Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 9 of 49 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Hydraulic. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Tires. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports0 fire reports2 injury reports
What owners actually said
49 reports
130,000 miles · Feb 13, 2014
Electrical System
TL* THE CONTACT OWNS A 1999 GMC SAVANNA. THE CONTACT STATED THAT UPON STARTING THE VEHICLE, HE HEARD AN ABNORMAL NOISE. THE CONTACT INSPECTED THE VEHICLE AND FUND THAT THE STARTER BOLT HAD FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 130,000. THE VIN…
Read full complaint
TL* THE CONTACT OWNS A 1999 GMC SAVANNA. THE CONTACT STATED THAT UPON STARTING THE VEHICLE, HE HEARD AN ABNORMAL NOISE. THE CONTACT INSPECTED THE VEHICLE AND FUND THAT THE STARTER BOLT HAD FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 130,000. THE VIN WAS NOT AVAILABLE. *TR
NHTSA ODI #10564196
66,000 miles · Aug 19, 2006
Steering
THE POWER BRAKE/STEERING PUMP SHAFT BROKE, RENDERING THE POWER BRAKE AND STEERING INOPERABLE. THE PROBLEM OCCURRED WHILE TRAVELING DOWNHILL AND PRESENTED A SAFETY PROBLEM. THE VEHICLE ONLY HAD 70,000 MILES AT THE TIME. I WAS AND REMAIN CONCERNED THAT THE PART DEFECT WAS NOT IDENTIFIED EARLIER AND PRESENTED A POTENTIAL SAFETY HA…
Read full complaint
THE POWER BRAKE/STEERING PUMP SHAFT BROKE, RENDERING THE POWER BRAKE AND STEERING INOPERABLE. THE PROBLEM OCCURRED WHILE TRAVELING DOWNHILL AND PRESENTED A SAFETY PROBLEM. THE VEHICLE ONLY HAD 70,000 MILES AT THE TIME. I WAS AND REMAIN CONCERNED THAT THE PART DEFECT WAS NOT IDENTIFIED EARLIER AND PRESENTED A POTENTIAL SAFETY HAZARD. THE PART HAS BEEN REPLACED, BUT I WANT TO KNOW IF THE REPLACEMENT PART IS SAFE AND HOW GMC WILL REIMBURSE ME FOR ALL OF THE COSTS I INCURRED TO CORRECT THE PROBLEM. IT WAS VERY DISTRESSING TO LOSE ALL POWER STEERING AND BRAKING WHILE THE VEHICLE WAS IN MOTION. HAD I BEEN TRAVELING FASTER, INJURIES MOST ASSUREDLY WOULD HAVE OCCURRED. I HAVE SEEN ELSEWHERE ON THE INTERNET THAT A 2000 GMC SAVANA VAN RECALL WAS ISSUED FOR THE SAME DEFECTIVE PART. *NM
NHTSA ODI #10166024
60,000 miles · Apr 4, 2005
Steering
STEERING FAILED COMPLETELY. DEALER STATED THE CONVERSION COMPANY MADE THE VEHICLE TOO HEAVY. *AK
NHTSA ODI #10117371
53,321 miles · Jan 13, 2005
Steering
WHILE DRIVING 5 MPH SUDDENLY, THE DRIVER WAS NOT ABLE TO STEER TO THE RIGHT. THE DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND DROVE IT TO THE SHOP FOR INSPECTION. THE MECHANIC DETERMINED THAT THE POWER STEERING PUMP NEEDED TO BE REPLACED. PLEASE PROVIDE FURTHER DETAILS. *NM......IT HAPPENED AFTER MAKING A SHAR…
Read full complaint
WHILE DRIVING 5 MPH SUDDENLY, THE DRIVER WAS NOT ABLE TO STEER TO THE RIGHT. THE DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND DROVE IT TO THE SHOP FOR INSPECTION. THE MECHANIC DETERMINED THAT THE POWER STEERING PUMP NEEDED TO BE REPLACED. PLEASE PROVIDE FURTHER DETAILS. *NM......IT HAPPENED AFTER MAKING A SHARP TURN TO THE LEFT. CONSUMER COULD NOT STEER THE VAN LEFT RIGHT.THE MECHANIC INDICATED THAT THE SHAFT FROM THE POWER STEERING PUMP WA SSHEARED IN HALF. *AK
NHTSA ODI #10107394
Mileage unknown · Dec 7, 2004
Structure
DEFECTIVE HINGES ON SIDE CARGO DOORS. SIDE DOORS NOT FREQUENTLY USED. REPEATEDLY GREASED/OILED TO REDUCE TENSION AND FORCE NECESSARY TO OPERATE DOORS. DOORS NOW INOPERABLE. HINGES CRACKED & RUSTED OUT COMPLETELY AFTER ONLY 3 1/2 YEARS OF OWNING VEHICLE. PASSENGERS WOULD BE TRAPPED INSIDE IF USING CENTER SEATS. HINGES ARE USEL…
Read full complaint
DEFECTIVE HINGES ON SIDE CARGO DOORS. SIDE DOORS NOT FREQUENTLY USED. REPEATEDLY GREASED/OILED TO REDUCE TENSION AND FORCE NECESSARY TO OPERATE DOORS. DOORS NOW INOPERABLE. HINGES CRACKED & RUSTED OUT COMPLETELY AFTER ONLY 3 1/2 YEARS OF OWNING VEHICLE. PASSENGERS WOULD BE TRAPPED INSIDE IF USING CENTER SEATS. HINGES ARE USELESS. PER GMC, MY PROBLEM; TAKE OWNERSHIP OF THE VEHICLE & IT'S ISSUES AFTER WARRANTY EXPIRED.*AK
NHTSA ODI #10102286
115,000 miles · May 3, 2004
Structure
HINGES ON 60/40 CARGO DOORS ARE VERY STIFF. DOORS HAVE BEEN DIFFICULT TO OPEN AND CLOSE FOR QUITE SOME TIME. RECENTLY, LOWER HINGE ON 40 DOOR HAS BROKEN. REPLACEMENT OF ALL HINGES ON THESE DOORS IS APPROXIMATELY $1100. HAVE NOT YET CONTACTED DEALER ABOUT PROBLEM (HAD SIMILAR PROBLEMS WITH HINGES ON 95 VANDURA).*AK
NHTSA ODI #10068220
Mileage unknown · Apr 30, 2004
Seat Belts
THE REAR PASSENGER'S SEAT BELT BUCKLE WILL NOT RELEASE. THE DEALER INDICATED THAT THE VEHICLE IS NO LONGER UNDER WARRANTY. *LA
NHTSA ODI #10071942
99,500 miles · Apr 20, 2004
Air Bags
PASSENGER SIDE AIR BAG DEPLOYED WHILE THE VAN WAS PARKED. THE AIR BAG WARNING LIGHT CAME ON AND STAYED ON 2 DAYS PRIOR TO THE INCIDENT. *AK *JB
NHTSA ODI #10064668
Mileage unknown · Jan 28, 2004
Seats
PASSENGER SEAT HAS TIPPED BACK; THREE TIMES. EACH TIME THE DEALERSHIP REPLACED THE HINGE PIN AND PUT A SMALL SPROCKET TO LOCK IN PLACE. THIS DOESN'T SEEM TO FIX THE PROBLEM. THE ONLY REASON SOMEONE HASN'T BEEN HURT IS THE DISCOVERY OF THE MISSING PINS WHEN A PASSENGER IS LOADING INTO THE BACK.*AK
NHTSA ODI #10055099
Mileage unknown · Jan 7, 2004
Power Train
WHILE SHIFTING GEARS TRANSMISSION WOULD DOWN SHIFT ON ITS OWN. VEHICLE WAS TOWED TO THE DEALER FOR ANALYSIS, AND MECHANIC REPLACED TRANSMISSION. *AK
VEHICLE DESCRIPTION: PASSENGER VANS EQUIPPED WITH A BRAKE WARNING INDICATOR. SOME OF THESE VEHICLES HAVE A POWER STEERING COOLER HOSE THAT CAN SEPARATE FROM THE POWER BRAKE BOOSTER FLUID FLOW SWITCH ASSEMBLY.
Consequence & remedy
Consequence: IF THIS OCCURS, POWER STEERING FLUID COULD FLOW ONTO HOT ENGINE PARTS AND AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT FOR THREE SCREW CLAMPS TO THE POWER STEERING HOSE JOINTS. IF THE CLAMPS ARE NOT THE SCREW TYPE, DEALERS WILL REPLACE THE CLAMPS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1999 GMC Savana Problems, Complaints & Recalls | Skip That Year
Illustration