IllustrationSPEEDOMETER ON 2004 GMC ENVORY STARTED ACTING UP AND WOULD READ TWICE THE ACTUAL SPEED OF VEHICLE. THEN IT FROZE AT 80 MPH. IT STILLS IS NOT WORKING. IT JUMPS AROUND ALL THE TIME NOW. *TR
2004 GMC Envoy Xl
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Envoy Xl years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
130–25K
2525–50K
4450–75K
2575–100K
26100–150K
12150K+
145 reports with mileage · 42 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports6 fire reports6 injury reports
Electrical System complaints
81 reportsOWN A 2004 ENVOY XL. SPEEDOMETER STUCK MAXED OUT AT 100+ MPH. HAD TO HAVE THE INSTRUMENT PANEL REPLACED. QUITE A SHOCK WHEN YOU LOOK DOWN AND THINK YOU ARE GOING 100. SHOULD BE PART OF RECALL. *TR
DRIVING DOWN THE ROAD OUR SPEEDOMETER WENT HAYWIRE AND THEN QUIT WORKING. I CALLED GMC AND THEY SAID OUR VEHICLE IS NOT COVERED UNDER THE CURRENT VEHICLES THAT ARE COVERED AND THAT OUR VEHICLE HAS NOT BEEN REPORTED AS A VEHICLE EXPERIENCING DIFFICULTIES. WE OWN A GMC 2004 ENVOY XL.*CN
THE SPEEDOMETER ON MY 2004 GMC ENVOY XL MALFUNCTIONED. ITS READINGS ARE VERY ERRATIC AND DO NOT CORRESPOND AT ALL WITH THE SPEED OF THE VEHICLE. FOR EXAMPLE, READINGS OF 10 MPH WHILE DRIVING ON THE INTERSTATE WITH THE FLOW OF TRAFFIC AND 100 MPH WHILE STOPPED AT A TRAFFIC LIGHT. THE READINGS VARY ANYWHERE FROM O MPH TO PAST 120 …
Read full complaint
THE SPEEDOMETER ON MY 2004 GMC ENVOY XL MALFUNCTIONED. ITS READINGS ARE VERY ERRATIC AND DO NOT CORRESPOND AT ALL WITH THE SPEED OF THE VEHICLE. FOR EXAMPLE, READINGS OF 10 MPH WHILE DRIVING ON THE INTERSTATE WITH THE FLOW OF TRAFFIC AND 100 MPH WHILE STOPPED AT A TRAFFIC LIGHT. THE READINGS VARY ANYWHERE FROM O MPH TO PAST 120 MPH AND ARE COMPLETELY UNRELATED TO THE VEHICLE'S SPEED. THIS FAILURE OCCURRED SUDDENLY. THE FIRST SIGN WAS THE SPEEDOMETER STICKING AT 10 MPH EVEN AS I ACCELERATED; IT THEN BEGAN THE ERRATIC BEHAVIOR MENTIONED ABOVE. AS A CONSEQUENCE, IT IS IMPOSSIBLE TO DETERMINE THE SPEED AT WHICH THIS VEHICLE IS TRAVELING. THIS WAS ESPECIALLY CONCERNING TO ME SINCE THIS FAILURE OCCURRED AS I WAS TRAVELING HOME FROM INDIANA TO SOUTH CAROLINA WITH MY WIFE AND 3 CHILDREN IN THE VEHICLE. THIS OCCURRED YESTERDAY AND HAS NOT BEEN REPAIRED AT THIS TIME. *TR
