IllustrationFRONT BRAKE PADS WERE DEFECTIVE.*AK *JB
2000 GMC Savana
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Savana years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 14 of 49 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports2 fire reports1 injury reports
What owners actually said
49 reportsCATALYTIC CONVERTER HAS BEEN REPLACED FOUR TIMES IN LESS THAN THREE YEARS. MY DEALER JUST KEEPS SHRUGGING THEIR SHOULDERS AND TELLING ME THEY DON'T KNOW WHY. THEY TELL ME EVERY TIME, IT WAS BROKEN INTO MANY SMALL PIECES AND WHEN THEY TAPPED ON THE MANIFOLD THAT IT SOUNDED LIKE SALT IN THERE..*JB
INSIDE LEFT FRONT BRAKE PAD WORE DOWN COMPLETELY AT 17,109 MILES, DAMAGING ROTOR, REQUIRING ROTOR REPLACEMENT AND BRAKE JOB. THERE WAS ABSOLUTELY NO NOTICE SUCH AS A SQUEAL OR OTHER INDICATION THAT WOULD NORMALLY OCCUR PRIOR TO A BRAKE COMPONENT FAILURE. DEALER CLAIMED IT WAS "NORMAL" WEAR ALTHOUGH THE OTHER THREE PADS HAD PL…
Read full complaint
INSIDE LEFT FRONT BRAKE PAD WORE DOWN COMPLETELY AT 17,109 MILES, DAMAGING ROTOR, REQUIRING ROTOR REPLACEMENT AND BRAKE JOB. THERE WAS ABSOLUTELY NO NOTICE SUCH AS A SQUEAL OR OTHER INDICATION THAT WOULD NORMALLY OCCUR PRIOR TO A BRAKE COMPONENT FAILURE. DEALER CLAIMED IT WAS "NORMAL" WEAR ALTHOUGH THE OTHER THREE PADS HAD PLENTY OF LIFE LEFT ON THEM. DEALER WOULD NOT COVER REPAIRS. GM CUSTOMER SERVICE WAS CONTACTED AND PROVIDED NO HELP. CUST. SERVICE ALSO SIDED WITH THE DEALER MECHANIC, SAYING IT WAS "NORMAL" WEAR AND WOULD NOT BE COVERED. I ENDED UP HAVING THEM REPAIRED/REPLACED AT ANOTHER LOCATION. SEEMS TO BE A COMMON PROBLEM AS I HAVE SEEN MANY PRIOR COMPLAINTS OF THIS SAME TYPE ON THE SAME OR SIMILAR TYPE VEHICLES. THIS APPEARS TO BE A SAFETY RELATED COMPLAINT TO ME, BUT THUS FAR, AFTER MANY YEARS OF COMPLAINTS OF THIS TYPE, NO INVESTIGATION HAS BEEN INITIATED. INADEQUATE BRAKING SYSTEMS FOR THIS TYPE OF VEHICLE. SHOULD BE A RECALL TO PROVIDE HEAVY DUTY BRAKES FOR THESE VANS. DT
WHILE DRIVING ON INTERSTATE AT 65 MPH, I NOTICED A VIBRATION OR ROUGH RIDE FOLLOWED BY A COMPLETE TREAD SEPERATION AND BLOW OUT OF THE RIGHT REAR TIRE ON MY GMC 3500 SERIES LONG WHEELBASE SAVANNA VAN. TREAD REMAINED ATTACHED TO CASING SCRAPING A THREE FOOT ARCH ON THE SIDE FENDER PANEL(PAINT SCRAPED FROM STEEL BELTS AND BLACK RU…
Read full complaint
WHILE DRIVING ON INTERSTATE AT 65 MPH, I NOTICED A VIBRATION OR ROUGH RIDE FOLLOWED BY A COMPLETE TREAD SEPERATION AND BLOW OUT OF THE RIGHT REAR TIRE ON MY GMC 3500 SERIES LONG WHEELBASE SAVANNA VAN. TREAD REMAINED ATTACHED TO CASING SCRAPING A THREE FOOT ARCH ON THE SIDE FENDER PANEL(PAINT SCRAPED FROM STEEL BELTS AND BLACK RUBBER DEPOSITED)AND THE TAIL PIPE WAS PULLED INTO THE WHEEL CAUSING IT TO FOLD IN TWO AT THE AXLE. DEBRISE FROM THE TIRE HIT SEVERAL OTHER CARS AND NO ACCIDENT RESULTED FROM THIS FAILURE. TIRE SIZE WAS 245/75/16E INFLATED TO PROPER PRESURE FIVE DAYS PRIOR, ROTATED AT REGULAR INTERVALS AND VISUALLY CHECKED FREQUENTLY. DT
