← New search

2003 Ford Windstar

Owner reports · Recalls · Investigations

More warning signs than most Windstar years

Owner complaints for the 2003 Ford Windstar are substantially higher than the model-year median of 192.

About this comparison →

When problems were reported

Mileage at the reported incident

1,283 reports with mileage · 227 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Service Brakes. Review the 296 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 282 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 280 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

33 crash reports27 fire reports28 injury reports

Engine And Engine Cooling complaints

47 reports
Clear category filter
138,000 miles · Nov 18, 2013
Engine And Engine CoolingFuel System, Gasoline

THE VEHICLE STOPS IN THE MIDDLE OF TRAFFIC. IT WILL STALL OUT WHEN STOPPED. THE CAR WILL NOT RESTART. IT IS NOT ANYTHING THAT PERTAINS TO A TUNE UP OR OIL CHANGE OR TRANSMISSION FLUID. THE RADIATOR GOT LOW A;LITTLE BUT THAT WAS NOT THE PROBLEM. THERE WAS A RECALL ON 2003 FORD WINDSTAR LIMITED EDITION BUT MINE WAS NOT IN THI…

Read full complaint

THE VEHICLE STOPS IN THE MIDDLE OF TRAFFIC. IT WILL STALL OUT WHEN STOPPED. THE CAR WILL NOT RESTART. IT IS NOT ANYTHING THAT PERTAINS TO A TUNE UP OR OIL CHANGE OR TRANSMISSION FLUID. THE RADIATOR GOT LOW A;LITTLE BUT THAT WAS NOT THE PROBLEM. THERE WAS A RECALL ON 2003 FORD WINDSTAR LIMITED EDITION BUT MINE WAS NOT IN THIS RECALL. I FEEL THAT MY CAR SHOULD BE FIXED BECAUSE IT HIS A SAFETY HAZARD. PLUS THE FRONT WHEEL BEARINGS ARE BAD, WHICH CAUSES MY TIRES TO GO BALD. FORD WILL NOT FIX THE LIFE THREATENING SITUATION. *TR

NHTSA ODI #10552786

90,000 miles · Aug 4, 2013
Engine And Engine CoolingService Brakes

THE ABS AND ENGINE LIGHTS HAVE BEEN ON MY 2003 FORD WINDSTAR FOR YEARS. HOWEVER, THEY WERE ELECTRICAL MISFIRES AND DID NOT AFFECT THE OPERATION OF THE VEHICLE. IT DOES NOW SEEM THAT THE ABS IS FAILING. THE CAR BRAKES NORMALLY AT LOW SPEEDS. HOWEVER, OVER 30 MPH IT NOW SEEMS THAT THE BRAKES LOCK UP AND THE CAR PULLS TO THE RI…

Read full complaint

THE ABS AND ENGINE LIGHTS HAVE BEEN ON MY 2003 FORD WINDSTAR FOR YEARS. HOWEVER, THEY WERE ELECTRICAL MISFIRES AND DID NOT AFFECT THE OPERATION OF THE VEHICLE. IT DOES NOW SEEM THAT THE ABS IS FAILING. THE CAR BRAKES NORMALLY AT LOW SPEEDS. HOWEVER, OVER 30 MPH IT NOW SEEMS THAT THE BRAKES LOCK UP AND THE CAR PULLS TO THE RIGHT. I DO NOT FEEL THAT THE CAR IS SAFE TO DRIVE, AS IT SCREECHED AND LOCKED UP WHEN I WAS STOPPING AT A RED LIGHT. *TR

NHTSA ODI #10533526

124,000 miles · May 22, 2013
Engine And Engine CoolingPower Train

OUR VAN WAS FINE UNTIL IT WAS HAVING A HARD TIME SHIFTING. WE TOOK THE VAN INTO A TRANSMISSION SPECIALIST AND HAD TO REPLACE THE TRANSMISSION DUE TO WATER. AND ALSO HAD THE WATER TO THE RADIATOR COMPLETELY BYPASS THE TRANSMISSION. EVERYTHING WAS FINE UNTIL MONTHS LATER IT WAS HAVING A HARD TIME SHIFTING. SOMEHOW A LOT OF WAT…

Read full complaint

OUR VAN WAS FINE UNTIL IT WAS HAVING A HARD TIME SHIFTING. WE TOOK THE VAN INTO A TRANSMISSION SPECIALIST AND HAD TO REPLACE THE TRANSMISSION DUE TO WATER. AND ALSO HAD THE WATER TO THE RADIATOR COMPLETELY BYPASS THE TRANSMISSION. EVERYTHING WAS FINE UNTIL MONTHS LATER IT WAS HAVING A HARD TIME SHIFTING. SOMEHOW A LOT OF WATER HAD GOTTEN IN THERE. THERE'S NO WAY IT'S FROM THE RADIATOR SINCE LIKE I SAID IT BYPASSES THE TRANNY AND HAS A DIFFERENT COOLING THING?? NOW HE THINKS IT'S FROM THE A/C. SO NOW IT'S IN THE SHOP AGAIN AND I ALREADY SPENT $300 FOR A COMPLETE FLUSH. NOW I MIGHT HAVE TO DO IT AGAIN. PLUS HE'S GOING TO MAKE A SHIELD FOR THE A/C. THIS IS CRAZY. *TR

NHTSA ODI #10513081

114,089 miles · Feb 11, 2012
Engine And Engine CoolingPower Train

WHILE DRIVING ON THE HIGHWAY ON A TRIP FROM CHICAGO TO NORTH CAROLINE, MY CAR SUDDENLY LOST POWER. IT WAS AS IF I JUST PUT IT INTO NEUTRAL; I COULD HEAR THE ENGINE REV WHEN I APPLIED THE GAS BUT NOTHING ELSE HAPPENED. LUCKILY, I WAS NEAR AN EXIT RAMP AND PULLED TO THE SIDE OF THE ROAD WITHOUT INCIDENT. I TRIED PUTTING THE CAR IN…

Read full complaint

WHILE DRIVING ON THE HIGHWAY ON A TRIP FROM CHICAGO TO NORTH CAROLINE, MY CAR SUDDENLY LOST POWER. IT WAS AS IF I JUST PUT IT INTO NEUTRAL; I COULD HEAR THE ENGINE REV WHEN I APPLIED THE GAS BUT NOTHING ELSE HAPPENED. LUCKILY, I WAS NEAR AN EXIT RAMP AND PULLED TO THE SIDE OF THE ROAD WITHOUT INCIDENT. I TRIED PUTTING THE CAR INTO ANOTHER GEAR, BUT THERE WAS NO CHANGE. WE ENDED UP GETTING THE CAR TOWED TO A GARAGE, WHERE THEY DETERMINED IT WAS AN ISSUE WITH THE TRANSMISSION. LATER, AFTER PULLING THE TRANSMISSION APART, THEY DETERMINED IT WAS SPECIFICALLY THE TORQUE CONVERTER WHICH HAD FAILED. MY FAMILY AND I (INCLUDING 4 CHILDREN AND 4 DOGS) HAD TO STAY IN A HOTEL FOR 3 DAYS UNTIL THE CAR WAS REPAIRED. DURING THAT TIME, I INVESTIGATED THIS PARTICULAR VEHICLE PROBLEM (VIA THE INTERNET) AND FOUND THAT IT IS COMMON IN WINDSTARS AND FREESTARS. THERE IS A RECALL IN PLACE FOR THE FREESTAR BUT NOT ENOUGH COMPLAINTS HAVE BEEN FILED FOR THE WINDSTAR YET. THIS NEEDS TO BE RECTIFIED ASAP!!!! I WAS LUCKY THAT I WAS DRIVING IN CONDITIONS THAT ALLOWED ME TO SAFELY MANEUVER MY CAR TO THE SIDE OF THE ROAD WITHOUT CAUSING OR BEING INVOLVED IN A ACCIDENT. THE SAFETY OF MYSELF, MY CHILDREN AND THE OTHER PEOPLE ON THE ROAD WITH ME, A WINDSTAR OWNER, SHOULD NOT BE PUT AT RISK BECAUSE OF A KNOWN TORQUE CONVERTER DEFECT. THE WINDSTAR NEEDS TO BE ADDED TO THE FORD RECALL FOR TORQUED CONVERTERS IMMEDIATELY. *TR

NHTSA ODI #10447478

186,000 miles · Jan 10, 2012
Engine And Engine CoolingStructure

TL* THE CONTACT OWNS A 2003 FORD WINDSTAR. THE CONTACT STATED THAT AFTER RECEIVING NOTIFICATION OF A MANUFACTURER'S RECALL FOR THE MOTOR BRACKETS, THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS. MONTHS AFTER THE RECALL REPAIRS WHILE THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH, THE ENGINE BEGAN SHIFTING ABNORMALLY. THE VEHICLE W…

Read full complaint

TL* THE CONTACT OWNS A 2003 FORD WINDSTAR. THE CONTACT STATED THAT AFTER RECEIVING NOTIFICATION OF A MANUFACTURER'S RECALL FOR THE MOTOR BRACKETS, THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS. MONTHS AFTER THE RECALL REPAIRS WHILE THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH, THE ENGINE BEGAN SHIFTING ABNORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED THE CONTACT THAT TWO MOTOR MOUNTS WERE FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MECHANIC ADVISED THE CONTACT THAT THE FAILURE MAY HAVE BEEN CAUSED BY THE PREVIOUS RECALL REPAIRS. THE FAILURE MILEAGE WAS APPROXIMATELY 186,000. THE VIN WAS UNAVAILABLE. UPDATED 02/09/12*LJ UPDATED 04/18/12

NHTSA ODI #10443311

132,871 miles · Nov 30, 2011
Electrical SystemEngine And Engine CoolingPower Train

I HAVE HAD NO TRANSMISSION ISSUES WITH MY 2003 FORD WINDSTAR VAN. I DROVE HOME FROM WORK EARLY THIS MORNING (3:30AM.) I WENT TO LEAVE FOR AN APPOINTMENT AT NOON ON THE SAME DAY, AND NOTHING. I STARTED MY VAN, ATTEMPTED TO PUT IT IN GEAR AND NOTHING!! NO WARNING, NO NOTHING!! I HAVE NEVER TOWED WITH THIS VEHICLE (IT DOESN'T …

