Engine. Review the 236 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 108 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports5 fire reports3 injury reports

Power Train complaints

108 reports

Clear category filter

Mileage unknown · Mar 20, 2025

Power Train

I suddenly lost all power in my pickup. I'd try to accelerate and it would just lag and then all of a sudden it would gain power and take off. It wouldn't shift gears and I could not go over 30 mph, as it was running at about 2-3000 rpm. Once I was in a safe spot to stop, it would not shift into manual or reverse.

NHTSA ODI #11649580

Mileage unknown · Mar 18, 2025

Power Train

Read full complaint

03/08/2025 While at Interstate speed engine turned off as did the entire vehicle electrical system in the truck. Steering control was maintained (though not power assisted) and brake control was in the same position. Truck was brought to a safe position in the breakdown lane and a re start was attempted to find that engine would not rotate and a number of dash indications were displayed including check engine. No indication of low oil pressure light nor any other warning was displayed prior engine shutdown event were noted. Truck was taken to an independent repair center for evaluation. Initial inspection noted that engine would neither turn via electric starter nor by manual rotation of crank shaft with a socket and breaker bar. Truck may be inspected near owners residence. Safety risk was low due to the low traffic condition of the interstate travelled at the time.

NHTSA ODI #11648942

Mileage unknown · Mar 18, 2025

Power Train

Read full complaint

The transmission on this vehicle has given me problems. I have had the vehicle in a certified garage many times with complaints of a hard shifting transmission. First Chevrolet told me “it’s normal” but there is nothing normal about jerking so hard it throws a drink from a cup holder. Then I was told I needed a transmission wash. That was about $500 for it to “fix” the problem. Chevrolet told me the transmission was may or may not work and it may only be temporary. In my case it has reduced the hard shifting transmission but it’s still obvious. Now when I drive I remove my foot from the accelerator when it shifts from 1st to 2nd. I also make sure to keep a spill proof lid on my coffee because I never know when the transmission may throw it out of the cup holder.

NHTSA ODI #11648908

Mileage unknown · Mar 10, 2025

Electrical SystemPower Train

Read full complaint

The contact owns a 2022 GMC Sierra 1500. The contact stated that after shifting to park(P) and turning off the vehicle, the message "Shift to Park" remained displayed on the instrument panel, with an audible chime coming from the vehicle. The contact was forced to use the key fob to lock and unlock the doors several times to correct the failure. The dealer was notified of the failure and an appointment was scheduled to have the vehicle repaired. The manufacturer was notified of the failure and provided the contact with a case number. The contact was then referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was unknown.

NHTSA ODI #11647334

81,000 miles · Mar 4, 2025

EnginePower Train

Read full complaint

The contact owns a 2022 GMC Sierra 1500. The contact stated that while her husband was driving 30-35 MPH, the vehicle stalled. No warning lights were illuminated. The contact's husband was able to pull over onto the side of the road. The contact's husband attempted to restart the vehicle, and the vehicle failed to restart. The vehicle was towed to the dealer where it was diagnosed and determined that the engine had seized and needed to be replaced. The contact's husband stated that the tow truck driver could not move the gear shifter into neutral(N) when the vehicle was being towed. The vehicle was not repaired. The manufacturer was notified of the failure. The vehicle remained at the dealer and had not been driven since. The failure mileage was 81,000.

NHTSA ODI #11646347

Mileage unknown · Mar 1, 2025

EngineFuel/propulsion SystemPower Train

Engine catastrophic failure while under extended warranty. Engine failed in February of 24 however I had told dealership I was having troubles with Engine and shifting also tires from 1st 11000 miles it also kept reduce power on me and basically shut down 3 times in middle of hwy. The 6.2 engine locked up on the mechanic who was…

Read full complaint

NHTSA ODI #11645731

Mileage unknown · Feb 28, 2025

EnginePower Train

While driving at 65 mph, the engine locked up, the truck went into neutral, and all power was lost. This occurred with no warning at all. The truck was towed 40 miles to a GMC dealership for repairs. GMC dealership has indicated that the engine is permanently locked up and will have to be replaced. The dealership did not pro…

