2020 Forest River Cedar Creek

While driving down the road at highway speeds (65-68 M.P.H.) the "under belly" of the 2020 Cedar Creek 5th wheel trailer became dislodged and fell onto the freeway. Large sections of plastic (Estimating 36" X 48") as well as insulation was thrown onto the highway. After further inspection one could see the brackets holding the wooden cross member beams into place were only fastened with one sheet metal screw. The brackets were designed to have two sheet metal screws holding the bracket to the frame of the trailer. It was also noted wooden cross member beams were never fastened to the brackets. (There are no screw holes present indicating the beams were ever secured to the brackets.) The underbelly would have been secured to the cross member beams which may have been the cause of the failure resulting in the plastic and debris to be dislodged and falling onto the freeway.

LEAF SPRING BRACKET OR AXLE MOUNT CAME LOOSE CAUSING THE AXLE TO COME LOOSE ON DRIVERS SIDE CAUSING THE WHOLE RV TO FISH TAIL - LUCKILY NO BODILY INJURY OCCURRED. THIS HAPPENED ON STATE RT 22 NEAR CONWAY SOUTH CAROLINIA. INCIDENT DATE WAS APRIL 7, 2020. THE DEALER HAS PROVIDED LIMITED INFORMATION ON REPAIR - WAITING FOR PARTS. CONTACTED FACTORY AND THEY ALSO STATED WAITING ON 3 PARTY VENDOR PARTS. NO EXPLANATION ON WHY THIS HAPPENED. AFTER SOME INTERNET SEARCHING FOUND THE ATTACHED PDF AND ALSO COPY OF LETTER SENT TO CEDAR CREEK.

UPON TURNING INTO A PARKING LOT WITH A VERY SMALL INCLINE AT APPROXIMATELY 2 MILES PER HOUR, THE REAR OF THE FIFTH WHEEL BOTTOMED OUT & SCRAPED THE PAVEMENT CAUSING IT TO RIP OFF THE BOTTOM OF THE BACK CAP. AS A RESULT OF THE BACK CAP BEING PULLED AWAY FROM THE FRAME, IT ALSO CAUSED US TO HAVE TO PULL THE FIFTH WHEEL HOME WITHOUT ANY BRAKE LIGHTS, HAZARD LIGHTS OR TURN SIGNALS, WHICH IS A HAZARD TO US & OTHER DRIVERS ON THE ROAD. THE REAR OF THE FIFTH WHEEL SITS ENTIRELY TOO LOW TO GROUND & THIS WILL HAPPEN EVERY TIME IT IS PULLED TO A NEW LOCATION UNLESS THE DRIVEWAYS ARE PERFECTLY LEVEL WITH THE HIGHWAY.*JB