Read full complaint

I HAVE HAD NO TRANSMISSION ISSUES WITH MY 2003 FORD WINDSTAR VAN. I DROVE HOME FROM WORK EARLY THIS MORNING (3:30AM.) I WENT TO LEAVE FOR AN APPOINTMENT AT NOON ON THE SAME DAY, AND NOTHING. I STARTED MY VAN, ATTEMPTED TO PUT IT IN GEAR AND NOTHING!! NO WARNING, NO NOTHING!! I HAVE NEVER TOWED WITH THIS VEHICLE (IT DOESN'T EVEN HAVE A HITCH,) THE TOTAL WEIGHT OF PEOPLE RIDING IN IT HAS BEEN 350 POUNDS. THERE HAS BEEN NO STRESS ON THIS ENGINE AS I DON'T LIVE IN MOUNTAINESS AREAS. I AM A SINGLE MOM OF 4 LITTLE KIDS, RECEIVING NO CHILD SUPPORT, WORKING PT, JUST ABLE TO PAY THE BILLS, AND FORD NEEDS TO FIX THIS ISSUE!! I HAVE ALSO HAD NUMEROUS OTHER 'PROBLEMS' BUT NOTHING SO MAJOR THE VEHICLE COULDN'T BE DRIVEN (INTERIOR LIGHTS FLASHING, BLENDER DOOR ACTUATOR GOING OUT 3X IN A YEAR, ROUGH IDEAL ESPECIALLY WHEN COLD, BACK DOOR HANDLES NOT WORKING FROM INSIDE, BACK DOORS SO HARD TO OPEN AND CLOSE, I CAN HARDLY DO IT, BACK WIPER WORKED ONE DAY THEN JUST STOPPED AND HASN'T WORKED SINCE, ONE BACK WINDOW OPENS AND CLOSES ONLY WHEN IT FEELS LIKE IT. I ALSO JUST PUT $70 IN GAS IN THIS VEHICLE! UGH!! *KB

NHTSA ODI #10437872

103,000 miles · Nov 16, 2011
Engine And Engine CoolingFire

TL* THE CONTACT OWNS A 2003 FORD WINDSTAR. THE CONTACT WAS DRIVING 30 MPH WHEN FLAMES EMITTED FROM THE ENGINE. THE CONTACT ALSO MENTIONED PRIOR TO THE FAILURE THAT A LOUD NOISE WAS HEARD FROM THE ENGINE AFTER THE START OF THE IGNITION. THE FIRE CAUSED NO INJURIES AND BOTH THE POLICE AND FIRE DEPARTMENTS WERE CONTACTED. THE VEHI…

Read full complaint

TL* THE CONTACT OWNS A 2003 FORD WINDSTAR. THE CONTACT WAS DRIVING 30 MPH WHEN FLAMES EMITTED FROM THE ENGINE. THE CONTACT ALSO MENTIONED PRIOR TO THE FAILURE THAT A LOUD NOISE WAS HEARD FROM THE ENGINE AFTER THE START OF THE IGNITION. THE FIRE CAUSED NO INJURIES AND BOTH THE POLICE AND FIRE DEPARTMENTS WERE CONTACTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS DESTROYED. THE FAILURE AND THE CURRENT MILEAGES WERE 103,000.

NHTSA ODI #10436032

Mileage unknown · Oct 4, 2011
Electrical SystemEngine And Engine CoolingUnknown Or Other

2003 FORD WINDSTAR 71,000 MILES - BOUGHT NEW FOR $35,000 IN DECEMBER 2003, I PURCHASED A NEW 2003 FORD WINDSTAR. I AM THE ONLY DRIVER OF THIS VAN, TO AND FROM WORK AND A FEW ROAD TRIPS. IN THE BEGINNING A FEW THINGS WENT WRONG BUT I WASN'T TOO CONCERNED AT THE TIME. SINCE THEN, HERE IS A LIST OF THINGS THAT HAS GONE WRONG…

Read full complaint

2003 FORD WINDSTAR 71,000 MILES - BOUGHT NEW FOR $35,000 IN DECEMBER 2003, I PURCHASED A NEW 2003 FORD WINDSTAR. I AM THE ONLY DRIVER OF THIS VAN, TO AND FROM WORK AND A FEW ROAD TRIPS. IN THE BEGINNING A FEW THINGS WENT WRONG BUT I WASN'T TOO CONCERNED AT THE TIME. SINCE THEN, HERE IS A LIST OF THINGS THAT HAS GONE WRONG WITH THIS VAN: 1.NO HEAT - BLENDER ACTUATOR 2.DRIVER'S SIDE WINDOW WOULDN'T ROLL UP OR DOWN (FIXED) 3.PASSENGER SIDE WINDOW AND BACK WINDOWS DO NOT WORK 4.INTERIOR LIGHTS GO ON AND OFF 5.GASKET REPLACED ON ENGINE BECAUSE CAR WAS DYING WHEN I CAME TO A STOP. ($450) 6.REAR WINDOW DEFROSTER DOESN'T WORK 7.RUSTING OUT BY BACK TIRES 8.TRANSMISSION FAILURE $2,800. FLUID FROM THE RADIATOR GOT INTO THE TRANSMISSION FLUID! (NOW HOW DID THAT HAPPEN OTHER THAN BEING DEFECTIVE) 9.2 SAFETY RECALLS I AM LUCKY I HAVEN'T BEEN KILLED IN THIS VEHICLE! THE TRANSMISSION FAILED WITH NO WARNING! YOU WOULD THINK WHEN I HAD MY CAR SERVICED THEY WOULD HAVE NOTICED THAT MY TRANSMISSION FLUID DID NOT LOOK RIGHT. I AM SO FRUSTRATED WITH THIS VAN THAT I HAVE WORKED HARD AND STRUGGLED TO PAY FOR, BUT I DID IT. MY ENTIRE FAMILY HAS ALWAYS STUCK BY FORD AND I HAVE ALWAYS DEFENDED THEM. I CAN'T AFFORD ANOTHER VEHICLE RIGHT NOW SO I HAD TO DIG DEEP TO PAY FOR THESE REPAIRS. I HAVE DONE QUITE A BIT OF RESEARCH ON THIS VEHICLE AND I CANNOT BELIEVE THERE HASN'T BEEN A RECALL ON THE TRANSMISSION. NOW I AM STUCK WITH DRIVING A $35,000 VAN THAT I DON'T FEEL SAFE DRIVING! [XXX] COPY TO: NHTSA (NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION) MISSOURI ATTORNEY GENERAL (CONSUMER PROTECTION) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #10428426

Mileage unknown · Sep 8, 2011
Engine And Engine CoolingExterior LightingPower Train

I WAS PARKED OUTSIDE MY HOME.I WENT OUT TO MY VAN TO GO PICK UP DINNER AND TO MY DISTRESS, THE VAN WOULDN'T REVERSE OR GO FORWARD. AFTER SOME INVESTIGATION FROM ONLINE SOURCE AND AUTO MECHANICS, THIS IS AN ONGOING PROBLEM WITH FORD'S TRANSMISSIONS. NO WARNING OF A PROBLEM.IN THE PAST WEEKS,MY INTERIOR LIGHTS WOULD COME ON WHILE …

Read full complaint

I WAS PARKED OUTSIDE MY HOME.I WENT OUT TO MY VAN TO GO PICK UP DINNER AND TO MY DISTRESS, THE VAN WOULDN'T REVERSE OR GO FORWARD. AFTER SOME INVESTIGATION FROM ONLINE SOURCE AND AUTO MECHANICS, THIS IS AN ONGOING PROBLEM WITH FORD'S TRANSMISSIONS. NO WARNING OF A PROBLEM.IN THE PAST WEEKS,MY INTERIOR LIGHTS WOULD COME ON WHILE IM DRIVING. THIS VAN IS A HAZARD. YOU REALLY NEED TO INVESTIGATE THIS PLEASE. *TR

NHTSA ODI #10424368

129,000 miles · Sep 3, 2011
Engine And Engine CoolingService Brakes, HydraulicSteering

ABS LIGHT IS ON AS WELL AS CHECK ENGINE LIGHT.CAR IS IDLING ROUGH. CHECKED WITH NUMEROUS CAR REPAIR PLACES WITH NO SUCCESS. ALSO, VAN IS PULLING TO THE RIGHT EVEN AFTER I CHANGED TIRES AND DID ALIGNMENT CHECK ! *TR

NHTSA ODI #10423180

Official recalls

8

15V608000 · SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly

Sep 29, 2015

Ford Motor Company (Ford) is recalling certain model year 1998-2003 Windstar vehicles manufactured September 2, 1997, to July 3, 2003. The affected vehicles were previously remedied to safeguard against the rear axle cracking from corrosion, however, the remedy brackets may have been misinstalled. The incorrect bracket installations may limit the effectiveness of the service repair for NHTSA recalls 10V-385, 12V-193, and 12V-195.

Consequence & remedy

Consequence: If the brackets were not installed properly, the rear axle may fracture, affecting the vehicle handling and increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect the brackets to verify their proper installation. If a bracket is found to have been misinstalled, the rear axle will be replaced. These repairs will be performed free of charge. The began on October 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S27.

12V193000 · Power Train:axle Assembly

May 3, 2012

FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997, THROUGH JULY 3, 2003, AND CURRENTLY REGISTERED OR ORIGINALLY SOLD IN VIRGINIA. OVER TIME, CORROSION CAN WEAKEN THE REAR AXLE MAKING IT SUSCEPTIBLE TO TORSIONAL STRESS. CORROSION AND STRESS CAN LEAD TO CRACKS WHICH, IF UNDETECTED, CAN INCREASE AND RESULT IN A COMPLETE FRACTURE OF THE AXLE.

Consequence & remedy

Consequence: A FRACTURED AXLE CAN AFFECT VEHICLE HANDLING AND INCREASE THE RISK OF A CRASH.

Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND INSTALL REAR AXLE REINFORCEMENT BRACKETS, OR REPLACE THE AXLES, AS NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

12V194000 · Suspension:front:control Arm

May 3, 2012

FORD IS RECALLING CERTAIN MODEL YEAR 1999-2003 WINDSTAR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATE OF VIRGINIA. CORROSION-RELATED FRACTURES OF THE FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS AND BODY MOUNT ATTACHMENTS MAY OCCUR.

Consequence & remedy

Consequence: A SEPARATION OF A FRONT LOWER CONTROL ARM REAR ATTACHING BRACKET MAY RESULT IN A LOWER CONTROL ARM SEPARATION. A SEPARATION OF BOTH FRONT SUBFRAME REAR BODY MOUNTS MAY RESULT IN SEPARATION OF THE STEERING INTERMEDIATE SHAFT. EITHER CONDITION COULD RESULT IN SIGNIFICANT LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS AND BOTH BODY MOUNT ATTACHMENTS AT THE REAR OF THE FRONT SUBFRAME AND MAKE THE NECESSARY REPAIRS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 18, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

12V195000 · SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly

May 3, 2012

FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997, THROUGH JULY 3, 2003, REGISTERED IN PUERTO RICO. DUE TO INCREASED STRESSES CAUSED BY HIGH CYCLES OF TORSIONAL LOADING, SPECIFIC TO THIS MARKET, THE REAR AXLE CAN CRACK.

Consequence & remedy

Consequence: A FRACTURED AXLE MAY RESULT IN A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND INSTALL A REINFORCEMENT BRACKET ON THE REAR AXLE OR REPLACE THE AXLES, AS NECESSARY. THIS SERVICE WILL BE PROVIDED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 1, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

11V030000 · Structure:frame And Members:underbody Shields

Jan 26, 2011

FORD IS RECALLING CERTAIN MODEL YEAR 1999-2003 WINDSTAR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, UTAH, VERMONT, WEST VIRGINIA, AND WISCONSIN. A SEPARATION OF A FRONT LOWER CONTROL ARM REAR ATTACHING BRACKET MAY RESULT IN A LOWER CONTROL ARM SEPARATION. A SEPARATION OF BOTH FRONT SUBFRAME REAR BODY MOUNTS MAY RESULT IN SEPARATION OF THE STEERING INTERMEDIATE SHAFT.

Consequence & remedy

Consequence: THIS COULD RESULT IN REDUCED STEERING CONTROL INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS, AND BOTH BODY MOUNT ATTACHMENTS AT THE REAR OF THE FRONT SUBFRAME, AND MAKE THE NECESSARY REPAIRS FREE OF CHARGE. IF REPAIRS CANNOT BE MADE TO A VEHICLE, FORD WILL OFFER TO REPURCHASE THE VEHICLE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 21, 2011. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

10V385000 · SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly

Aug 26, 2010

FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997 THROUGH FEBRUARY 28, 2003 AND CURRENTLY REGISTERED OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. AFTER MANY YEARS OF VEHICLE SERVICE IN THESE AREAS, CORROSION CAN WEAKEN THE REAR AXLE, MAKING IT SUSCEPTIBLE TO TORSIONAL STRESS. CORROSION AND STRESS CAN LEAD TO CRACKS WHICH IF UNDETECTED CAN PROPAGATE AND RESULT IN A COMPLETE FRACTURE OF THE AXLE.

Consequence & remedy

Consequence: A FRACTURED AXLE CAN AFFECT VEHICLE HANDLING AND INCREASE THE RISK OF A CRASH.

Remedy: AS PARTS BECOME AVAILABLE, DEALERS WILL INSPECT AND IF NECESSARY INSTALL THE REAR AXLE REINFORCEMENT BRACKETS FREE OF CHARGE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 20, 2010. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

09V399000 · Vehicle Speed Control

Oct 13, 2009

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence & remedy

Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

03V459000 · Seats:mid/rear Assembly

Nov 6, 2003

CERTAIN MINIVANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." DURING TESTING, A THIRD ROW BENCH FLOOR-TO-SEAT LATCH RELEASED BEFORE THE STRENGTH REQUIREMENT WAS MET. IDENTICAL LATCHES ARE USED IN THE SECOND ROW OF SEATS.

Consequence & remedy

Consequence: IF THE LATCHES ON TH4E SECOND OR THIRD ROW SEATS OF THE VEHICLE RELEASE IN A CRASH, THE POTENTIAL FOR OCCUPANT INJURY IS INCREASED.

Remedy: DEALERS WILL REPLACE THE SEAT-TO-FLOOR LATCHES ON THE SECOND AND THIRD ROW OF SEATS. OWNER NOTIFICATION BEGAN ON NOVEMBER 21, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

6

EA10007 · Front Subframe Corrosion Failures

Opened Dec 20, 2010 · Closed Mar 17, 2011

Status: closed (inferred from source dates) · Structure:frame And Members; Suspension

In a January 26, 2011 Defect Information Report, Ford Motor Company (Ford) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address corrosion related fractures in the front lower control arm rear attaching brackets and body mount attachments at the rear of the front subframe in approximately 425,288 model year (MY) 1999 through 2003 Ford Windstar vehicles manufactured from April 1998 to July 2003 and either sold or currently registered in the following high corrosion (Salt-Belt) states:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Utah, Vermont, West Virginia and Wisconsin (NHTSA Recall No. 11V-030, Ford Recall No. 11S16).According to Ford, separation of a front lower control arm rear attaching bracket may result in a lower control arm separation and separations of both front subframe rear body mounts may result in separation of the steering intermediate shaft.Either condition could result in diminished vehicle directional control, increasing the risk of a crash.Dealers will inspect the lower control arm rear attachment flanges and the rear body mount sections of the subframe on the right (passenger) and left (driver) sides of the vehicle.Owners of vehicles that pass the inspection will be notified when to return for installation of reinforcement brackets to extend the durability of the front subframe assembly in affected areas in the presence of corrosion.Owners of vehicles that do not pass inspection, but can be repaired, will be offered transportation until parts become available.Repurchase offers will be extended to owners of vehicles that cannot be repaired with the reinforcement brackets.This investigation is closed.