Read full complaint

NHTSA ODI #11645480

Mileage unknown · Feb 25, 2025

Power Train

Read full complaint

Coolant control valve failure (P1098) after 50k service. When this engine code appears the vehicle goes into reduced power mode. While it does this at inopportune time and creates potential for colission with other vehicles such as when merging with traffic. The coolant control valve is a known issue and GM has just recently recalssified it from their powertrain warranty to their much shorter bumper to bumper or emissions warranty without notifity owners of this change. This move directly puts owners and drivers at risk while on the road. GM should be accountable to resolve this problem as failures are across multiples years and are happening to vehicles at all milages with some less than 5k miles. This is an obvious failure on their part and they should be required to rectify the situation.

NHTSA ODI #11644914

Mileage unknown · Feb 2, 2025

EnginePower Train

Read full complaint

On or around January 27 2025 my 2022 sierra loss power and shut down at night and dropped to 0 rpm. I was close to the house and got pulled home by relative. When I did get it cranked lifters were tapping which was common in the 6.2 but I drained my oil and filter and saw the glitter look. Truck was still tapping after warmed up. Last night I about got hit at an intersection when same thing happened. I felt a jar, and truck went to zero rpm and loss power. Truck said, put in neutral and try again. When I pushed starter had a click. Then I pushed start again and it started smoking. It burnt my starter up, because engine is seized. I saw where there is an investigation on this and I really hope it goes through because that was a scary moment and it is safety concern. Twice the same thing. But now can’t turn crankshaft, nothing to drive, making payments on a 80,000 truck that is my personal and work vehicle. 92000 miles on my truck and have my oil changed regularly. I’m stuck between rock and hard place, but will be getting it towed to a dealer somewhere. To here I need a 6.2l engine in my sierra slt. 2 year old truck it is stressful. I know im going to here 10,000 $$$ I don’t have.

NHTSA ODI #11640172

Mileage unknown · Jan 31, 2025

Power Train

Read full complaint

Engine - catastrophic failure 6.2 liter V8. Vehicle is currently at dealer awaiting full engine replacement. Failure left me stranded waiting for tow to dealer. Problem has been diagnosed as rod and main bearing failure, engine replacement imminent. Vehicle was running perfectly fine all day. Went to take my daughter to basketball practice in evening initially everything was fine, then we heard squeeking, turned around to bring right back home, lost power in intersection, truck stalled. Got restarted check engine light came on and limp mode reduced power activated. Truck towed to dealer and oil pan was pulled. Rob and main bearings have scattered metal throughout the engine. Truck confirmed to need full replacement.

NHTSA ODI #11639900

Official recalls

26V083000 · Power Train:automatic Transmission:control Module:software; Power Train:automatic Transmission:fluid/lubricant:valves/valve Body

Feb 12, 2026

General Motors, LLC is recalling certain 2020 Chevrolet Silverado 2500, 3500, GMC Sierra 2500, 3500, and 2020-2022 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles that may have been repaired incorrectly under recall 24V797. The transmission control valve may fail and cause the rear wheels to lock up.

Consequence & remedy

Consequence: Rear wheel lock up increases the risk of a crash.

Remedy: Dealers will inspect the vehicles and update the transmission control software, free of charge. Owner notification letters were mailed March 6, 2026. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252516560. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.

Additional source detail variants (2)

Power Train:automatic Transmission:fluid/lubricant:valves/valve Body

Consequence: Rear wheel lock up increases the risk of a crash.

Remedy: Dealers will inspect the vehicles and update the transmission control software, free of charge. Owner notification letters were mailed March 6, 2026. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252516560. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.

Power Train:automatic Transmission:control Module:software

Consequence: Rear wheel lock up increases the risk of a crash.

25V274000 · Engine And Engine Cooling:engine:hard Parts Internal/mechanical

Apr 24, 2025

General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.

Consequence & remedy

Consequence: Engine failure increases the risk of a crash.

Remedy: Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.