ELECTRICAL PROBLEMS. I HAVE HAD BOTH REAR TAILGATE SENSORS GO OUT AT THE SAME TIME. I HAVE THE SPEEDOMETER ACTING ERRATICALLY OFF AND ON OFF AND ON. I HAVE HAD THE STARTER SWITCH GO OUT TWICE. *TR
SPEEDOMETER ON MY 2004 GMC ENVOY XL SLT READS INCORRECTLY AT ALL TIMES. BEGAN AS READING HIGH OCCASIONALLY, NOW IT IS ENTIRELY UNRELIABLE. SOMETIMES HIGH, SOMETIMES LOW, SOMETIMES 140MPH IN THE DRIVEWAY. *TR
THE SPEEDOMETER/TACHOMETER IN MY 2004 GMC ENVOY READ INACCURATELY. THE NEEDLES READ WAY OFF OF WHERE THEY SHOULD BE (IE. READING 45 MPH AT IDLE AND TACH AT 8,000 RPMS AT IDLE). *TR
SPEEDOMETER IS ERRATIC OFTEN 30 TO 80 MPH OFF AND WILL NOT RETURN TO 0 MPH WHEN STOPPED. CURRENTLY IT READS ABOVE 120 MPH AND WILL NOT MOVE UP OR DOWN. *TR
ENGINE, CHECK GADGES LIGHT APPEARS, SUV STALLS, RADIO LIGHTS AND STEERING LIGHTS KEEPS FAILING. I HAVE TAKEN MY 04 ENVOYXL INTO THE DEALERSHIP OVER 7 TIMES FOR THE SAME PROBLEM IN WHICH THEY HAVE NOT YET BEEN ABLE TO FIX/RESOLVE. MY ENVOYXL CHECK ENGINE AND CHECK GADGES LIGHTS KEEP POPPING ON AND THE VEHICLE CONTINUES TO CUT O…
Read full complaint
ENGINE, CHECK GADGES LIGHT APPEARS, SUV STALLS, RADIO LIGHTS AND STEERING LIGHTS KEEPS FAILING. I HAVE TAKEN MY 04 ENVOYXL INTO THE DEALERSHIP OVER 7 TIMES FOR THE SAME PROBLEM IN WHICH THEY HAVE NOT YET BEEN ABLE TO FIX/RESOLVE. MY ENVOYXL CHECK ENGINE AND CHECK GADGES LIGHTS KEEP POPPING ON AND THE VEHICLE CONTINUES TO CUT OFF/STALL THE DEALERSHIP HAS NOT YET FIXED THE PROBLEM, I HAVE TAKEN THE SUV IN OVER 6 TIMES FOR THIS PROBLEM. FROM 2004 UNTIL NOW 2007 THE PROBLEM CONTINUES. THE LIGHTS ON THE DASH BOARD KEEPS GOING OUT. THEY HAVE REPLACED THE LIGHTS AT LEAST 2 OR 3 TIMES BUT THEY KEEP GOING OUT. THESE LIGHTS ARE ON THE RADIO PART, THE BUTTONS WHICH OPERATE THE RADIO AND SWITCHES THE STATION. THE PANELS SEEMS TO GET VERY HOT. THE LIGHTS ARE CURRENTLY OUT NOW AFTER BEING REPLACED 3 TIMES AND NOW THE VEHICLE IS OUT OF WARRANTY. THE PAINT ON THE SUV IS VERY DULL AND THE LEATHER ON THE 2ND ROW SEAT IS CRACKING, COMPLETELY WORN AND VERY CHEAP. I COMPLAINED TO THE DEALERSHIP 1 YEAR AFTER I PURCHASED THE VEHICLE THAT THE LEATHER IS WORN OUT TOO FAST, NOTHING WAS DONE ABOUT THE 2ND ROW LEATHER SEATS. THE PAINT ON THE EXTERIOR IS DULL AND SPOTTY, I COMPLAINED TO THE DEALERSHIP BEFORE THE 36,000 MILE WARRANTY EXPIRED AND NOTHING WAS DONE ABOUT THE PAINT EITHER. THIS SUV IS A LEMON, IT CONTINUES TO CUT OFF ALTHOUGH