← New search

2009 GMC Sierra 1500

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2009 GMC Sierra 1500 do not stand out strongly from the model-year median of 181.

About this comparison →

When problems were reported

Mileage at the reported incident

117 reports with mileage · 117 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Air Bags. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Structure. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

4 crash reports4 fire reports3 injury reports

Power Train complaints

9 reports
Clear category filter
Mileage unknown · Mar 11, 2025
Power Train

Allison transmission - random hard shifts, random multiple DTC's, random limp mode. Clear codes and works fine until it doesn't. Might have to clear codes 3-4 times a day or it might make it a week before it goes into limp mode again.

NHTSA ODI #11647697

Mileage unknown · Dec 8, 2022
Power Train

Yes, the airbag has not been replaced but I have another SERIOUS SAFETY PROBLEM with this vehicle: The stabilitrak system does NOT work, it is NOT POSSIBLE to shift into gear, if the vehicle is put into use there is a definite possibility that the truck will go into LIMP MODE with a very limited speed (20 mph?) while trying to…

Read full complaint

Yes, the airbag has not been replaced but I have another SERIOUS SAFETY PROBLEM with this vehicle: The stabilitrak system does NOT work, it is NOT POSSIBLE to shift into gear, if the vehicle is put into use there is a definite possibility that the truck will go into LIMP MODE with a very limited speed (20 mph?) while trying to keep up with the traffic flow at 75+mph while the. transmission searches for which gear and wheel to apply power. This is a frightening experience to say the least. And I am without my work truck (and work) for more than 4 months because GMC has no ETA for parts to repair this problem. I guess this is NOT. safety issue in reality since I cannot/ will not drive this piece of dangerous GENERAL MOTORS engineering nightmare. When I search for solutions to this problem I find that there are many many GM vehicles (cars,suvs,vans, trucks) experiencing the same SERIOUSLY DANGEROUS situations. It is time to investigate this company before it shutters its doors and moves offshore to leave their junk in the United States without responsibility for repairs or accidents. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI #11496603

Mileage unknown · Jun 18, 2021
Power Train

First had transmission replaced, then a second one, now third time they say transfer case, locking itself in gear, and dangerous cause wanted to take off fast in reverse. All this happening just in a couple months time. Cost 3500 for transmission, now saying transfer case will cost me more money, and I still owe 800 on the trans…

Read full complaint

First had transmission replaced, then a second one, now third time they say transfer case, locking itself in gear, and dangerous cause wanted to take off fast in reverse. All this happening just in a couple months time. Cost 3500 for transmission, now saying transfer case will cost me more money, and I still owe 800 on the transmission replacement. It is a 2009 GMC Sierra LD, vin is [XXX]. Thank you hope you can help me out on this. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI #11421412

140,000 miles · Jan 6, 2020
Power Train

REAR END LOCKS UP. IF THE WHEELS SPIN THEN THE TRUCK WONT MOVE. IT GETS STUCK AND YOU HAVE TO FORCE IT FORWARD UNTIL THE WHEELS START MOVING FREELY AGAIN.

NHTSA ODI #11297490

83,000 miles · Jun 8, 2017
Power Train

TRANSMISSION FILLER TUBE IS BREAKING. THERE IS A RECALL BUT NOT ON MINE. WHY? I ORDERED A NEW ONE.

NHTSA ODI #10994016

65,000 miles · Mar 15, 2017
Electrical SystemFuel/propulsion SystemPower Train

MY TRUCK DIED IN TRAFFIC BUT I WAS ABLE TO GET STARTED AND HOME (2 MILES). MY CHECK ENGINE LIGHT CAME ON AND I AM READING A CODE U0191, WHICH REFERS TO THE FUEL PUMP FLOW CONTROL MODULE. I HAD TO PURCHASE A BATTERY BECAUSE I HAD A BATTERY DRAINING ISSUE AND WAS HAVING TO JUMP IT IF IT SAT FOR A COUPLE OF DAYS. MY TRUCK WILL NOT …

Read full complaint

MY TRUCK DIED IN TRAFFIC BUT I WAS ABLE TO GET STARTED AND HOME (2 MILES). MY CHECK ENGINE LIGHT CAME ON AND I AM READING A CODE U0191, WHICH REFERS TO THE FUEL PUMP FLOW CONTROL MODULE. I HAD TO PURCHASE A BATTERY BECAUSE I HAD A BATTERY DRAINING ISSUE AND WAS HAVING TO JUMP IT IF IT SAT FOR A COUPLE OF DAYS. MY TRUCK WILL NOT START AT THIS TIME. AFTER DOING SOME CHECKING, BOTH MY FUEL PUMP AND FUEL FLOW MODULE FUSES ARE HOT EVEN WITH THE TRUCK IGNITION OFF. WHICH WOULD INDICATE A SHORT IN THE SYSTEM. AFTER SOME RESEARCH , I FOUND A SAFETY RECALL THAT DESCRIBES THE EXACT ISSUE BUT MY VIN DOESN'T COME UP IN THE RECALL. RECALL BULLETIN # 14515B . I GUESS WHAT I AM ASKING IS WHY WASN'T MY VEHICLE INCLUDED IN THE RECALL? APPARENTLY THIS IS AFFECTING MORE VEHICLES THAT WHAT THE RECALL INCLUDED.

NHTSA ODI #10966135

74,259 miles · May 3, 2016
EnginePower Train

EXCESSIVE OIL USAGE, HAVE HAD IT MONITORED 3 TIMES PER GM. USES OIL EVERY 2 THOUSAND MILES ,THEY ARE AWARE THAT THESE 5.3 V8 ARE DOING SO. THERE IS A SERVICE BULLETIN OUT ON THIS PROBLEM, THIS PROBLEM NEEDS TO BE INVESTIGATED BY OUR GOVERNMENT.

