IllustrationCONCERNS REGARDING NO KEY LOCK ON THE PASSENGER SIDE OF THE 2004 GMC CANYON.*MR THIS VEHICLE HAS MANUAL DOOR LOCKS, AN A KEY LOCK IS NO LONGER PROVIDED ON THE RIGHT DOOR. CONSUMER STATES THIS COULD BE A PROBLEM IN THE EVENT THAT EMERGENCY ACCESS WERE REQUIRED. *BF *NM
2004 GMC Canyon
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 GMC Canyon do not stand out strongly from the model-year median of 38.
About this comparison →How this year compares
Owner complaints by model year
Compare all Canyon years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
110–25K
725–50K
1150–75K
1275–100K
10100–150K
6150K+
57 reports with mileage · 23 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports4 fire reports1 injury reports
Latches/locks/linkages complaints
4 reportsI RECENTLY PURCHASED A BASIC 2004 GMC CANYON (I.E., NO POWER WINDOWS/LOCKS). I WAS NOT INFORMED THAT THE PASSENGER DOOR DID NOT HAVE A KEYED ENTRY. I RECENTLY SAW ANOTHER COMPLAINT REGARDING THE SAME ISSUE ON THE NHTSA WEBSITE AND HAVE SEEN OTHER COMMENTS ON OTHER WEBSITES. ADDITIONALLY, A FRIEND ALSO BOUGHT A BASIC 2004 COL…
Read full complaint
I RECENTLY PURCHASED A BASIC 2004 GMC CANYON (I.E., NO POWER WINDOWS/LOCKS). I WAS NOT INFORMED THAT THE PASSENGER DOOR DID NOT HAVE A KEYED ENTRY. I RECENTLY SAW ANOTHER COMPLAINT REGARDING THE SAME ISSUE ON THE NHTSA WEBSITE AND HAVE SEEN OTHER COMMENTS ON OTHER WEBSITES. ADDITIONALLY, A FRIEND ALSO BOUGHT A BASIC 2004 COLORADO AND WAS NOT INFORMED OF THE LACK OF THIS FEATURE. ASIDE FROM THE NUISANCE IN NOT BEING ABLE TO OPEN THE DOOR DIRECTLY, I AGREE WITH THE OTHER COMPLAINT ON THE NHTSA WEBSITE THAT THIS IS A POTENTIAL SAFETY ISSUE IF THE DRIVER'S SIDE DOOR IS BLOCKED AND A CHILD OR OTHER PERSON BECOMES INJURED OR SICK AND YOU CANNOT OPEN THE PASSENGER SIDE DOOR. PERSONALLY, I BELIEVE THAT GMC SHOULD OFFER TO CORRECT THIS PROBLEM ON THESE BASIC TRUCKS OR AT LEAST OFFER THE MODIFICATION AT A REASONABLE PRICE. I E-MAILED GMC REGARDING THIS ISSUE BUT THE RESPONSE BASICALLY SKIRTED THE ISSUE. I ALSO INCLUDED THE ABOVE COMMENTS TO GMC ON THE CUSTOMER SATISFACTION FORM.*AK
THERE IS NO KEY LOCK CYLINDER ON THE PASSENGER SIDE DOOR.*MR *NM
I OWN A 2004 GMC CANYON, AND SOMEONE PARKED TOO CLOSE TO MY DRIVERSIDE FOR ME TO GET INTO THE VEHICLE, WHEN I WENT TO THE PASSENGERS SIDE I DISCOVERED THERE WAS NO LOCK IN THE PASSENGER DOOR. I DO NOT HAVE KEYLESS ENTRY. I WAS TRYING TO GET INTO THE VEHICLE TO REACH MY MEDICATION. I HAD NO WAY INTO THE VEHICLE. THE DEALER DID NO…
Read full complaint
I OWN A 2004 GMC CANYON, AND SOMEONE PARKED TOO CLOSE TO MY DRIVERSIDE FOR ME TO GET INTO THE VEHICLE, WHEN I WENT TO THE PASSENGERS SIDE I DISCOVERED THERE WAS NO LOCK IN THE PASSENGER DOOR. I DO NOT HAVE KEYLESS ENTRY. I WAS TRYING TO GET INTO THE VEHICLE TO REACH MY MEDICATION. I HAD NO WAY INTO THE VEHICLE. THE DEALER DID NOT DISCLOSE THE ABSENCE OF A PASSENGER SIDE DOOR LOCK. THIS CANNOT BE SAFE, WHAT IF A CHILD WAS IN THE TRUCK.*AK
Official recalls
310V575000 · Child Seat
Nov 18, 2010
GM IS RECALLING CERTAIN MODEL YEAR 2004-2011, CHEVROLET COLORADO, GMC CANYON, MODEL YEAR 2006, ISUZU I-280/I-350, AND MODEL YEAR 2007-2008, I-290/I-370, REGULAR CAB VEHICLES AND EXTENDED CAB VEHICLES WITHOUT A REAR SEAT AND EQUIPPED WITH A FRONT 60/40 SPLIT BENCH SEAT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT IS NOT ACCESSIBLE AND THE OWNER MANUAL DOES NOT INCLUDE INSTRUCTIONS REGARDING HOW TO USE THE TOP TETHER.
