Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 2 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
2 reports
Mileage unknown · Aug 13, 2023
Electrical SystemService BrakesVehicle Speed Control
Vehicle was driving fine, then warning lights that ABS system was no longer functioning, cruse control inoiperable, "go to shop immediatly" with no apparent cause. I took it to a shop and they attached the electronic scanner which indicated "Front Right Speed Sensor failed". This is the second speed sensor that I have had repl…
Read full complaint
Vehicle was driving fine, then warning lights that ABS system was no longer functioning, cruse control inoiperable, "go to shop immediatly" with no apparent cause. I took it to a shop and they attached the electronic scanner which indicated "Front Right Speed Sensor failed". This is the second speed sensor that I have had replaced this year (the first was one of the rear speed sensors). I replaced the front right speed sensor this morning, but the system has not reset. I hate to drive the vehicle with the warnings still indicated and cruise control inoperable, but I have no choice.
NHTSA ODI #11538211
100,000 miles · Jan 20, 2021
Wheels
I WORK FOR AN EXPEDITE TRANSPORT CARRIER. IN MY NOW CLOSE TO 3 YEARS DRIVING TWO SPRINTER 2500'S I HAVE HAD 7 OF THE 10 RIMS FAIL. IN EACH AND EVERY CASE THE SAME PROBLEM DEVELOPED. A HAIRLINE FRACTURE HAS THE RIM LOSING AIR NEAR WHERE THE VALVE STEM HOLE WAS PUNCHED. I MENTIONED 10 RIMS AS EVEN ONE OF THE TWO SPARES FAILED. IMH…
Read full complaint
I WORK FOR AN EXPEDITE TRANSPORT CARRIER. IN MY NOW CLOSE TO 3 YEARS DRIVING TWO SPRINTER 2500'S I HAVE HAD 7 OF THE 10 RIMS FAIL. IN EACH AND EVERY CASE THE SAME PROBLEM DEVELOPED. A HAIRLINE FRACTURE HAS THE RIM LOSING AIR NEAR WHERE THE VALVE STEM HOLE WAS PUNCHED. I MENTIONED 10 RIMS AS EVEN ONE OF THE TWO SPARES FAILED. IMHO THIS IS A CLEAR INDICATION THAT THIS PROBLEM IS NOT A WEAR AND TEAR THING. AFTER GETTING NEW TIRES LAST WEEK ALONG WITH A REPLACEMENT RIM I EXPLAINED MY PROBLEM TO THE TIRE TECHNICIAN. TO MY SURPRISE THEY FOUND A LEAK IN A RIM THAT WAS SUPPOSED TO BE REMOUNTED. THE OWNER OF THE TRANSPORTATION COMPANY I DRIVE FOR ALSO OWNS 3 MERCEDES 2500 SPRINTERS AND ALL 3 VEHICLES HAVE HAD SIMILAR PROBLEMS. I HAVE NOW STARTED COLLECTING THE DEFECTIVE RIMS. I HAVE 3 ALONG WITH PHOTOS OF A 4TH SHOWING THE LIQUID STOP LEAK OOZING FROM A FRACTURE. THESE RIMS ARE NOT RUSTY AND THE TECHNICIANS THEORY IS THAT THE HOLE STAMPING PROCESS FOR THE VALVE STEM HAS LIKELY COMPROMISED THE INTEGRITY OF THE STEEL NEAR THE HOLE. I BELIEVE THAT THESE RIMS AHOULD BE REPLACED
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach at their connection points under certain operating conditions, causing hydraulic fluid to leak.
Consequence & remedy
Consequence: The sudden loss of power steering assist and hydraulic steering fluid leaking onto the roadway may increase the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will check the return line connections of the power steering system, correcting it as needed, free of charge. The recall began December 23, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this campaign is NV3LETULPE.
Vantage Mobility International, LLC (Vantage) is recalling certain 2015-2018 Ford Transit Van, Mercedes-Benz Sprinter, and 2007 Ford F-250-based shuttle vehicles equipped with Freedman GO-3S foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Vantage has notified owners, instructing them to contact Freedman for a repair kit, free of charge. The recall began March 25, 2019. Owners may contact Freedman customer service at 1-800-443-4540.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2017 Freightliner Sprinter 2500 and 3500 and Mercedes-Benz Sprinter 2500 and 3500 vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the driver frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the driver frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: DVUSA will notify owners, and dealers will replace the front driver air bag module, free of charge. The recall is began March 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2014-2017 Freightliner Sprinter 2500 and 3500 and Mercedes-Benz Sprinter 2500 and 3500 vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: DVUSA will notify owners, and dealers will replace the front passenger air bag module, free of charge. The recall began March 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2013-2016 Mercedes-Benz Sprinter 2500 and 3500 and Freightliner Sprinter 2500 and 3500 vans. These vehicles were manufactured without a reinforcement plate and protective bracket on the air bag control unit. As a result, the air bag control unit may not remain functional after the initial impact, possibly preventing additional air bags from deploying in response to a secondary impact.
Consequence & remedy
Consequence: If additional air bags do not deploy as intended, the occupants are at an increased risk of injury.
Remedy: DVUSA will notify owners, and dealers will install a reinforcement plate and protective bracket around the air bag control unit, free of charge. The recall began on May 26, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2016 Mercedes-Benz Sprinter 2500 and 3500 vehicles manufactured May 31, 2015, to April 30, 2016, and 2015-2016 Freightliner Sprinter 2500 and 3500 vehicles manufactured May 1, 2015, to April 30, 2016. The affected vehicles are configured to have super-high roofs, but may not be equipped with the required crash pads.
Consequence & remedy
Consequence: If the required crash pads are missing, it can increase the risk of injury to a front passenger seat occupant if they are unbelted.
Remedy: DVUSA will notify owners, and dealers will install the required crash-pads, free of charge. The recall began on August 11, 2016. Owners may contact DVUSA customer service at 1-877-762-8267.
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2016 Mercedes Benz and Freightliner Sprinter 2500 and 3500 vehicles manufactured April 1, 2015, to October 31, 2015. The affected vehicles may have had multiple layers of paint applied, and as a result, in a crash, the windows may separate from the vehicle when the outer layer of paint peels from the layer below.
Consequence & remedy
Consequence: If the windows separate from the vehicle in a crash, the occupants are at a greater risk of injury.
Remedy: DVUSA will notify owners, and dealers will remove the windows and inspect the paintwork, repainting the vehicles as necessary, free of charge. This recall began August 4, 2016. Owners may contact DVUSA customer service at 1-770-705-2070.
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2016 Mercedes-Benz and Freightliner Sprinter 2500 and 3500 vans manufactured April 29, 2015, to December 15, 2015. The affected vehicles have a tire pressure label that incorrectly states a higher maximum load capacity than the vehicle is designed for.
Consequence & remedy
Consequence: The vehicle may be overloaded if loaded to the incorrect weight shown on the label, possibly resulting in axle or tire failure, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz and Freightliner dealers will replace the incorrect tire pressure label, free of charge. The recall began March 2016. Owners may contact DVUSA customer service at 1-877-762-8267.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2015 Freightliner Sprinter 2500 Problems, Complaints & Recalls | Skip That Year
Illustration