NHTSA ODI #10862758

48,000 miles · Dec 4, 2013
Power Train

TRANSMISSION DELAY FROM PARK TO DRIVE. AS TRANSMISSION MOVES INTO DRIVE THE TRUCK JERKS FORWARD VIOLENTLY. PARK TO REVERSE DID NOT SEEM TO BE A PROBLEM. DEALER WORKED ON THE TRUCK FOR APPROXIMATELY 8 HOURS, FLUSHED TRANSMISSION, AND PERFORMED OIL CHANGE, DID NOT NOTICE ANY METAL IN THE TRANSMISSION FLUID AND SOUGHT AN UPDATE FO…

Read full complaint

TRANSMISSION DELAY FROM PARK TO DRIVE. AS TRANSMISSION MOVES INTO DRIVE THE TRUCK JERKS FORWARD VIOLENTLY. PARK TO REVERSE DID NOT SEEM TO BE A PROBLEM. DEALER WORKED ON THE TRUCK FOR APPROXIMATELY 8 HOURS, FLUSHED TRANSMISSION, AND PERFORMED OIL CHANGE, DID NOT NOTICE ANY METAL IN THE TRANSMISSION FLUID AND SOUGHT AN UPDATE FOR THE TCM (WAS UP-TO-DATE); HOWEVER, A SMALL AMOUNT OF WATER WAS SEEN IN THE OIL PAN. DEALER PERFORMED A TEST DRIVE AND THE TRUCK APPEARED TO BE BACK IN WORKING CONDITION. OWNER ATTEMPTED TO DRIVE THE TRUCK OUT OF THE DEALER LOT BUT THE TRANSMISSION WOULD NOT ENGAGE. OWNER ATTEMPTED TO PUT THE TRUCK IN REVERSE, THE TRANSMISSION WOULD NOT ENGAGE. TRUCK WAS LEFT AT THE DEALER FOR FURTHER EVALUATION. NO ADDITIONAL INFORMATION AT THIS TIME. TRANSMISSION STILL UNDER WARRANTY. *TR

NHTSA ODI #10554832

43,503 miles · Aug 18, 2013
Power TrainService BrakesWheels

AFTER BEING STOPPED WITH ENGINE OFF AND EMERGENCY BRAKE ENGAGED, STARTED ENGINE, DISENGAGED EMERGENCY BRAKE AND ACCELERATED. SIGNIFICANT VIBRATION IN THE REAR OF THE TRUCK. TOOK VEHICLE TO CHEVROLET/GMC DEALERSHIP AND WAS ADVISED THAT THE REAR WHEEL CYLINDERS WERE LEAKING AND NEEDED TO BE REPLACED AFTER ONLY 43500 MILES. THIS IN…

Read full complaint

AFTER BEING STOPPED WITH ENGINE OFF AND EMERGENCY BRAKE ENGAGED, STARTED ENGINE, DISENGAGED EMERGENCY BRAKE AND ACCELERATED. SIGNIFICANT VIBRATION IN THE REAR OF THE TRUCK. TOOK VEHICLE TO CHEVROLET/GMC DEALERSHIP AND WAS ADVISED THAT THE REAR WHEEL CYLINDERS WERE LEAKING AND NEEDED TO BE REPLACED AFTER ONLY 43500 MILES. THIS INCIDENT FOLLOWED AN ISSUE ON 11-29-12 WHERE THE THROTTLE POSITION SENSOR MALFUNCTIONED AND THE ENGINE RAN VERY ROUGH AND THE TRUCK WAS DIFFICULT TO STOP. *TR

NHTSA ODI #10535942

Official recalls

4

21V050000 · Air Bags:frontal:passenger Side:inflator Module

Feb 5, 2021

General Motors, LLC (GM) is recalling certain 2007-2011 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL, and 2009-2011 Chevrolet Silverado 2500, Silverado 3500, GMC Sierra 2500 and Sierra 3500 vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 22, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on March 1, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328760.

21V052000 · Air Bags:frontal:passenger Side:inflator Module

Feb 5, 2021

General Motors, LLC (GM) is recalling certain 2009 Cadillac Escalade, Escalade ESV, Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500, Silverado 3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500, Sierra 3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2007-2008 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with non-desiccated passenger frontal inflators containing phase-stabilized ammonium nitrate (PSAN) propellant. These inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 23, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on September 20, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-458-8006, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328780.

21V053000 · Air Bags:frontal:passenger Side:inflator Module

Feb 5, 2021

General Motors, LLC (GM) is recalling certain 2013 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, GM is recalling certain 2010 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Additionally, GM is recalling certain 2009 Cadillac Escalade, Escalade ESV, and Escalade EXT, Chevrolet Avalanche, Silverado 1500, Silverado 2500/3500, Suburban, Tahoe, GMC Sierra 1500, Sierra 2500/3500, Yukon, and Yukon XL vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C."

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: GM will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. Interim letters notifying owners of the safety risk were mailed on February 24, 2021. Second notification letters will be mailed once the remedy is available. Owner notification letters were mailed on May 11, 2021. Owners may contact Cadillac customer service at 1-800-458-8006; Chevrolet customer service at 1-800-222-1020; and GMC customer service at 1-800-462-8782. GM's number for this recall is N212328790.

18V267000 · Equipment

Apr 26, 2018

General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence & remedy

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.