NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
47 reportsClear category filter48,197 miles · Aug 6, 2018
Electrical SystemPower Train
TL* THE CONTACT OWNS A 2011 GMC ACADIA. WHILE ATTEMPTING TO TURN THE VEHICLE OFF, THE GEAR SHIFTER WOULD NOT SHIFT INTO THE PARK POSITION. AS A RESULT, THE IGNITION KEY COULD NOT BE REMOVED FROM THE IGNITION, CAUSING THE ENGINE TO KEEP RUNNING. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE F…
Read full complaint
TL* THE CONTACT OWNS A 2011 GMC ACADIA. WHILE ATTEMPTING TO TURN THE VEHICLE OFF, THE GEAR SHIFTER WOULD NOT SHIFT INTO THE PARK POSITION. AS A RESULT, THE IGNITION KEY COULD NOT BE REMOVED FROM THE IGNITION, CAUSING THE ENGINE TO KEEP RUNNING. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE LOCAL DEALER (BILL CRISPIN CHEVROLET, 7112 E MICHIGAN AVE, SALINE, MI) WAS NOTIFIED, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 48,197.
NHTSA ODI #11118121
180,000 miles · Jul 24, 2018
Electrical SystemExterior Lighting
I HAVE A 2011 GMC ACADIA SLT. MY CAR IS EQUIPPED XENON HIGH INTENSITY DISCHARGE (HID TVD) LOW BEAMS LAMPS. BOTH PASSENGER AND DRIVERS SIDE LOW BEAM LIGHT SOCKETS HAVE MELTED INSIDE EACH HEAD LIGHT ASSEMBLY. THE LOW BEAM LAMP CONNECTORS AND PORTIONS OF EACH WIRING HARNESS HAVE MELTED FROM THE INTENSE HEAT OF THE HID LAMP. I CONTA…
Read full complaint
I HAVE A 2011 GMC ACADIA SLT. MY CAR IS EQUIPPED XENON HIGH INTENSITY DISCHARGE (HID TVD) LOW BEAMS LAMPS. BOTH PASSENGER AND DRIVERS SIDE LOW BEAM LIGHT SOCKETS HAVE MELTED INSIDE EACH HEAD LIGHT ASSEMBLY. THE LOW BEAM LAMP CONNECTORS AND PORTIONS OF EACH WIRING HARNESS HAVE MELTED FROM THE INTENSE HEAT OF THE HID LAMP. I CONTACTED GMC CUSTOMER ASSISTANCE CENTER TO SEE IF A RECALL HAS BEEN INITIATED. NO RECALL. I WAS GIVEN A CASE NUMBER AND THE CONTACT INFORMATION FOR MY LOCAL CUSTOMER EXPERIENCE MANAGER. I WAS ENCOURAGED TO SCHEDULE AN APPOINTMENT AT THE DEALERSHIP SO MY LIGHT ISSUE COULD BE LOOKED INTO BY A GMC MAINTENANCE TEAM. I WAS ENCOURAGED TO RESOLVE MY LIGHTING ISSUE WITH MY CUSTOMER EXPERIENCE MANAGER.
NHTSA ODI #11113363
100,000 miles · Sep 26, 2017
Electrical SystemEnginePower Train
I WAS DRIVING MY 2011 GMC ACADIA AND ALL OF A SUDDEN THE CAR STARTED TO DECELERATE. I PULLED OVER AND TURN THE CAR OFF AND THEN THE CAR WOULD NOT START AGAIN. I HAD IT TOWED TO THE DEALERSHIP. THE DEALERSHIP IS SAYING THERE IS AN ISSUE WITH THE TIMING CHAIN. THE DEALERSHIP SAID THAT THE TIMING CHAIN FAILED. UPON DOING RESEARCH, …
Read full complaint
I WAS DRIVING MY 2011 GMC ACADIA AND ALL OF A SUDDEN THE CAR STARTED TO DECELERATE. I PULLED OVER AND TURN THE CAR OFF AND THEN THE CAR WOULD NOT START AGAIN. I HAD IT TOWED TO THE DEALERSHIP. THE DEALERSHIP IS SAYING THERE IS AN ISSUE WITH THE TIMING CHAIN. THE DEALERSHIP SAID THAT THE TIMING CHAIN FAILED. UPON DOING RESEARCH, I SEE THAT THIS IS A COMMON ISSUE WITH GMC MODELS, ESPECIALLY THE ACADIA MODEL. THE DEALERSHIP IS SAYING THAT THE REPAIR IS GOING TO COST ME $7500. GIVEN THAT THIS IS WELL-KNOWN ISSUE WITH THE ACADIA MODEL, I FEEL THAT THIS ISSUE SHOULD BE RECALLED FOR THE SAFETY OF CONSUMERS.
NHTSA ODI #11030021
Mileage unknown · May 2, 2017
Air BagsElectrical System
VEHICLES AIRBAG WAS ACTIVATED, BROUGHT TO CHEVY DEALERSHIP WAS TOLD IT WAS A WIRING ISSUE INVOLVING PASSENGER SIDE. WAS TOLD THERE WAS. O WARRANTY OR RECALLS TO COVER PROBLEM AND WOULD REQUIRE COMPLETE REWIRE OF HARNESS AS THEY WERE UNSURE WHICH WIRE WAS CAUSING THE ISSUE ($2,000). THROUGH RESEARCH FOUND THAT IT IS A KNOWN PRO…
Read full complaint
VEHICLES AIRBAG WAS ACTIVATED, BROUGHT TO CHEVY DEALERSHIP WAS TOLD IT WAS A WIRING ISSUE INVOLVING PASSENGER SIDE. WAS TOLD THERE WAS. O WARRANTY OR RECALLS TO COVER PROBLEM AND WOULD REQUIRE COMPLETE REWIRE OF HARNESS AS THEY WERE UNSURE WHICH WIRE WAS CAUSING THE ISSUE ($2,000). THROUGH RESEARCH FOUND THAT IT IS A KNOWN PROBLEM FOR 2008-2011 ACADIA'S BUT OUR VIN WASN'T DESIGNATED AS BEING INVOLVED IN RECALL. HOW GM CAN CLAIM THAT A VEHICLE WXPERIENCING THE EXACT SAME ISSUE AS THE RECALL ISN'T COVERED UNDER THE RECALL IS RIDICULOUS. THIS APPEARS TO ONCE AGAIN BE GM DISREGARDING SAFETY CAUSED BY THEIR FAILURES IN PRODUCTION SO THAT THEY CAN MAKE MORE MONEY.
NHTSA ODI #10983128
140,000 miles · Apr 20, 2017
Electrical System
TL* THE CONTACT OWNS A 2011 GMC ACADIA. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT MENTIONED THAT THE FAILURE RECURRED MULTIPLE TIMES. THE CONTACT, A MECHANIC, FOUND NO ISSUES WITH THE BATTERY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAI…
Read full complaint
TL* THE CONTACT OWNS A 2011 GMC ACADIA. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT MENTIONED THAT THE FAILURE RECURRED MULTIPLE TIMES. THE CONTACT, A MECHANIC, FOUND NO ISSUES WITH THE BATTERY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.
NHTSA ODI #10979440
85,000 miles · Feb 9, 2017
Electrical System
TL* THE CONTACT OWNS A 2011 GMC ACADIA. THE CONTACT STATED THAT EVERY TIME THE AIR CONDITIONING WAS ACTIVATED, THE AIR FAILED TO BLOW OUT. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE REAR EVAPORATOR CORE AND BLOWER MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE F…
Read full complaint
TL* THE CONTACT OWNS A 2011 GMC ACADIA. THE CONTACT STATED THAT EVERY TIME THE AIR CONDITIONING WAS ACTIVATED, THE AIR FAILED TO BLOW OUT. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE REAR EVAPORATOR CORE AND BLOWER MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE WAS 85,000.
