a I a high voltage alarm signal code. This was the diagnostic inform received from the dealership service department. Primary]: MDIAG : MISC. VEHICLE DIAGNOSIS. CHECK ENGINE LIGHT ILLUMINATED AND GETTING MESSAGE FOR SERVICE TRANSMISSION, UNABLE TO SHIFT. PLEASE CHECK AND ADVISE * Repair items per diagnosis: FOUND P07B4 STORED IN SYSTEM. VERIFIED WIRING OK TO GEAR SHIFT CONTROL MODULE. SI STATES IF WIRING GOOD TO REPLACE GEAR SHIFT CONTROL MODULE AND IF CODE RESETS TO REPLACE ECM. RECOMMEND STARTING BY REPLACING GEAR SHIFT CONTROL MODULE The truck would not shift or go into gear at all. This was concerning because the transmission could have stopped shifting while I was driving myself and my children around. This warning light came on while I was driving on the highway. My vehicle has about 58,000 miles on it and is still under powertrain warranty. But the dealership is saying this repair isn’t included.
NHTSA ODI #11742551
Mileage unknown · Jun 3, 2026
Power TrainVehicle Speed Control
The truck side toy down shift and the accelerator was very high…. When I was going to park the reverse was not shifting…
NHTSA ODI #11741918
Mileage unknown · Jun 1, 2026
Power Train
Upon accelerating on the freeway, rear wheels locked up completely almost causing me to hit multiple vehicles. Was repeatable and was able to record the event. Manufacturer claims unable to reproduce and bring back if it happens again. No lights were set.
NHTSA ODI #11741318
Mileage unknown · May 30, 2026
Electrical SystemEnginePower Train
Model: Sierra Denali Ultimate Engine: 6.2L V8 VIN: [XXX] Mileage at Most Recent Incident: Approximately 52,000 miles Safety Complaint Summary I am submitting this complaint to report a recurring loss-of-propulsion and engine power event involving my 2023 GMC Sierra Denali Ultimate equipped with the 6.2L V8 engine. This vehicle …
Read full complaint
Model: Sierra Denali Ultimate Engine: 6.2L V8 VIN: [XXX] Mileage at Most Recent Incident: Approximately 52,000 miles Safety Complaint Summary I am submitting this complaint to report a recurring loss-of-propulsion and engine power event involving my 2023 GMC Sierra Denali Ultimate equipped with the 6.2L V8 engine. This vehicle has experienced two separate incidents in which it suddenly lost power while being operated at highway speeds. During both events, the vehicle unexpectedly lost propulsion without warning and without any apparent driver input or mechanical indication beforehand. No warning lights, check-engine lights, reduced-engine-power messages, service transmission messages, or other warning indicators were displayed prior to the failure. The vehicle simply lost power while traveling in traffic. During both occurrences, I was forced to safely maneuver the vehicle to the shoulder of the roadway while rapidly losing speed among surrounding traffic. Once stopped, the vehicle would not resume normal operation until it was restarted. After restarting, the vehicle appeared to operate normally; however, the fact that this condition has now occurred twice raises significant concerns regarding the reliability and safety of the vehicle. Safety Risk This condition presents a significant and immediate safety risk because sudden loss of propulsion during highway operation can leave the driver unable to maintain speed, safely merge, maneuver, or avoid surrounding traffic. The unexpected reduction in speed creates the potential for rear-end collisions, loss of vehicle control, or other traffic accidents, particularly when operating on high-speed roadways. Because the vehicle provided no warning before losing power, there is little opportunity for a driver to take preventive action. Additional Information • Vehicle: 2023 GMC Sierra Denali Ultimate • Engine: 6.2L V8 • VIN: [XXX] • Approximate Mileage: 52,000 miles • Number of Incident INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 55
NHTSA ODI #11741004
Mileage unknown · May 29, 2026
Engine
The lifters on my 2023 GMC Sierra failed and damaged my engine. The truck has approx 78,000 miles. I do have an extended warranty to 100,000 miles. I got the truck to my GMC Dealer who confirmed the problem was lifter failure. There might be camshaft damage but will have to tear the engine down. It seems like GMC is dragging …
Read full complaint
The lifters on my 2023 GMC Sierra failed and damaged my engine. The truck has approx 78,000 miles. I do have an extended warranty to 100,000 miles. I got the truck to my GMC Dealer who confirmed the problem was lifter failure. There might be camshaft damage but will have to tear the engine down. It seems like GMC is dragging there feet. It is known the lifters are a problem on this engine but GMC continues to sell them. There was no warning that the lifters would fail. The lifters could have failed while driving at high speeds and the driver could loss control.
