2017 Forest River Rockwood

The contact owns a 2017 Forest River Rockwood RV equipped with Castle Rock Tires, Tire Line: Radial ST226, Tire Size: 225/75/R15, DOT Number: (N/A). The contact stated while driving 55-60 MPH, the front and rear driver's side tires experienced blowouts. The contact was able to pull to the side of the road. The tires were replaced with a spare tire and a replacement tire. The tires were original tires. Additionally, the contact stated while driving to the residence, the rear passenger's side tire experienced a blowout. The contact was able to pull to the side of the road and noticed that the front passenger's side tire was also damaged. The contact's husband was in the process of purchasing two replacement tires from the tire shop. The front and rear passenger's side tires were not replaced. The tires were original tires. The manufacturer was not contacted. The RV failure mileage was approximately 2,500. The tires failure mileage was approximately 2,500.

TL* THE CONTACT OWNS A 2017 FOREST RIVER ROCKWOOD. THE CONTACT STATED THAT THE UPPER AND LOWER METAL BRACKETS WERE BENT. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED AS OF YET. THE CONTACT WAS CONCERNED THAT THE WATER TANK MAY FALL OFF THE TRAILER. A DEALER WAS NOT CONTACTED. THE MANUFACTURER HAD NOT BEEN INFORMED OF FAILURE. A FAILURE MILEAGE WAS NOT PROVIDED. *DT*DT *TR

NHTSA RECALL 17V129 THE SLIDE ROOM MOUNTING BRACKET DOES NOT MEET THE TOLERANCE OF 3 1/2 INCH MINIMAL DIMENSION AWAY FROM THE TREAD OF THE DRIVER'S SIDE FRONT TIRE. FOREST RIVER HAD SENT A REPLACEMENT BRACKET WHICH HAS BEEN INSTALLED BY ORCHARD TRAILERS IN WHATELY, MA WHICH DOES NOT MEET THE MINIMAL TOLERANCE. WE ARE UNABLE TO GET THIS RECALL RESOLVED AS OF 11/30/18 ( THE ORIGINAL RECALL NOTICE WAS DATED 02/24/2017). WE PURCHASED THIS TRAILER ON 04/15/2017, UNAWARE THAT THERE WAS A SAFETY RECALL IN EFFECT AT THE TIME WHICH HAD NOT BEEN ADDRESSED.*DT *AS

WHILE TRAVELING HOME FROM CAMPING ON I-4, THE LEFT REAR TRAILER TIRE BLEW. AFTER SAFELY GETTING TO THE SIDE OF THE HIGHWAY, I DISCOVERED THE RIGHT SIDE TIRE WAS ALSO BLOWN ON THE SAME AXLE. I HAD TO PUT TWO NEW TIRES ON MY CAMPER. WHILE DRIVING TO THE TIRE STORE TO REPLACE THE FRONT TWO TIRES, A THIRD TIRE ON THE RIGHT FRONT AXLE BLEW. THE TIRES IN QUESTION ARE CASTLE ROCK ( MADE IN CHINA ) ST225/75R15 LOAD RANGE D-DOT JULT IMT 0216. I HAD EXACTLY 65 PSI IN THOSE TIRES PRIOR TO GETTING ON THE HIGHWAY.

SLIDE OUT MECHANISM IN RIGHT REAR WHEEL PASSENGER SIDE IS INSTALLED/BUILT/DESIGNED SO THAT PART OF IT'S MECHANISM MADE OF 1/4" STEEL STICKS INTO THE TIRE OF THE VEHICLE. IT HAS CUT INTO THE TIRE AS SEEN IN PHOTOS (ATTACHED) THE TIRE HAS NOT BEEN COMPLETELY DESTROYED HOWEVER IT CONTINUALLY BEING CUT/DAMAGED BY THIS METAL. THIS TRAVEL TRAILER CANNOT BE USED UNDER IT CURRENT CONDITION DUE TO POTENTIAL DANGER INVOLVED, NOT TO MENTION RUINING AN OTHERWISE NEW TIRE. I HAVE CONTACTED THE MANUFACTURER REGARDING THIS. I BELIEVE, HAD I NOT NOTICED THIS, CATASTROPHIC FAILURE UNDER USE COULD CAUSE DEATH OR SERIOUS PERSONAL INJURY.

A SPRING IN THE DEXTER ELECTRIC BRAKE ASSEMBLY FAILED, CAUSING BRAKE COMPONENTS TO FALL INTO THE BRAKE DRUM WHILE TRAVELING AT HIGHWAY SPEEDS ON AN INTERSTATE HIGHWAY. THIS LED TO BRAKE FAILURE, COMPONENT DESTRUCTION, AND OVERHEATING OF THE WHEEL. BECAUSE THIS HAPPENED ON A TRAILER, WE DIDN'T REALIZE WHAT HAPPENED UNTIL WE REACHED OUR DESTINATION. WE HAD PUT APPROXIMATELY 1,000 MILES ON THIS NEW VEHICLE WHEN IT HAPPENED. (THERE ARE MANY SIMILAR REPORTS ON VARIOUS RV OWNER INTERNET DISCUSSION GROUPS.)