MANY ATTEMPTS HAS BEEN MADE TO REPAIR THE PROBLEM, I THINK THEY SHOULD BUY THIS VEHICLE BACK SINCE IT CAN'T BE FIXED. THERE IS A DEFECT IN THE ELECTRICAL SYSTEM SINCE THESE LIGHTS ON THE INSTRUMENT PANEL CONTINUES TO WEAR OUT VERY FAST AND THE RADIO HAD TO BE REPLACED ALREADY BUT THE LIGHTS CONTINUES TO BLOW OUT ON THE INSTRUMENT PANEL AND THE STEERING WHEEL WHICH ALSO CONTROLS THE RADIO AND OTHER COMPONENTS. *TR
THE SPEEDOMETER HAS BECOME ERRATIC ON MY 2004 GMC ENVOY XUV. I WAS TOLD BY A DEALERSHIP IT WILL REQUIRE REPLACEMENT IN THE RANGE OF 300 DOLLARS JUST FOR PARTS. THIS APPEARS TO BE A MANUFACTURING DEFECT THAT CONVENIENTLY APPEARS SHORTLY AFTER THE EXPIRATION OF THE WARRANTY. FROM WEB POSTS IT IS OBVIOUSLY A WIDESPREAD PROBLEM THAT…
Read full complaint
THE SPEEDOMETER HAS BECOME ERRATIC ON MY 2004 GMC ENVOY XUV. I WAS TOLD BY A DEALERSHIP IT WILL REQUIRE REPLACEMENT IN THE RANGE OF 300 DOLLARS JUST FOR PARTS. THIS APPEARS TO BE A MANUFACTURING DEFECT THAT CONVENIENTLY APPEARS SHORTLY AFTER THE EXPIRATION OF THE WARRANTY. FROM WEB POSTS IT IS OBVIOUSLY A WIDESPREAD PROBLEM THAT SHOULD BE ADDRESSED BY THE MANUFACTURER. I HAVE RECENTLY RECEIVED A SPEEDING TICKET AND MY INSPECTION IS DUE!!!!! *TR
Official recalls
104V527000 · Exterior Lighting:brake Lights
Nov 1, 2004
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence & remedy
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
EA07009 · Fuel Pump Module Leaks Gasoline
Opened Jul 10, 2007 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF COLUMBIA.CONSUMERS IN THE SALT BELT REGION REPORTED TO ODI THAT THEY COULD SMELL FUEL VAPORS IN THEIR VEHICLES WHILE DRIVING.UPON FURTHER EXAMINATION OF THEIR VEHICLES, THEY DISCOVERED THAT FUEL VAPORS WERE COMING OUT OF THE TOP OF THE FUEL TANK. THIS CONDITION IS CAUSED BY CORROSION OF THE RETURN AND SENDER LINES OF THE FUEL PUMP MODULE.WATER AND ROAD SALT COLLECT ON TOP OF THE FUEL PUMP LEADING TO SMALL PINHOLES APPEARING ON THE FUEL LINES.FUEL MAY LEAK AND COLLECT ON TOP OF THE MODULE AND/OR SPILL ONTO THE GROUND.THE DATA EVALUATED UNDER THIS INVESTIGATION REFLECT A RELATIVELY LOW FREQUENCY OF OCCURRENCE THAT LARGELY ARISES IN SALT BELT STATES.GM HAS EXTENDED THE WARRANTY ON THE SUBJECT COMPONENT TO TEN YEARS OR 120,000 MILES.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SELECT DOCUMENT SEARCH.
