NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
269 reports180,000 miles · Jul 24, 2018
Electrical SystemExterior Lighting
I HAVE A 2011 GMC ACADIA SLT. MY CAR IS EQUIPPED XENON HIGH INTENSITY DISCHARGE (HID TVD) LOW BEAMS LAMPS. BOTH PASSENGER AND DRIVERS SIDE LOW BEAM LIGHT SOCKETS HAVE MELTED INSIDE EACH HEAD LIGHT ASSEMBLY. THE LOW BEAM LAMP CONNECTORS AND PORTIONS OF EACH WIRING HARNESS HAVE MELTED FROM THE INTENSE HEAT OF THE HID LAMP. I CONTA…
Read full complaint
I HAVE A 2011 GMC ACADIA SLT. MY CAR IS EQUIPPED XENON HIGH INTENSITY DISCHARGE (HID TVD) LOW BEAMS LAMPS. BOTH PASSENGER AND DRIVERS SIDE LOW BEAM LIGHT SOCKETS HAVE MELTED INSIDE EACH HEAD LIGHT ASSEMBLY. THE LOW BEAM LAMP CONNECTORS AND PORTIONS OF EACH WIRING HARNESS HAVE MELTED FROM THE INTENSE HEAT OF THE HID LAMP. I CONTACTED GMC CUSTOMER ASSISTANCE CENTER TO SEE IF A RECALL HAS BEEN INITIATED. NO RECALL. I WAS GIVEN A CASE NUMBER AND THE CONTACT INFORMATION FOR MY LOCAL CUSTOMER EXPERIENCE MANAGER. I WAS ENCOURAGED TO SCHEDULE AN APPOINTMENT AT THE DEALERSHIP SO MY LIGHT ISSUE COULD BE LOOKED INTO BY A GMC MAINTENANCE TEAM. I WAS ENCOURAGED TO RESOLVE MY LIGHTING ISSUE WITH MY CUSTOMER EXPERIENCE MANAGER.
NHTSA ODI #11113363
120,000 miles · Jul 12, 2018
Steering
TL* THE CONTACT OWNS A 2011 GMC ACADIA. WHILE DRIVING BELOW 10 MPH, THE POWER STEERING FAILED AND CAUSED THE STEERING WHEEL TO BECOME VERY DIFFICULT TO TURN IN EITHER DIRECTION. THE VEHICLE WAS TAKEN TO THE DEALER (MAYSE AUTOMOTIVE GROUP INC, 2032 S ELLIOTT AVE, AURORA, MO) WHO WAS UNABLE TO DUPLICATE OR DETERMINE THE CAUSE OF T…
Read full complaint
TL* THE CONTACT OWNS A 2011 GMC ACADIA. WHILE DRIVING BELOW 10 MPH, THE POWER STEERING FAILED AND CAUSED THE STEERING WHEEL TO BECOME VERY DIFFICULT TO TURN IN EITHER DIRECTION. THE VEHICLE WAS TAKEN TO THE DEALER (MAYSE AUTOMOTIVE GROUP INC, 2032 S ELLIOTT AVE, AURORA, MO) WHO WAS UNABLE TO DUPLICATE OR DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. *TT CONTACT STATES THIS OCCURRENCE HAS HAPPENED THREE TIMES. *TT
NHTSA ODI #11110918
98,000 miles · Jun 19, 2018
Exterior Lighting
HEADLIGHT BULB AND ASSEMBLY SYSTEM COMPLETELY MELTED! WENT TO REPLACE THE BULBS THAT I THOUGHT WERE JUST BLOWN OUT BUT THE BULBS EXPLODED AND MELTED EVERYTHING. TOOK IT TO THE LOCAL DEALERSHIP TO FIX AND THEY SAID IT WOULD COST $2500.00 TO FIX IN ORDERING NEW ASSEMBLY. THEY SAID THEY HAVE SEEN THIS HAPPEN ON ACADIAS BEFORE. I WE…
Read full complaint
HEADLIGHT BULB AND ASSEMBLY SYSTEM COMPLETELY MELTED! WENT TO REPLACE THE BULBS THAT I THOUGHT WERE JUST BLOWN OUT BUT THE BULBS EXPLODED AND MELTED EVERYTHING. TOOK IT TO THE LOCAL DEALERSHIP TO FIX AND THEY SAID IT WOULD COST $2500.00 TO FIX IN ORDERING NEW ASSEMBLY. THEY SAID THEY HAVE SEEN THIS HAPPEN ON ACADIAS BEFORE. I WENT ONLINE AND SURE ENOUGH MELTED HEADLIGHTS AND WIRING WERE A COMMON PROBLEM. WHEN I CALLED THE HEADQUARTERS CUSTOMER SERVICE LINE TO ASK IF A RECALL HAD BEEN ISSUED A FOREIGN GENTLEMAN WROTE DOWN MY INFORMATION AND SAID SOMEONE WILL GET BACK WITH YOU BUT THERE SHOULD BE NO REASON IT MELTED UNLESS SOMEONE OR SOMETHING HAPPENED TO IT. I'VE NEVER BEEN IN A WRECK EVER. I ASKED THE GUY WHAT IT WOULD TAKE TO GET THIS FIXED ME OR ONE OF MY KIDS DYING IN A WRECK AND IS SUING YOU TO MAKE SURE WE HAVE A SAFE VEHICLE. I TOLD HIM I DIDN'T APPRECIATE HIS I DON'T CARE ATTITUDE TOWARDS MY FEELINGS OF HAVING SMALL CHILDREN IN A CAR THAT HAS A PART THAT IS COMMON AND KNOWN TO MELT AND NOT GET FIXED.
