NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
12 reports172,600 miles · Jun 9, 2019
Electrical SystemEngineSteeringCrashInjury
ON 5-24-19, I WAS TRAVELING WEST ON HWY 56, 4 MILES EAST OF HERINGTON KS. SUDDENLY WITHOUT NOTICE, MY ENGINE SHUT OFF, I WAS LEFT WITH A DEAD TRUCK, TRAVELING AT 62 MPH, AND MY TANKER WAS FULLY LOADED, I COULD NOT HOLD THE TRUCK ON THE ROAD, THE RIGHT FRONT TIRE CAUGHT THE SOFT EDGE OF THE ROAD, AND I WAS PULLED INTO THE DITCH,…
Read full complaint
ON 5-24-19, I WAS TRAVELING WEST ON HWY 56, 4 MILES EAST OF HERINGTON KS. SUDDENLY WITHOUT NOTICE, MY ENGINE SHUT OFF, I WAS LEFT WITH A DEAD TRUCK, TRAVELING AT 62 MPH, AND MY TANKER WAS FULLY LOADED, I COULD NOT HOLD THE TRUCK ON THE ROAD, THE RIGHT FRONT TIRE CAUGHT THE SOFT EDGE OF THE ROAD, AND I WAS PULLED INTO THE DITCH, MY SEMI ROLLED AND I WAS PINNED INSIDE THE CAB, EMS PERSONAL WORKED FOR OVER 90 MINUTES TO FREE ME FROM THE WRECKAGE. IM VERY LUCKY TO BE ALIVE, RECOVERY WILL TAKE MONTHS. I WANT TO SEE AN INVESTIGATION INTO THIS PROBLEM, THIS MODEL HAS MANY ELECTRICAL PROBLEMS, BUT WHEN YOU LOOSE EVERYTHING, YOU CRASH. IF YOU ARE DRIVING A FREIGHTLINER CASCADIA I'M PRAYING FOR YOU, I HOPE THIS PROBLEM CAN BE FOUND, AND FIXED, GOING THROUGH WHAT I WENT THROUGH IS HORRIBLE. WHEN THE TOTAL LOSS OF POWER OCCURRED, MY DIGITAL VOLTAGE GAUGE WENT FROM 14.1 VOLTS TO 4.7 VOLTS
NHTSA ODI #11218765
Mileage unknown · Mar 19, 2019
Electrical SystemExterior Lighting
TRAILER LIGHT NOT WORKING DAMAGED SAM CHASSIS
NHTSA ODI #11189852
500,000 miles · Sep 2, 2018
Electrical SystemPower TrainService Brakes
THIS VEHICLE IT'S HAVING POWER TRAIN PROBLEMS CAUSING THE VEHICLE BEEN HARD TO CONTROL ON THE ROAD PLUS ITS BRAKING WRONG AT TIMES. SOME TIMES IT BRAKE WELL, MOST OF THE TIMES IT DON'T BRAKE. ONGUARD SYSTEM TOO INTRUSIVE MAKING VERY HARD BRAKING IN FALSE ( BRIDGE DETECTED AS STOPED OBJET, ONGUARD IT FULL ALIGNED. TRANSMISSION IT…
Read full complaint
THIS VEHICLE IT'S HAVING POWER TRAIN PROBLEMS CAUSING THE VEHICLE BEEN HARD TO CONTROL ON THE ROAD PLUS ITS BRAKING WRONG AT TIMES. SOME TIMES IT BRAKE WELL, MOST OF THE TIMES IT DON'T BRAKE. ONGUARD SYSTEM TOO INTRUSIVE MAKING VERY HARD BRAKING IN FALSE ( BRIDGE DETECTED AS STOPED OBJET, ONGUARD IT FULL ALIGNED. TRANSMISSION IT'S NOT SMOOTH AT BACKING OR PULLING SLOWLY. MORE THAN 70,000 DOLLARS INVESTED IN REPAIRS IN A TIME OF 2.5 YEARS AND THE PROBLEMS PERSIST. FREIGHTLINER DEALERS SEEMS CARELESS ABOUT IT AND STATED IT'S NOT FAULT ON IT. AND LAST TIME THEY SAID IT'S A TIRE RELATED PROBLEM BUT THEY DON'T KNOW WHAT AND THEY NOT ABLE TO FIX.
NHTSA ODI #11123999
Mileage unknown · Feb 7, 2017
Fuel System, DieselVehicle Speed Control
TL* THE CONTACT DROVE A 2011 FREIGHTLINER CASCADIA. THE CONTACT DROVE THE VEHICLE FOR WORK. THE CONTACT STATED THAT THE DIESEL ENHANCEMENT FLUID LEVEL COMPONENT FAILED TO WORK PROPERLY, INCLUDING THE SENSOR/WARNING INDICATOR. IN ADDITION, THE SPEEDOMETER FAILED TO FUNCTION AND THE EQUIPMENT WAS NOT FUNCTIONING PROPERLY. THE CONT…
Read full complaint
TL* THE CONTACT DROVE A 2011 FREIGHTLINER CASCADIA. THE CONTACT DROVE THE VEHICLE FOR WORK. THE CONTACT STATED THAT THE DIESEL ENHANCEMENT FLUID LEVEL COMPONENT FAILED TO WORK PROPERLY, INCLUDING THE SENSOR/WARNING INDICATOR. IN ADDITION, THE SPEEDOMETER FAILED TO FUNCTION AND THE EQUIPMENT WAS NOT FUNCTIONING PROPERLY. THE CONTACT WAS NOT ABLE TO DRIVE THE VEHICLE DUE TO THE FAILURES. THE VEHICLE WAS LEFT AT A TRUCK STOP. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.
NHTSA ODI #10950072
520,000 miles · Apr 20, 2016
Electrical SystemExterior LightingFuel/propulsion System
WHEN OUR VEHICLE IS OPERATING AT HIGHWAY SPEEDS THE VEHICLE LOSES ALL POWER AS IF YOU HAD TURNED OFF THE IGNITION SWITCH AND THEN TURNED IT BACK ON. THIS LASTS FOR A FEW SECONDS WHERE TOTAL CONTROL TO THE VEHICLE IS LOST BEFORE IT RESUMES NORMAL WORKING CONDITIONS. WE HAVE SPOKEN TO THE LOCAL FREIGHTLINER DEALER WHO HAS ADVISE…
Read full complaint
WHEN OUR VEHICLE IS OPERATING AT HIGHWAY SPEEDS THE VEHICLE LOSES ALL POWER AS IF YOU HAD TURNED OFF THE IGNITION SWITCH AND THEN TURNED IT BACK ON. THIS LASTS FOR A FEW SECONDS WHERE TOTAL CONTROL TO THE VEHICLE IS LOST BEFORE IT RESUMES NORMAL WORKING CONDITIONS. WE HAVE SPOKEN TO THE LOCAL FREIGHTLINER DEALER WHO HAS ADVISED US THAT THIS IS A COMMON ISSUE WITH THESE UNITS, HOWEVER, THEY ARE UNAWARE OF WHAT CAUSES THIS ISSUE AND ARE UNABLE TO FIX IT. WE DO NOT CURRENTLY HAVE ANY REPAIR ITEMS TO INCLUDE WITH THIS AS THE DEALER HAS NOT CHARGED US FOR ANY WORK DUE TO THEIR INABILITY TO REPAIR IT. THIS PUTS ANY DRIVER IN A COMPROMISED POSITION AS THEY ARE UNABLE TO CONTROL THEIR TRUCK DURING THESE PERIODS OF COMPLETE POWER OUTAGE. THE POWER OUTAGE ON THE UNIT HAS HAPPENED ON MULTIPLE OCCASIONS WITH THIS UNIT WITH NO REMEDY PROVIDED FROM THE DEALER.
NHTSA ODI #10860522
483,000 miles · Dec 11, 2015
Engine
TL* THE CONTACT OWNS A 2011 FREIGHTLINER CASCADIA. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH, THE ENGINE STALLED AND RESTARTED WHILE ALL THE WARNING LIGHTS WHERE ILLUMINATED. THE FAILURE WAS PERSISTENT. THE CONTACT ALSO STATED THAT HE RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V616000 (TRAILER HITCHES) BUT THE RECAL…
Read full complaint
TL* THE CONTACT OWNS A 2011 FREIGHTLINER CASCADIA. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH, THE ENGINE STALLED AND RESTARTED WHILE ALL THE WARNING LIGHTS WHERE ILLUMINATED. THE FAILURE WAS PERSISTENT. THE CONTACT ALSO STATED THAT HE RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V616000 (TRAILER HITCHES) BUT THE RECALL REMEDY WAS NOT AVAILABLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT COULD NOT BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 483,000.
NHTSA ODI #10809749
538,000 miles · Feb 28, 2015
Fuel/propulsion SystemPower TrainService Brakes
1. AT FIRST, I FELT THE VEHICLE HESITATE WHEN I UP-SHIFT. I GOT INTO THE HIGHWAY AND THE ENGINE STARTED TO MISS GRADUALLY AND GETTING WORSE. I PULLED INTO A FREIGHT-LINER AND THE SAY THAT FUEL LINE IS CONTAMINATED BECAUSE THE FUEL PUMP BROKE INSIDE. THEY SAID THEY HAVE TO FLUSH OUT THE LINES AND REPLACE THE FILTER, INJECTORS, FU…
Read full complaint
1. AT FIRST, I FELT THE VEHICLE HESITATE WHEN I UP-SHIFT. I GOT INTO THE HIGHWAY AND THE ENGINE STARTED TO MISS GRADUALLY AND GETTING WORSE. I PULLED INTO A FREIGHT-LINER AND THE SAY THAT FUEL LINE IS CONTAMINATED BECAUSE THE FUEL PUMP BROKE INSIDE. THEY SAID THEY HAVE TO FLUSH OUT THE LINES AND REPLACE THE FILTER, INJECTORS, FUEL PUMP AND HIGH PRESSURE FUEL LINES. I JUST BOUGHT A FULL TANK OF DIESEL BEFORE THE INCIDENT. ALL THE FUEL WILL BE DUMPED AND FUEL TANKS WILL BE CLEANED. I HAVE THE ESTIMATED REPAIR TO COST OVER $10,000 DOLLARS. I CALLED DAIMLER CORPORATE OFFICE TO SEE IF THEY COULD HELP ME TO COVER SOME OF THE BILLS THEY DECLINED WITH THE EXCUSE THAT THE TRUCK IS 38,000 MILES OVER THE WARRANTY AN ESTIMATE OF ABOUT 2 MONTHS.THIS PROBLEM IS NOT MY FAULT, IT IS A DEFECTIVE PRODUCT. 2. THE BOTTOM SCREW HOLDING THE FUEL RAIL LEAKS OIL. THEY SEALED THE OIL IN WITH SILICON AND I JUST CHANGED AIR COMPRESSOR FOR OIL LEAK. I HAVE JUST BOUGHT THE TRUCK 6 MONTHS AGO. THE TRUCK MAY HAVE HAD AN ACCIDENT BEFORE. WHEN I STEP HARD ON THE BRAKE PEDAL, I HEAR A LOUD METAL KNOCKING NOISE FROM THE FRONT DRIVER SIDE BRAKE CHAMBER. AND THAT AFFECT THE STEERING. *TR
NHTSA ODI #10691274
538,000 miles · Feb 28, 2015
Fuel/propulsion System
1. AT FIRST, I FELT THE VEHICLE HESITATE WHEN I UP-SHIFT. I GOT INTO THE HIGHWAY AND THE ENGINE STARTED TO MISS GRADUALLY AND GETTING WORSE. I PULLED INTO A FREIGHT-LINER AND THE SAY THAT FUEL LINE IS CONTAMINATED BECAUSE THE FUEL PUMP BROKE INSIDE. THEY SAID THEY HAVE TO FLUSH OUT THE LINES AND REPLACE THE FILTER, INJECTORS, FU…
Read full complaint
1. AT FIRST, I FELT THE VEHICLE HESITATE WHEN I UP-SHIFT. I GOT INTO THE HIGHWAY AND THE ENGINE STARTED TO MISS GRADUALLY AND GETTING WORSE. I PULLED INTO A FREIGHT-LINER AND THE SAY THAT FUEL LINE IS CONTAMINATED BECAUSE THE FUEL PUMP BROKE INSIDE. THEY SAID THEY HAVE TO FLUSH OUT THE LINES AND REPLACE THE FILTER, INJECTORS, FUEL PUMP AND HIGH PRESSURE FUEL LINES. I JUST BOUGHT A FULL TANK OF DIESEL BEFORE THE INCIDENT. ALL THE FUEL WILL BE DUMPED AND FUEL TANKS WILL BE CLEANED. I HAVE THE ESTIMATED REPAIR TO COST OVER $10,000 DOLLARS. I CALLED DAIMLER CORPORATE OFFICE TO SEE IF THEY COULD HELP ME TO COVER SOME OF THE BILLS THEY DECLINED WITH THE EXCUSE THAT THE TRUCK IS 38,000 MILES OVER THE WARRANTY AN ESTIMATE OF ABOUT 2 MONTHS.THIS PROBLEM IS NOT MY FAULT, IT IS A DEFECTIVE PRODUCT. 2. THE BOTTOM SCREW HOLDING THE FUEL RAIL LEAKS OIL. THEY SEALED THE OIL IN WITH SILICON AND I JUST CHANGED AIR COMPRESSOR FOR OIL LEAK. I HAVE JUST BOUGHT THE TRUCK 6 MONTHS AGO. *TR
NHTSA ODI #10691273
50,000 miles · Oct 2, 2012
SeatsInjury
TL* THE CONTACT OWNS A 2011 FREIGHTLINER CASCADIA. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE DRIVER'S SEAT LOST AIR PRESSURE RAPIDLY, CAUSING HIM TO SLAM INTO THE FLOOR LOSING SIGHT OF THE ROADWAY AND HIS FOOTING. THE FAILURE RECURRED REPEATEDLY. THE CONTACT DEVELOPED A COMPRESSED DISC IN HIS NECK AND DAMAGED HIS BRACHIA…
Read full complaint
TL* THE CONTACT OWNS A 2011 FREIGHTLINER CASCADIA. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE DRIVER'S SEAT LOST AIR PRESSURE RAPIDLY, CAUSING HIM TO SLAM INTO THE FLOOR LOSING SIGHT OF THE ROADWAY AND HIS FOOTING. THE FAILURE RECURRED REPEATEDLY. THE CONTACT DEVELOPED A COMPRESSED DISC IN HIS NECK AND DAMAGED HIS BRACHIAL PLEXUS, CAUSING A LOSS OF THE FULL FUNCTION OF HIS RIGHT ARM AND HANDS.THE CONTACT ALERTED THE OWNER OF THE VEHICLE AND BOTH THE DRIVER AND PASSENGER SEATS WERE REPLACED. THE FAILURE RECURRED. THE MILEAGE WAS NOT AVAILABLE. UPDATED 11/13/12 *CN THE CONSUMER STATED THE VEHICLE IS OWNED BY SCHNEIDER TRUCKING. THE AIR VALVE FOR THE SEAT NEEDS TO BE REPLACED. UPDATED 11/29/2012 *JS UPDATED 12/12/12 *BF UPDATED 12/19/2012 *JS
NHTSA ODI #10478314
248,561 miles · Sep 22, 2012
Electrical System
I STARTED TRAVELING DOWN THE ROAD AND THE SPEEDOMETER DROPPED TO 5 MPH, AND STAYED THERE FOR ABOUT 100 MILES WHILE I WAS ON THE WAY TO TAKE IT TO A SHOP. BEFORE I MADE IT TO THE SHOP IT STARTED WORKING PROPERLY AGAIN. THE COMPANY IM LEASED ON TO INFORMED ME THEY ARE HAVING THIS SAME ISSUE WITH THEIR CASCADIAS ALSO. THE SPEEDOMET…
Read full complaint
I STARTED TRAVELING DOWN THE ROAD AND THE SPEEDOMETER DROPPED TO 5 MPH, AND STAYED THERE FOR ABOUT 100 MILES WHILE I WAS ON THE WAY TO TAKE IT TO A SHOP. BEFORE I MADE IT TO THE SHOP IT STARTED WORKING PROPERLY AGAIN. THE COMPANY IM LEASED ON TO INFORMED ME THEY ARE HAVING THIS SAME ISSUE WITH THEIR CASCADIAS ALSO. THE SPEEDOMETER WILL JUST STOP WORKING FOR A LITTLE BIT AND THEN JUST START BACK AGAIN, IT WILL ALSO HAVE A CHECK ENGINE LIGHT COME ON AFTER ABOUT 40 MILES. *TR
NHTSA ODI #10476742
Official recalls
23Apr 14, 2020
Daimler Trucks North America LLC (DTNA) is recalling certain 2006-2020 Freightliner Columbia, 2006-2021 Freightliner Business Class M2, 2007-2020 Freightliner Coronado, 2014-2021 Freightliner 122 SD, 2007 Sterling A 9500, 2006 Freightliner Argosy, 2006-2007 Sterling AT9500, 2008-2021 Freightliner Cascadia, 2006-2008 Freightliner Classic, 2006-2011 Freightliner Century Class, 2006-2010 Freightliner FLD, and 2017 Western Star 5700 vehicles. The rear reflective tape may be partially covered by the mudflap hanger bracket, which may reduce the vehicle's visibility to other drivers on the road. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: The vehicle's rearward visibility may be reduced, increasing the risk of a crash.
Remedy: DTNA will notify owners, and dealers will inspect and reposition the reflective tape to ensure that it is completely visible, as necessary, free of charge. The recall began May 29, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL848.
Dec 15, 2017
Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Freightliner Cascadia, Century Class, Columbia and Coronado trucks and Western Star 4700, 4900, 5700, 5900 and 6900 trucks. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Remedy: DTNA will notify owners, and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on April 11, 2018. Owners may contact DTNA customer service at 1-800-547-0712, or contact Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. DTNA's number for this recall is FL-759.
Nov 27, 2017
Daimler Trucks North America, LLC (DTNA) is recalling certain 2008-2018 Freightliner Cascadia, Western Star 4700, 4900, 5700, and 6900 trucks. After hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal.
Consequence & remedy
Consequence: If the brake lights fail to illuminate, there would not be a signal to other motorists that the vehicle is slowing, increasing the risk of a crash.
Remedy: DTNA will notify owners, and dealers will repair the vehicles, free of charge. Daimler issued interim notifications to owners on January 22, 2018. The recall began on May 9, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-756.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
Daimler Trucks North America, LLC (DTNA) is recalling certain 2008-2018 Freightliner Cascadia, Western Star 4700, 4900, 5700, and 6900 trucks. After hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal.
Consequence: If the brake lights fail to illuminate, there would not be a signal to other motorists that the vehicle is slowing, increasing the risk of a crash.
Remedy: DTNA will notify owners, and dealers will repair the vehicles, free of charge. Daimler issued interim notifications to owners on January 22, 2018. The recall began on May 9, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-756.
Exterior Lighting:brake Lights
Daimler Trucks North America, LLC (DTNA) is recalling certain 2008-2018 Freightliner Cascadia, Western Star 4700, 4900, 5700, and 6900 trucks. After hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal.
Consequence: If the brake lights fail to illuminate, there would not be a signal to other motorists that the vehicle is slowing, increasing the risk of a crash.
Remedy: DTNA will notify owners, and dealers will repair the vehicles, free of charge. Daimler issued interim notifications to owners on January 22, 2018. The recall began on May 9, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-756.
Oct 1, 2015
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2011-2014 Cascadia, Business Class M2, Coronado, and Columbia Glider vehicles manufactured April 5, 2010, to June 15, 2013. The affected trucks are equipped with Fontaine Ultra LT Fifth Wheel connectors, which, due to cumulative damage to the fifth wheel and its locking mechanism, have a locking mechanism that may fail to operate or to properly engage.
Consequence & remedy
Consequence: If the fifth wheel and locking mechanism are sufficiently damaged, the locking mechanism may fail to operate as intended and the trailer may unexpectedly detach from the tractor, increasing the risk of a crash.
Remedy: DTNA will notify owners, and DTNA authorized service facilities will replace the fifth wheel with an Ultra NT model fifth wheel, free of charge. The recall began on November 20, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-692.
Mar 4, 2015
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2007-2011 Freightliner Cascadia trucks manufactured March 26, 2007, to August 31, 2010. Water may leak into the Signal-detection and Activation Module (SAM) Chassis causing corrosion which may result in electrical shorts or possible intermittent operation of trailer lights.
Consequence & remedy
Consequence: Intermittent operation of the trailer lights may prevent other drivers from knowing that the truck is slowing or stopping, increasing the risk of a vehicle crash. Additionally, an electrical short in the SAM chassis may result in a a fire.
Remedy: DTNA will notify owners, and dealers will inspect the SAM chassis for corrosion, replacing it as necessary. Any vehicle that does not have a drip shield mounted in the cab over the SAM chassis will receive one. These repairs will be performed free of charge. An interim letter was sent to owners on May 4, 2015. The recall began on October 8, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-679.
Oct 29, 2014
Daimler Trucks of North America LLC (DTNA) is recalling certain model year 2011-2015 Freightliner Cascadia and M2 trucks manufactured June 2, 2011 to October 23, 2014. The vehicles are not in compliance with the requirements of the Federal Motor Vehicle Safety Standards No. 303, "Fuel System Integrity Of Compressed Natural Gas Vehicles." Specifically, the tail pipe on these vehicles terminates under the compressed natural gas (CNG) tank and can overheat the fuel system.
Consequence & remedy
Consequence: Due to the area of its placement, the exhaust system forces heat around, and may overheat, the fuel system components, increasing the risk of a vehicle fire.
Remedy: DTNA will notify owners, and dealers will extend the tailpipe beyond the cabinet, free of charge. The recall began Feburary 12, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-671.
Additional source detail variants (2)
Fuel System, Other:storage:tank Assembly
Daimler Trucks of North America LLC (DTNA) is recalling certain model year 2011-2015 Freightliner Cascadia and M2 trucks manufactured June 2, 2011 to October 23, 2014. The vehicles are not in compliance with the requirements of the Federal Motor Vehicle Safety Standards No. 303, "Fuel System Integrity Of Compressed Natural Gas Vehicles." Specifically, the tail pipe on these vehicles terminates under the compressed natural gas (CNG) tank and can overheat the fuel system.
Consequence: Due to the area of its placement, the exhaust system forces heat around, and may overheat, the fuel system components, increasing the risk of a vehicle fire.
Remedy: DTNA will notify owners, and dealers will extend the tailpipe beyond the cabinet, free of charge. The recall began Feburary 12, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-671.
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Daimler Trucks of North America LLC (DTNA) is recalling certain model year 2011-2015 Freightliner Cascadia and M2 trucks manufactured June 2, 2011 to October 23, 2014. The vehicles are not in compliance with the requirements of the Federal Motor Vehicle Safety Standards No. 303, "Fuel System Integrity Of Compressed Natural Gas Vehicles." Specifically, the tail pipe on these vehicles terminates under the compressed natural gas (CNG) tank and can overheat the fuel system.
Consequence: Due to the area of its placement, the exhaust system forces heat around, and may overheat, the fuel system components, increasing the risk of a vehicle fire.
Remedy: DTNA will notify owners, and dealers will extend the tailpipe beyond the cabinet, free of charge. The recall began Feburary 12, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-671.
Feb 21, 2014
Daimler Trucks North America LLC (Daimler) is recalling certain model year 2008-2015 Freightliner 114SD, Cascadia, M2 Business Class, Sterling LT8500, and Thomas Built Buses Saf-T-Liner HDX vehicles manufactured February 19, 2008, through February 11, 2014, and equipped with Cummins Westport Model ISL G and Cummins Westport Model ISX12 G engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor.
Consequence & remedy
Consequence: The sensor malfunction could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a vehicle fire or burn injury to a person near the exhaust pipe.
Remedy: Cummins and Cummins Westport will notify owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The recall began on April 12, 2014. Customers may contact Daimler at 1-800-385-4357 or Cummins Inc. at 1-800-343-7357. Daimler's number for this recall is FL-660.
Aug 16, 2012
Daimler Trucks North America (DTNA) is recalling certain model year 2009-2012 Freightliner, Sterling, and Western Star vehicles manufactured from July 7, 2008, through December 15, 2011, and equipped with perpendicular air tank mounting brackets. The air tank mounting brackets may develop cracks which can lead to the air tank brackets separating from the frame rail. The air tanks may also separate from the vehicle.
