NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
269 reports95,000 miles · Aug 17, 2017
Engine
TL* THE CONTACT OWNS A 2011 GMC ACADIA. WHILE ATTEMPTING TO START THE VEHICLE, THE ENGINE STALLED. THE FAILURE OCCURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE CYLINDER HEAD FAILED. THE CONTACT STATED THAT OIL PENETRATED THE CYLINDER HEAD, SPARK PLUG TUBE, AND TIMING CHAIN…
Read full complaint
TL* THE CONTACT OWNS A 2011 GMC ACADIA. WHILE ATTEMPTING TO START THE VEHICLE, THE ENGINE STALLED. THE FAILURE OCCURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE CYLINDER HEAD FAILED. THE CONTACT STATED THAT OIL PENETRATED THE CYLINDER HEAD, SPARK PLUG TUBE, AND TIMING CHAIN, WHICH CAUSED THE ENGINE TO FAIL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 95,000.
NHTSA ODI #11016035
56,000 miles · Aug 11, 2017
Air Bags
TL* THE CONTACT OWNS A 2011 GMC ACADIA. THE CONTACT STATED THAT THE AIR BAG INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE …
Read full complaint
TL* THE CONTACT OWNS A 2011 GMC ACADIA. THE CONTACT STATED THAT THE AIR BAG INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 56,000.
NHTSA ODI #11014624
16,226 miles · Aug 10, 2017
Steering
SQUEAKING/WHINING IN STEERING COLUMN. DEALERSHIP DIAGNOSIS, POWER STEERING GEAR LEAKING (RACK & PINION) AND MUST BE REPLACED. COST, $1432.00 PLUS TAX. VEHICLE HAS ONLY 17948 MILES. NOT COVERED BY WARRANTY OR MANUF. RECALL. OUT OF WARRANTY DUE TO AGE OR TIME. POWER STEERING COULD FAIL AS IT HAS IN OTHER VEHICLES. DEFINITELY A SAF…
Read full complaint
SQUEAKING/WHINING IN STEERING COLUMN. DEALERSHIP DIAGNOSIS, POWER STEERING GEAR LEAKING (RACK & PINION) AND MUST BE REPLACED. COST, $1432.00 PLUS TAX. VEHICLE HAS ONLY 17948 MILES. NOT COVERED BY WARRANTY OR MANUF. RECALL. OUT OF WARRANTY DUE TO AGE OR TIME. POWER STEERING COULD FAIL AS IT HAS IN OTHER VEHICLES. DEFINITELY A SAFETY ISSUE. GMC SHOULD STAND BEHIND THEIR VEHICLES AS THIS IS A DESIGN OR ENGINEERING FLAW. THIS CONDITION IS NOTICED WHEN EVER THE STEERING WHEEL IS TURNED IN EITHER DIRECTION.
NHTSA ODI #11014273
32,000 miles · Aug 10, 2017
Steering
THE POWER STEERING STOPS WORKING WHEN TRYING TO PARK OR MOVING AT A SLOW SPEED. I AM IN GOOD SHAPE AND IT TAKES ME ALL MY POWER WITH TWO HANDS TO TURN THE STEERING WHEEL. THERE IS NO WARNING IT CATCHES YOU OFF GUARD AND MULTIPLE TIMES ALMOST HIT CARS IN SPOTS NEXT TO WHERE I PARK. WE ALSO HAVE HAD THE AIR CONDITIONING FIXED TWIC…
Read full complaint
THE POWER STEERING STOPS WORKING WHEN TRYING TO PARK OR MOVING AT A SLOW SPEED. I AM IN GOOD SHAPE AND IT TAKES ME ALL MY POWER WITH TWO HANDS TO TURN THE STEERING WHEEL. THERE IS NO WARNING IT CATCHES YOU OFF GUARD AND MULTIPLE TIMES ALMOST HIT CARS IN SPOTS NEXT TO WHERE I PARK. WE ALSO HAVE HAD THE AIR CONDITIONING FIXED TWICE SINCE WE'VE BOUGHT IT AND STILL DOESN'T BLOW AS COLD AS IT SHOULD. THE CAR HAS 78,000 MILES.
NHTSA ODI #11014096
135,000 miles · Aug 5, 2017
Steering
AT SLOW SPEED TURNS POWER STEERING SEEMS TO LOSE POWER ASSIST
NHTSA ODI #11013038
86,000 miles · Jun 21, 2017
Steering
LOSS OF POWER STEERING AT LOW SPEED. HAD THE ENTIRE RACK REPLACED (PRIOR TO POWER STEERING LOSS), AS WELL AS THE POWER STEERING PUMP REPLACED (AFTER POWER STEERING LOSS AND COVERED UNDER THE TSB) AND WITHIN TO WEEKS OF HAVING THE POWER STEERING PUMP REPLACED, THE EXACT SAME THING OCCURRED. AT VERY LOW SPEED, IN A PARKING LOT,…
Read full complaint
LOSS OF POWER STEERING AT LOW SPEED. HAD THE ENTIRE RACK REPLACED (PRIOR TO POWER STEERING LOSS), AS WELL AS THE POWER STEERING PUMP REPLACED (AFTER POWER STEERING LOSS AND COVERED UNDER THE TSB) AND WITHIN TO WEEKS OF HAVING THE POWER STEERING PUMP REPLACED, THE EXACT SAME THING OCCURRED. AT VERY LOW SPEED, IN A PARKING LOT, MAKING A RIGHT HAND TURN, I LOST ALL POWER STEERING AND HEARD A LOUD SCREECHING NOISE AS I ATTEMPTED TO MANEUVER MY VERY HEAVY SUV TO A SAFE AREA WITH NO POWER STEERING. "SERVICE BATTERY CHARGING SYSTEM" ERROR CAME UP ON MY IN-DASH SCREEN AND THEN IT WENT AWAY. I TURNED THE ENGINE OFF AND RE-STARTED WITH NO POWER STEERING STILL AND THEN RE-STARTED AGAIN AN THAT IS WHEN THE POWER STEERING WORKED AGAIN. THE ENTIRE TIME, THE RADIO AND LIGHTS WERE ON AND DID NOT FAIL. I DROVE THE CAR DIRECTLY TO THE DEALERSHIP AND AFTER A FULL DAY OF HAVING MY CAR, THEY TOLD ME I NEEDED A NEW ALTERNATOR NOW AT AT COST OF $1200!!!! I'M NOT SURE HOW THE ALTERNATOR IS RELATED SINCE I DO NOT HAVE ELECTRIC POWER STEERING?!?!?! I FEEL LIKE THIS DEFECT IS COSTING CUSTOMERS THOUSANDS OF DOLLARS FOR A DEFECT FROM THE MANUFACTURE AND GM NEEDS TO WAKE UP AND ISSUE A RECALL BEFORE SOMEONE IS KILLED!!
NHTSA ODI #11000348
77,000 miles · Jun 6, 2017
Engine
THE CAR HAS 77,000 MILES AND HAD TO REPLACE THE TIMING CHAIN AND ALL COMPONENTS INVOLVED. THE SERVICE MANAGER SAID THEY HAD RECALLS ON 2007-2009 VEHICLES BUIT HAD SINCE FIXED THE PROBLEM BUT APPARENTLY NOT. I HAD MY MACHANIC FIX THIS THE COST WAS $1636.00 WHICH WAS WAY CHEAPER THAN THE DEALER. I THINK THAT GMC SHOULD RESOLVE THI…
Read full complaint
THE CAR HAS 77,000 MILES AND HAD TO REPLACE THE TIMING CHAIN AND ALL COMPONENTS INVOLVED. THE SERVICE MANAGER SAID THEY HAD RECALLS ON 2007-2009 VEHICLES BUIT HAD SINCE FIXED THE PROBLEM BUT APPARENTLY NOT. I HAD MY MACHANIC FIX THIS THE COST WAS $1636.00 WHICH WAS WAY CHEAPER THAN THE DEALER. I THINK THAT GMC SHOULD RESOLVE THIS PROBLEM AS I HEARD THIS IS A COMMON PROBLEM STILL.