NHTSA ODI #11102569
72,531 miles · Jun 6, 2018
Steering
WHEN GOING SLOW AND MAKING A TURN RIGHT OR LEFT I LOSE POWER STEERING THIS HAPPENS BOTH FORWARD OR BACKWARD WHEN I SPEED UP THE POWER STEERING COME BACK TO NORMAL.
NHTSA ODI #11100160
120,000 miles · May 23, 2018
Visibility/wiper
WINDSHIELD WIPERS WON'T WORK
NHTSA ODI #11097700
103,000 miles · May 8, 2018
Steering
POWER STEERING WENT OUT AND ALMOST HIT ANOTHER VEHICLE. WORKS GOING DOWN A 2 LANE HIGHWAY OVER 35 MPH, BUT STOPS WORKING AS YOU TURN INTO PARKING LOTS, ROAD, ETC AT LOWER SPEEDS. STEERING IS EXTREMELY DIFFICULT AND HAVE NOTICED MANY ACADIA OWNERS ARE HAVING THIS ISSUE. CAR IS A 2011 DENALI ACADIA WITH 103,000 MILES.
NHTSA ODI #11092482
80,637 miles · Apr 23, 2018
EngineSeat Belts
I TOOK OUR 2011 GMC ACADIA, MILEAGE 80,637, TO THE DEALERSHIP ON 12/16/2017 BECAUSE THE DISPLAY SHOWED "SERVICE AIR BAG." THE SERVICE TECHNICIAN REPORTED THAT HE FOUND DTC B0022 AND B0015 STORED IN SDM, TESTED CIRCUITS, GOOD. HE FOUND EXCESSIVE RESISTANCE IN BOTH FRONT SEAT BELT ANCHOR PRETENSIONS AND RECOMMENDED REPLACEMENT OF…
Read full complaint
I TOOK OUR 2011 GMC ACADIA, MILEAGE 80,637, TO THE DEALERSHIP ON 12/16/2017 BECAUSE THE DISPLAY SHOWED "SERVICE AIR BAG." THE SERVICE TECHNICIAN REPORTED THAT HE FOUND DTC B0022 AND B0015 STORED IN SDM, TESTED CIRCUITS, GOOD. HE FOUND EXCESSIVE RESISTANCE IN BOTH FRONT SEAT BELT ANCHOR PRETENSIONS AND RECOMMENDED REPLACEMENT OF BOTH FRONT ANCHOR PRETENSIONERS, CPA CONNECTORS WITH LEADS AND REPROGRAM THE SDM. REPAIR ESTIMATE OF $1,164.51. CHARGED $125 TO DIAGNOSE. IT WAS EXPLAINED TO ME THAT THE PRETENSIONERS ARE CONNECTED TO AND COMMUNICATE WITH THE AIR BAG. IN ADDITION, THE SERVICE TECHNICIAN FOUND THE FRONT ENGINE MOUNT WEAK. REPAIR ESTIMATE OF $447.85. THE SEAT BELT PRETENSIONERS AND "SERVICE AIR BAG" APPEAR TO BE SIGNIFICANT SAFETY ISSUES. I CONTACTED GMC ON 04/23/2018 TO REQUEST REPAIR ASSISTANCE AND TO INQUIRE IF THERE WAS A RECALL, CASE # 8-4111443314. I WAS ADVISED THAT I WOULD HAVE TO PAY OUT OF POCKET.
NHTSA ODI #11089727
83,000 miles · Apr 20, 2018
Power Train
TRANSMISSION FLARES OUT (GOES INTO NEUTRAL) BETWEEN GEARS WHEN MERGING INTO HIGHWAY TRAFFIC AT SPEEDS OF AROUND 45-60 MPH. MOST OFTEN OCCURS WHEN INITIALLY ACCELERATING TO MERGE INTO FASTER TRAFFIC AND THEN HAVING TO TAKE MY FOOT OFF THE GAS FOR A SECOND OR TWO TO ALLOW FASTER CARS TO GO BY, AND THEN TRYING TO ACCELERATE AGAIN.…
Read full complaint
TRANSMISSION FLARES OUT (GOES INTO NEUTRAL) BETWEEN GEARS WHEN MERGING INTO HIGHWAY TRAFFIC AT SPEEDS OF AROUND 45-60 MPH. MOST OFTEN OCCURS WHEN INITIALLY ACCELERATING TO MERGE INTO FASTER TRAFFIC AND THEN HAVING TO TAKE MY FOOT OFF THE GAS FOR A SECOND OR TWO TO ALLOW FASTER CARS TO GO BY, AND THEN TRYING TO ACCELERATE AGAIN. THE TRANSMISSION IS IN NEUTRAL AND IT SEEMS IT IS CAUGHT BETWEEN GEARS (4TH & 5TH GEARS I BELIEVE) WHEN I TRY TO ACCELERATE AGAIN. ENGINE REVS TO 5000 TO 6000 RPM RANGE BECAUSE IT IS NOT IN GEAR. HAVE TO TAKE FOOT OFF OF THE GAS AND WAIT A COUPLE SECONDS FOR TRANSMISSION TO GET INTO GEAR SO I CAN CONTINUE DRIVING. IN THE MEANTIME FASTER CARS ARE APPROACHING AS I'M IN THE MIDDLE OF MERGING INTO HIGHWAY TRAFFIC. NOT BEING ABLE TO ACCELERATE WHEN MERGING INTO HIGHWAY TRAFFIC CREATES A VERY UNSAFE SITUATION. THIS ISSUE HAS OCCURRED 2-3 TIMES A MONTH FOR THE LAST SEVERAL YEARS. HAVE HAD IT LOOKED AT A NUMBER OF TIMES BY GM SERVICE CENTER BUT THEY ARE UNABLE TO REPRODUCE THE EVENT WHEN THEY TEST DRIVE MY VEHICLE AND THERE AREN'T ANY SPECIAL CODES POPPING UP IN THE COMPUTER LOG FOR THEM TO JUSTIFY DOING ANYTHING TO FIX THE PROBLEM. SO THEY ARE NOT ABLE TO DO ANYTHING ABOUT THIS CONDITION.
NHTSA ODI #11089049
140,000 miles · Apr 10, 2018
Steering
TL* THE CONTACT OWNS A 2011 GMC ACADIA. WHILE OPERATING THE VEHICLE, THE STEERING WHEEL FELT LOOSE AND A WHINING NOISE WAS HEARD WHEN IT WAS TURNED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (SELLERS BUICK GMC, 38000 GRAND RIVER AVE, FARMINGTON HILLS, MI) WHERE IT WAS DIAGNOSED THAT THE POWER STEERING FLUID LEAKED FROM THE VEHIC…
Read full complaint
TL* THE CONTACT OWNS A 2011 GMC ACADIA. WHILE OPERATING THE VEHICLE, THE STEERING WHEEL FELT LOOSE AND A WHINING NOISE WAS HEARD WHEN IT WAS TURNED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (SELLERS BUICK GMC, 38000 GRAND RIVER AVE, FARMINGTON HILLS, MI) WHERE IT WAS DIAGNOSED THAT THE POWER STEERING FLUID LEAKED FROM THE VEHICLE AND THE POWER STEERING FLUID SEALS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 140,000.
NHTSA ODI #11084362
Mileage unknown · Apr 9, 2018
Visibility/wiper
BACK WINDSHIELD SHATTERED WHEN TRUNK WAS CLOSED USING THE POWER TRUNK DOOR FEATURE. ONE MONTH LATER, THE DRIVER'S SIDE REAR QUARTER PANEL WINDOW SHATTERED WHEN THE TRUNK WAS CLOSED USING THE POWER TRUNK DOOR FEATURE. CAR WAS STATIONARY IN BOTH INSTANCES.
NHTSA ODI #11083988
Official recalls
5Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Apr 9, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET TRAVERSE, BUICK ENCLAVE, AND GMC ACADIA VEHICLES CURRENTLY REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING AND THE DISTRICT OF COLUMBIA. SNOW OR ICE BUILDUP ON THE WINDSHIELD OR ON THE WIPER MAY RESTRICT THE MOVEMENT OF THE WIPER ARM, CAUSING THE WIPER ARM TO LOOSEN AND CAUSE THE WIPER TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL TIGHTEN THE WIPER ARM NUTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration