IllustrationFRAME IS CRACKED AND NEARLY SEPARATED ABOVE REAR AXLE. *TR
2002 Freightliner FS-65
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all FS-65 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 5 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Structure complaints
4 reportsTL* THE CONTACT OWNS A 2002 FREIGHTLINER FS65 SCHOOL BUS. THE CONTACT STATED THAT THE CROSS MEMBER FRAME WAS CRACK. THE CONTACT MENTIONED THAT THE FAILURE WAS FOUND AFTER A ROUTINE MAINTENANCE WAS COMPLETED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO OFFERED TO PAY FOR THE PARTS NEEDED FOR THE REPAIRS. THE VEHICLE WAS NO…
Read full complaint
TL* THE CONTACT OWNS A 2002 FREIGHTLINER FS65 SCHOOL BUS. THE CONTACT STATED THAT THE CROSS MEMBER FRAME WAS CRACK. THE CONTACT MENTIONED THAT THE FAILURE WAS FOUND AFTER A ROUTINE MAINTENANCE WAS COMPLETED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO OFFERED TO PAY FOR THE PARTS NEEDED FOR THE REPAIRS. THE VEHICLE WAS NOT REPAIR. THE FAILURE MILEAGE WAS 172,982.
TL* THE CONTACT OWNS A 2002 FREIGHTLINER FS65 SCHOOL BUS. THE CONTACT STATED THAT AFTER COMPLETING A ROUTINE MAINTENANCE ON THE VEHICLE THEY NOTICED THAT THE CROSS MEMBER FRAME WAS CRACK. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE WHO STATED THEY WILL REIMBURSE FOR THE PARTS BUT NOT FOR THE LABOR. THE VEHICLE WAS NOT REPAIRED.…
Read full complaint
TL* THE CONTACT OWNS A 2002 FREIGHTLINER FS65 SCHOOL BUS. THE CONTACT STATED THAT AFTER COMPLETING A ROUTINE MAINTENANCE ON THE VEHICLE THEY NOTICED THAT THE CROSS MEMBER FRAME WAS CRACK. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE WHO STATED THEY WILL REIMBURSE FOR THE PARTS BUT NOT FOR THE LABOR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 71,525.
TL* THE CONTACT OWNS A 2002 FREIGHT-LINER FS65 SCHOOL BUS. THE CONTACT STATED THAT AFTER HAVING ROUTING MAINTENANCE DONE ON THE VEHICLE, HE WAS NOTIFIED THAT THE CROSS MEMBER FRAME HAD DEVELOPED A CRACK. THE MANUFACTURER WAS NOTIFIED WHO STATED THAT THEY WOULD REIMBURSE FOR THE PARTS BUT NOT FOR THE LABOR. THE VEHICLE WAS NOT RE…
Read full complaint
TL* THE CONTACT OWNS A 2002 FREIGHT-LINER FS65 SCHOOL BUS. THE CONTACT STATED THAT AFTER HAVING ROUTING MAINTENANCE DONE ON THE VEHICLE, HE WAS NOTIFIED THAT THE CROSS MEMBER FRAME HAD DEVELOPED A CRACK. THE MANUFACTURER WAS NOTIFIED WHO STATED THAT THEY WOULD REIMBURSE FOR THE PARTS BUT NOT FOR THE LABOR. THE VEHICLE WAS NOT REPAIR. THE FAILURE MILEAGE WAS 129,210.
Official recalls
305V205000 · Fuel System, Diesel
Apr 27, 2005
CERTAIN 1998-2003 MY FREIGHTLINER FS-65 SCHOOL BUS CHASSIS AND MB-45, MB-55, AND XB SHUTTLE BUS CHASSIS, AND THOMAS BUILT BUS: MVP-ER AND MVP-EF SCHOOL BUS AND NON-SCHOOL BUS MODELS EQUIPPED WITH CUMMINS ISB DIESEL ENGINES AND EQUIPPED WITH FEDERAL-MOGAL 12 AND 24 VOLT FUEL LIFT PUMPS. THE FUEL PUMP COULD FAIL TO TRANSFER FUEL APPROPRIATELY CREATING AN ENGINE STALL CONDITION.
Consequence & remedy
Consequence: SHOULD THE ENGINE STALL WHILE THE VEHICLE IS IN USE, A POSSIBLE VEHICLE CRASH COULD OCCUR.
Remedy: CUMMINS WILL NOTIFY THE CUSTOMERS OF FREIGHTLINER AND THOMAS BUILT AND REPLACE THE FUEL LIFT PUMP FREE OF CHARGE. OWNERS MAY CONTACT CUMMINS AT 1-800-DIESELS.
04V343000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Jul 12, 2004
ON CERTAIN SCHOOL BUSES CHASSIS EQUIPPED WITH CATERPILLAR ENGINES AND HYDRAULIC BRAKES. A BRAIDED GROUND STRAP FOR THE STARTER MAY RUB ON A STEEL CHASSIS BRAKE LINE POTENTIALLY CAUSING A FLUID LEAK.
Consequence & remedy
Consequence: A BRAKE FLUID LEAK CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE THE STOPPING DISTANCE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE BRAKE LINE AND REPLACE IT, IF NECESSARY. THE BRAIDED GROUND STRAP WILL BE REPLACED WITH AN INSULATED CABLE. THE RECALL BEGAN ON AUGUST 10, 2004. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
02V084000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Apr 2, 2002
ON CERTAIN SCHOOL BUSES, THE BRAKE HOSES FROM THE CHASSIS TO FRONT BRAKE CHAMBERS COULD DEVELOP LEAKS DUE TO THE HOSE ROUTING THAT COULD OVERSTRESS THE HOSE DURING SHARP TURNS.
Consequence & remedy
Consequence: THE VEHICLE COULD HAVE REDUCED BRAKING CAPACITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR IMPROPER ROUTING. IF IMPROPER ROUTING IS FOUND, DEALERS WILL REPLACE AND CORRECT THE HOSE ROUTING. OWNER NOTIFICATION BEGAN APRIL 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE02024 · Front Air Brake Hose Leakage
Opened Feb 22, 2002 · Closed Mar 25, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available