PE05006 · Turn Signal Failures
Opened Feb 4, 2005 · Closed May 6, 2005
Status: closed (inferred from source dates) · Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit; Exterior Lighting:turn Signal:switch
BY LETTER DATED APRIL 29, 2005, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING ASAFETY RECALL ( NHTSA RECALL NO. 05V198 ) INVOLVING CERTAIN MODEL YEARS (MY) 2003-2004 ISUZU ASCENDER, CHEVROLET TRAILBLAZER, GMC ENVOY, OLDSMOBILE BRAVADA AND MY 2004 BUICK RAINER VEHICLES.THE RECALL APPLIES TO VEHICLES BUILT FROM APRIL 2003 THROUGH NOVEMBER 2003 FOR A TOTAL VEHICLE POPULATION OF 286,478.GM REPORTS THE DIRECTIONAL/HAZARD SIGNALS FAILURE IS DUE TO STICKING CONTACTS ON ROUTING RELAYS IN THE FLASHER MODULE.GM WILL REPLACE THE FLASHER MODULE ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (3)
Exterior Lighting:turn Signal:flasher Unit
BY LETTER DATED APRIL 29, 2005, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING ASAFETY RECALL ( NHTSA RECALL NO. 05V198 ) INVOLVING CERTAIN MODEL YEARS (MY) 2003-2004 ISUZU ASCENDER, CHEVROLET TRAILBLAZER, GMC ENVOY, OLDSMOBILE BRAVADA AND MY 2004 BUICK RAINER VEHICLES.THE RECALL APPLIES TO VEHICLES BUILT FROM APRIL 2003 THROUGH NOVEMBER 2003 FOR A TOTAL VEHICLE POPULATION OF 286,478.GM REPORTS THE DIRECTIONAL/HAZARD SIGNALS FAILURE IS DUE TO STICKING CONTACTS ON ROUTING RELAYS IN THE FLASHER MODULE.GM WILL REPLACE THE FLASHER MODULE ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED APRIL 29, 2005, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING ASAFETY RECALL ( NHTSA RECALL NO. 05V198 ) INVOLVING CERTAIN MODEL YEARS (MY) 2003-2004 ISUZU ASCENDER, CHEVROLET TRAILBLAZER, GMC ENVOY, OLDSMOBILE BRAVADA AND MY 2004 BUICK RAINER VEHICLES.THE RECALL APPLIES TO VEHICLES BUILT FROM APRIL 2003 THROUGH NOVEMBER 2003 FOR A TOTAL VEHICLE POPULATION OF 286,478.GM REPORTS THE DIRECTIONAL/HAZARD SIGNALS FAILURE IS DUE TO STICKING CONTACTS ON ROUTING RELAYS IN THE FLASHER MODULE.GM WILL REPLACE THE FLASHER MODULE ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED APRIL 29, 2005, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING ASAFETY RECALL ( NHTSA RECALL NO. 05V198 ) INVOLVING CERTAIN MODEL YEARS (MY) 2003-2004 ISUZU ASCENDER, CHEVROLET TRAILBLAZER, GMC ENVOY, OLDSMOBILE BRAVADA AND MY 2004 BUICK RAINER VEHICLES.THE RECALL APPLIES TO VEHICLES BUILT FROM APRIL 2003 THROUGH NOVEMBER 2003 FOR A TOTAL VEHICLE POPULATION OF 286,478.GM REPORTS THE DIRECTIONAL/HAZARD SIGNALS FAILURE IS DUE TO STICKING CONTACTS ON ROUTING RELAYS IN THE FLASHER MODULE.GM WILL REPLACE THE FLASHER MODULE ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA04021 · Brake Lamp Failure
Opened Aug 3, 2004 · Closed Nov 4, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
GM STATES THAT SOME BRAKE/TAIL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO MALFUNCTIONING BRAKE/TAIL LAMP SOCKETS.ON MARCH 2, 2004, GM INITIATED A 6-YEAR/72,000 MILE SPECIAL POLICY FOR 989,487 SUBJECT VEHICLES TO INSPECT AND REPLACE THE REAR BRAKE/TAIL LAMP BULB SOCKET ASSEMBLIES.ON APRIL 4, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-032) BASED ON CONSUMER COMPLAINTS ALLEGING BRAKE LIGHTS NOT OPERATING WHEN THE BRAKE PEDAL IS DEPRESSED.ON AUGUST 3, 2004 ODI UPGRADED PE04-032 TO AN ENGINEERING ANALYSIS (EA04-021).BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V527) COVERING SUBJECT VEHICLES THAT WERE NOT ALREADY REPAIRED UNDER GM'S SPECIAL POLICY.MY 2004 SUBJECT VEHICLES BUILT AFTER AUGUST 8, 2003 CONTAIN IMPROVED BRAKE LAMP ASSEMBLIES AND ARE NOT INCLUDED IN THE RECALL.GM DEALERS WILL INSTALL THE IMPROVED BRAKE LAMP ASSEMBLY ON SUBJECT VEHICLES BUILT ON AUGUST 8, 2003 AND EARLIER.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.