NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
21 reportsClear category filter85,393 miles · Oct 15, 2019
Engine
TL* THE CONTACT OWNS A 2013 GMC ARCADIA. WHILE DRIVING AT LOW SPEEDS AND MAKING A TURN, THE VEHICLE STALLED. ALSO, THE STABILITRAK DISABLE AND TRACTION CONTROL DISABLE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO TEAM ONE CHEVROLET BUICK (1616 LANSING RD, CHARLOTTE, MI 48813, (517) 543-0200) WHERE IT WAS DIAGNOSED TH…
Read full complaint
TL* THE CONTACT OWNS A 2013 GMC ARCADIA. WHILE DRIVING AT LOW SPEEDS AND MAKING A TURN, THE VEHICLE STALLED. ALSO, THE STABILITRAK DISABLE AND TRACTION CONTROL DISABLE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO TEAM ONE CHEVROLET BUICK (1616 LANSING RD, CHARLOTTE, MI 48813, (517) 543-0200) WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE AN ENGINE WAS ORDERED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER:[XXX]. THE FAILURE MILEAGE WAS 85,393. CONSUMER STATED ENGINE WAS REPLACED. ('PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).')*JB
NHTSA ODI #11268736
Mileage unknown · May 10, 2019
Electrical SystemEngineExterior Lighting
I HAVE NEVER HAD TO REPLACE BULBS IN THE HEADLIGHTS IN A VEHICLE I HAVE OWNED. THE HEADLIGHTS IN THIS VEHICLE WERE GOOD ABOUT 2 YEARS. BUT, SINCE THEN I HAVE HAD TO REPLACE BOTH BULBS IN THE HEADLIGHTS EVERY YEAR. AND, I HAVE TO HAVE THE A/C SYSTEM WORKED ON EVERY YEAR AS WELL BEGINNING 3 MONTHS AFTER I PURCHASED IT. PURCHASIN…
Read full complaint
I HAVE NEVER HAD TO REPLACE BULBS IN THE HEADLIGHTS IN A VEHICLE I HAVE OWNED. THE HEADLIGHTS IN THIS VEHICLE WERE GOOD ABOUT 2 YEARS. BUT, SINCE THEN I HAVE HAD TO REPLACE BOTH BULBS IN THE HEADLIGHTS EVERY YEAR. AND, I HAVE TO HAVE THE A/C SYSTEM WORKED ON EVERY YEAR AS WELL BEGINNING 3 MONTHS AFTER I PURCHASED IT. PURCHASING THIS VEHICLE IS THE WORST DECISION I HAVE EVER MADE IN MY LIFE. I AM CONSTANTLY HAVING SOMETHING BREAK. HEADLIGHTS, WHEEL BEARINGS, MOTOR MOUNT, MULTIPLE ISSUES WITH A/C, TRANSMISSION.
NHTSA ODI #11206895
62,700 miles · Jan 11, 2019
Engine
PISTON CONNECTOR ROD PUT A WHOLE IN THE ENGINE AT ONLY 62700 (2700 MILES AFTER OIL CHANGE THAT WAS ALWAYS CHANGED AFTER OIL CHANGE LIGHT CAME ON AROUND EVERY 4500 TO 5000 MILES)MILES ON THE VEHICLE. WE WERE DRIVING AT 70 MPH ON MAJOR HIGHWAY AND SUDDENLY STOP RESPONDING AND WOULD NOT START IN AN AREA THAT ONLY HAD HALF OF EMERGE…
Read full complaint
PISTON CONNECTOR ROD PUT A WHOLE IN THE ENGINE AT ONLY 62700 (2700 MILES AFTER OIL CHANGE THAT WAS ALWAYS CHANGED AFTER OIL CHANGE LIGHT CAME ON AROUND EVERY 4500 TO 5000 MILES)MILES ON THE VEHICLE. WE WERE DRIVING AT 70 MPH ON MAJOR HIGHWAY AND SUDDENLY STOP RESPONDING AND WOULD NOT START IN AN AREA THAT ONLY HAD HALF OF EMERGENCY LANE(SO THE CAR WAS TAKING PART OF TRAVEL LANES) .THIS WAS DECEMBER 27,2018 AT 11:30 PM WITH ME, MY WIFE, OUR 2 KIDS, OUR NEPHEW AND THEIR FRIEND (8, 12,13 AND 14 YEARS OLD) WE WERE COMING BACK FROM A SKI TRIP 1 AND HALF HOUR FROM HOME, IT HAPPENED ABOUT 40 MINUTES AWAY FROM HOME .WE COULD NOT COME OUT THE CAR, IT WAS NOT SAFE PLACE OUT OF THE CAR. STATE POLICE DROVE BY AND DID NOT STOP, I CALLED THEN TO SEND SOMEONE UNTIL TOW TRUCK COME.TOW TRUCK CAME FIRST AFTER AROUND 45 MINUTES.CAR COMPUTER CLUSTER START TO SHOW BATTERY WAS DYING, IT WAS PIT BLACK WITH 18 WHEELER AND CARS FLYING BY. THIS IS A SAFETY ISSUE - DRIVERS WITH FAMILIES SHOULD BE MADE AWARE.I WENT TO THE LOCAL GMC DEALER TO ASK WHY IT HAPPENED SINCE CAR HAS 62700 MILES AND THEY ASK ME IF MY WIFE DOES OFF ROAD I SAID NO.BUT I ASKED MY WIFE TO MAKE SURE SHE SAID NO.BUT TO MAKE DOUBLE AND TRIPLE SURE I ASKED MY 8 YEARS OLD DAUGHTER AND MY 12 YEARS OLD IF THEIR MOTHER DRIVES ON MUD, WATER,BUMP HILLS, WET LAND, SHAKING PLACES AND POT HOLES. THEY SAID NO BUT THAT WOULD BE FUN (LOL). THANK YOU GMC FOR A NICE HOLIDAY GIFT.
NHTSA ODI #11166589
103,000 miles · Oct 24, 2018
EnginePower Train
THESE SYMPTOMS STARTED OVER 2 YEARS AGO AND IS VERY INTERMITTENT. DRIVING ON THE HIGHWAY, THE VEHICLE SUDDENLY LOSES POWER, UNABLE TO ACCELERATE AND THE TRANSMISSION WILL NOT SHIFT OUT OF HIGH GEAR. THE DECREASE IN SPEED IS SIGNIFICANT ENOUGH THAT ON NOW 3 OCCASIONS THE VEHICLE HAS ALMOST NEARLY BEEN REAR-ENDED. ADDITIONALLY…
Read full complaint
THESE SYMPTOMS STARTED OVER 2 YEARS AGO AND IS VERY INTERMITTENT. DRIVING ON THE HIGHWAY, THE VEHICLE SUDDENLY LOSES POWER, UNABLE TO ACCELERATE AND THE TRANSMISSION WILL NOT SHIFT OUT OF HIGH GEAR. THE DECREASE IN SPEED IS SIGNIFICANT ENOUGH THAT ON NOW 3 OCCASIONS THE VEHICLE HAS ALMOST NEARLY BEEN REAR-ENDED. ADDITIONALLY, ON THE INSTRUMENT PANEL THE FOLLOWING INDICATORS AND MESSAGES OCCUR: - "CHECK ENGINE LIGHT" - "TRACTION CONTROL OFF" - "ENGINE POWER IS REDUCED" - "SERVICE TRACTION CONTROL" - "SERVICE STABILITRAK" ADDITIONAL SYMPTOMS: - LOSS OF POWER STEERING - LOSS OF POWER BRAKES ONCE VEHICLE IS TURNED OFF AND SITS FOR A FEW MINUTES. THE VEHICLE WILL START AND ALL OF THE SYMPTOMS ABOVE WILL GO AWAY WITH THE EXCEPTION SOMETIMES OF THE CHECK ENGINE LIGHT. THIS INDICATOR GOES OFF AFTER VEHICLE HAS SAT OVERNIGHT. NOTE THIS OCCURS VERY INFREQUENTLY...SOMETIMES MONTHS IN BETWEEN. AUGUST 2018, DEALERSHIP (CHEV AUTOMATION NORTH, DENVER, CO) DIAGNOSED AS TRANSMISSION PROBLEM. PAID $5800 FOR REPLACEMENT. OCTOBER 22, 2018, ALL OF THE SYMPTOMS DESCRIBED ABOVE OCCURRED AGAIN WHILE ON HIGHWAY NEARLY CRASHING THE VEHICLE. WIFE NOW REFUSES TO DRIVE THE CAR AGAIN. THIS VEHICLE IS TOTALLY UNSAFE. IT IS UNFORTUNATE THAT A FATAL ACCIDENT MUST OCCUR BEFORE ANY REAL ATTENTION IS MADE TO FIXING A PROBLEM OF THIS MAGNITUDE WITH GM VEHICLES.
NHTSA ODI #11142454
40,600 miles · Sep 17, 2018
Engine
PISTON PUT A WHOLE IN THE ENGINE AT ONLY 40,000 MILES ON THE VEHICLE. WE WERE DRIVING AT 70MPH ON MAJOR HIGHWAY. THIS IS A SAFETY ISSUE - DRIVERS SHOULD BE MADE AWARE.
NHTSA ODI #11129912
95,000 miles · Sep 4, 2018
Engine
TL* THE CONTACT OWNS A 2013 GMC ACADIA. WHILE DRIVING 50 MPH, THE VEHICLE SLOWED DOWN AND STALLED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE AND INSTRUCTED THE CONTACT TO CALL NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000.
NHTSA ODI #11124260
101,000 miles · Jul 7, 2017
Electrical SystemElectronic Stability Control (esc)EngineFire
THE SERVICE DEPARTMENT FAILED TO PROPERLY REPAIR MY VEHICLE AND POSSIBLY SOLD MY VEHICLE TO ME WITH PRIOR KNOWLEDGE OF FAULTY "BATTERY CHARGING SYSTEM". I WAS TOLD I JUST NEEDED A NEW BATTERY (WHICH WAS REPLACED TWICE WITHIN THE SAME WEEK). THIS PROCESS BEGAN ON 11/12/2016. I RECEIVED THE SAME ERROR ON MY DASH (BATTERY CHARGING …
Read full complaint
THE SERVICE DEPARTMENT FAILED TO PROPERLY REPAIR MY VEHICLE AND POSSIBLY SOLD MY VEHICLE TO ME WITH PRIOR KNOWLEDGE OF FAULTY "BATTERY CHARGING SYSTEM". I WAS TOLD I JUST NEEDED A NEW BATTERY (WHICH WAS REPLACED TWICE WITHIN THE SAME WEEK). THIS PROCESS BEGAN ON 11/12/2016. I RECEIVED THE SAME ERROR ON MY DASH (BATTERY CHARGING SYSTEM NEEDS SERVICING) AND MY BATTERY HAD TO BE JUMPED JUST LIKE BEFORE ON 4/12/2017. I CONTACTED ONSTAR AND MADE AN APPT.WITH THE SERVICE DEPARTMENT AT MCCARTHY MORSE CHEVROLET FOR THE NEXT MORNING (4/13/2017). HOWEVER I DIDN'T MAKE IT BECAUSE MY CAR WENT UP IN FLAMES IN MY GARAGE ABOUT 15MINS. AFTER ME AND MY CHILDREN GOT OUT OF IT!!!! OTHER ISSUES THAT WERE ADDRESSED DURING THIS 6MO. TIME FRAME INCLUDED: A/C REPLACEMENT, HEAD GASKETS AND HEAD BOLTS REPLACEMENT, TIMING CHAIN AND CAM SHAFT ACTUATORS REPLACEMENT, AND FLYWHEEL REPLACEMENT. I FEEL LIKE THE SERVICES DEPARTMENT HAD PRIOR KNOWLEDGE OF THESE ISSUES AND DIDN'T CORRECT THEM BEFORE EITHER.
NHTSA ODI #11003735
70,000 miles · Jun 15, 2017
Electrical SystemEngine
TL* THE CONTACT OWNS A 2013 GMC ACADIA. WHILE DRIVING 70 MPH, THE VEHICLE DECELERATED TO 40 MPH AND THE TRACTION CONTROL, STABILITY CONTROL, AND ENGINE REDUCED POWER WARNING INDICATORS ILLUMINATED AFTER THE FAILURE OCCURRED. THE ENGINE FAILED AND THE VEHICLE WAS TOWED TO THE DEALER (JACK MAXTON CHEVROLET EAST DUBLIN ROAD COLUMBU…
Read full complaint
TL* THE CONTACT OWNS A 2013 GMC ACADIA. WHILE DRIVING 70 MPH, THE VEHICLE DECELERATED TO 40 MPH AND THE TRACTION CONTROL, STABILITY CONTROL, AND ENGINE REDUCED POWER WARNING INDICATORS ILLUMINATED AFTER THE FAILURE OCCURRED. THE ENGINE FAILED AND THE VEHICLE WAS TOWED TO THE DEALER (JACK MAXTON CHEVROLET EAST DUBLIN ROAD COLUMBUS, OHIO, 43229, 614-681-0129) WHERE IT WAS DIAGNOSED THAT THE COMPUTER SYSTEM FAILED DUE TO THE THROTTLE BODY. THE COMPOSITION SENSOR WAS REPROGRAMMED AND THE THROTTLE BODY WAS REPLACED. THE FAILURE WAS NOT CORRECTED AND RECURRED AFTER THREE MONTHS. THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER FOR DIAGNOSTIC TESTING AND A FAILURE CODE WAS PRODUCED AT THE FUSE BOX. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
NHTSA ODI #10995328
50,720 miles · Jun 9, 2017
EnginePower TrainUnknown Or Other
WHILE DRIVING THE CAR IT LOST POWER, ALL THE DASH LIGHT WENT OFF, THEN THE POWER STEERING SHUT DOWN, WHILE DRIVING 45 MILES AN HR. ONCE ABLE TO PULL OVER, THE CAR SHUT DOWN AND COULD NOT START BACK UP. THE KEY WOULD NOT COME OUT OF IGNITION. HAD IT TOWED TO THE LOCAL DEALER THE CAR WAS BOUGHT FROM. THEY REPORTED IT WAS THE ENGIN…
Read full complaint
WHILE DRIVING THE CAR IT LOST POWER, ALL THE DASH LIGHT WENT OFF, THEN THE POWER STEERING SHUT DOWN, WHILE DRIVING 45 MILES AN HR. ONCE ABLE TO PULL OVER, THE CAR SHUT DOWN AND COULD NOT START BACK UP. THE KEY WOULD NOT COME OUT OF IGNITION. HAD IT TOWED TO THE LOCAL DEALER THE CAR WAS BOUGHT FROM. THEY REPORTED IT WAS THE ENGINE CONTROL MODULE WHICH THEY REPLACED BUT THE CAR STILL WILL NOT TURN ON. NOW THE SAY IT IS AN ELECTRICAL SHORT AND CAN'T FIND IT.. THIS CAR IS DANGEROUS TO DRIVE AS THIS IS THE SECOND TIME THIS HAS HAPPENED AND WE FEEL THAT THEY ARE JUST GIVING US THE RUN AROUND. THIS CAR HAS BEEN IN THE SHOP MULTIPLE TIMES AND NEVER FIXED PROPERLY
NHTSA ODI #10994131
1,000 miles · Jan 16, 2015
Electrical SystemEngineSteering
MY VEHICLE HAS COMPLETELY SHUT OFF 4 TIMES IN THE PAST 2 YEARS WHILE DRIVING, THANK GOD THERE WAS NO ACCIDENT. ALSO MY POWER DOOR LOCKS HAVE LOCKED AND UNLOCKED REPEATEDLY BY THEMSELVES WITHOUT PRESSING ANY BUTTON IN VEHICLE OR KEY FOB. THE LOCKS WILL GO UP AND DOWN UNTIL I SHUT THE CAR OFF AND THEN RESTART. THE LOCKS HAS HAPPE…
Read full complaint
MY VEHICLE HAS COMPLETELY SHUT OFF 4 TIMES IN THE PAST 2 YEARS WHILE DRIVING, THANK GOD THERE WAS NO ACCIDENT. ALSO MY POWER DOOR LOCKS HAVE LOCKED AND UNLOCKED REPEATEDLY BY THEMSELVES WITHOUT PRESSING ANY BUTTON IN VEHICLE OR KEY FOB. THE LOCKS WILL GO UP AND DOWN UNTIL I SHUT THE CAR OFF AND THEN RESTART. THE LOCKS HAS HAPPENED 6 TIMES. ALSO, MY ELECTRIC POWER STEERING GEAR(RACK) NEEDED TO BE REPLACED AT 30000 MILES. THERE WERE 2 RECALLS ONE FOR AIRBAGS AND ONE FOR SEATBELTS. THIS VEHICLE IS UNSAFE AND FRANKLY DANGEROUS, THANK GOD IT NEVER SHUT OFF ON A HIGHWAY. I HAVE BROUGHT IT TO TWO DIFFERENT GMC DEALER SERVICE CENTERS AND THEY CAN NOT DIAGNOSE OR RECREATE THE PROBLEM WHICH MEANS THEY CANNOT FIX THESE PROBLEMS. I DON'T KNOW IF THIS IS ISOLATED TO JUST MY VEHICLE OR THIS IS A PROBLEM RELATED TO THIS PARTICULAR MODEL AND YEAR CAR. I DO NOT FEEL SAFE DRIVING THIS CAR, PLEASE HELP US. THANK YOU. *TR
NHTSA ODI #10673035
Official recalls
3Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration