NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
70 reports87,400 miles · Aug 8, 2006
Fuel System, Gasoline
WHILE FILLING MY 2002 GMC ENVOY, I OBSERVED GAS POURING OUT OF THE TOP OF THE TANK DOWN OVER THE REAR AXLE AND NEAR THE TAILPIPE. I NOTICED THIS BECAUSE THE GAS PUMP DID NOT SHUT OFF AT THE APPROPRIATE LEVEL. I CALLED GMC AND REPORTED IT. THEY WERE AT FIRST RELUCTANT TO GIVE ME THE AGENCY I COULD REPORT THIS TOO BUT AFTER SPE…
Read full complaint
WHILE FILLING MY 2002 GMC ENVOY, I OBSERVED GAS POURING OUT OF THE TOP OF THE TANK DOWN OVER THE REAR AXLE AND NEAR THE TAILPIPE. I NOTICED THIS BECAUSE THE GAS PUMP DID NOT SHUT OFF AT THE APPROPRIATE LEVEL. I CALLED GMC AND REPORTED IT. THEY WERE AT FIRST RELUCTANT TO GIVE ME THE AGENCY I COULD REPORT THIS TOO BUT AFTER SPEAKING TO A SUPERVISOR THEY FINALLY TOLD ME I COULD REPORT THE POSSIBLE DEFECT TO THE NHTSA. *NM
NHTSA ODI #10164986
71,000 miles · Jun 19, 2006
Power Train
TRANSMISSION FAILURE. *JB
NHTSA ODI #10160182
34,000 miles · Mar 4, 2006
Latches/locks/linkages
THE REAR WINDOW ON THE TAILGATE POPS OPEN ABOUT EVERY OTHER MONTH. THE DASHBOARD DISPLAY ADVISES THIS HAS HAPPENED BUT IT CAN BE EASILY HEARD WHEN THE LATCH POPS. THIS HAS BEEN OCCURRING FOR SEVERAL YEARS. THE DATE BELOW IS THE MOST RECENT OCCURRANCE. *NM
NHTSA ODI #10151796
101,000 miles · Feb 14, 2006
Power Train
DT*: THE CONTACT STATED WHILE EXITING THE EXPRESSWAY AT 45 MPH THE VEHICLE LOST ALL TRANSMISSION CONTROL. THE ENGINE REVVED AND THE VEHICLE COASTED TO A STOP. THE VEHICLE WAS PUT INTO PARK HOWEVER, THE VEHICLE STILL ROLLED. THE VEHICLE WAS TOWED TO A DEALER FOR INSPECTION. UPON INSPECTION THE TRANSFER CASE AND MODULE NEEDED…
Read full complaint
DT*: THE CONTACT STATED WHILE EXITING THE EXPRESSWAY AT 45 MPH THE VEHICLE LOST ALL TRANSMISSION CONTROL. THE ENGINE REVVED AND THE VEHICLE COASTED TO A STOP. THE VEHICLE WAS PUT INTO PARK HOWEVER, THE VEHICLE STILL ROLLED. THE VEHICLE WAS TOWED TO A DEALER FOR INSPECTION. UPON INSPECTION THE TRANSFER CASE AND MODULE NEEDED TO BE REPLACED. THERE IS A NHTSA RECALL #01V334000, REGARDING THE TRANSMISSION AND TRANSFER CASE. THE VEHICLE HAS THE SAME PROBLEM AS INDICATED IN THE RECALL HOWEVER; IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN. NO REPAIRS HAVE BEEN MADE.
