Engine. Review the 204 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 91 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 78 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

5 crash reports2 fire reports1 injury reports

What owners actually said

468 reports

Mileage unknown · Apr 15, 2025

EngineCrash

Read full complaint

While towing my boat to the Florida Keys, I encountered a series of mechanical issues on Interstate 75. The engine’s exhaust became excessively loud, causing the engine to abruptly shut off. Despite successfully maneuvering into the safety lane, I was unable to restart the engine. I promptly contacted the dealership, which dispatched a tow truck to my location. However, the tow truck driver was unable to put the vehicle in neutral gear. Subsequently, I reached out to GMC, which informed me that the tow truck required a flatbed for transportation. I waited another two hours for a flatbed truck to tow the vehicle to the dealership. A few days later, I received notification that my engine had seized, necessitating an engine replacement. The dealership informed me that the 6.2-liter engine was experiencing a national backorder. I had purchased this used vehicle less than a month prior and had not yet made my initial payment. Consequently, I find myself without a vehicle. The dealership has been unable to provide an accurate timeline for the repair to be completed.

NHTSA ODI #11654653

Mileage unknown · Apr 13, 2025

Engine

Complete engine failure while driving at highway speeds which put me and my family in dangerous risk of injury or death. The dealer confirmed the engine failure and needs engine replacement. The engine failed with no warning which only had 8700 miles.

NHTSA ODI #11654332

Mileage unknown · Apr 12, 2025

Power Train

Read full complaint

Transmission locking up Was never notified about recall and my truck was never put on recall list they have gas lighted me and others with 23 models having same known issues Yes it is stuck at the dealer waiting on back ordered part but they arent aloud to inspect the gears in the transmission due to only replacing the control module Prior to this i had other failures between fuel control module to def fluid tank to shortened wire harness all of this issues make the vehicle go crazy between acceleration/ hard and no shifting which is a danger to drive and then there will be more wear and tear on other components that arent being addressed

NHTSA ODI #11654259

31,230 miles · Apr 10, 2025

Power Train

Read full complaint

The contact owns a 2023 GMC Sierra 1500. The contact stated while driving at an undisclosed speed, the “Service Transmission Now” warning light illuminated. Additionally, the contact stated that the warning light and a message indicated that the transmission would stop shifting soon. The vehicle was taken to the dealer; however, the vehicle was not inspected. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 31,230.

NHTSA ODI #11653960

Mileage unknown · Apr 10, 2025

Engine

Read full complaint

4-5-25 Going 65 mph truck shut off for no reason. Dash message stated “press button to restart” I managed to pull over on side of road and place in park and restarted. Drove home and Chevy dealer service was closed. 4-7-25 Called in morning to get truck into service. 4-8-25 Service advisor called and stated No dash lights no codes . I explained that it was scary to have truck shutoff with no reason.i also stated that truck lurches and auto stop sounds wierd. Dealership Said tech was going to investigate further. I got a call next day 4-9-25 Service advisor said the main bearings bad and tech recreated problem and that motor was blown and need to order new from Michigan . Service advisor said he ordered engine and that it was known issue and covered under warranty. I asked how long he would have truck and he stated NO ETA. Truck engine seized during tech driving to reproduce my issue.

NHTSA ODI #11653806

Mileage unknown · Apr 8, 2025

Engine

Turned onto highway. Got up to about 60 miles per hour. After a couple minutes the truck lost all power. Was pressing gas and noticed speed declining. Looked at dash and noticed rpm decreasing. All lights were off in the dash. I let the truck coast to the edge of the highway. Attempted to jump start and replace battery and nothi…

Read full complaint

NHTSA ODI #11653561

Mileage unknown · Apr 7, 2025

EnginePower Train

Read full complaint

My wife and I were traveling westbound on [XXX] just outside of Durkee Oregon, when while going up a hill with Cruse set to 72, the truck began to slow down drastically. When I looked down I was then going 60 and showing down fast. I was able to get to the side of the road and then the truck stopped, it shut off. At that point the truck has not be back on. It would not turn on and Onstar reported that there is an issue with the Engine and transmission. No warning lights came on until we stopped. Then the Engine light was on and the truck said that it was overheating but the oil temps were normal. I feel lucky that there was not much traffic. My wife and I were on the side of the road for 2 hours at dusk and in the dark with 65+ MPH traffic zooming by. Also had a impossible time tracking down a rental call just to continue to my wife's grandmother's funeral service. I just talked with the dealer and they will not have a diagnoses for me until late tomorrow. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI #11653215

Mileage unknown · Apr 7, 2025

StructureUnknown Or Other

The electronic tailgate randomly opens on it's own/fails and opens when it has not been pushed to open. The vehicle is available for inspection. The tailgate opens randomly and can be unknown that it is open. No warning of it at all. It has happened multiple times, the most recent being today 4/7/2025. I know that a recall has…

Read full complaint

NHTSA ODI #11653214

Mileage unknown · Apr 4, 2025

Power Train

Read full complaint

The system that is not working properly is the transmission. It is available for inspection upon request. The safety of the vehicle, and myself, was put at risk because the transmission (once warmed up / at least 30-60 minutes of driving takes place) downshifts hard, making a clunking noise, and has at worst given the vehicle a rough nudge/jolt forward upon downshifting particularly from 2nd to 1st gear (it is a 10 speed transmission). This issue, when it occurs, will require me (the driver) to apply extra force to the brake pedal due to the rough downshift / jolt upon shift. The issue is exacerbated when quickly stopping the vehicle causing the transmission to downshift more rapidly. The vehicle's transmission flaws, of which this happens to be one of them, were being looked into at a certified repair facility (dealership). After the vehicle was in their possession 3 days, they informed me that they could not replicated or reproduce the issue. I informed and reminded the following: (1) the vehicle has to be warm and operated for I would state at least 30-60 minutes of driving before the issue arises (2) I have recorded videos of the problematic sounds of the transmission. (3) I am willing to go for a test drive to try to replicate the issue with dealership staff, but the issue is infrequent and the vehicle must be warmed-up and/or driven more than the typical "test drive" for the issue to be observed. The vehicle component has been inspected by a certified repair facility (dealership), but not directly by a manufacturer's direct representative, police, insurance representatives, or others. The transmission is also problematic in another way (rattling at low rpm's during upshift), but pertaining to safety the downshift is most concerning as described above. There were/are no warning lamps or messages. The symptoms of the problem pertaining to the transmission began occurring around 11,800-12,000 miles in my estimation.

NHTSA ODI #11652846

33,000 miles · Apr 4, 2025

Engine And Engine Cooling

Read full complaint

The contact owns a 2023 GMC Sierra 1500. The contact stated while driving at various speeds, the vehicle experienced a loss of motive power. The contact shifted to neutral(N) and was able to restart the vehicle. Additionally, the contact stated that while driving 55 MPH and pulling an unloaded trailer, the vehicle suddenly stalled. A message advising the contact to shift to neutral(N) and to attempt to start the vehicle was displayed; however, the vehicle failed to restart as intended. The contact was still able to use the power brakes and the power steering, which allowed the contact to pull over in a safe area. The vehicle was towed to the dealer, where it was diagnosed that the presence of copper filings in the oil had caused the engine to run roughly. The dealer determined that the engine needed to be replaced; however, the part was not available. Additionally, the average waiting period for an engine was approximately 6 months. The vehicle was not repaired. The manufacturer was informed of the failure and a case was filed. The failure mileage was 33,000.

NHTSA ODI #11652788

Official recalls

25V274000 · Engine And Engine Cooling:engine:hard Parts Internal/mechanical

Apr 24, 2025

General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.

Consequence & remedy

Consequence: Engine failure increases the risk of a crash.

Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.

24V674000 · Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp; Service Brakes, Hydraulic:power Assist:electric:control Module:software

Sep 12, 2024

General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."

Consequence & remedy

Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.

Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.

Additional source detail variants (2)

Service Brakes, Hydraulic:power Assist:electric:control Module:software

Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.

Remedy: The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.

Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp

Consequence: Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.

22V903000 · Exterior Lighting:lighting Control Module:software

Dec 8, 2022

General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.

Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy

Opened Aug 20, 2026 · No close date supplied

Status: open (inferred from source dates) · Engine

On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy

Opened Jan 16, 2026 · Closed Aug 20, 2026

Status: closed (inferred from source dates) · Engine

On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

EA25007 · Loss Of Motive Power Due To Engine Failure

Opened Oct 23, 2025 · No close date supplied

Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical

The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Engine And Engine Cooling:engine:hard Parts Internal/mechanical

Engine

PE25001 · Loss Of Motive Power Due To Engine Failure

Opened Jan 16, 2025 · Closed Oct 23, 2025

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical

On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Engine And Engine Cooling:engine:hard Parts Internal/mechanical

Engine