Consequence & remedy
Consequence: BOTH NHTSA AND GM DISCOURAGE PLACEMENT OF A CHILD IN A FRONT SEAT. NEVERTHELESS, THERE ARE INDIVIDUAL CIRCUMSTANCES THAT MAY REQUIRE PLACEMENT OF A CHILD IN A RESTRAINT IN THE FRONT CENTER SEATING POSITION OF THIS VEHICLE THAT DOES NOT OFFER A REAR SEAT. LACK OF ACCESS TO THE TOP TETHER ANCHOR AND A LACK OF INSTRUCTIONS AS TO HOW TO USE IT, MAY RESULT IN IMPROPER INSTALLATION OF A CHILD RESTRAINT. IMPROPER INSTALLATION OF A CHILD RESTRAINT CAN RESULT IN A REDUCTION IN THE RESTRAINT'S PERFORMANCE IN THE EVENT OF A CRASH AND AN INCREASED RISK OF INJURY OR DEATH TO THE CHILD SEATED IN THE RESTRAINT.
Remedy: DEALERS WILL CUT A HOLE INTO THE BACK PANEL TRIM COVER TO ALLOW ACCESS TO THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT POSITION AND WILL PROVIDE SUPPLEMENTAL INFORMATION AS TO USE IN THE OWNER'S MANUAL. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR VISIT GM'S WEBSITE AT WWW.GMOWNERCENTER.COM.
09V310000 · Exterior Lighting:brake Lights:switch
Jul 29, 2009
GM IS RECALLING 185,903 MODEL YEAR 2004-2009 COLORADO, GMC MODEL YEAR 2009-2004 CANYON, MODEL YEAR 2006 I-280, I-350, MODEL YEAR 2007-2008 I-290, AND I-370, PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALABAMA, ARIZONA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, PUERTO RICO, SOUTH CAROLINA, TEXAS, U.S. VIRGIN ISLANDS AND UTAH. SOME OF THESE VEHICLES HAVE A BRAKE LAMP SWITCH THAT MAY NOT WORK AS DESIGNED DUE TO CONTAMINATION IN THE SWITCH.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE SIMULTANEOUS LOSS OF ALL BRAKE LAMPS OR CAUSE ALL OF THE BRAKE LAMPS TO STAY ON CONTINUOUSLY. BOTH OF THESE CONDITIONS COULD FAIL TO WARN OTHERS OF THE DRIVER'S INTENTIONS AND COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS AS SPECIFIED IN THE RECALL BULLETIN FREE OF CHARGE. GM ANTICIPATES THAT PARTS WILL BE AVAILABLE BY JUNE 2010. A SPECIAL COVERAGE FOR VEHICLES REGISTERED IN ALL OTHER STATES WILL BE IMPLEMENTED IN THE SAME TIME FRAME. IN THE INTERIM, OWNERS WHO EXPERIENCE THE FAILURE CAN OBTAIN A FREE REPAIR, HOWEVER THEY WILL BE REQUIRED TO RETURN WHEN THE NEW DESIGN PART BECOMES AVAILABLE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.
06V139000 · Exterior Lighting:brake Lights:switch
Apr 27, 2006
CERTAIN PICKUP TRUCKS MAY EXPERIENCE THE PERMANENT LOSS OF BRAKE LAMP FUNCTION OR BRAKE LAMPS THAT ARE ILLUMINATED AT ALL TIMES. THE CENTER HIGH-MOUNTED STOP LAMP (CHMSL) IS AFFECTED IN BOTH INSTANCES. ALSO, IF EQUIPPED, THE CRUISE CONTROL WILL BECOME INOPERATIVE. ANY TRAILER BRAKE LAMPS WHICH ARE CONNECTED TO THE VEHICLE'S BRAKE LAMP WIRING WILL MIMIC THE VEHICLE'S BRAKE LAMPS WHEN EITHER CONDITION OCCURS.
Consequence & remedy
Consequence: A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED, AND A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE BRAKE LAMP SWITCH ASSEMBLY. THE RECALL BEGAN ON DECEMBER 5, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463 OR ISUZU AT 1-800-255-6727.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ09001 · Brake Lamp Switch Malfunction
Opened Feb 25, 2009 · Closed Jul 30, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights:switch
ON JULY 28,2009, GM INITIATED A REGIONAL RECALL CAMPAIGN ON CERTAIN MODEL YEAR (MY) 2004-2009 CHEVROLET COLORADO AND GMC CANYON VEHICLES AND MY2006-2008 ISUZU I-SERIES VEHICLES.THE STATES AND U.S. TERRITORIES INVOLVED ARE AL, AZ, FL, GA, HI, LA, MS, NV, NM, PR, SC, TX, VI AND UT.A TOTAL OF 185,903 VEHICLES WILL BE RECALLED WITH 92,272 VEHICLES WITHIN THE SCOPE OF THIS INVESTIGATION.IN ADDITION, A SPECIAL COVERAGE/EXTENDED WARRANTY PROGRAM WILL BE INITIATED FORVEHICLES REGISTERED IN ALL OTHER STATES. GM DETERMINED THAT BRAKE LAMP SWITCH FAILURES ARE MORE LIKELY TO OCCUR IN VEHICLES IN WHICH CUSTOMERS USED INTERIOR CLEANERS CONTAINING SILICON AND THAT RESIDE IN HOT GEOGRAPHICAL LOCATIONS.BRAKE LAMP SWITCH CONTAMINATION FAILURE CAN CAUSE LOSS OF THE BRAKE LAMPS OR THE BRAKE LAMPS TO STAY ON CONTINUOUSLY, INCREASING THE RISK OF REAR-END CRASHES.GM HAS REPORTED NO CRASHES OR INJURIES DUE TO THE FAILURE OF THE BRAKE LAMP SWITCH.ODI INITIALLY REPORTED ONE CRASH INCIDENT, BUT LATER DOWNGRADED THE REPORT DUE TO THE ABSENCE OF ACTUAL PROPERTY DAMAGE OR COST INCURRED WHEN THE VEHICLE WAS LIGHTLY TAPPED FROM BEHIND AT LOW SPEED.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V0310).
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
ON JULY 28,2009, GM INITIATED A REGIONAL RECALL CAMPAIGN ON CERTAIN MODEL YEAR (MY) 2004-2009 CHEVROLET COLORADO AND GMC CANYON VEHICLES AND MY2006-2008 ISUZU I-SERIES VEHICLES.THE STATES AND U.S. TERRITORIES INVOLVED ARE AL, AZ, FL, GA, HI, LA, MS, NV, NM, PR, SC, TX, VI AND UT.A TOTAL OF 185,903 VEHICLES WILL BE RECALLED WITH 92,272 VEHICLES WITHIN THE SCOPE OF THIS INVESTIGATION.IN ADDITION, A SPECIAL COVERAGE/EXTENDED WARRANTY PROGRAM WILL BE INITIATED FORVEHICLES REGISTERED IN ALL OTHER STATES. GM DETERMINED THAT BRAKE LAMP SWITCH FAILURES ARE MORE LIKELY TO OCCUR IN VEHICLES IN WHICH CUSTOMERS USED INTERIOR CLEANERS CONTAINING SILICON AND THAT RESIDE IN HOT GEOGRAPHICAL LOCATIONS.BRAKE LAMP SWITCH CONTAMINATION FAILURE CAN CAUSE LOSS OF THE BRAKE LAMPS OR THE BRAKE LAMPS TO STAY ON CONTINUOUSLY, INCREASING THE RISK OF REAR-END CRASHES.GM HAS REPORTED NO CRASHES OR INJURIES DUE TO THE FAILURE OF THE BRAKE LAMP SWITCH.ODI INITIALLY REPORTED ONE CRASH INCIDENT, BUT LATER DOWNGRADED THE REPORT DUE TO THE ABSENCE OF ACTUAL PROPERTY DAMAGE OR COST INCURRED WHEN THE VEHICLE WAS LIGHTLY TAPPED FROM BEHIND AT LOW SPEED.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V0310).
