IllustrationSEVERE CORROSION OF BODY FRAME HARD POINT TO REAR OF LOWER CONTROL ARM OF FRONT SUSPENSION CAUSED BOTH FRONT WHEELS TO SPLAY OUT WITH UNCONTROLLABLE CAMBER AND STEERING. BOTH FRONT TIRES WORE ON INNER HALF OF TIRES ONLY AND VEHICLE REQUIRED HARD LEFT FORCE ON STEERING WHEEL TO CONTROL. *TR
1994 Geo Metro
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1994 Geo Metro do not stand out strongly from the model-year median of 36.
About this comparison →How this year compares
Owner complaints by model year
Compare all Metro years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 68 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Seat Belts. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports1 fire reports11 injury reports
Structure complaints
7 reportsTL*THE CONTACT OWNS A 1994 GEO METRO. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT HEARD A NOISE WHEN SHE DROVE OVER A BUMP. THE DEALER STATED THAT THE FRONT DRIVER SIDE TIRE FRAME WAS CORRODED, AND THE TIRE COULD FALL AT ANY MOMENT. THE MANUFACTURER WAS NOTIFIED; HOWEVER, THEY STATED THAT THE VEHICLE WAS OLD AND THE CONTAC…
Read full complaint
TL*THE CONTACT OWNS A 1994 GEO METRO. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT HEARD A NOISE WHEN SHE DROVE OVER A BUMP. THE DEALER STATED THAT THE FRONT DRIVER SIDE TIRE FRAME WAS CORRODED, AND THE TIRE COULD FALL AT ANY MOMENT. THE MANUFACTURER WAS NOTIFIED; HOWEVER, THEY STATED THAT THE VEHICLE WAS OLD AND THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR. THE VEHICLE WILL BE TAKEN TO A BODY SHOP FOR REPAIR. THE CURRENT AND FAILURE MILEAGES WERE 159,000.
LTR FM SUSAN LEBLANC (WI) RE HER 1994 GM GEO METRO HATCHBACK, THE FRAME OF THE CAR BROKE AWAY FROM THE BODY OF THE CAR, REPLY TO THE JANESVILLE DISTRICT OFFICE, ALL ATTACHMENTS NOT IMAGED FWD TO NVS200. *PH *JB *CB
WHILE DRIVING AT HIGHWAY SPEED, THE FRAME BROKE WITHOUT WARNING. *AK THE CONSUMER NOTED SHE WAS ALMOST KILLED BY THE DEFLECTING STEEL FROM THE DEFECTIVE FRAME. *PH *JB
SUPPORT BEAM FOR THE ROOF HAS SHARP EDGE THAT CAUSED INJURY.
DRIVER'S AND PASSENGER'S WINDOW ROLLED, INTERNAL ATTACHMENT HARDWARE THAT MOVES THE WINDOW UP AND DOWN IS BROKE. *AK
IN SUN LIGHT REFLECTION OF DASH ON WINDSHIELD DISTORTS IN DRIVERS VISIBILITY. TT
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.