NHTSA ODI #10950441
89,500 miles · Aug 28, 2016
Electrical SystemService BrakesUnknown Or Other
OUR NITE MARE BEGAN DECEMBER 2015 PURCHASE OF THIS VEHICLE HAS BEEN IN SHOP MORE THEN WE'VE DRIVEN IT , FIRST THOUGHTS ON NON STARTING WAS NEEDED BIGGER BATTERY, DID THAT , SECOND THEY THOUGHT BATTERY ISSUES AGAIN , AN THIRD TIME OF NON STARTING SUPPOSE ABLE BAD GROUND ON TRANSMISSION, DID THAT, FOURTH TIME ANOTHER GROUND ON T…
Read full complaint
OUR NITE MARE BEGAN DECEMBER 2015 PURCHASE OF THIS VEHICLE HAS BEEN IN SHOP MORE THEN WE'VE DRIVEN IT , FIRST THOUGHTS ON NON STARTING WAS NEEDED BIGGER BATTERY, DID THAT , SECOND THEY THOUGHT BATTERY ISSUES AGAIN , AN THIRD TIME OF NON STARTING SUPPOSE ABLE BAD GROUND ON TRANSMISSION, DID THAT, FOURTH TIME ANOTHER GROUND ON TRANSMISSION BAD, FIFTH TIME THOUGHT SOME THING ELECTRICAL , PUT IN SOME SORT OF TRANSMISSION MODULE , SIXTH TIME BRAIN PART, SEVENTH TIME THE BACK HATCH AN 8TH TIME THEY HAVE NO IDEA ITS IN SHOP STILL FROM AUGUST 4TH LAST TIME DROVE ANIT LOCK BRAKES CAME ON AN SLOWED OUR SPEED FROM 55 TO 30 WE WERE ALL SCARED
NHTSA ODI #10902036
52,000 miles · Jan 26, 2016
Electrical SystemExterior Lighting
THE DAY TIME RUNNING LIGHT HAS FAILED AND MELTED THE HEADLIGHT HOUSING.
NHTSA ODI #10822429
40,000 miles · Jan 18, 2016
Electrical System
THE DRIVERS SIDE ELECTRICAL COMPONENTS GO HAYWIRE ON OCCASION. IT HAPPENS WHEN DRIVING, OR STATIONARY. HAPPENS IN ALL CONDITIONS. SOMETIMES I CAN'T MOVE MY SEAT, ROLL THE WINDOWS UP OR DOWN, OR UNLOCK THE DOORS USING THE DRIVERS SIDE CONTROLS. ADDITIONALLY, THE PASSENGER SIDE WINDOW WILL NOT ROLL DOWN A MAJORITY OF THE TIME. THE…
Read full complaint
THE DRIVERS SIDE ELECTRICAL COMPONENTS GO HAYWIRE ON OCCASION. IT HAPPENS WHEN DRIVING, OR STATIONARY. HAPPENS IN ALL CONDITIONS. SOMETIMES I CAN'T MOVE MY SEAT, ROLL THE WINDOWS UP OR DOWN, OR UNLOCK THE DOORS USING THE DRIVERS SIDE CONTROLS. ADDITIONALLY, THE PASSENGER SIDE WINDOW WILL NOT ROLL DOWN A MAJORITY OF THE TIME. THE RADIO ALSO, SWITCHES ITSELF FROM RADIO TO SAYING THERE IS AN AC ADAPTER PLUGGED IN SO IT WONT PLAY MUSIC, WHEN THERE IS NO ADAPTER TO INPUT MUSIC PLUGGED IN. THE GUARD OVER THE SEAT CONTROLS CAME UNHOOKED ABOUT A MONTH AFTER PURCHASE WITHOUT ANYONE TOUCHING IT. I HAVE REATTACHED IT BACK INTO PLACE NUMEROUS TIMES, IT DOESN'T STAY. I CALLED DEALER AND HE WAS CONFIDENT THERE WOULD BE A RECALL SOON TO COVER IT. HAS BEEN ALMOST 3 YEARS AND MY WARRANTY HAS ALREADY BEEN UP, AND THE RECALL THAT WAS "SURE TO COVER IT" HAS NOT HAPPENED YET.