Exterior Lighting
ON JULY 28,2009, GM INITIATED A REGIONAL RECALL CAMPAIGN ON CERTAIN MODEL YEAR (MY) 2004-2009 CHEVROLET COLORADO AND GMC CANYON VEHICLES AND MY2006-2008 ISUZU I-SERIES VEHICLES.THE STATES AND U.S. TERRITORIES INVOLVED ARE AL, AZ, FL, GA, HI, LA, MS, NV, NM, PR, SC, TX, VI AND UT.A TOTAL OF 185,903 VEHICLES WILL BE RECALLED WITH 92,272 VEHICLES WITHIN THE SCOPE OF THIS INVESTIGATION.IN ADDITION, A SPECIAL COVERAGE/EXTENDED WARRANTY PROGRAM WILL BE INITIATED FORVEHICLES REGISTERED IN ALL OTHER STATES. GM DETERMINED THAT BRAKE LAMP SWITCH FAILURES ARE MORE LIKELY TO OCCUR IN VEHICLES IN WHICH CUSTOMERS USED INTERIOR CLEANERS CONTAINING SILICON AND THAT RESIDE IN HOT GEOGRAPHICAL LOCATIONS.BRAKE LAMP SWITCH CONTAMINATION FAILURE CAN CAUSE LOSS OF THE BRAKE LAMPS OR THE BRAKE LAMPS TO STAY ON CONTINUOUSLY, INCREASING THE RISK OF REAR-END CRASHES.GM HAS REPORTED NO CRASHES OR INJURIES DUE TO THE FAILURE OF THE BRAKE LAMP SWITCH.ODI INITIALLY REPORTED ONE CRASH INCIDENT, BUT LATER DOWNGRADED THE REPORT DUE TO THE ABSENCE OF ACTUAL PROPERTY DAMAGE OR COST INCURRED WHEN THE VEHICLE WAS LIGHTLY TAPPED FROM BEHIND AT LOW SPEED.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V0310).
PE04076 · Inadvertent Front Airbag Deployment
Opened Nov 10, 2004 · Closed Mar 14, 2005
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal
ALL REPORTS INDICATE INADVERTENT DEPLOYMENT DURING IGNITION START-UP (KEY-ON) AND WITH THE VEHICLE NOT IN MOTION.REPORTED INJURIES WERE MINOR AND CONSIST OF SKIN ABRASION AND BRUISES.THE INCIDENT DATES RANGED FROM JULY THROUGH NOVEMBER 2004.ODI HAS RECEIVED NO ADDITIONAL REPORTS SINCE OPENING THIS INVESTIGATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Air Bags:frontal
ALL REPORTS INDICATE INADVERTENT DEPLOYMENT DURING IGNITION START-UP (KEY-ON) AND WITH THE VEHICLE NOT IN MOTION.REPORTED INJURIES WERE MINOR AND CONSIST OF SKIN ABRASION AND BRUISES.THE INCIDENT DATES RANGED FROM JULY THROUGH NOVEMBER 2004.ODI HAS RECEIVED NO ADDITIONAL REPORTS SINCE OPENING THIS INVESTIGATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Air Bags
ALL REPORTS INDICATE INADVERTENT DEPLOYMENT DURING IGNITION START-UP (KEY-ON) AND WITH THE VEHICLE NOT IN MOTION.REPORTED INJURIES WERE MINOR AND CONSIST OF SKIN ABRASION AND BRUISES.THE INCIDENT DATES RANGED FROM JULY THROUGH NOVEMBER 2004.ODI HAS RECEIVED NO ADDITIONAL REPORTS SINCE OPENING THIS INVESTIGATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.