NHTSA ODI #11740911
Mileage unknown · May 28, 2026
EngineFuel/propulsion SystemVehicle Speed Control
After driving my vehicle for a short period of time I stopped to go shopping. When I returned to my vehicle I started it as usual and the check engine light illuminated. I began driving and within 0.25 miles I received an info enter message that stated my vehicle would have reduced acceleration and to please drive safely. My en…
Read full complaint
After driving my vehicle for a short period of time I stopped to go shopping. When I returned to my vehicle I started it as usual and the check engine light illuminated. I began driving and within 0.25 miles I received an info enter message that stated my vehicle would have reduced acceleration and to please drive safely. My engine fans became noticeably louder and ran the entire trip home (about 15 minutes). After pulling into my driveway I sat in the vehicle and listen to the fans continue to operate. Additionally, my OnStar system, WiFi, and navigation systems quit working. A P1098 Code was returned when using a diagnostic code device. Disconnecting the battery would cause the check engine light to extinguish and for the truck to operate without reduced acceleration; however, OnStar, navigation and WiFi would not work. After shutting off the engine and then restarting the check engine light would once again illuminate and the reduced acceleration message reappeared.
NHTSA ODI #11740519
Mileage unknown · May 22, 2026
Structure
Driving down the interstate and the front trim bezel on the hood flew off. The plastic clips broke from underneath. GM had a recall on this same issue in 2022 but not 2023 yet. Could of had an accident with the piece flying off at interstate speeds.
NHTSA ODI #11739478
Mileage unknown · May 21, 2026
Engine
On May 13. 2026 traveling southbound on I15 Utah at 75 MPH the engine Stop and put the tranmisson in N and I move the truck to a stop. then the Truck shut Down. I had the Truck tow to the nearest GMC and was informed that the Engine had sezed. I had recalled done to pervent engine failure.
NHTSA ODI #11739416
Mileage unknown · May 21, 2026
Engine
This vehicle has experienced repeated catastrophic engine and drivability failures since purchase and has now undergone four engine replacements under warranty. Despite these major repairs, the vehicle continues to experience dangerous shutdown/stalling conditions. The primary safety issue occurs while braking or coming to a st…
Read full complaint
This vehicle has experienced repeated catastrophic engine and drivability failures since purchase and has now undergone four engine replacements under warranty. Despite these major repairs, the vehicle continues to experience dangerous shutdown/stalling conditions. The primary safety issue occurs while braking or coming to a stop. The engine will suddenly shut off unexpectedly, creating a serious traffic hazard and leaving the vehicle unable or difficult to restart. This has occurred multiple times and creates a dangerous situation in traffic and at intersections. The vehicle remains under manufacturer warranty, however the defect has not been successfully repaired despite extensive service attempts and multiple complete engine replacements. The condition substantially impairs the safety, reliability, and use of the vehicle. This vehicle was acquired through a fleet/lease arrangement for company use and was not purchased for resale. It is a light-duty 1500-series pickup with approximately 7,100–7,200 GVWR used as a company vehicle. Complete repair history, diagnostic records, warranty repairs, and engine replacement documentation can be obtained from: Stevens GMC Bristol, Connecticut The vehicle has been repeatedly presented for repair and the defect remains unresolved. This appears to be a serious ongoing safety-related defect involving engine shutdown/stalling while braking or stopping.
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: Engine failure increases the risk of a crash.
Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist:electric:control Module:software
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Aug 20, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy
Opened Jan 16, 2026 · Closed Aug 20, 2026
Status: closed (inferred from source dates) · Engine
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
EA25007 · Loss Of Motive Power Due To Engine Failure
Opened Oct 23, 2025 · No close date supplied
Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25001 · Loss Of Motive Power Due To Engine Failure
Opened Jan 16, 2025 · Closed Oct 23, 2025
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:hard Parts Internal/mechanical
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2023 GMC Sierra 1500 Problems, Complaints & Recalls | Skip That Year
Illustration