Additional source detail variants (2)

Structure:frame And Members

In a January 26, 2011 Defect Information Report, Ford Motor Company (Ford) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address corrosion related fractures in the front lower control arm rear attaching brackets and body mount attachments at the rear of the front subframe in approximately 425,288 model year (MY) 1999 through 2003 Ford Windstar vehicles manufactured from April 1998 to July 2003 and either sold or currently registered in the following high corrosion (Salt-Belt) states:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Utah, Vermont, West Virginia and Wisconsin (NHTSA Recall No. 11V-030, Ford Recall No. 11S16).According to Ford, separation of a front lower control arm rear attaching bracket may result in a lower control arm separation and separations of both front subframe rear body mounts may result in separation of the steering intermediate shaft.Either condition could result in diminished vehicle directional control, increasing the risk of a crash.Dealers will inspect the lower control arm rear attachment flanges and the rear body mount sections of the subframe on the right (passenger) and left (driver) sides of the vehicle.Owners of vehicles that pass the inspection will be notified when to return for installation of reinforcement brackets to extend the durability of the front subframe assembly in affected areas in the presence of corrosion.Owners of vehicles that do not pass inspection, but can be repaired, will be offered transportation until parts become available.Repurchase offers will be extended to owners of vehicles that cannot be repaired with the reinforcement brackets.This investigation is closed.

Suspension

In a January 26, 2011 Defect Information Report, Ford Motor Company (Ford) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address corrosion related fractures in the front lower control arm rear attaching brackets and body mount attachments at the rear of the front subframe in approximately 425,288 model year (MY) 1999 through 2003 Ford Windstar vehicles manufactured from April 1998 to July 2003 and either sold or currently registered in the following high corrosion (Salt-Belt) states:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Utah, Vermont, West Virginia and Wisconsin (NHTSA Recall No. 11V-030, Ford Recall No. 11S16).According to Ford, separation of a front lower control arm rear attaching bracket may result in a lower control arm separation and separations of both front subframe rear body mounts may result in separation of the steering intermediate shaft.Either condition could result in diminished vehicle directional control, increasing the risk of a crash.Dealers will inspect the lower control arm rear attachment flanges and the rear body mount sections of the subframe on the right (passenger) and left (driver) sides of the vehicle.Owners of vehicles that pass the inspection will be notified when to return for installation of reinforcement brackets to extend the durability of the front subframe assembly in affected areas in the presence of corrosion.Owners of vehicles that do not pass inspection, but can be repaired, will be offered transportation until parts become available.Repurchase offers will be extended to owners of vehicles that cannot be repaired with the reinforcement brackets.This investigation is closed.

DP10005 · Rear Axle Fracture Recall Scope

Opened Dec 15, 2010 · Closed Dec 21, 2010

Status: closed (inferred from source dates) · SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly

On November 5, 2010, NHTSA received a Defect Petition from the owner of a MY 2003 Ford Windstar vehicle registered in the state of New York requesting that the scope of Recall 10V-385 be expanded to include additional MY 2003 vehicles experiencing the defect condition.The petitioner initially filed a complaint (VOQ 10345125) with ODI on July 25, 2010, two days after the axle failure.The complaint was subsequently amended and the petition filed after the consumer was denied compensation and repair under the recall.ODI has identified a total of five complaints from owners of MY 2003 Ford Windstar vehicles in Salt Belt states that were built after February 28, 2003, Ford's original cutoff date for 10V-385.On November 30, 2010, Ford submitted a letter supplementing recall 10V-385 (Ford 10S13) to add certain vehicles to the program.Ford's analysis of parts and information from the field showed: 1) that the revised heat treated axle introduced in production on February 28, 2003, may still have the potential for cracks due to corrosion related stress; and 2) that vehicles operated in Utah may be exposed to the same combination of environmental factors that can make them susceptible to cracks from stress related corrosion.Based on this analysis, Ford expanded the scope of 10V-385 to include MY 2003 vehicles built after February 28, 2003 and sold or currently registered in Salt Belt states and MY 1998 through 2003 vehicles sold or currently registered in Utah.Ford estimated that approximately 29,900 vehicles in the expanded scope may currently remain in service.Based on the above amended defect report submission, the petition has become moot and is therefore denied.

PE10026 · Front Subframe Corrosion Failures

Opened Jul 20, 2010 · Closed Dec 20, 2010

Status: closed (inferred from source dates) · Structure:frame And Members; Suspension

The Office of Defects Investigation (ODI) has identified 346 complaints to ODI and Ford alleging fracture, cracking and or excessive corrosion of the front subframes in model year (MY) 1999 through 2003 Ford Windstar vehicles.Approximately 97 percent of these complaints (334) involve vehicles that have been operated in Salt Belt states, which make up approximately 60 percent of the subject vehicle sales in the United States.The front subframe, sometimes referred to as the engine cradle, is a structural component of the Windstar vehicles that carries the engine, transaxle, steering rack and certain front suspension components (e.g., lower control arm).For complaints with sufficient information to identify the location of the failure, most describe problems with the rear mounting bracket for the front passenger-side lower control arm with some related to the rear body mount attachment located in the same general area of the subframe (right-rear section near the front passenger wheel).The remainder of the reports allege fracture of the front subframe at other or, most often, unspecified locations.Almost all of the complaints that specified the side of the vehicle indicated that the problem occurred on the right/passenger side (106), with only a few indicating the left/driver side (2) or both sides (3) were affected.Ford and several complainants attributed the right-side failures to the routing of the air-conditioning lines above the front subframe on that side of the vehicle, further noting that condensation has been observed dripping onto the front subframe in the area of the affected components (the A/C drain tube is also located on the right side, near the front subframe).ODI has identified 93 complaints related to lower control arm attachments, including 80 that appear to involve complete separations.All but one of these involved vehicles from Salt Belt states.All three crash incidents appear to be related to lower control arm separations, including one road departure into a road-side sign resulting in a totalled vehicle and a lane departure into another vehicle.Almost half of the ODI complaints related to control arm separation occurred at speeds greater than 20 mph and about a quarter occurred at highway speeds.Three-quarters of these complaints allege experiencing difficulty controlling the vehicle and about 40 percent appear to have resulted in departures from the intended lane of travel.Testing by both Ford and NHTSA have demonstrated that lower control arm separation from the rear attachment bracket results in significant toe out of the affected wheel, which affects the driver's ability to control vehicle direction.According to Ford, moderate braking improved vehicle controllability by reducing the amount of toe out, possibly explaining incidents that did not allege a loss of control.ODI's analysis of complaints related to the rear body mount identified 41 complaints (ODI only).These complaints generally report experiencing progressively worsening noise concerns when turning, accelerating or braking.Although, some of the complaints that appeared to involve a complete separation of the body mount alleged difficulty steering, the effects on vehicle control from this failure mode do not appear to be as great as those resulting from control arm separation.However, ODI is seeking more information regarding two complaints which alleged that body mount failure resulted in disconnection of the steering wheel from the steering rack (one occurred during vehicle service).This investigation has been upgraded to an Engineering Analysis (EA10-007) for subject vehicles sold or currently re

Additional source detail variants (2)

Structure:frame And Members

The Office of Defects Investigation (ODI) has identified 346 complaints to ODI and Ford alleging fracture, cracking and or excessive corrosion of the front subframes in model year (MY) 1999 through 2003 Ford Windstar vehicles.Approximately 97 percent of these complaints (334) involve vehicles that have been operated in Salt Belt states, which make up approximately 60 percent of the subject vehicle sales in the United States.The front subframe, sometimes referred to as the engine cradle, is a structural component of the Windstar vehicles that carries the engine, transaxle, steering rack and certain front suspension components (e.g., lower control arm).For complaints with sufficient information to identify the location of the failure, most describe problems with the rear mounting bracket for the front passenger-side lower control arm with some related to the rear body mount attachment located in the same general area of the subframe (right-rear section near the front passenger wheel).The remainder of the reports allege fracture of the front subframe at other or, most often, unspecified locations.Almost all of the complaints that specified the side of the vehicle indicated that the problem occurred on the right/passenger side (106), with only a few indicating the left/driver side (2) or both sides (3) were affected.Ford and several complainants attributed the right-side failures to the routing of the air-conditioning lines above the front subframe on that side of the vehicle, further noting that condensation has been observed dripping onto the front subframe in the area of the affected components (the A/C drain tube is also located on the right side, near the front subframe).ODI has identified 93 complaints related to lower control arm attachments, including 80 that appear to involve complete separations.All but one of these involved vehicles from Salt Belt states.All three crash incidents appear to be related to lower control arm separations, including one road departure into a road-side sign resulting in a totalled vehicle and a lane departure into another vehicle.Almost half of the ODI complaints related to control arm separation occurred at speeds greater than 20 mph and about a quarter occurred at highway speeds.Three-quarters of these complaints allege experiencing difficulty controlling the vehicle and about 40 percent appear to have resulted in departures from the intended lane of travel.Testing by both Ford and NHTSA have demonstrated that lower control arm separation from the rear attachment bracket results in significant toe out of the affected wheel, which affects the driver's ability to control vehicle direction.According to Ford, moderate braking improved vehicle controllability by reducing the amount of toe out, possibly explaining incidents that did not allege a loss of control.ODI's analysis of complaints related to the rear body mount identified 41 complaints (ODI only).These complaints generally report experiencing progressively worsening noise concerns when turning, accelerating or braking.Although, some of the complaints that appeared to involve a complete separation of the body mount alleged difficulty steering, the effects on vehicle control from this failure mode do not appear to be as great as those resulting from control arm separation.However, ODI is seeking more information regarding two complaints which alleged that body mount failure resulted in disconnection of the steering wheel from the steering rack (one occurred during vehicle service).This investigation has been upgraded to an Engineering Analysis (EA10-007) for subject vehicles sold or currently re

Suspension

The Office of Defects Investigation (ODI) has identified 346 complaints to ODI and Ford alleging fracture, cracking and or excessive corrosion of the front subframes in model year (MY) 1999 through 2003 Ford Windstar vehicles.Approximately 97 percent of these complaints (334) involve vehicles that have been operated in Salt Belt states, which make up approximately 60 percent of the subject vehicle sales in the United States.The front subframe, sometimes referred to as the engine cradle, is a structural component of the Windstar vehicles that carries the engine, transaxle, steering rack and certain front suspension components (e.g., lower control arm).For complaints with sufficient information to identify the location of the failure, most describe problems with the rear mounting bracket for the front passenger-side lower control arm with some related to the rear body mount attachment located in the same general area of the subframe (right-rear section near the front passenger wheel).The remainder of the reports allege fracture of the front subframe at other or, most often, unspecified locations.Almost all of the complaints that specified the side of the vehicle indicated that the problem occurred on the right/passenger side (106), with only a few indicating the left/driver side (2) or both sides (3) were affected.Ford and several complainants attributed the right-side failures to the routing of the air-conditioning lines above the front subframe on that side of the vehicle, further noting that condensation has been observed dripping onto the front subframe in the area of the affected components (the A/C drain tube is also located on the right side, near the front subframe).ODI has identified 93 complaints related to lower control arm attachments, including 80 that appear to involve complete separations.All but one of these involved vehicles from Salt Belt states.All three crash incidents appear to be related to lower control arm separations, including one road departure into a road-side sign resulting in a totalled vehicle and a lane departure into another vehicle.Almost half of the ODI complaints related to control arm separation occurred at speeds greater than 20 mph and about a quarter occurred at highway speeds.Three-quarters of these complaints allege experiencing difficulty controlling the vehicle and about 40 percent appear to have resulted in departures from the intended lane of travel.Testing by both Ford and NHTSA have demonstrated that lower control arm separation from the rear attachment bracket results in significant toe out of the affected wheel, which affects the driver's ability to control vehicle direction.According to Ford, moderate braking improved vehicle controllability by reducing the amount of toe out, possibly explaining incidents that did not allege a loss of control.ODI's analysis of complaints related to the rear body mount identified 41 complaints (ODI only).These complaints generally report experiencing progressively worsening noise concerns when turning, accelerating or braking.Although, some of the complaints that appeared to involve a complete separation of the body mount alleged difficulty steering, the effects on vehicle control from this failure mode do not appear to be as great as those resulting from control arm separation.However, ODI is seeking more information regarding two complaints which alleged that body mount failure resulted in disconnection of the steering wheel from the steering rack (one occurred during vehicle service).This investigation has been upgraded to an Engineering Analysis (EA10-007) for subject vehicles sold or currently re

PE10016 · Rear Axle Cracking

Opened May 13, 2010 · Closed Sep 22, 2010

Status: closed (inferred from source dates) · Suspension

In a letter dated August 26, 2010, Ford Motor Company (Ford) submitted a Defect Information Report notifying NHTSA that it will conduct a safety recall (NHTSA Recall No. 10V-385) to address a rear axle defect in model year (MY) 1998 through 2003 Ford Windstar vehicles built at the Oakville assembly plant from September 1, 1997 through February 28, 2003 and either sold or currently registered in high corrosion (Salt-Belt) states where the use of salt and other corrosive chemicals may be used to treat snow/ice covered roads.The following states are included in Ford's recall:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. The subject vehicles utilize a Stamped/Formed axle assembly manufactured by Benteler automotive Corporation of Galesburg, MI.According to Ford, after many years of vehicle service in the Salt-Belt states, corrosion can weaken the rear axle, making it susceptible to torsional stress.There is a risk that the combined effects of corrosion and stress can lead to cracks which, if undetected, can propagate and result in a complete fracture of the axle.A completely fractured axle can affect vehicle handling and increase the risk of a crash.To correct the safety defect, Ford will initially inspect all of the subject vehicles brought into Ford/Lincoln-Mercury dealerships for possible cracked axles.Owners of vehicles without cracked axles will be notified when to return for the installation of reinforcement brackets to extend the axle durability in the presence of corrosion.Owners who have vehicles with cracked axles will either be offered a repair or alternative transportation until parts become available. On May 13, 2010, the Office of Defects Investigation (ODI) opened PE10-016 to investigate complaints of rear axle cracking in MY 1999 through 2003 Ford Windstar minivans.Combining ODI and Ford complaint data, ODI is aware of a total 891 complaints alleging rear axle cracking in the subject vehicles.Over a third of the complaints (334) allege that the cracking progressed to a complete fracture of the rear axle, including 8 allegations of crashes resulting in 3 injuries. Approximately 57 percent of the subject vehicles (524,661) were sold in Salt-Belt states covered by Ford's recall and Ford estimates that approximately 463,000 of these remain in service.Ninety-six percent of the complaints (858) and all of the complaints alleging complete fracture were from the recall region.The action taken by Ford is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.

EA08021 · Engine Compartment Fires

Opened Sep 17, 2008 · Closed Oct 14, 2009

Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Vehicle Speed Control; Vehicle Speed Control:cruise Control

EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.

Additional source detail variants (7)

Electrical System

EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.

Electrical System:wiring

EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.

Service Brakes, Hydraulic

EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.

Vehicle Speed Control:cruise Control

EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.

Vehicle Speed Control

EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.

PE08035 · Engine Compartment Fires

Opened May 13, 2008 · Closed Sep 17, 2008

Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Vehicle Speed Control

ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.

Additional source detail variants (3)

Electrical System

ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.

Electrical System:wiring

ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.

Vehicle Speed Control

ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.