Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 8 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Tires. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Visibility. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
8 reports
43,815 miles · Aug 9, 2016
Engine
NO. 10 SPARK PLUG BLOWOUT AT 60 MPH ON FREEWAY, DAMAGING THE IGNITION COIL, ENGINE BLOCK AND WIRING HARNESS. THIS IS A KNOWN ISSUE SINCE 1997 WITH THE FORD TRITON ENGINE DUE TO A LONG-STANDING SHODDY DESIGN (USE OF STEEL ENGINE BLOCK W/ALUMINIUM INSERTS FOR THE SPARK PLUGS, AND ONLY 4 THREADS FOR THE SPARK PLUGS, INSTEAD OF TH…
Read full complaint
NO. 10 SPARK PLUG BLOWOUT AT 60 MPH ON FREEWAY, DAMAGING THE IGNITION COIL, ENGINE BLOCK AND WIRING HARNESS. THIS IS A KNOWN ISSUE SINCE 1997 WITH THE FORD TRITON ENGINE DUE TO A LONG-STANDING SHODDY DESIGN (USE OF STEEL ENGINE BLOCK W/ALUMINIUM INSERTS FOR THE SPARK PLUGS, AND ONLY 4 THREADS FOR THE SPARK PLUGS, INSTEAD OF THE STANDARD 6 THREADS.
NHTSA ODI #10894614
Mileage unknown · Sep 13, 2004
Tires
THE CONSUMER FOUND A 4 INCH SPLIT IN THE SIDEWALL OF THE RIGHT INNER TIRE. *NM THE CONSUMER HAD THE TIRE REPLACED AND PUT AIR IN ALL THE TIRES, HOWEVER WHILE DRIVING, THE CONSUMER ALL OF A SUDDEN FELT A VIBRATION AND DISCOVERED THE TREAD CAME OFF THE RIGHT REAR OUTSIDE TIRE. THE CONSUMER WAS ABLE TO PURCHASE A USED FIRESTONE …
Read full complaint
THE CONSUMER FOUND A 4 INCH SPLIT IN THE SIDEWALL OF THE RIGHT INNER TIRE. *NM THE CONSUMER HAD THE TIRE REPLACED AND PUT AIR IN ALL THE TIRES, HOWEVER WHILE DRIVING, THE CONSUMER ALL OF A SUDDEN FELT A VIBRATION AND DISCOVERED THE TREAD CAME OFF THE RIGHT REAR OUTSIDE TIRE. THE CONSUMER WAS ABLE TO PURCHASE A USED FIRESTONE TIRE, HOWEVER WHILE DRIVING, THERE WAS A LOUD BANG AND THE CONSUMER FOUND THAT THE RIGHT REAR INNER TIRE HAD BLOWN OUT THE SIDE WALL THAT FACED THE INSIDE OF THE OUTER TIRES. THE CONSUMER REPLACED ALL THE TIRES WITH BF GOODRICH. *JB
NHTSA ODI #10092708
27,000 miles · Sep 19, 2003
Tires
FIRESTONE STEELTEX R4S TIRE FAILURE BEFORE SEPARATION OF TREAD. *JB
NHTSA ODI #10039175
29,000 miles · Sep 19, 2003
Tires
PASSENGER REAR INSIDE DUAL TIRE FAILURE. *JB
NHTSA ODI #10039171
13,850 miles · Jun 27, 2003
Tires
TIRE VALVE SYSTEM BLEW OUT AND CAUSED TIRE TO GO FLAT. *MR THE CONSUMER HAD ALL OF THE VALVE STEMS REPLACED WITH STAINLESS STEEL BOLTS. THE CONSUMER FELT THERE SHOULD BE A REIMBURSEMENT FOR THE REPLACEMENT. *SCC *JB
NHTSA ODI #10026439
13,850 miles · Jun 26, 2003
Tires
WHILE DRIVING, THE TWO REAR TIRE VALVES BROKE AND THE TIRES WENT FLAT (FIRESTONE STEEL RADIAL F4S SIZE#LT22575R16-MS, PLEASE PROVIDE THE DOT NUMBER). *NLM. *AK PH *JB
NHTSA ODI #10021609
Mileage unknown · Dec 3, 2002
Tires
CONSUMER STATED THAT WHILE DRIVING EXPERIENCED COMPLETE TREAD SEPARATION RESULTING IN A BLOWOUT OF TIRE. VEHICLE IS A 1999 FOUR WINDS CHATEAU. TIRE INFO: FIRESTONE 225/75R16 DOT NO.- **PLZ PROVIDE** ORIGINAL TIRES 25,800K MILES ON TIRE INSIDE DUAL ON PASSENGER SIDE
NHTSA ODI #8023593
Mileage unknown · Oct 3, 2001
Visibility
CONSUMER WAS INFORMED BY A FORD DEALERSHIP THE LOWER MIRROR ARM ON THE PASSENGER SIDE IS GOING TO BREAK LOOSE BECAUSE OF A MANUFACTURING DEFECT THAT HAS CAUSED TWO METAL STRESS CRACKS.*JB
ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.
Consequence & remedy
Consequence: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.
Remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR FOUR WINDS AT 1-219-266-1111.
VEHICLE DESCRIPTION: CERTAIN MOTORHOMES EQUIPPED WITH SAFETY BELT ASSEMBLIES PRODUCED BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.
Consequence & remedy
Consequence: SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.
Remedy: AM-SAFE NOTIFIED FOUR WINDS' CUSTOMERS TO RETURN THEIR VEHICLE TO AN AUTHORIZED DEALER TO HAVE THE SEAT BELTS REPAIRED FREE OF CHARGE. OWNER NOTIFICATION BEGAN AUGUST 31, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AM-SAFE COMMERCIAL PRODUCTS AT 219-266-8330 OR FOUR WINDS AT 219-266-1111.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2000 Four Winds Chateau Problems, Complaints & Recalls | Skip That Year
Illustration