Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 2 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
2 reports
60,500 miles · Jan 30, 2018
Electrical System
TL* THE CONTACT OWNS A 2005 FOUR WINDS WINDSPORT RV. WHILE DRIVING 65 MPH, THE RV STALLED WITHOUT WARNING. THE RV WAS TOWED TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS THEN TAKEN TO VALDOSTA RV (7427 SONNY ROGERS MEMORIAL DR, HAHIRA, GA 31632, (229) 561-9591) WHERE IT WAS DIAGNOSED THAT THE…
Read full complaint
TL* THE CONTACT OWNS A 2005 FOUR WINDS WINDSPORT RV. WHILE DRIVING 65 MPH, THE RV STALLED WITHOUT WARNING. THE RV WAS TOWED TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS THEN TAKEN TO VALDOSTA RV (7427 SONNY ROGERS MEMORIAL DR, HAHIRA, GA 31632, (229) 561-9591) WHERE IT WAS DIAGNOSED THAT THE BATTERY CONTROL CENTER RELAY BECAME DISCONNECTED. THE RV WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 53,000. *TT *TR
NHTSA ODI #11065912
2,618 miles · May 2, 2007
Service Brakes, Hydraulic
LEAVING FLORIDA DRIVING TO NC, ONE HOUR ON ROAD ABS LIGHT CAME ON AND 10 MINUTES LATER BRAKE FAILURE LIGHT CAME ON AND NO BRAKES. WE STOPPED A WORKHORSE DEALER AND NEXT DAY THEY REPLACED RIGHT REAR SENSOR. LEFT DEALER AND 1 HOUR LATER THE SAME PROBLEM CAME UP. MOTOR HOME WAS TOWED TO JACKSONVILLE,FL AND ANOTHER SENSOR WAS REPLAC…
Read full complaint
LEAVING FLORIDA DRIVING TO NC, ONE HOUR ON ROAD ABS LIGHT CAME ON AND 10 MINUTES LATER BRAKE FAILURE LIGHT CAME ON AND NO BRAKES. WE STOPPED A WORKHORSE DEALER AND NEXT DAY THEY REPLACED RIGHT REAR SENSOR. LEFT DEALER AND 1 HOUR LATER THE SAME PROBLEM CAME UP. MOTOR HOME WAS TOWED TO JACKSONVILLE,FL AND ANOTHER SENSOR WAS REPLACED ON LEFT REAR WHEEL. WORKHORSE INSPECTED UNIT 1/17/07 AND COULD NOT TELL US WHY WE LOST BRAKES. *TR
FOUR WINDS IS RECALLING 684 MY 2002-2006 INFINITY, MY 2002-2007 WINDESPORT, MY 2004-2008 HURRICANE, MY 2006-2007 MEGALLAN AND MY 2008 FUN MOVER MOTOR HOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.
Consequence & remedy
Consequence: THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY FOR THIS CAMPAIGN PLEASE SEE 09V-110. WORKHORSE WILL CONDUCT THE OWNER AND DEALER NOTIFICATION. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.
ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GM 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.
Consequence & remedy
Consequence: IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD RESULT.
Remedy: CHEVROLET AND WORKHORSE ARE HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN (PLEASE SEE 06V225 AND 06V289). DEALERS WILL REPLACE THE FUEL RAIL PULSE DAMPER RETAINER CLIPS ON THESE ENGINES FREE OF CHARGE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, WORKHORSE AT 877-294-6773 OR THOR INDUSTRIES AT 937-596-6849.
CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH ACTIA CORPORATE INSTRUMENT CLUSTERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 101 "CONTROLS AND DISPLAYS" AND 105 "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." IF THE BRAKE FAIL INPUT FALLS BELOW A VOLTAGE OF 1.5V, THE BRAKE FAILURE LAMP AND ALARM WILL BE ACTIVATED. ALSO ACTIVATION OF THE ABS TELLTALE WHEN THE ABS IS NOT PROPERLY FUNCTIONING DOES NOT ALWAYS OCCUR.
Consequence & remedy
Consequence: AT NIGHT THE INSTRUMENT CLUSTER LIGHTS MAY FAIL AND THE DRIVER MAY NOT BE ABLE TO SEE THE INSTRUMENT PANEL GAUGES AND THE BRAKE WARNING LIGHT INDICATOR WHICH COULD INCREASING THE RISK OF A CRASH.
Remedy: WORKHORSE IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN AND REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731 OR FOUR WINDS AT 574-266-1111.
ON CERTAIN MOTOR HOMES, THE FUEL LINES ON THE CHASSIS COULD CHAFE AGAINST THE STEEL FLOOR STRUCTURE, CAUSING THE FUEL LINE TO RUPTURE.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE BRAIDED FUEL SUPPLY LINE TO DETERMINE IF THE FUEL LINE HAS BECOME EXCESSIVELY WORN OR CHAFFED. IF THERE IS NO VISIBLE DAMAGE TO THE FUEL LINE, THE DEALER WILL SECURE THE FUEL LINE TO THE MAIN WIRING LOOM. IF DAMAGE IS DISCOVERED, THE FUEL LINE WILL BE REPLACED AND PROPERLY ANCHORED. THE RECALL BEGAN JULY 16, 2004. OWNERS SHOULD CONTACT FOUR WINDS AT
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Four Winds Windsport Problems, Complaints & Recalls | Skip That Year
Illustration