25V060000 · Structure:body:bumpers:active Shutters/grill

Feb 6, 2025

General Motors, LLC (GM) is recalling certain 2022 GMC Sierra 1500 vehicles equipped with chrome front grille deflectors. The attachments that hold the front grille deflectors in place may fracture, resulting in grille detachment.

Consequence & remedy

Consequence: A detached front grille deflector may become a road hazard, increasing the risk of a crash.

Remedy: Dealers will reinforce or repair all attachment points on the chrome front grille deflector, free of charge. Owner notification letters were mailed March 17, 2025. Owners may call GM customer service for GMC at 1-800-462-8782. GM's number for this recall is N242490120.

24V797000 · Power Train:automatic Transmission:control Module:software; Power Train:automatic Transmission:fluid/lubricant:valves/valve Body

Oct 24, 2024

General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.

Consequence & remedy

Consequence: Rear wheel lock-up can increase the risk of a crash.

Remedy: Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242454440.

Additional source detail variants (2)

Power Train:automatic Transmission:fluid/lubricant:valves/valve Body

Consequence: Rear wheel lock-up can increase the risk of a crash.

Remedy: Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242454440.

Power Train:automatic Transmission:control Module:software

Consequence: Rear wheel lock-up can increase the risk of a crash.

22V903000 · Exterior Lighting:lighting Control Module:software

Dec 8, 2022

General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.

Remedy: The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.

22V463000 · Exterior Lighting:brake Lights

Jun 30, 2022

General Motors (GM) has decided that certain 2022 model year Chevrolet Silverado, and GMC Sierra vehicles equipped with an accessory sport bar. The accessory sport bar contains a high-mounted brake light that may not function. In addition, it may block the vehicle's existing high-mounted brake light. As such, these vehicles may fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 108, "lamps, reflective devices, and associated equipment."

Consequence & remedy

Consequence: An inoperative high-mounted brake light can reduce visibility to other drivers and increase the risk of a crash.

Remedy: Dealers will inspect the installation of the accessory bar and provide the correct vehicle wiring, if necessary, free of charge. Interim owner notification letters advising owners of the safety risk were mailed on August 10, 2022. Owner notification letters were mailed on January 27, 2023. Owners may contact GM's customer service on 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020.. GM's recall number for this recall is N222368110.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA26005 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy

Opened Aug 20, 2026 · No close date supplied

Status: open (inferred from source dates) · Engine

On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. Additionally, ODI has received 191 reports of L87 engine failures in engines produced after the production period cited in Recall 25V-274. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI is opening this Engineering Analysisto continue investigating complaints of post-remedy engine failure. ODI is expanding the scope of this Investigation to include engines produced after the production period cited in the recall. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

RQ26001 · Loss Of Motive Power Due To Engine Failure Post Recall Remedy

Opened Jan 16, 2026 · Closed Aug 20, 2026

Status: closed (inferred from source dates) · Engine

On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s recall remedy for Recall 25V-274 consisted of two different repairs, either an oil viscosity change or an engine replacement, based on the results of the remedy inspection procedure. ODI continues to receive reports of engine failures after the completion of the recall remedy. To date, ODI has received 499 complaints alleging post-remedy engine failure in vehicles subject to Recall 25V-274, 473 of which involved an oil viscosity change and 26 a complete engine replacement. GM reported receiving 6,953 complaints of post-remedy engine failure. ODI will close this RQ and continue to investigate complaints of post-remedy engine failure for Recall 25V-274 as part of an Engineering Analysis (EA26005). To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

EA25007 · Loss Of Motive Power Due To Engine Failure

Opened Oct 23, 2025 · No close date supplied

Status: open (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical

The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274. This presents a potential safety risk that warrants further investigation. ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Engine And Engine Cooling:engine:hard Parts Internal/mechanical

Engine

PE25001 · Loss Of Motive Power Due To Engine Failure

Opened Jan 16, 2025 · Closed Oct 23, 2025

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:hard Parts Internal/mechanical

On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issues. GM’s recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Engine And Engine Cooling:engine:hard Parts Internal/mechanical

Engine