Consequence & remedy
Consequence: Air tanks that become separated from a moving vehicle may create a road debris hazard, increasing the risk of a crash.
Remedy: DTNA will notify owners, and dealers will replace the air mounting brackets, free of charge. The recall began on December 24, 2012. Owners may contact Daimler Trucks North America toll free at 1-800-547-0712.
Feb 28, 2012
DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006-2013 FREIGHTLINER, STERLING, AND WESTERN STAR VEHICLES, EQUIPPED WITH DETROIT DIESEL EPA07 AND EPA10, DD13 AND DD15/16 ENGINES, MANUFACTURED FROM JANUARY 20, 2006, THROUGH FEBRUARY 20, 2012. THE PUMP TO RAIL HIGH PRESSURE FUEL LINE SUPPORT SYSTEM USED ON THESE ENGINES IS SENSITIVE TO ASSEMBLY TORQUE AND MAY BE DAMAGED DURING SERVICE WORK. AS A RESULT OF OTHER REPAIRS, THE LINE SUPPORTS MAY LOOSEN, POTENTIALLY LEADING TO FUEL LINE CRACKING AND A FUEL LEAK.
Consequence & remedy
Consequence: A FUEL LEAK COULD CREATE A ROAD HAZARD, INCREASING THE RISK OF A CRASH. ALSO A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DTNA WILL NOTIFY OWNERS, AND WHERE NECESSARY, THE HIGH PRESSURE FUEL LINE SUPPORT SYSTEM WILL BE REPLACED BY DTNA AUTHORIZED SERVICE FACILITIES, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
Oct 13, 2011
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2005-2011 FREIGHTLINER CASCADIA, COLUMBIA, CENTURY, CORONADO, AND CLASSIC XL TRUCKS MANUFACTURED FROM NOVEMBER 1, 2004, THROUGH JUNE 15, 2010 FOR THE RACK AND PINION STEERING SYSTEM. THE LOWER PINION BEARING MAY CORRODE AND FAIL. A FAILED BEARING MAY LEAD TO DAMAGE OF THE SPOOL VALVE SEALS. A DAMAGE SPOOL VALVE SEAL MAY ALLOW HYDRAULIC FLUID TO FLOW TO THE RIGHT OR LEFT TURN PORT INSTEAD OF FLOWING TO THE RETURN PORT.
Consequence & remedy
Consequence: THE STEERING COULD UNEXPECTEDLY TURN LEFT OR RIGHT, MAKING THE VEHICLE MORE DIFFICULT TO CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DAIMLER TRUCKS WILL INSPECT THE LOWER BEARING FOR CORROSION. IF CORROSION IS FOUND, THE RACK AND PINION SYSTEM WILL BE REPLACED. IF NO CORROSION IS FOUND, ON THE BEARING, THE BEARING WILL BE PACKED WITH GREASE AND THE RUBBER BELLOWS WILL BE REPLACED WITH SEALANT ADDED BETWEEN THE BELLOWS AND THE RACK HOUSING. AN INTERIM LETTER WAS MAILED IN DECEMBER 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
Sep 8, 2011
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2006-2012 FREIGHTLINER BUSINESS CLASS M2, CASCADIA, CENTURY, COLUMBIA, CORONADO AND STERLING A-LINE VEHICLES BUILT WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) SYSTEM MANUFACTURED FROM SEPTEMBER 15, 2005 THROUGH SEPTEMBER 1, 2011. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.
Consequence & remedy
Consequence: IF THE DRIVER IS SLOW TO REACT DURING THIS ESC INTERVENTION, THE VEHICLE MAY DEVIATE FROM THE INTENDED LINE OF TRAVEL INCREASING THE RISK OF A CRASH.
Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE ESC MODULE WITH THE APPROPRIATE SOFTWARE VERSION AS NECESSARY, FREE OF CHARGE. AN INTERIM OWNER NOTIFICATION WILL BE MAILED ON OR ABOUT NOVEMBER 21, 2011. THE DATE FOR AVAILABILITY OF THE FINAL REMEDY IS SUBJECT TO VALIDATION TESTING AND PARTS AVAILABILITY. THE SAFETY RECALL BEGAN ON MARCH 28, 2012. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
Jun 21, 2011
DTNA IS RECALLING CERTAIN MODEL YEAR 2008-2012 FREIGHTLINER; CASCADIA, CENTURY CLASS, COLUMBIA, AND CORONADO, CERTAIN MODEL YEAR 2008-2009 STERLING; A-LINE AND L-LINE AND CERTAIN MODEL YEAR 2009-2012 WESTERN STAR CONSTELLATION VEHICLES, MANUFACTURED FROM JANUARY 14, 2008, THROUGH JUNE 15, 2011, BUILT WITH DETROIT DIESEL 15 OR 16 ENGINES. THE BOLT ATTACHING A RUBBER ISOLATOR TO A SUPPORT BRACKET MAY BECOME LOOSE AND BACK OUT, POTENTIALLY CONTACTING AN UN-FUSED STARTER CABLE AND CREATING A SHORT CIRCUIT.
Consequence & remedy
Consequence: A SHORT CIRCUIT BETWEEN AN UN-FUSED BATTERY CABLE AND CHASSIS GROUND COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A NEW BOLT AND ISOLATOR AND REPAIR THE RECREATIONAL VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 21, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
May 18, 2011
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2011 FREIGHTLINER CASCADIA, CENTURY, COLUMBIA, CORONADO, M2, AND WESTERN STAR 4900 HEAVY TRUCKS MANUFACTURED FROM FEBRUARY 19, 2009, THROUGH JULY 9, 2010, EQUIPPED WITH SPECIFIC DD13 AND DD15 ENGINES ASSEMBLED WITH A BOSCH HIGH PRESSURE FUEL PUMP ELEMENT WHICH MAY DEVELOP A CRACK DUE TO HYDROGEN INDUCED STRESS CORROSION. THE CRACK MAY RESULT IN A DIESEL FUEL LEAK.
Consequence & remedy
Consequence: IF A DIESEL FUEL LEAK CONTINUES UNDETECTED, FUEL MAY SPILL ONTO THE ROADWAY INCREASING THE RISK OF A CRASH.
Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES, FREE OF CHARGE. THIS RECALL IS AN EXPANSION OF A PREVIOUS RECALL (SEE RECALL CAMPAIGN 10V-339). THE SAFETY RECALL BEGAN ON MAY 18, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
May 18, 2011
DTNA IS RECALLING CERTAIN MODEL YEAR 2011 BUSINESS CLASS M2, AND CORONADO, MODEL YEAR 2011-2012 CASCADIA VEHICLES EQUIPPED WITH FONTAINE ULTRA LT FIFTH WHEELS AND MANUFACTURED FROM APRIL 7, 2010, THROUGH MARCH 7, 2011. DURING THE COUPLING PROCESS ON VEHICLES EQUIPPED WITH PRE-MODIFICATION FONTAINE ULTRA LT FIFTH WHEELS, IT IS POSSIBLE FOR THE DRIVER TO PARTIALLY CLOSE THE FIFTH WHEEL LOCK, AND IF RELYING ON A TUG TEST (PULL TEST), AND NOT PERFORMING THE REQUIRED VISUAL INSPECTION, THINK THAT THE FIFTH WHEEL LOCK IS PROPERLY COUPLED TO THE TRAILER KING PIN, WHEN IN FACT, IT IS NOT.
Consequence & remedy
Consequence: IF THE TRACTOR IS NOT FULLY CONNECTED TO THE TRAILER, THE TRAILER MAY DISENGAGE WHILE IN USE, INCREASING THE RISK OF A CRASH.
Remedy: FONTAINE NOTIFIED OWNERS IN FEBRUARY 2011, AND IS HANDLING THE REMEDY FOR THIS CAMPAIGN. FONTAINE IS IN THE PROCESS OF RETROFITTING ALL AFFECTED VEHICLES, FREE OF CHARGE. OWNERS MAY CONTACT FONTAINE AT 1-800-874-9780 OR DTNA AT 1-800-547-0712.
Apr 26, 2011
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2011-2012 FREIGHTLINER CASCADIA, M2, AND WESTERN STAR 4900 VEHICLES, MANUFACTURED FROM JANUARY 11, 2011, THROUGH FEBRUARY 21, 2011, AND EQUIPPED WITH A MERITOR DRIVELINE. THE TUBING USED TO ASSEMBLE THE AFFECTED DRIVELINES HAS A NONCONFORMING SEAM WELD WITH INSUFFICIENT BONDING OF THE MATERIAL.
Consequence & remedy
Consequence: A TUBE SEAM WELD THAT IS NOT PROPERLY BONDED CAN RESULT IN THE DRIVELINE ASSEMBLY FRACTURING ALONG THE LENGTH OF THE TUBE SEAM WELD. THE FRACTURED TUBE CAN TWIST OR SEVER. THIS COULD RESULT IN ADDITIONAL DAMAGE TO THE DRIVELINE, THE VEHICLE TO WHICH IT IS ATTACHED AND ANY ADDITIONAL NEARBY COMPONENTS. THIS MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE DRIVELINES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 27, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
Apr 20, 2011
DTNA IS RECALLING CERTAIN MODEL YEAR 2011 FREIGHTLINER CASCADIA, COLUMBIA GLIDER KIT, CORONADO, M2, AND WESTERN STAR4900 HEAVY TRUCKS MANUFACTURED FROM OCTOBER 16, 2010, THROUGH MARCH 9, 2011, EQUIPPED WITH GUNITE AUTOMATIC SLACK ADJUSTERS MANUFACTURED FROM OCTOBER 15, 2010, THROUGH JANUARY 31, 2011. DUE TO AN INCOMPLETE "KNITTING" OF THE IRON AT THE TIME OF CASTING, INADEQUATE STRUCTURAL INTEGRITY OF THE SLACK ADJUSTER HOUSING CAN OCCUR, WHICH COULD CAUSE THE HOUSING TO BREAK AT THE HANDLE UNDER NORMAL OPERATING LOADS.
Consequence & remedy
Consequence: IF THE SLACK ADJUSTER HOUSING WERE TO BREAK, THE WHEEL BRAKE TO WHICH THE SLACK ADJUSTER IS ATTACHED WOULD NO LONGER FUNCTION, CAUSING THE VEHICLE TO HAVE REDUCED BRAKING CAPACITY AND, IF MOUNTED ON THE STEER AXLE, THE VEHICLE COULD PULL TO ONE SIDE, POSSIBLY RESULTING IN A CRASH.
Remedy: DTNA WILL NOTIFY OWNERS AND DEALERS WILL REPLACE ANY AFFECTED SLACK ADJUSTERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 5, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
Mar 3, 2011
DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 FREIGHTLINER, CASCADIA, CENTURY, COLUMBIA FLD, AND M2, STERLING 9500, AND WESTERN STAR 4900 HEAVY TRUCKS MANUFACTURED FROM MARCH 20, 2006, THROUGH JUNE 30, 2010, EQUIPPED WITH SPECIFIC MBE4000 EPA07 MODEL ENGINES. THE INTAKE AIR GRID HEATER MAY SHORT CIRCUIT AND FAIL DUE TO EXCESSIVE INTERNAL TEMPERATURES.
Consequence & remedy
Consequence: A SHORT CIRCUITED GRID HEATER COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.
Remedy: DTNA WILL NOTIFY OWNERS OF THE RECALL DURING MARCH 2011. ANOTHER NOTIFICATION WILL BE ISSUED ONCE THE REMEDY IS RELEASED. DTNA EXPECTS THE REMEDY TO BE AVAILABLE BY DECEMBER 1, 2011. REPAIRS WILL BE PERFORMED BY DTNA DEALERS FREE OF CHARGE. OWNERS MAY CONTACT DTNA TOLL-FREE AT 1-800-547-0712. THIS RECALL IS ASSCOCIATED WITH A PREVIOUS RECALL, CAMPAIGN NUMBER 10V-341.
Feb 23, 2011
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 ARGOSY, CASCADIA, AND CORNOADO HEAVY TRUCKS MANUFACTURED FROM JANUARY 4, 2010, THROUGH NOVEMBER 30, 2010, EQUIPPED WITH 40K AIRLINER SUSPENSIONS. THE REAR SUSPENSION MAY FRACTURE THROUGH THE CENTER BOLT HOLE AFTER VEHICLE ASSEMBLY.
Consequence & remedy
Consequence: IF UNDETECTED, OVER TIME THE REAR END OF THE SPRING MAY SEPARATE FROM THE VEHICLE CAUSING A HAZARDOUS ROAD DEBRIS SITUATION, INCREASING THE RISK OF A CRASH.
Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE MONO LEAF SPRINGS FREE OF CHARGE. DAIMLER TRUCKS WILL SEND AN INTERIM LETTER TO OWNERS INFORMING THEM OF THE RECALL. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT AUGUST 5, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
Feb 23, 2011
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2011 FREIGHTLINER CASCADIA AND CONORADO AND WESTERN STAR 4900 HEAVY TRUCKS MANUFACTURED FROM APRIL 22, 2010, THROUGH JANUARY 28, 2011, EQUIPPED WITH AN EPA10 ISX ENGINE. THE ROUTING AND SECURING OF THE ALTERNATOR CABLES MAY ALLOW THE CABLE TO CONTACT OR NEARLY CONTACT AN ENGINE HEAT SHIELD POTENTIALLY DAMAGING THE CABLE INSULATION.
Consequence & remedy
Consequence: A POSITIVE ALTERNATOR CABLE, WITH DAMAGED INSULATION, THAT MAY CONTACT A GROUNDED COMPONENT CAN CAUSE A SHORT CIRCUIT THAT CAN RESULT IN A FIRE.
Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE ALTERNATOR CABLES FOR DAMAGE TO THE INSULATION. CABLES WITH DAMAGE TO THE INSULATION WILL BE REPLACED. THE CABLE ROUTING AND SECURING WILL BE MODIFIED TO ENSURE SUFFICIENT CLEARENCE TO THE HEAT SHIELD. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MAY 27, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
Nov 4, 2010
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2011 FREIGHTLINER CORONADO, COLUMBIA, FLD MILITARY, BUSINESS CLASS M2, CASCADIA, CENTURY, AND WESTERN STAR 4900 TRUCKS MANUFACTURED FROM AUGUST 9, 2010, THROUGH OCTOBER 27, 2010 FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THESE VEHICLES WERE EQUIPPED WITH LABELS MISSING RECOMMENDED COLD TIRE INFLATION PRESSURES.
Consequence & remedy
Consequence: FAILURE TO FOLLOW PROPER TIRE INFLATION RECOMMENDATIONS CAN RESULT IN TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: LABELS WITH MISSING INFORMATION WILL BE REPLACED WITH CORRECTED LABELS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 15, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
Jul 27, 2010
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2011 FREIGHTLINER CASCADIA, CENTURY, COLUMBIA, CORONADO, M2, AND WESTERN STAR 4900 HEAVY TRUCKS MANUFACTURED FROM FEBRUARY 19, 2009 THROUGH JULY 9, 2010, EQUIPPED WITH SPECIFIC DD13 AND DD15 ENGINES ASSEMBLED WITH A BOSCH HIGH PRESSURE FUEL PUMP ELEMENT WHICH MAY DEVELOP A CRACK DUE TO HYDROGEN INDUCED STRESS CORROSION. OVER TIME THE BARREL OF THE BOSCH HIGH PRESSURE FUEL PUMP ELEMENT USED ON SPECIFIC DD13/DD15 ENGINES MAY DEVELOP A CRACK DUE TO HYDROGEN INDUCED STRESS CORROSION RESULTING IN A DIESEL FUEL LEAK.
Consequence & remedy
Consequence: IF A DIESEL FUEL LEAK CONTINUES UNDETECTED, FUEL MAY SPILL ONTO THE ROADWAY POTENTIALLY RESULTING IN A CRASH.
Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 28, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
Jul 27, 2010
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 FREIGHTLINER, FCCC, STERLING, AND WESTERN STAR HEAVY TRUCKS MANUFACTURED FROM SEPTEMBER 5, 2006, THROUGH JUNE 30, 2010, EQUIPPED WITH SPECIFIC MBE900 EPA04 AND EPA07 MODEL ENGINES. THE INTAKE AIR GRID HEATER MAY SHORT CIRCUIT AND FAIL DUE TO EXCESSIVE INTERNAL TEMPERATURES.
Consequence & remedy
Consequence: A SHORT CIRCUITED GRID HEATER COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.
Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JULY 29, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
May 7, 2010
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FREIGHTLINER COLUMBIA, CASCADIA, CORONADO, CENTURY, M2, STERLING 9500, AND WESTERN STAR 4900 VEHICLES EQUIPPED WITH DD 13 AND DD15/DD16 ENGINES AND MANUFACTURED FROM JANUARY 1, 2007 THROUGH APRIL 5, 2010. SHOULD THE FUEL FILTER BECOME RESTRICTED, THE LOW PRESSURE FUEL FLANGE MAY DEVELOP A CRACK RESULTING IN A FUEL LEAK.
Consequence & remedy
Consequence: FUEL LEAKING ONTO THE ROADWAY MAY RESULT IN VEHICLE CRASH.
Remedy: THE LOW PRESSURE FUEL FLANGE WILL BE REPLACED WITH A MORE ROBUST COMPONENT. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 17, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5RQ20001 · Sam Cab Water Intrusion
Opened Aug 31, 2020 · Closed Jun 26, 2025
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:fuses And Circuit Breakers
On August 31, 2020, the Office of Defects Investigation (ODI) opened a recall query, RQ20001, to investigate the allegations of water intrusion into the truck cab signal-detect and activation module (SAM cab).The investigation further evaluated the effectiveness of the original recall remedy, and the installation of an updated drip shield as it relates to continual water intrusion resulting in the loss of electrical functions and potential fire.The potential hazard was the increased risk of a crash and injury in certain model year (MY) 2007-2021 Freightliner Cascadia P3 vehicles manufactured by Daimler Trucks North America (DTNA). ODI sent DTNA an information request (IR) letter on September 29, 2020.DTNA's November 20, 2020, IR response detailed how the company had implemented various improvements through recall 09V024 and multiple technical service bulletins (TSBs) to mitigate water intrusion.The effectiveness of new windshield seals and revisions to the drip shield is evident by the downward trend in claims rate from an average high of 7.64% in the beginning product life of Cascadia P3 (MYs 2007-2009), to 1.79% average for MYs 2011-2018, and down to 0.49% towards the end of the Cascadia P3 production.Moreover, the data shows that most failures occurred within the first three years of service with a significant downward trend thereafter. In view of the current overall low failure rate, the nature of early-life failure, and failure rate trending downward since model year 2017, this Recall Query (RQ) is closed. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical System
On August 31, 2020, the Office of Defects Investigation (ODI) opened a recall query, RQ20001, to investigate the allegations of water intrusion into the truck cab signal-detect and activation module (SAM cab).The investigation further evaluated the effectiveness of the original recall remedy, and the installation of an updated drip shield as it relates to continual water intrusion resulting in the loss of electrical functions and potential fire.The potential hazard was the increased risk of a crash and injury in certain model year (MY) 2007-2021 Freightliner Cascadia P3 vehicles manufactured by Daimler Trucks North America (DTNA). ODI sent DTNA an information request (IR) letter on September 29, 2020.DTNA's November 20, 2020, IR response detailed how the company had implemented various improvements through recall 09V024 and multiple technical service bulletins (TSBs) to mitigate water intrusion.The effectiveness of new windshield seals and revisions to the drip shield is evident by the downward trend in claims rate from an average high of 7.64% in the beginning product life of Cascadia P3 (MYs 2007-2009), to 1.79% average for MYs 2011-2018, and down to 0.49% towards the end of the Cascadia P3 production.Moreover, the data shows that most failures occurred within the first three years of service with a significant downward trend thereafter. In view of the current overall low failure rate, the nature of early-life failure, and failure rate trending downward since model year 2017, this Recall Query (RQ) is closed. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:wiring:fuses And Circuit Breakers
On August 31, 2020, the Office of Defects Investigation (ODI) opened a recall query, RQ20001, to investigate the allegations of water intrusion into the truck cab signal-detect and activation module (SAM cab).The investigation further evaluated the effectiveness of the original recall remedy, and the installation of an updated drip shield as it relates to continual water intrusion resulting in the loss of electrical functions and potential fire.The potential hazard was the increased risk of a crash and injury in certain model year (MY) 2007-2021 Freightliner Cascadia P3 vehicles manufactured by Daimler Trucks North America (DTNA). ODI sent DTNA an information request (IR) letter on September 29, 2020.DTNA's November 20, 2020, IR response detailed how the company had implemented various improvements through recall 09V024 and multiple technical service bulletins (TSBs) to mitigate water intrusion.The effectiveness of new windshield seals and revisions to the drip shield is evident by the downward trend in claims rate from an average high of 7.64% in the beginning product life of Cascadia P3 (MYs 2007-2009), to 1.79% average for MYs 2011-2018, and down to 0.49% towards the end of the Cascadia P3 production.Moreover, the data shows that most failures occurred within the first three years of service with a significant downward trend thereafter. In view of the current overall low failure rate, the nature of early-life failure, and failure rate trending downward since model year 2017, this Recall Query (RQ) is closed. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
AQ18002 · Daimler Trucks North America Recalls
Opened Apr 23, 2018 · Closed Jul 11, 2024
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch; Steering:hydraulic Power Assist:hose, Piping, And Connections
On April 23, 2018, the National Highway Traffic Safety Administration (“NHTSA”) opened Audit Query (AQ18002) to assess the timeliness and scope of four recalls filed by Daimler Trucks North America, LLC (“DTNA”). NHTSA subsequently expanded AQ18002 to examine the timeliness and scope of three additional DTNA recalls and compliance with early warning reporting and manufacturer communications reporting requirements. NHTSA and DTNA entered into a Consent Order on December 29, 2020, to resolve NHTSA’s assertions that certain recalls within the scope of AQ18002 were untimely, DTNA failed to timely submit certain manufacturer communications to NHTSA, and DTNA failed to submit field reports to NHTSA as required. As part of the Consent Order, DTNA agreed to a total civil penalty of thirty million dollars ($30,000,000), of which ten million dollars ($10,000,000) was paid on January 12, 2021. Also, of that total civil penalty, DTNA agreed to spend five million dollars ($5,000,000) on the specific performance obligations to develop advanced data analytics capabilities to enhance its ability to detect and study emerging safety-related defect trends on its vehicles (“Safety Data Analytics infrastructure”) and an advanced data analytics and reporting platform that integrates data on emerging safety-related defect trends on its vehicles and recall lessons learned (“Safety Communications Platform”). The Consent Order also held fifteen million dollars ($15,000,000) of the civil penalty in abeyance pending DTNA’s satisfactory completion of the requirements of the Consent Order, and its compliance with the Safety Act, and regulations thereunder. NHTSA and DTNA agreed to a two-year term for the Consent Order—with an option for NHTSA to extend the Consent Order for an additional year, if warranted. In the Consent Order, DTNA agreed to numerous performance obligations, including monthly meetings with NHTSA to discuss potential safety issues, recent manufacturer communications, and recall decision-making, among other things; quarterly meetings with NHTSA to discuss DTNA’s progress on the performance obligations under the Consent Order, including the Safety Data Analytics infrastructure and Safety Communications Platform, and any issues related to compliance with the Consent Order, Safety Act, or regulations; development of written procedures and employee training materials to help DTNA comply with its legal obligations to timely identify and report safety defects and noncompliances, submit complete and accurate recall filings, and timely submit manufacturer communications and field reports to NHTSA; and identifying and reporting previously unreported manufacturer communications and field reports. Also, via the Consent Order, DTNA acknowledged that the failure or inability to identify a specific root cause, develop an adequate remedy or repair, or confirm the affected population of vehicles are not bases for delaying filing a recall with NHTSA. On December 22, 2022, NHTSA extended the Consent Order for a term of one year due to concerns about DTNA’s compliance with its recall-related obligations. Specifically, NHTSA expressed concerns about the completeness of DTNA’s recall reports and issues identified with owner notification letters during the term of the Consent Order, as well as the length of time that DTNA took to consider a straightforward noncompliance issue before filing a recall and DTNA’s interactions with NHTSA during the term of the Consent Order. NHTSA addressed these concerns with DTNA during the third year of the Consent Order. The extended term of the Consent Order expired on December 28, 2023. Based on the Consent Order, this investigation, AQ18002, is closed. Closure of this AQ has no bearing on the terms of the Consent Order or DTNA’s ongoing legal obligations, and it does not represent a determination by NHTSA as to DTNA’s performance under the Consent Order.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
On April 23, 2018, the National Highway Traffic Safety Administration (“NHTSA”) opened Audit Query (AQ18002) to assess the timeliness and scope of four recalls filed by Daimler Trucks North America, LLC (“DTNA”). NHTSA subsequently expanded AQ18002 to examine the timeliness and scope of three additional DTNA recalls and compliance with early warning reporting and manufacturer communications reporting requirements. NHTSA and DTNA entered into a Consent Order on December 29, 2020, to resolve NHTSA’s assertions that certain recalls within the scope of AQ18002 were untimely, DTNA failed to timely submit certain manufacturer communications to NHTSA, and DTNA failed to submit field reports to NHTSA as required. As part of the Consent Order, DTNA agreed to a total civil penalty of thirty million dollars ($30,000,000), of which ten million dollars ($10,000,000) was paid on January 12, 2021. Also, of that total civil penalty, DTNA agreed to spend five million dollars ($5,000,000) on the specific performance obligations to develop advanced data analytics capabilities to enhance its ability to detect and study emerging safety-related defect trends on its vehicles (“Safety Data Analytics infrastructure”) and an advanced data analytics and reporting platform that integrates data on emerging safety-related defect trends on its vehicles and recall lessons learned (“Safety Communications Platform”). The Consent Order also held fifteen million dollars ($15,000,000) of the civil penalty in abeyance pending DTNA’s satisfactory completion of the requirements of the Consent Order, and its compliance with the Safety Act, and regulations thereunder. NHTSA and DTNA agreed to a two-year term for the Consent Order—with an option for NHTSA to extend the Consent Order for an additional year, if warranted. In the Consent Order, DTNA agreed to numerous performance obligations, including monthly meetings with NHTSA to discuss potential safety issues, recent manufacturer communications, and recall decision-making, among other things; quarterly meetings with NHTSA to discuss DTNA’s progress on the performance obligations under the Consent Order, including the Safety Data Analytics infrastructure and Safety Communications Platform, and any issues related to compliance with the Consent Order, Safety Act, or regulations; development of written procedures and employee training materials to help DTNA comply with its legal obligations to timely identify and report safety defects and noncompliances, submit complete and accurate recall filings, and timely submit manufacturer communications and field reports to NHTSA; and identifying and reporting previously unreported manufacturer communications and field reports. Also, via the Consent Order, DTNA acknowledged that the failure or inability to identify a specific root cause, develop an adequate remedy or repair, or confirm the affected population of vehicles are not bases for delaying filing a recall with NHTSA. On December 22, 2022, NHTSA extended the Consent Order for a term of one year due to concerns about DTNA’s compliance with its recall-related obligations. Specifically, NHTSA expressed concerns about the completeness of DTNA’s recall reports and issues identified with owner notification letters during the term of the Consent Order, as well as the length of time that DTNA took to consider a straightforward noncompliance issue before filing a recall and DTNA’s interactions with NHTSA during the term of the Consent Order. NHTSA addressed these concerns with DTNA during the third year of the Consent Order. The extended term of the Consent Order expired on December 28, 2023. Based on the Consent Order, this investigation, AQ18002, is closed. Closure of this AQ has no bearing on the terms of the Consent Order or DTNA’s ongoing legal obligations, and it does not represent a determination by NHTSA as to DTNA’s performance under the Consent Order.
Steering:hydraulic Power Assist:hose, Piping, And Connections
On April 23, 2018, the National Highway Traffic Safety Administration (“NHTSA”) opened Audit Query (AQ18002) to assess the timeliness and scope of four recalls filed by Daimler Trucks North America, LLC (“DTNA”). NHTSA subsequently expanded AQ18002 to examine the timeliness and scope of three additional DTNA recalls and compliance with early warning reporting and manufacturer communications reporting requirements. NHTSA and DTNA entered into a Consent Order on December 29, 2020, to resolve NHTSA’s assertions that certain recalls within the scope of AQ18002 were untimely, DTNA failed to timely submit certain manufacturer communications to NHTSA, and DTNA failed to submit field reports to NHTSA as required. As part of the Consent Order, DTNA agreed to a total civil penalty of thirty million dollars ($30,000,000), of which ten million dollars ($10,000,000) was paid on January 12, 2021. Also, of that total civil penalty, DTNA agreed to spend five million dollars ($5,000,000) on the specific performance obligations to develop advanced data analytics capabilities to enhance its ability to detect and study emerging safety-related defect trends on its vehicles (“Safety Data Analytics infrastructure”) and an advanced data analytics and reporting platform that integrates data on emerging safety-related defect trends on its vehicles and recall lessons learned (“Safety Communications Platform”). The Consent Order also held fifteen million dollars ($15,000,000) of the civil penalty in abeyance pending DTNA’s satisfactory completion of the requirements of the Consent Order, and its compliance with the Safety Act, and regulations thereunder. NHTSA and DTNA agreed to a two-year term for the Consent Order—with an option for NHTSA to extend the Consent Order for an additional year, if warranted. In the Consent Order, DTNA agreed to numerous performance obligations, including monthly meetings with NHTSA to discuss potential safety issues, recent manufacturer communications, and recall decision-making, among other things; quarterly meetings with NHTSA to discuss DTNA’s progress on the performance obligations under the Consent Order, including the Safety Data Analytics infrastructure and Safety Communications Platform, and any issues related to compliance with the Consent Order, Safety Act, or regulations; development of written procedures and employee training materials to help DTNA comply with its legal obligations to timely identify and report safety defects and noncompliances, submit complete and accurate recall filings, and timely submit manufacturer communications and field reports to NHTSA; and identifying and reporting previously unreported manufacturer communications and field reports. Also, via the Consent Order, DTNA acknowledged that the failure or inability to identify a specific root cause, develop an adequate remedy or repair, or confirm the affected population of vehicles are not bases for delaying filing a recall with NHTSA. On December 22, 2022, NHTSA extended the Consent Order for a term of one year due to concerns about DTNA’s compliance with its recall-related obligations. Specifically, NHTSA expressed concerns about the completeness of DTNA’s recall reports and issues identified with owner notification letters during the term of the Consent Order, as well as the length of time that DTNA took to consider a straightforward noncompliance issue before filing a recall and DTNA’s interactions with NHTSA during the term of the Consent Order. NHTSA addressed these concerns with DTNA during the third year of the Consent Order. The extended term of the Consent Order expired on December 28, 2023. Based on the Consent Order, this investigation, AQ18002, is closed. Closure of this AQ has no bearing on the terms of the Consent Order or DTNA’s ongoing legal obligations, and it does not represent a determination by NHTSA as to DTNA’s performance under the Consent Order.
PE18004 · Pndb Electrical Power Distribution
Opened Apr 23, 2018 · Closed Nov 22, 2020
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:fuses And Circuit Breakers
On April 23, 2018, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE18-004) to investigate certain alleged defects affecting the Powernet Distribution Box (PNDB) and associated wiring on certain model year (MY) 2011-2016 Freightliner Cascadia (P3 platform) truck tractors that may result in disruption or loss of electrical power to the PNDB itself and other electrical circuits, thermal events, and/or vehicle fires.On May 7, 2018, ODI sent an Information Request (IR) letter to Daimler Trucks North America LLC (DTNA). On June 19, 2018, ODI received an IR response from DTNA that included vehicle production, consumer complaint, field report, warranty, manufacturer actions, changes and other data related to the alleged defects. On April 8, 2019, ODI received a supplemental IR response from DTNA that included their assessment of the alleged defects. Furthermore, ODI engaged in discussions with the manufacturer about the alleged defects on multiple occasions during the course of this investigation. ODI analysis of all available data indicates there is not an apparent defect trend. The most recent field report data reviewed was from 2017Q1 and the most recent complaint data was received by ODI in 2019Q1. The complaint rate is low. Most warranty claims occurred early in the vehicles' service life, and with the newest of the subject vehicles being over four years old, they are all now beyond that point. The warranty claim rates for loose input or output terminals (0.16%), loose fuses (0.25%), PNDB power (B+) supply cable corrosion or improper PNDB power (B+) supply cable routing and/ or securement (0.00%) are all low.The most serious consequence in the warranty claim data alleged engine shutoff with a vehicle in motion. While some vehicles did experience a loss of electrical power resulting in loss of motive power with no immediate restart capability, the bulk of the warranty claims were for vehicles equipped with an optional cab power disconnect switch solenoid with an automatic reset feature that may exhibit a brief, intermittent loss of power. If the input and output voltages differ by an unacceptable amount, potentially due to foreign object debris or corrosion on the solenoid's contacts, the PNDB senses the difference and enters an auto-reset mode in an attempt to correct the condition. The internal contacts open for one second, stopping the flow of electricity, and then close, restoring the flow for two seconds. This cycle is repeated for up to five times; after a maximum of thirteen seconds, the PNDB defaults to the on position and electrical power is restored. This condition exhibits a transient loss of power but it does not cause any permanent engine disablement. As a precaution, the solenoid-equipped PNDB part was modified in August 2017 to eliminate the auto-reset feature. Since 2010, there has been only 1 report of vehicle fire and zero reports of crash, injury or death. Accordingly, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves the right to take further action if warranted by the circumstances.
Additional source detail variants (2)
Electrical System
On April 23, 2018, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE18-004) to investigate certain alleged defects affecting the Powernet Distribution Box (PNDB) and associated wiring on certain model year (MY) 2011-2016 Freightliner Cascadia (P3 platform) truck tractors that may result in disruption or loss of electrical power to the PNDB itself and other electrical circuits, thermal events, and/or vehicle fires.On May 7, 2018, ODI sent an Information Request (IR) letter to Daimler Trucks North America LLC (DTNA). On June 19, 2018, ODI received an IR response from DTNA that included vehicle production, consumer complaint, field report, warranty, manufacturer actions, changes and other data related to the alleged defects. On April 8, 2019, ODI received a supplemental IR response from DTNA that included their assessment of the alleged defects. Furthermore, ODI engaged in discussions with the manufacturer about the alleged defects on multiple occasions during the course of this investigation. ODI analysis of all available data indicates there is not an apparent defect trend. The most recent field report data reviewed was from 2017Q1 and the most recent complaint data was received by ODI in 2019Q1. The complaint rate is low. Most warranty claims occurred early in the vehicles' service life, and with the newest of the subject vehicles being over four years old, they are all now beyond that point. The warranty claim rates for loose input or output terminals (0.16%), loose fuses (0.25%), PNDB power (B+) supply cable corrosion or improper PNDB power (B+) supply cable routing and/ or securement (0.00%) are all low.The most serious consequence in the warranty claim data alleged engine shutoff with a vehicle in motion. While some vehicles did experience a loss of electrical power resulting in loss of motive power with no immediate restart capability, the bulk of the warranty claims were for vehicles equipped with an optional cab power disconnect switch solenoid with an automatic reset feature that may exhibit a brief, intermittent loss of power. If the input and output voltages differ by an unacceptable amount, potentially due to foreign object debris or corrosion on the solenoid's contacts, the PNDB senses the difference and enters an auto-reset mode in an attempt to correct the condition. The internal contacts open for one second, stopping the flow of electricity, and then close, restoring the flow for two seconds. This cycle is repeated for up to five times; after a maximum of thirteen seconds, the PNDB defaults to the on position and electrical power is restored. This condition exhibits a transient loss of power but it does not cause any permanent engine disablement. As a precaution, the solenoid-equipped PNDB part was modified in August 2017 to eliminate the auto-reset feature. Since 2010, there has been only 1 report of vehicle fire and zero reports of crash, injury or death. Accordingly, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves the right to take further action if warranted by the circumstances.
Electrical System:wiring:fuses And Circuit Breakers
On April 23, 2018, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE18-004) to investigate certain alleged defects affecting the Powernet Distribution Box (PNDB) and associated wiring on certain model year (MY) 2011-2016 Freightliner Cascadia (P3 platform) truck tractors that may result in disruption or loss of electrical power to the PNDB itself and other electrical circuits, thermal events, and/or vehicle fires.On May 7, 2018, ODI sent an Information Request (IR) letter to Daimler Trucks North America LLC (DTNA). On June 19, 2018, ODI received an IR response from DTNA that included vehicle production, consumer complaint, field report, warranty, manufacturer actions, changes and other data related to the alleged defects. On April 8, 2019, ODI received a supplemental IR response from DTNA that included their assessment of the alleged defects. Furthermore, ODI engaged in discussions with the manufacturer about the alleged defects on multiple occasions during the course of this investigation. ODI analysis of all available data indicates there is not an apparent defect trend. The most recent field report data reviewed was from 2017Q1 and the most recent complaint data was received by ODI in 2019Q1. The complaint rate is low. Most warranty claims occurred early in the vehicles' service life, and with the newest of the subject vehicles being over four years old, they are all now beyond that point. The warranty claim rates for loose input or output terminals (0.16%), loose fuses (0.25%), PNDB power (B+) supply cable corrosion or improper PNDB power (B+) supply cable routing and/ or securement (0.00%) are all low.The most serious consequence in the warranty claim data alleged engine shutoff with a vehicle in motion. While some vehicles did experience a loss of electrical power resulting in loss of motive power with no immediate restart capability, the bulk of the warranty claims were for vehicles equipped with an optional cab power disconnect switch solenoid with an automatic reset feature that may exhibit a brief, intermittent loss of power. If the input and output voltages differ by an unacceptable amount, potentially due to foreign object debris or corrosion on the solenoid's contacts, the PNDB senses the difference and enters an auto-reset mode in an attempt to correct the condition. The internal contacts open for one second, stopping the flow of electricity, and then close, restoring the flow for two seconds. This cycle is repeated for up to five times; after a maximum of thirteen seconds, the PNDB defaults to the on position and electrical power is restored. This condition exhibits a transient loss of power but it does not cause any permanent engine disablement. As a precaution, the solenoid-equipped PNDB part was modified in August 2017 to eliminate the auto-reset feature. Since 2010, there has been only 1 report of vehicle fire and zero reports of crash, injury or death. Accordingly, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves the right to take further action if warranted by the circumstances.
PE12018 · Air Brake Reservoir Bracket Fracture
Opened Jun 25, 2012 · Closed Sep 20, 2012
Status: closed (inferred from source dates) · Service Brakes, Air:supply:reservoir/tank
The Office of Defects Investigation (ODI) received Early Warning Reporting (EWR) data from the manufacturer that indicated some number of subject vehicles had allegedly experienced a fracture of one or more support brackets resulting in an unsecured air brake reservoir.This could result in a loss of air pressure necessary for proper service brake application and a potential road hazard if the reservoir separates from the vehicle in operation.By letter dated August 15, 2012, Daimler Trucks North America LLC (DTNA) has notified ODI that it has initiated a safety recall (identified by NTHSA Recall No. 12V-405 and DTNA Recall No. FL-631) to address a safety defect in approximately 1,663 model year (MY) 2009 through 2012 Freightliner 114SD, Business Class M2, Cascadia, Coronado, Sterling 9500 and Western Star 4700 trucks manufactured from July 7, 2008 through December 15, 2011, originally equipped with a specific perpendicular oriented air brake reservoir support bracket (P/N 12-22981-000).To date ODI is unaware of any bracket failures that resulted in a complete separation of the reservoir from the vehicle.Affected owners will be notified by DTNA beginning October 15, 2012 and affected vehicles will have the subject air brake reservoir support brackets replaced with a more robust bracket.Repairs will be performed by DTNA authorized service facilities.Copies of DTNA's reimbursement plan for pre-notification remedies will be submitted to ODI as a supplemental report when available.Accordingly, this investigation is closed.
PE11012 · Fontaine Ultra Lt 5th Wheel False Latch
Opened Apr 15, 2011 · Closed Jun 27, 2011
Status: closed (inferred from source dates) · Trailer Hitches:fifth Wheel Assembly
DTNA submitted a 573 Recall notice (11V-289) prior to the IR response date and therefore was granted permission to forgo submission of the IR response.Freightliner reported that Fontaine's TSB issued in March had resulted in the remedy of 55 percent of all subject vehicles with an additional 33% scheduled by the time of their 573 submission.Freightliner will issue another notification 1 July if 100% of the subject population is not remedied by that time.ODI is aware that the Ultra LT 5th wheel was also installed on several other OEM's vehicles.ODI will work with Fontaine and the manufacturers to ensure that the remaining vehicles are identified and remedied.
Illustration