NHTSA ODI #10150283
Mileage unknown · Feb 2, 2006
Power Train
THE CABLE CONNECTING THE SHIFT LEVER TO THE TRANSMISSION PULLED LOSE AND LOCKED THE TRANSMISSION IN THE PRE-FAILURE STATE. IF THIS HAPPENS WHEN SOMEONE IS SHIFTING INTO PARK, THEY MAY NOT REALIZE THAT THE TRANSMISSION DID NOT GO INTO PARK AND THE VEHICLE COULD ROLL CAUSING AN ACCIDENT. THE PLASTIC CONNECTOR ON THE SHIFT CABLE IS…
Read full complaint
THE CABLE CONNECTING THE SHIFT LEVER TO THE TRANSMISSION PULLED LOSE AND LOCKED THE TRANSMISSION IN THE PRE-FAILURE STATE. IF THIS HAPPENS WHEN SOMEONE IS SHIFTING INTO PARK, THEY MAY NOT REALIZE THAT THE TRANSMISSION DID NOT GO INTO PARK AND THE VEHICLE COULD ROLL CAUSING AN ACCIDENT. THE PLASTIC CONNECTOR ON THE SHIFT CABLE IS LOCATED VERY CLOSE TO THE EXHAUST PIPE AND APPEARS TO LOSE HIGH TEMP OVER TIME. (THE EARS PULLED THROUGH). *JB
NHTSA ODI #10149304
30,000 miles · Dec 2, 2005
Service Brakes, Hydraulic
DT: THE CONTACT STATES THE ABS BRAKES ARE NOT ACTIVATING PROPERLY. THE BRAKES WILL NOT HOLD. THE VEHICLE WAS TAKEN TO THE DEALERSHIP MULTIPLE TIMES. THEY HAVE BEEN UNABLE TO DIAGNOSE THE CAUSE OF THE PROBLEM. *AK
NHTSA ODI #10144219
62,000 miles · Oct 25, 2005
Power Train
IN 10 DAYS, HAD THE TRANSMISSION GO OUT ($3200), EXHAUST MANIFOLD GASKETS START LEAKING ($400), 4WD SWITCH ($250), AUTOMATIC TRANSMISSION PARK LOCK IN STEERING COLUMN ($250) AND NOW I HAVE A 4WD SERVICE LIGHT ON. THE DEALER HAS BEEN TOTALLY UNHELPFUL. ALTHOUGH I AM AN ENGINEER AT A TIER 1 U.S. AUTO SUPPLIER, I WILL BE LOOKING …
Read full complaint
IN 10 DAYS, HAD THE TRANSMISSION GO OUT ($3200), EXHAUST MANIFOLD GASKETS START LEAKING ($400), 4WD SWITCH ($250), AUTOMATIC TRANSMISSION PARK LOCK IN STEERING COLUMN ($250) AND NOW I HAVE A 4WD SERVICE LIGHT ON. THE DEALER HAS BEEN TOTALLY UNHELPFUL. ALTHOUGH I AM AN ENGINEER AT A TIER 1 U.S. AUTO SUPPLIER, I WILL BE LOOKING OVERSEAS FOR MY NEXT CAR. *JB
NHTSA ODI #10140749
62,000 miles · Oct 25, 2005
Power Train
MY 2002 GMC ENVOY SEEMED TO BE RUNNING FINE. ONE DAY ON THE WAY HOME, I HEARD A LOUD BANG AND MY RPM'S SEEMED TO GO UP. IT ALMOST MADE ME SWERVE INTO ONCOMING TRAFFIC DUE TO THE DISTRACTION. WHEN I GOT TO WHERE I WAS GOING, I FOUND OUT THAT I HAD NO REVERSE, AND IT SHIFTED EXTREMELY HARD BETWEEN 1ST AND 2ND GEAR. DEALER TOLD …
Read full complaint
MY 2002 GMC ENVOY SEEMED TO BE RUNNING FINE. ONE DAY ON THE WAY HOME, I HEARD A LOUD BANG AND MY RPM'S SEEMED TO GO UP. IT ALMOST MADE ME SWERVE INTO ONCOMING TRAFFIC DUE TO THE DISTRACTION. WHEN I GOT TO WHERE I WAS GOING, I FOUND OUT THAT I HAD NO REVERSE, AND IT SHIFTED EXTREMELY HARD BETWEEN 1ST AND 2ND GEAR. DEALER TOLD ME THEY NEVER HEARD OF IT, BUT IT NEEDED A SUN GEAR, APPROXIMATELY $2,000 TO FIX. I OPTED FOR THE NEW TRANNY FOR $3,200. *JB
NHTSA ODI #10140746
65,097 miles · Oct 25, 2005
Engine And Engine Cooling