CONSUMER STATES THAT WHILE DRIVEN THE VEHICLE THE POWER STEERING PUMP CAUSING THE VEHICLE TO LOOSE ALL POWER STEERING AND BRAKE SYSTEM. GMC WAS CALLED AND DEALER FIXED THE PROBLEM. NLM
BRAKE BEARING HAVE BURNED OUT ON PASSENGER SIDE OF VEHICLE CAUSING TOTAL BRAKE FAILURE, WHICH COULD EVENTUALLY CAUSE WHEEL TO FALL COMPLETELY OFF. PLEASE GIVE ANY FURTHER DETAILS.*AK
REAR DOOR WILL OPEN TOO WIDE, HITTING FRONT DOOR, AND CAUSING DAMAGE. DEALER NOTIFIED. *AK
SEAT BELT BUCKLE IN REAR BENCH BROKE, UNABLE TO FASTEN SEAT BELT. CONTACTED DEALER, UNABLE TO FIX PROBLEM.*AK
BRAKES ARE APPLIED AT HIGHWAY SPEED AND VEHICLE VIBRATES. PEDAL WOULD GO PARTIALY TO THE FLOOR, RESULTING IN EXTENDED STOPPING, ANDCAUSING A COLLISION. *AK
INTERMITTENTLY WHEN BRAKES ARE APPLIED AT HEIGHWAY SPEEDS VEHICLE VIBRATES, PEDAL WOULD GOES TO THE FLOOR, RESULTING IN EXTENDED STOPPING, AND COLLISION.*AK
Official recalls
205V005000 · Power Train:driveline:driveshaft
Jan 7, 2005
SOME PICKUP TRUCKS, VANS, AND SPORT UTILITY VEHICLES EQUIPPED WITH A HYDRAULIC PUMP DRIVESHAFT THAT CAN FRACTURE, RESULTING IN IMMEDIATE LOSS OF HYDRAULIC POWER STEERING ASSIST. ON CERTAIN VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, THE SAME CONDITION CAN RESULT IN LOSS OF POWER ASSIST FOR BRAKING AFTER THE RESERVE PRESSURE IS DEPLETED.
Consequence & remedy
Consequence: AN INOPERATIVE PUMP CAN CAUSE INCREASED STEERING EFFORT, AND IN HYDRO-BOOST EQUIPPED VEHICLES ALSO INCREASED BRAKING EFFORT, BUT DOES NOT COMPLETELY ELIMINATE THE ABILITY TO STEER OR SLOW THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE HYDRAULIC PUMP. THE CAMPAIGN BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
00V085000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Mar 16, 2000
VEHICLE DESCRIPTION: PASSENGER VANS EQUIPPED WITH A BRAKE WARNING INDICATOR. SOME OF THESE VEHICLES HAVE A POWER STEERING COOLER HOSE THAT CAN SEPARATE FROM THE POWER BRAKE BOOSTER FLUID FLOW SWITCH ASSEMBLY.
Consequence & remedy
Consequence: IF THIS OCCURS, POWER STEERING FLUID COULD FLOW ONTO HOT ENGINE PARTS AND AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT FOR THREE SCREW CLAMPS TO THE POWER STEERING HOSE JOINTS. IF THE CLAMPS ARE NOT THE SCREW TYPE, DEALERS WILL REPLACE THE CLAMPS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA04012 · Hydraulic Pump Failres
Opened Apr 30, 2004 · Closed Feb 28, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Additional source detail variants (2)
Service Brakes, Hydraulic:power Assist
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Steering:hydraulic Power Assist System
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.