NHTSA ODI #10820789
Mileage unknown · Nov 10, 2015
Electrical System
MY 2011 GMC ACADIA SUDDENLY DRAINED THE BATTERY, I TRIED TO START IT AND DIDN'T WORK, THE BATTERY WAS DEAD, SO I REPLACED THE BATTERY WITH A NEW ONE, THE NEXT DAY THE NEW BATTERY WAS DRAINED LIKE THE OLD ONE, SO I TOOK THE BATTERY BACK TO AUTOZONE, THEY CHECKED THE BATTERY AND WAS NOTHING WRONG WITH IT, THEY ALSO CHECKED THE VEH…
Read full complaint
MY 2011 GMC ACADIA SUDDENLY DRAINED THE BATTERY, I TRIED TO START IT AND DIDN'T WORK, THE BATTERY WAS DEAD, SO I REPLACED THE BATTERY WITH A NEW ONE, THE NEXT DAY THE NEW BATTERY WAS DRAINED LIKE THE OLD ONE, SO I TOOK THE BATTERY BACK TO AUTOZONE, THEY CHECKED THE BATTERY AND WAS NOTHING WRONG WITH IT, THEY ALSO CHECKED THE VEHICLE FOR ANY POSSIBLE PROBLEMS AND THE DIAGNOSTIC DIDN'T SHOW ANY PROBLEMS, SO THEY REPLACED THE BATTERY AGAIN WITH A NEW ONE,... SO I HAD THE NEW BATTERY INSTALLED ON MY VEHICLE AND WENT HOME, THE NEXT MORNING WHEN I TRIED TO START THE VEHICLE THE BATTERY WAS DEAD, I WENT ONLINE AND FOUND FORUMS TALKING ABOUT THE SAME PROBLEM, I BOUGHT THIS VEHICLE FOR MY WIFE AND SHE GOT VERY DISSAPOINTED FOR HAVING THIS ISSUES WITH THE VEHICLE, IT'S THE FIRST TIME THAT WE PURCHASED A GMC, WE HAD ALWAYS BOUGHT FORD VEHICLES, I CALLED GMC AND THEY DON'T HAVE ANY REPORTS WITH THIS TYPE OF PROBLEMS BUT THERE IS A LOT OF COMMENTS ON INTERNET FROM PEOPLE SUFFERING THE SAME SITUATION, .....I DON'T KNOW WHAT TO DO, AND CAN'T KEEP CHANGING THE BATTERY EVERYDAY TO BE ABLE TO USE MY VEHICLE.
NHTSA ODI #10789611
Official recalls
5Apr 8, 2021
General Motors, LLC (GM) is recalling certain 2010-2015, 2017 Buick Enclave, 2010-2019 Chevrolet Traverse, and 2011-2016 GMC Acadia vehicles. The side curtain air bags may not be properly attached.
Consequence & remedy
Consequence: Unsecured side curtain air bags may not perform as intended, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will inspect and, if necessary, realign or replace the weld nuts, free of charge. Owner notification letters were mailed on May 24, 2021. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N202321200.
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Apr 9, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET TRAVERSE, BUICK ENCLAVE, AND GMC ACADIA VEHICLES CURRENTLY REGISTERED IN ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING AND THE DISTRICT OF COLUMBIA. SNOW OR ICE BUILDUP ON THE WINDSHIELD OR ON THE WIPER MAY RESTRICT THE MOVEMENT OF THE WIPER ARM, CAUSING THE WIPER ARM TO LOOSEN AND CAUSE THE WIPER TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IF THIS OCCURS, DRIVER VISIBILITY COULD BE REDUCED, INCREASING THE RISK OF A CRASH.
Remedy: GM WILL NOTIFY OWNERS, AND DEALERS WILL TIGHTEN THE WIPER ARM NUTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 20, 2012.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Illustration