I WAS DRIVING ON MECHANICSVILLE ROAD AT 45 MPH AS IS THE SPEED LIMIT THERE. THE CAR LURCHED TO A STOPPED. THE EMERGENCY MESSAGE READ, "MAJOR BRAKE FAILURE, GO IMMEDIATELY TO THE DEALER. THE SERVICE MANAGER SAID HE HAD ONE SUCH INCIDENT WITH A GENTLEMAN EARLIER, AND IT WAS A BREAK IN THE GASKET LEAKING OIL ONTO THE BRAKE SENSO…
Read full complaint
I WAS DRIVING ON MECHANICSVILLE ROAD AT 45 MPH AS IS THE SPEED LIMIT THERE. THE CAR LURCHED TO A STOPPED. THE EMERGENCY MESSAGE READ, "MAJOR BRAKE FAILURE, GO IMMEDIATELY TO THE DEALER. THE SERVICE MANAGER SAID HE HAD ONE SUCH INCIDENT WITH A GENTLEMAN EARLIER, AND IT WAS A BREAK IN THE GASKET LEAKING OIL ONTO THE BRAKE SENSOR SOAKING IT WITH OIL THAT LEAD TO THIS FAILURE. IT TURNS OUT THAT IS WHAT EXACTLY LEAD TO MY BRAKE FAILURE. THE GASKET BROKE AND LEAKED OIL ONTO THE BREAK SENSOR CAUSING THE BREAKS TO FAIL.
NHTSA ODI #10140713
35,000 miles · Oct 18, 2005
Service Brakes, Hydraulic
BRAKE ROTORS RUST FROM THE INSIDE OUT.*JB
NHTSA ODI #10140072
Official recalls
3Oct 27, 2005
CERTAIN SPORT UTILITY VEHICLES HAVE A REAR SIDE CLOSURE LATCH THAT MAY NOT LATCH OR UNLATCH DUE TO CORROSION CAUSED BY ROAD SPLASH, SUCH AS WATER AND ROAD SALT. THESE VEHICLES WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA.
Consequence & remedy
Consequence: IF THE DOOR IS NOT LATCHED PROPERLY AND IT GOES UNNOTICED, IT MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN UNBELTED OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A SEAL ALONG THE LOWER PART OF THE ROCKER PANEL TO PREVENT INTRUSION OF CORROSIVE MATERIAL, AND INSPECT THE REAR SIDE CLOSURE LATCHES. FUNCTIONAL LATCHES WILL BE CLEANED AND LUBRICATED. NON-FUNCTIONING LATCHES WILL BE REPLACED. THE RECALL BEGAN ON FEBRUARY 24, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR ISUZU AT 1-800-255-6727.
Nov 1, 2004
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence & remedy
Consequence: AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
Feb 4, 2004
CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.
Consequence & remedy
Consequence: DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR GMC AT 1-866-996-9463.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
EA07009 · Fuel Pump Module Leaks Gasoline
Opened Jul 10, 2007 · Closed Aug 28, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF COLUMBIA.CONSUMERS IN THE SALT BELT REGION REPORTED TO ODI THAT THEY COULD SMELL FUEL VAPORS IN THEIR VEHICLES WHILE DRIVING.UPON FURTHER EXAMINATION OF THEIR VEHICLES, THEY DISCOVERED THAT FUEL VAPORS WERE COMING OUT OF THE TOP OF THE FUEL TANK. THIS CONDITION IS CAUSED BY CORROSION OF THE RETURN AND SENDER LINES OF THE FUEL PUMP MODULE.WATER AND ROAD SALT COLLECT ON TOP OF THE FUEL PUMP LEADING TO SMALL PINHOLES APPEARING ON THE FUEL LINES.FUEL MAY LEAK AND COLLECT ON TOP OF THE MODULE AND/OR SPILL ONTO THE GROUND.THE DATA EVALUATED UNDER THIS INVESTIGATION REFLECT A RELATIVELY LOW FREQUENCY OF OCCURRENCE THAT LARGELY ARISES IN SALT BELT STATES.GM HAS EXTENDED THE WARRANTY ON THE SUBJECT COMPONENT TO TEN YEARS OR 120,000 MILES.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SELECT DOCUMENT SEARCH.
PE07014 · Fuel Tank Leak
Opened Mar 13, 2007 · Closed Jun 12, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline:storage:tank Assembly
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
IN JUNE 2007, GM WILL EXPAND ITS SPECIAL POLICY TO ADDRESS FUEL TANK INLET CHECK VALVE (ICV) FRACTURES ON CERTAIN MODEL YEAR (MY) TRAILBLAZER EXT AND GMC ENVOY XL VEHICLES.THE EXPANDED POLICY COVERS MY 2002-2004 TRAILBLAZER EXT, GMC ENVOY XL, AND GMC ENVOY XUV VEHICLES AND WILL EXTEND FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER COMES FIRST).GM WILL PROVIDE FREE REPAIR OF THE FUEL TANK. IT IS SENDING LETTERS TO OWNERS BEGINNING IN JUNE OF 2007.THIS ACTION SUPERSEDES GM'S PREVIOUS 7 YEAR/70,000 MILE SPECIAL POLICY FOR MY 2002 TRAILBLAZER EXT AND ENVOY XL VEHICLES.THE CONDITION IS MOST OFTEN REPORTED AS ILLUMINATION OF THE SERVICE ENGINE SOON (SES) LIGHT.THE VEHICLE'S DIAGNOSTIC SYSTEM DETECTS THE PRESENCE OF A FUEL SYSTEM PRESSURE LEAK AND ILLUMINATES THE SES LIGHT.OTHER OWNERS REPORT SMELLING GASOLINE FUMES. THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE07013 · Fuel Pump Module Leaks Gasoline
Opened Mar 12, 2007 · Closed Jul 10, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
ODI HAS RECEIVED REPORTS THAT THE FUEL PUMP MODULE LEAKS FUEL AND OR VAPOR UNDERNEATH THE VEHICLE.GM STATES, THE FAILURE MECHANISM IS CORROSION OF THE FUEL PUMP MODULE FLANGE WHICH MAY LEAD TO A FUEL LEAK.CORROSION OF THE FUEL PUMP MODULE FLANGE IS THE RESULT OF THE VEHICLE OPERATING IN A CORROSIVE ENVIRONMENT.ODI HAS UPGRADED THIS PE TO ENGINEERING ANALYSIS (EA07-009) TO FURTHER ASSESS THIS ISSUE.
EA04021 · Brake Lamp Failure
Opened Aug 3, 2004 · Closed Nov 4, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
GM STATES THAT SOME BRAKE/TAIL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO MALFUNCTIONING BRAKE/TAIL LAMP SOCKETS.ON MARCH 2, 2004, GM INITIATED A 6-YEAR/72,000 MILE SPECIAL POLICY FOR 989,487 SUBJECT VEHICLES TO INSPECT AND REPLACE THE REAR BRAKE/TAIL LAMP BULB SOCKET ASSEMBLIES.ON APRIL 4, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-032) BASED ON CONSUMER COMPLAINTS ALLEGING BRAKE LIGHTS NOT OPERATING WHEN THE BRAKE PEDAL IS DEPRESSED.ON AUGUST 3, 2004 ODI UPGRADED PE04-032 TO AN ENGINEERING ANALYSIS (EA04-021).BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V527) COVERING SUBJECT VEHICLES THAT WERE NOT ALREADY REPAIRED UNDER GM'S SPECIAL POLICY.MY 2004 SUBJECT VEHICLES BUILT AFTER AUGUST 8, 2003 CONTAIN IMPROVED BRAKE LAMP ASSEMBLIES AND ARE NOT INCLUDED IN THE RECALL.GM DEALERS WILL INSTALL THE IMPROVED BRAKE LAMP ASSEMBLY ON SUBJECT VEHICLES BUILT ON AUGUST 8, 2003 AND EARLIER.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Illustration