NHTSA ODI #10993369
65,000 miles · May 30, 2017
Air BagsVisibility/wiper
MY SERVICE AIRBAG LIGHT STAYS ON WHEN I TURN MY VEHICLE ON AT ALL TIME. I'VE TAKEN IT TO THE DEALERSHIP TWICE AND THEY TELL ME THEY CAN'T FIND ANYTHING WRONG. WHEN DRIVING IF I TRY TO CLEAN MY WINDOW, THE WINDSHIELD WIPER FLUID WILL NOT SPRAY OUT ON THE PASSENGERS SIDE AND SOMETIMES IT WILL COME OUT BUT IT WON'T SPRAY ON THE WIN…
Read full complaint
MY SERVICE AIRBAG LIGHT STAYS ON WHEN I TURN MY VEHICLE ON AT ALL TIME. I'VE TAKEN IT TO THE DEALERSHIP TWICE AND THEY TELL ME THEY CAN'T FIND ANYTHING WRONG. WHEN DRIVING IF I TRY TO CLEAN MY WINDOW, THE WINDSHIELD WIPER FLUID WILL NOT SPRAY OUT ON THE PASSENGERS SIDE AND SOMETIMES IT WILL COME OUT BUT IT WON'T SPRAY ON THE WINDSHIELD. IT'S LIKE IT DOESN'T HAVE ENOUGH PRESSURE TO SPRAY IT ON THE WINDSHIELD. THIS HAPPENS EVERY TIME WHILE I'M DRIVING AND TRY TO CLEAN MY WINDSHIELD TO SEE BETTER. I'VE TAKEN IT TO THE DEALERSHIP AND THEY TELL ME NOTHING WRONG.
NHTSA ODI #10992336
Mileage unknown · May 2, 2017
Air BagsElectrical System
VEHICLES AIRBAG WAS ACTIVATED, BROUGHT TO CHEVY DEALERSHIP WAS TOLD IT WAS A WIRING ISSUE INVOLVING PASSENGER SIDE. WAS TOLD THERE WAS. O WARRANTY OR RECALLS TO COVER PROBLEM AND WOULD REQUIRE COMPLETE REWIRE OF HARNESS AS THEY WERE UNSURE WHICH WIRE WAS CAUSING THE ISSUE ($2,000). THROUGH RESEARCH FOUND THAT IT IS A KNOWN PRO…
Read full complaint
VEHICLES AIRBAG WAS ACTIVATED, BROUGHT TO CHEVY DEALERSHIP WAS TOLD IT WAS A WIRING ISSUE INVOLVING PASSENGER SIDE. WAS TOLD THERE WAS. O WARRANTY OR RECALLS TO COVER PROBLEM AND WOULD REQUIRE COMPLETE REWIRE OF HARNESS AS THEY WERE UNSURE WHICH WIRE WAS CAUSING THE ISSUE ($2,000). THROUGH RESEARCH FOUND THAT IT IS A KNOWN PROBLEM FOR 2008-2011 ACADIA'S BUT OUR VIN WASN'T DESIGNATED AS BEING INVOLVED IN RECALL. HOW GM CAN CLAIM THAT A VEHICLE WXPERIENCING THE EXACT SAME ISSUE AS THE RECALL ISN'T COVERED UNDER THE RECALL IS RIDICULOUS. THIS APPEARS TO ONCE AGAIN BE GM DISREGARDING SAFETY CAUSED BY THEIR FAILURES IN PRODUCTION SO THAT THEY CAN MAKE MORE MONEY.
NHTSA ODI #10983128
140,000 miles · Apr 20, 2017
Electrical System
TL* THE CONTACT OWNS A 2011 GMC ACADIA. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT MENTIONED THAT THE FAILURE RECURRED MULTIPLE TIMES. THE CONTACT, A MECHANIC, FOUND NO ISSUES WITH THE BATTERY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAI…
Read full complaint
TL* THE CONTACT OWNS A 2011 GMC ACADIA. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT MENTIONED THAT THE FAILURE RECURRED MULTIPLE TIMES. THE CONTACT, A MECHANIC, FOUND NO ISSUES WITH THE BATTERY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.
NHTSA ODI #10979440
Official recalls
5Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Apr 9, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET TRAVERSE, BUICK ENCLAVE, AND GMC ACADIA VEHICLES CURRENTLY REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING AND THE DISTRICT OF COLUMBIA. SNOW OR ICE BUILDUP ON THE WINDSHIELD OR ON THE WIPER MAY RESTRICT THE MOVEMENT OF THE WIPER ARM, CAUSING THE WIPER ARM TO LOOSEN AND CAUSE THE WIPER TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL TIGHTEN THE WIPER ARM NUTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration