NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
38 reportsClear category filter51,500 miles · Feb 16, 2021
Back Over PreventionElectrical SystemLane Departure
DRIVER SIDE DETECTION BLIND ZONE, INTERMITTENTLY COMES ON, THEN AFTER SEVERAL DAYS JUST STOPPED WORKING, I REPLACE THE BLIND ZONE MODULE LOCATED UNDER REAR BUMPER, IT WORKED FINE FOR A WEEK AND THEN SHOWS SERVICE SIDE DETECTION SYSTEM, AND BOTH SIDES BLIND LIGHTS ON MIRRORS DON'T WORK, ALL THIS HAPPENED WHILE THE VEHICLE IS RUNN…
Read full complaint
DRIVER SIDE DETECTION BLIND ZONE, INTERMITTENTLY COMES ON, THEN AFTER SEVERAL DAYS JUST STOPPED WORKING, I REPLACE THE BLIND ZONE MODULE LOCATED UNDER REAR BUMPER, IT WORKED FINE FOR A WEEK AND THEN SHOWS SERVICE SIDE DETECTION SYSTEM, AND BOTH SIDES BLIND LIGHTS ON MIRRORS DON'T WORK, ALL THIS HAPPENED WHILE THE VEHICLE IS RUNNING
NHTSA ODI #11396535
115,000 miles · Dec 12, 2020
Air BagsElectrical SystemPower Train
AIR BAG SERVICE LIGHT IS ON. DEFECTIVE WIRING HARNESS. TRANSMITION ISSUES AS PER A COMMON COMPLAINT ON THIS VEHICLE. THE VEHICLE SHOWS ALL OF THESE ISSUES BOTH WHEN RUNNING PARKED AND WHILE IN MOTION ON ALL TYPES OF ROADWAYS
NHTSA ODI #11383162
63,000 miles · Aug 8, 2020
Electrical System
GM IS IN NON COMPLIANCE WITH GLOBAL SAFETY FIELD INVESTIGATIONS DCS5011 ...D&S MOTORS RUGBY ND [A GM DEALER] STATES THEY CAN NOT GET THE KIT-ACADIA MY 2013-14 PART NO. 84651473 ---- MY VEHICLE REQUIRED REPAIR WITHIN THAT EXTENDED WARRANTY TIME FROM. I AM NOW ON MY 3RD FAILED BECAUSE OF WATER INTRUSION , THE NEW WIRING HARNSS…
Read full complaint
GM IS IN NON COMPLIANCE WITH GLOBAL SAFETY FIELD INVESTIGATIONS DCS5011 ...D&S MOTORS RUGBY ND [A GM DEALER] STATES THEY CAN NOT GET THE KIT-ACADIA MY 2013-14 PART NO. 84651473 ---- MY VEHICLE REQUIRED REPAIR WITHIN THAT EXTENDED WARRANTY TIME FROM. I AM NOW ON MY 3RD FAILED BECAUSE OF WATER INTRUSION , THE NEW WIRING HARNSS IS SUPPOSE TO REPAIR THE PROBLEM AND SUPPOSE TO HAVE BEEN INSTALLED AT NO COST TO THE CUSTOMER. THEY FIGURE THEY JUST CAN NOT GET IT AND THAT'S IT, THEY ARE DONE WITH ME! THEY STATE EVEN TODAY THEY CAN NOT GET THE KIT--THEY HAVE THEM FOR OTHER VEHICLES, BUT NOT MINE--I KNOW I WILL HAVE ANOTHER FAILER DOWN THE ROAD--YOUR PAPER SAYS IT IS URGENT --YES, IT ISW AS A LOT OF THINGS GO WACKY WHEN IT GOES! GM PAPER SAYS SPECIALCOVERAGE ADJUSTMENT N172097060 SIDE BLIND ZONE? HELP?
NHTSA ODI #11344077
4,000 miles · Feb 19, 2020
Electrical System
SERVICE SIDE DETECTION SENSORS . SENSORS FAILED 3 TIMES.SENSORS FILL WITH WATER FREEZE AND SHORT OUT. CABLE HARNESS ALSO HAD TO BE REPLACED BECAUSE IT MELTED.
NHTSA ODI #11310157
110,000 miles · Feb 13, 2020
Electrical System
THE SIDE BLIND ZONE DETECTION SYSTEM BECAME DEFECTIVE, FROM DEFECTIVE MODULES DAMAGED FROM THE ELEMENTS. THIS CAUSES MANY ELECTRICAL SYSTEMS TO BECOME DISABLED AND EVEN DISABLES THE VEHICLE COMPLETELY. THERE IS A SPECIAL WARRANTY BUT ONLY UP TO 80,000 MILES. MY VEHICLE IS BEYOND THAT. IT IS STILL EXTREMELY DANGEROUS FOR MANY GM …
Read full complaint
THE SIDE BLIND ZONE DETECTION SYSTEM BECAME DEFECTIVE, FROM DEFECTIVE MODULES DAMAGED FROM THE ELEMENTS. THIS CAUSES MANY ELECTRICAL SYSTEMS TO BECOME DISABLED AND EVEN DISABLES THE VEHICLE COMPLETELY. THERE IS A SPECIAL WARRANTY BUT ONLY UP TO 80,000 MILES. MY VEHICLE IS BEYOND THAT. IT IS STILL EXTREMELY DANGEROUS FOR MANY GM CUSTOMERS AND REPLACEMENT PARTS AND LABOR SHOULD BE COVERED FOR ALL!
NHTSA ODI #11309080
119,000 miles · Dec 23, 2019
Electrical SystemExterior Lighting
FIRST IT STARTED WITH THE DAYTIME RUNNING LIGHTS STAYING ON HOURS AFTER VEHICLE IS SHUT OFF THEN IT WENT TO PARKING LIGHTS STAYING ON AS WELL AND NOW THE DRIVER SIDE LIGHTS ARE OUT INCLUDING LISCENCE PLATE LIGHTS NOTHING WORKS BUT THE HEADLIGHT
NHTSA ODI #11290987
55,000 miles · Nov 22, 2019
Electrical System
TL* THE CONTACT OWNS A 2013 GMC ACADIA. WHILE DRIVING APPROXIMATELY 35 MPH, THE 'SERVICE SIDE DETECTION SYSTEM', 'LOW VOLTAGE' AND 'TRACTION CONTROL' MESSAGES SUDDENLY DISPLAYED BEFORE THE VEHICLE STALLED. THE VEHICLE WAS LATER RESTARTED, BUT THE FAILURE RECURRED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER AND…
Read full complaint
TL* THE CONTACT OWNS A 2013 GMC ACADIA. WHILE DRIVING APPROXIMATELY 35 MPH, THE 'SERVICE SIDE DETECTION SYSTEM', 'LOW VOLTAGE' AND 'TRACTION CONTROL' MESSAGES SUDDENLY DISPLAYED BEFORE THE VEHICLE STALLED. THE VEHICLE WAS LATER RESTARTED, BUT THE FAILURE RECURRED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 55,000.
NHTSA ODI #11281710
105,000 miles · Oct 2, 2019
Electrical System
SIDE VIEW INDICATOR LIGHTS ARE CONSTANTLY ON, DISRUPTED BY WATER INTRUSION INTO THE SENSORS. INITIAL RECALL STOPPED AT 80,000 MILES. THE LIGHTS CONSTANTLY BEING ON ARE A HAZARD AT NIGHT AS THERE IS INDIRECT LIGHT AFFECTING MY VISION AND COULD CAUSE AN ACCIDENT. ADDITIONALLY, THE MIRRORS ARE LOOKED AT DIRECTLY WHILE DRIVING AND T…
Read full complaint
SIDE VIEW INDICATOR LIGHTS ARE CONSTANTLY ON, DISRUPTED BY WATER INTRUSION INTO THE SENSORS. INITIAL RECALL STOPPED AT 80,000 MILES. THE LIGHTS CONSTANTLY BEING ON ARE A HAZARD AT NIGHT AS THERE IS INDIRECT LIGHT AFFECTING MY VISION AND COULD CAUSE AN ACCIDENT. ADDITIONALLY, THE MIRRORS ARE LOOKED AT DIRECTLY WHILE DRIVING AND THE FACT THAT THE INDICATOR LIGHTS ARE ALWAYS ON MAKES IT DIFFICULT TO VIEW THE MIRRORS AT NIGHT. I HAVE NEARLY CAUSED >10 ACCIDENTS DUE TO THIS.
NHTSA ODI #11265612
109,000 miles · Oct 2, 2019
Electrical SystemPower Train
THIS VEHICLE BEGAN HAVING A SHAKING OR JUMPING FEELING AT 1800 RPMS AROUND 85,000 MILES. UNABLE TO BE DIAGNOSED AT OUTSIDE MECHANIC. CONTINUED TO GET WORSE AND BEGAN HAPPENING AT OTHER RPMS. TOOK TO DEALERSHIP AFTER VEHICLE HIT 109,000 MILES AND DIAGNOSED AT TORQUE CONVERTER WHICH THEY REFUSE TO FIX BECAUSE OUTSIDE WARRANTY. PER…
Read full complaint
THIS VEHICLE BEGAN HAVING A SHAKING OR JUMPING FEELING AT 1800 RPMS AROUND 85,000 MILES. UNABLE TO BE DIAGNOSED AT OUTSIDE MECHANIC. CONTINUED TO GET WORSE AND BEGAN HAPPENING AT OTHER RPMS. TOOK TO DEALERSHIP AFTER VEHICLE HIT 109,000 MILES AND DIAGNOSED AT TORQUE CONVERTER WHICH THEY REFUSE TO FIX BECAUSE OUTSIDE WARRANTY. PER MY REVIEW OF OTHER SITES, THIS HAS BEEN A RECURRENT AND OBVIOUS ISSUE WITH THESE VEHICLES AND CAN LEAVE PEOPLE STRANDED ON THE HIGHWAY AS THE VEHICLE CAN LOSE POWER.
NHTSA ODI #11265608
115,000 miles · Sep 10, 2019
Electrical System
WHEN STARTING MY ENGINE, IT ROLLS OVER AND STARTS BUT CONTINUES TO CRANK/TURN (EVEN AFTER IT HAS STARTED).
NHTSA ODI #11254358
Official recalls
3Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration