NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
21 reportsClear category filterMileage unknown · Jul 10, 2025
Engine
I bought a 2013 gmc Acadia with a 3.6l engine and I was driving it home, and the engine locked up on me, and it didn’t throw a code or anything, it just shut off and wouldn’t start back up, and later I find out that it had an oil leak from somewhere and now I have to have the engine replaced, which is 13k dollars, the vehicle is…
Read full complaint
I bought a 2013 gmc Acadia with a 3.6l engine and I was driving it home, and the engine locked up on me, and it didn’t throw a code or anything, it just shut off and wouldn’t start back up, and later I find out that it had an oil leak from somewhere and now I have to have the engine replaced, which is 13k dollars, the vehicle is located at walker Chevrolet in nitro wv, I’m a single dad of 5 children and I can’t afford to fix this vehicle at that price, I asked if they could take payments to replace it, and they said not and that they would NOT Release the vehicle back to me until it is paid for, and now I’m stranded with 5 children with no way to go to the store or anything. The engine locked up on me in the middle of the four lane in st albans wv, and I almost got hit by vehicles that were behind me and everything.
NHTSA ODI #11672571
92,000 miles · Mar 21, 2025
Electrical SystemEngineTraction Control System
The contact owns a 2013 GMC Acadia. The contact stated that the vehicle was intermittently difficult to start. Additionally, the contact stated that while driving at various speeds, the vehicle stalled. The check engine and traction control warning lights were illuminated. The vehicle was taken to an independent mechanic, where …
Read full complaint
The contact owns a 2013 GMC Acadia. The contact stated that the vehicle was intermittently difficult to start. Additionally, the contact stated that while driving at various speeds, the vehicle stalled. The check engine and traction control warning lights were illuminated. The vehicle was taken to an independent mechanic, where the alternator, stabilizer, starter, ignition switch, door panel, axle, MAP sensor, canister valve, gas cap, and power master window switch were replaced. The mechanic determined that the failure was related to the fuse box. The dealer was notified of the failure and informed the contact that the VIN was not included in a recall related to the electrical system. The contact used a diagnostic scanner to scan the vehicle but was unable to retrieve any diagnostic trouble codes. The manufacturer was not notified of the failure. The failure mileage was approximately 92,000.
NHTSA ODI #11649804
Mileage unknown · Apr 10, 2024
Electrical SystemEngineUnknown Or OtherFire
My 2013 GMC ACADIA started fire on April 9, 2024 around 11PM in the driveway of our home. The vehicle was parked and off. The vehicle wasn’t used during the day. The last day of use was on April 8, 2024 around 6PM. The fire department stated it was potentially an electrical fire within the engine of the vehicle.
NHTSA ODI #11582226
Mileage unknown · Dec 12, 2023
EnginePower TrainVehicle Speed Control
At 35-40 and 55-65 mph, the car slips/ pulls back. I took it to the dealer, my rep said it is a known issue and GMC issued a bulletin but will not recall it because it's too expensive. There are thousands of reports online. Please investigate.
NHTSA ODI #11559683
Mileage unknown · Jun 11, 2023
Air BagsElectrical SystemEngine
Battery saver mode activated dinged then car talked to me. I've replaced the alternator and brand new battery.....car battery draining FAST n only pulling 11.03 volts when it's supposed hit 14.5-15.5volts. Also air bag lite is on saying service airbag. I've only had the car 3 months....bought it from a dealer march 13th n till 2…
Read full complaint
Battery saver mode activated dinged then car talked to me. I've replaced the alternator and brand new battery.....car battery draining FAST n only pulling 11.03 volts when it's supposed hit 14.5-15.5volts. Also air bag lite is on saying service airbag. I've only had the car 3 months....bought it from a dealer march 13th n till 2-3 days ago been working fine. Now saying service air bag n battery saver mode activated. I have no clue to this .....I'm lost after replacing the battery n alternator.
NHTSA ODI #11526464
Mileage unknown · Apr 29, 2023
Engine
Unknown. Engine blew. Was determined by independent service provider. Vehicle wouldn’t start and blew white smoke from the exhaust.
NHTSA ODI #11519598
Mileage unknown · Apr 18, 2023
EnginePower TrainUnknown Or Other
I dont know exactly what is wrong but from online videos i think power train or transmission. When driving the vehicle will struggle/delay shifting. When it does finally shift its so hard it throws u forward. When having to quickly get on the gas it will delay to where your not really moving. This almost caused accidents multipl…
Read full complaint
I dont know exactly what is wrong but from online videos i think power train or transmission. When driving the vehicle will struggle/delay shifting. When it does finally shift its so hard it throws u forward. When having to quickly get on the gas it will delay to where your not really moving. This almost caused accidents multiple times. ( not pulling out in front of people) entering interstate is a good exsample. It has also lost power when crossing intersection!
NHTSA ODI #11517617
Mileage unknown · Mar 1, 2022
EnginePower TrainUnknown Or Other
After having for just under a year the transmission seems to be acting up when going from 2nd to 3rd gear around 30mph to 40mph. After reading several forms it seems this is a common occurrence in these vehicles.. not sure if it’s been reported but all the forms are showing people had to spend a good amount to determine what the…
Read full complaint
After having for just under a year the transmission seems to be acting up when going from 2nd to 3rd gear around 30mph to 40mph. After reading several forms it seems this is a common occurrence in these vehicles.. not sure if it’s been reported but all the forms are showing people had to spend a good amount to determine what the issue is and seems that everyone had to replace the transmissions for the problem to go away. I’m not sure how everything works but feel it should be looked at maybe.
NHTSA ODI #11454610
Mileage unknown · May 4, 2021
EngineFuel/propulsion SystemPower Train
WHEN DRIVING IN TRAFFIC AND SLOWING DOWN OR COMING TO A STOP. THE VEHICLE GOES COMPLETELY DEAD. I WILL HAVE TO RESTART AT EACH STOP. WHEN IT DOES START, IT IS NOT A SMOOTH TAKE OFF, IT IS EXTREMELY ROUGH, ALMOST LIKE A MANUAL TRANSMISSION IN THE WRONG GEAR. THIS SHOULD NOT BE HAPPENING. AND IT IS GETTING WORST EVERY DAY. I H…
Read full complaint
WHEN DRIVING IN TRAFFIC AND SLOWING DOWN OR COMING TO A STOP. THE VEHICLE GOES COMPLETELY DEAD. I WILL HAVE TO RESTART AT EACH STOP. WHEN IT DOES START, IT IS NOT A SMOOTH TAKE OFF, IT IS EXTREMELY ROUGH, ALMOST LIKE A MANUAL TRANSMISSION IN THE WRONG GEAR. THIS SHOULD NOT BE HAPPENING. AND IT IS GETTING WORST EVERY DAY. I HAVE TO TRANSPORT MY FAMILY IN THIS VEHICLE AND IT IS VERY UNSAFE FOR US. I STILL HAVE A YEAR TO PAY FOR IT AND I AM HEARING MORE AND MORE CUSTOMERS WITH THE SAME COMPLAINT. THE DEALER DOESN'T WANT TO TOUCH IT, BECAUSE THEY ARE UNSURE WHAT IS WRONG, OR IF THEY CAN REPAIR IT. FRANKLY, THIS SHOULD NOT BE AN ISSUE WITH THIS MANY CARS. THERE HAVE BEEN SEVERAL NEAR-MISSES WITH ACCIDENTS BECAUSE OF THE CAR STALLING IN TRAFFIC.
NHTSA ODI #11415192
115,000 miles · Aug 18, 2020
EngineFire
TL* THE CONTACT OWNED A 2013 GMC ACADIA. THE CONTACT STATED THAT WHILE IN FOR SERVICE THE MECHANIC NOTICED THE ODOR OF SMOKE AND FUEL INSIDE THE VEHICLE. LATER WHILE THE VEHICLE WAS PARKED A FIRE HAD STARTED FROM WITHIN THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FLAMES. DURING THE IN…
Read full complaint
TL* THE CONTACT OWNED A 2013 GMC ACADIA. THE CONTACT STATED THAT WHILE IN FOR SERVICE THE MECHANIC NOTICED THE ODOR OF SMOKE AND FUEL INSIDE THE VEHICLE. LATER WHILE THE VEHICLE WAS PARKED A FIRE HAD STARTED FROM WITHIN THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FLAMES. DURING THE INCIDENT, THE VEHICLE WAS DESTROYED. THE VEHICLE WAS TOWED TO THE LOCAL DEALER STEP ON GMC (5651 PENSACOLA BLVD, PENSACOLA, FL 32505) WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS LATER INSPECTED BY AN INDEPENDENT COMPANY WHO WAS ALSO UNABLE TO DETERMINE THE CAUSE OF THE FIRE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000.*DT CONSUMER STATED VEHICLE HAD ORIGINAL EQUIPMENT.*JB
NHTSA ODI #11350108
Official recalls
3Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration