NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
261 reportsClear category filter100,000 miles · Jul 22, 2011
Electrical System
TL* THE CONTACT OWNS A 2002 FORD WINDSTAR. THE CONTACT STATED THAT THE ABS AND BRAKE WARNING LAMPS WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT BREAK FLUIDS WERE LEAKING ONTO THE WIRING HARNESS AND AS A RESULT, THEY PERFORMED THE REPAIRS SPECIFIED ON NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED …
Read full complaint
TL* THE CONTACT OWNS A 2002 FORD WINDSTAR. THE CONTACT STATED THAT THE ABS AND BRAKE WARNING LAMPS WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT BREAK FLUIDS WERE LEAKING ONTO THE WIRING HARNESS AND AS A RESULT, THEY PERFORMED THE REPAIRS SPECIFIED ON NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL). THE REMEDY FAILED TO REPAIR THE PROBLEM. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 135,000.
NHTSA ODI #10414712
146,000 miles · Jul 6, 2011
Electrical SystemService Brakes, Hydraulic
I PURCHASED A 2002 FORD WINDSTAR FROM GENOA FORD GENOA OHIO...WITH THE ABS LIGHT AND BRAKE LIGHT ON...THE SALSEMAN SAID THAT WE HAVE THE CAR PRICED LOW BECAUSE IT WILL NEED BRAKES...WE PURCHASED THE BRAKES AND STILL HAD THE PROBLEM...WE THEN HAD THE MASTER CYLINDER REPLACED THE NEXT DAY 3 DAYS LATER AS WE WHERE DRIVING THE VAN T…
Read full complaint
I PURCHASED A 2002 FORD WINDSTAR FROM GENOA FORD GENOA OHIO...WITH THE ABS LIGHT AND BRAKE LIGHT ON...THE SALSEMAN SAID THAT WE HAVE THE CAR PRICED LOW BECAUSE IT WILL NEED BRAKES...WE PURCHASED THE BRAKES AND STILL HAD THE PROBLEM...WE THEN HAD THE MASTER CYLINDER REPLACED THE NEXT DAY 3 DAYS LATER AS WE WHERE DRIVING THE VAN THE ABS AND BRAKE LIGHT TURNED ON AND THE VAN WAS NOT ABLE TO BE STARTED SO IT WAS TOWED FOR THE SECOND TIME...THE DAY BEFORE THIS WE HAD IT AT TIREMAN IN NORTHWOOD TO GET RADIATOR FLUSHED...AND NEW TIRES WHEN WE PULLED AWAY THE VAN LOST ALL POWER AND THEN THE BATTERY WAS REPLACED...SO TODAY AFTER THIS PROBLEM HAPPENED THE MECHANIC TELLS US WE NEED AN ALTERNATOR. IN THE MEAN TIME I HAVE SEARCHED ONLINE AND FOUND THAT RECALL #09S09 DEALS WITH ELECTRICAL ISSUES AS IN THE ABS THE SCDS THE CRUISE CONTROL ETC... SO THIS ISSUE OBVIOUSLY HAS NOT BEEN STOPPED WITH THE RECALL BEING PERFORMED ON MY VEHICLE AT GENOA FORD ON OCT 19, 2009( AS THE MECHANIC [XXX] TOLD ME ON THE PHONE)...SO I HAVE COME HERE TO FILE THIS COMPLAINT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10410698
112,000 miles · Jul 5, 2011
Electrical SystemService Brakes, Hydraulic
1. NONE SPECIFIC. THE RECALL HAS BEEN PERFORMED THAT REPLACES SOME WIRING IN ORDER TO AVOID POSSIBLE FIRE. 2. THE FAILURE IS A YELLOW ABS BRAKE LIGHT AND RED BRAKE LIGHT ON THE DASHBOARD INSTRUMENT CLUSTER COMING ON TOGETHER FAIRLY OFTEN BUT NOT ALWAYS. I UNDERSTAND THESE LIGHTS, SPECIFICALLY THE ABS LIGHT, MEANS THE ABS BRAKING…
Read full complaint
1. NONE SPECIFIC. THE RECALL HAS BEEN PERFORMED THAT REPLACES SOME WIRING IN ORDER TO AVOID POSSIBLE FIRE. 2. THE FAILURE IS A YELLOW ABS BRAKE LIGHT AND RED BRAKE LIGHT ON THE DASHBOARD INSTRUMENT CLUSTER COMING ON TOGETHER FAIRLY OFTEN BUT NOT ALWAYS. I UNDERSTAND THESE LIGHTS, SPECIFICALLY THE ABS LIGHT, MEANS THE ABS BRAKING SYSTEM IS NOT IN OPERATION MEANING PROBABLE LONGER STOPPING DISTANCES. I SUSPECT AS OTHERS HAVE SUGGESTED THESE LIGHTS ARE CAUSED BY A HEAT BUILDUP PROBLEM IN THE ABS MODULE THAT CAUSES THE MODULE TO WARP AND FAIL. 3. THE PROBLEM IS ONGOING. *KB
NHTSA ODI #10410453
70,000 miles · Jul 1, 2011
Electrical System
I AM THE OWNER OF A 2002 FORD WINDSTAR. I BOUGHT THE VEHICLE WITH 16,000 MILES ON IT AND IT NOW HAS 104,000. I AM CURRENT ON ALL OF THE RECALLS ISSUED BY FORD AS OF JUNE 2011. MY ABS LIGHT, AND BRAKE LIGHT HAVE BEEN COMING ON RANDOMLY THROUGHOUT THE COURSE OF DRIVING DURING THE DAY FOR THE PAST 4 YEARS. I LIVE IN FLORIDA. I…
Read full complaint
I AM THE OWNER OF A 2002 FORD WINDSTAR. I BOUGHT THE VEHICLE WITH 16,000 MILES ON IT AND IT NOW HAS 104,000. I AM CURRENT ON ALL OF THE RECALLS ISSUED BY FORD AS OF JUNE 2011. MY ABS LIGHT, AND BRAKE LIGHT HAVE BEEN COMING ON RANDOMLY THROUGHOUT THE COURSE OF DRIVING DURING THE DAY FOR THE PAST 4 YEARS. I LIVE IN FLORIDA. IT IS ON ALWAYS THROUGHOUT THE SUMMER AND LESS FREQUENT DURING THE WINTER MONTHS. I HAVE HAD THE COMPUTER UPDATED WITH THE LATEST SOFTWARE BY FORD 3 YEARS AGO WHEN THE PROBLEM STARTED OCCURRING... DID NOTHING TO HELP. I HAVE TAKEN IT TO THE FORD DEALERSHIP AND LOCAL MECHANIC. EACH HAVE LOOKED AT IT AND HAVE TOLD ME DIFFERENT THINGS. THE DEALER SUGGESTED I NEEDED A NEW ELECTRONIC CONTROL MODULE. ( I DID THE RECALL SUGGESTED BY FORD AND HAVE THE NEW WIRE HARNESS ON THE VAN. IT HAS DONE NOTHING TO SOLVE THE PROBLEM OF THE ABS LIGHT AND BRAKE LIGHT COMING ON) HE SAYS BECAUSE OF THE HEAT IT WARMS UP AND CAUSES INTERMITTENT ELECTRICAL CONNECTION IN THE UNIT BECAUSE THE FRAGILE BOARD IS BEING STRETCHED AND MALFORMED. THE CODE MOST COMMONLY SCANNED BY PROFESSIONAL MECHANICS IS CODE C1185. THE LOCAL MECHANIC (NOT FORD) TEST DROVE THE VAN AND FOUND ALL KINDS OF ABS CODES COMING UP AND SINKS FAILING. I LEFT IT AT HIS SHOP AND THE NEXT MORNING HE DROVE IT AGAIN AND THE LIGHTS WERE OFF. HE SAID IT IS A COMPUTER ISSUE BECAUSE EVERYTHING DOESN'T JUST FAIL ALL AT ONCE AND THEN NO LIGHTS COME ON THE NEXT DAY IN THE A.M. LATER THAT DAY WHEN I TOOK IT HOME AND IT STARTED TO HEAT UP IN THE SUMMER TIME HERE IN FLORIDA THE LIGHTS CAME BACK ON INDICATING TO ME THAT I HAD NO ANTI-LOCK BRAKES!!!!! FORD NEEDS TO RECALL THIS PART BECAUSE IT IS A SAFETY ISSUE THAT WE AS CUSTOMERS HAVE PAID FOR AND EXPECT. PLEASE LOOK INTO THIS ISSUE AND DO SOMETHING! *TR
NHTSA ODI #10410167
152,867 miles · Jun 29, 2011
Electrical System
2002 FORD WINDSTAR, 153028 MILES SAT BECAUSE OF REAR AXLE BROKE CLOSE TO HOME. GOT RECALL NOTICE FROM FORD FOR AXLE. CONTACTED COUNTRY ROADS FORD IN NEW MARTINSVILLE WV. THEY HAD VAN FOR COUPLE MONTHS WAITING FOR AXLE. AXLE WAS REPLACED BUT NO OTHER RECALLS WERE DONE PHYSICALLY. THE MECHANIC SIGNED THAT ALL WAS DONE. I GOT IN VA…
Read full complaint
2002 FORD WINDSTAR, 153028 MILES SAT BECAUSE OF REAR AXLE BROKE CLOSE TO HOME. GOT RECALL NOTICE FROM FORD FOR AXLE. CONTACTED COUNTRY ROADS FORD IN NEW MARTINSVILLE WV. THEY HAD VAN FOR COUPLE MONTHS WAITING FOR AXLE. AXLE WAS REPLACED BUT NO OTHER RECALLS WERE DONE PHYSICALLY. THE MECHANIC SIGNED THAT ALL WAS DONE. I GOT IN VAN, WHICH SAT FOR A COUPLE WEEKS, ATTEMPTED TO STOP AT LITE AND NO BRAKES. PEDAL WENT TO FLOOR. PUMPED BRAKES AN GRABBED E-BRAKE TO STOP INCHES FROM THE CAR IN FRONT OF ME. TOOK IT HOME AFTER FILLING MASTER CYLINDER WITH FLUID. FOUND THAT IT WAS LEAKING THRU THE SWITCH ITSELF. BRAKE FLUID TRAILED TO DIFFERENT CONNECTORS.TOOK IT BACK TO FORD. THEY DID THE RECALL FOR THE BRAKE SENSOR AND THE SUB FRAME. 11S16. NOW THE ENGINES REVS TO 2000 RPM WHEN THE STEERING WHEEL IS TURNED AND WHEN ITS SHIFTED FROM GEAR TO GEAR AT ANY GIVEN MOMENT. REVS UP AT ANY TIME WHICH IS A HAZARD TO ANYONE IN OR NEAR THE VEHICLE WHEN OPERATING AT LITES, IN STORE PARKING AREAS. THE WIRING HARNESS INSTALLED WAS MANUFACTURED 06-27-2008. PART NO. BW7T14A411A35NB CA. DIAGNOSTIC CODES CHANGE WHEN THE BATTERY TERMINALS ARE REMOVED, THEN REPLACED FOR RESETTING COMPUTER. THE CRUISE CONTROL WORKS WHEN IT WANTS TO. SHUTS OFF DURING DRIVING. THE UNCONTROLLABLE ENGINE REVS IS THE MOST SERIOUS OF THE PROBLEMS. CALLED COUNTRY ROADS FORD AGAIN AND THEY SAID IT WASN'T CAUSED BY ANYTHING THEY DID FOR THE RECALLS AND THAT ONLY 3 PERTAINED TO MY VEHICLE. HAVING A DIFFERENT SHOP LOOK AT IT. *TR
NHTSA ODI #10409360
173,000 miles · Jun 28, 2011
Electrical System
2002 FORD WINDSTAR - AT TIMES THE SPEEDOMETER BECOMES STUCK AT HALF THE SPEED I AM TRAVELING - GETS STUCK AROUND 25 MPH EVEN THOUGH I AM GOING 60 MPH. THE ABS LIGHT COMES ON FOR APPARENTLY NO REASON - DEFECT IN ELECTRICAL SYSTEM? I HAVE BEEN TOLD BY MY MECHANIC THAT THERE IS NOTHING WRONG WITH ABS. ACCORDING TO BEST FORD - TH…
Read full complaint
2002 FORD WINDSTAR - AT TIMES THE SPEEDOMETER BECOMES STUCK AT HALF THE SPEED I AM TRAVELING - GETS STUCK AROUND 25 MPH EVEN THOUGH I AM GOING 60 MPH. THE ABS LIGHT COMES ON FOR APPARENTLY NO REASON - DEFECT IN ELECTRICAL SYSTEM? I HAVE BEEN TOLD BY MY MECHANIC THAT THERE IS NOTHING WRONG WITH ABS. ACCORDING TO BEST FORD - THERE HAS BEEN NO RECALL FOR THESE ISSUES - OTHER PEOPLE APPARENTLY HAVING SAME ISSUES ACCORDING TO INFO POSTED ONLINE. *TR
NHTSA ODI #10409154
100,000 miles · Jun 24, 2011
Electrical SystemService Brakes, HydraulicVehicle Speed Control
TL* THE CONTACT OWNS A 2002 FORD WINDSTAR. THE CONTACT STATED THAT THE BRAKE AND ANTI LOCK BRAKING SYSTEM LIGHTS WOULD CONSTANTLY ILLUMINATE ON THE INSTRUMENT PANEL. THE CONTACT ALSO STATED THAT THE IGNITION LIGHT AND CRUISE CONTROL SWITCH DID NOT FUNCTION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THEY WERE UNAB…
Read full complaint
TL* THE CONTACT OWNS A 2002 FORD WINDSTAR. THE CONTACT STATED THAT THE BRAKE AND ANTI LOCK BRAKING SYSTEM LIGHTS WOULD CONSTANTLY ILLUMINATE ON THE INSTRUMENT PANEL. THE CONTACT ALSO STATED THAT THE IGNITION LIGHT AND CRUISE CONTROL SWITCH DID NOT FUNCTION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEGE WAS 100,000 AND THE CURRENT MILEAGE WAS 140,000.
NHTSA ODI #10408778
154,000 miles · Jun 21, 2011
Electrical SystemVehicle Speed Control
TL* THE CONTACT OWNS A 2002 FORD WINDSTAR. THE CONTACT STATED THAT THE ABS, BRAKE AND AIR BAG WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL) BUT THE FAILURE RECURRED. NEITHER THE DEALER NOR THE MANUFACTURER WAS CONTACTED IN REGARDS…
Read full complaint
TL* THE CONTACT OWNS A 2002 FORD WINDSTAR. THE CONTACT STATED THAT THE ABS, BRAKE AND AIR BAG WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL) BUT THE FAILURE RECURRED. NEITHER THE DEALER NOR THE MANUFACTURER WAS CONTACTED IN REGARDS TO THE MOST RECENT FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 154,000.
NHTSA ODI #10407741
130,000 miles · Jun 19, 2011
Electrical SystemService Brakes, Hydraulic
BRAKING DISTANCE SUDDENLY INCREASED. *TR
NHTSA ODI #10407441
145,000 miles · Jun 15, 2011
Electrical SystemFire
TL*THE CONTACT OWNS A 2002 FORD WINDSTAR. THE CONTACT RECEIVED RECALL NOTICE 09V399000 (VEHICLE SPEED CONTROL) AND TOOK THE VEHICLE TO A DEALER TO BE REPAIRED; HOWEVER, DUE TO A BRAKE FLUID LEAK IT CAUSED THE WIRING HARNESS TO BURN. THE DEALER ADVISED THE CONTACT THAT THE WIRING HARNESS HAD NOT BEEN COVERED UNDER THE RECALL; T…
Read full complaint
TL*THE CONTACT OWNS A 2002 FORD WINDSTAR. THE CONTACT RECEIVED RECALL NOTICE 09V399000 (VEHICLE SPEED CONTROL) AND TOOK THE VEHICLE TO A DEALER TO BE REPAIRED; HOWEVER, DUE TO A BRAKE FLUID LEAK IT CAUSED THE WIRING HARNESS TO BURN. THE DEALER ADVISED THE CONTACT THAT THE WIRING HARNESS HAD NOT BEEN COVERED UNDER THE RECALL; THEREFORE, DID NOT CHECK THAT COMPONENT WHEN THE RECALL WORK WAS PERFORMED. THE MANUFACTURER WAS AWARE OF THE FAILURE. THE CURRENT AND FAILURE MILES WERE 145,000.
NHTSA ODI #10406950
Official recalls
8Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 1998-2003 Windstar vehicles manufactured September 2, 1997, to July 3, 2003. The affected vehicles were previously remedied to safeguard against the rear axle cracking from corrosion, however, the remedy brackets may have been misinstalled. The incorrect bracket installations may limit the effectiveness of the service repair for NHTSA recalls 10V-385, 12V-193, and 12V-195.
Consequence & remedy
Consequence: If the brackets were not installed properly, the rear axle may fracture, affecting the vehicle handling and increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the brackets to verify their proper installation. If a bracket is found to have been misinstalled, the rear axle will be replaced. These repairs will be performed free of charge. The began on October 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S27.
May 3, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997, THROUGH JULY 3, 2003, AND CURRENTLY REGISTERED OR ORIGINALLY SOLD IN VIRGINIA. OVER TIME, CORROSION CAN WEAKEN THE REAR AXLE MAKING IT SUSCEPTIBLE TO TORSIONAL STRESS. CORROSION AND STRESS CAN LEAD TO CRACKS WHICH, IF UNDETECTED, CAN INCREASE AND RESULT IN A COMPLETE FRACTURE OF THE AXLE.
Consequence & remedy
Consequence: A FRACTURED AXLE CAN AFFECT VEHICLE HANDLING AND INCREASE THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND INSTALL REAR AXLE REINFORCEMENT BRACKETS, OR REPLACE THE AXLES, AS NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
May 3, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 1999-2003 WINDSTAR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATE OF VIRGINIA. CORROSION-RELATED FRACTURES OF THE FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS AND BODY MOUNT ATTACHMENTS MAY OCCUR.
Consequence & remedy
Consequence: A SEPARATION OF A FRONT LOWER CONTROL ARM REAR ATTACHING BRACKET MAY RESULT IN A LOWER CONTROL ARM SEPARATION. A SEPARATION OF BOTH FRONT SUBFRAME REAR BODY MOUNTS MAY RESULT IN SEPARATION OF THE STEERING INTERMEDIATE SHAFT. EITHER CONDITION COULD RESULT IN SIGNIFICANT LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS AND BOTH BODY MOUNT ATTACHMENTS AT THE REAR OF THE FRONT SUBFRAME AND MAKE THE NECESSARY REPAIRS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 18, 2012. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
May 3, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997, THROUGH JULY 3, 2003, REGISTERED IN PUERTO RICO. DUE TO INCREASED STRESSES CAUSED BY HIGH CYCLES OF TORSIONAL LOADING, SPECIFIC TO THIS MARKET, THE REAR AXLE CAN CRACK.
Consequence & remedy
Consequence: A FRACTURED AXLE MAY RESULT IN A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND INSTALL A REINFORCEMENT BRACKET ON THE REAR AXLE OR REPLACE THE AXLES, AS NECESSARY. THIS SERVICE WILL BE PROVIDED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 1, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Jan 26, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 1999-2003 WINDSTAR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, UTAH, VERMONT, WEST VIRGINIA, AND WISCONSIN. A SEPARATION OF A FRONT LOWER CONTROL ARM REAR ATTACHING BRACKET MAY RESULT IN A LOWER CONTROL ARM SEPARATION. A SEPARATION OF BOTH FRONT SUBFRAME REAR BODY MOUNTS MAY RESULT IN SEPARATION OF THE STEERING INTERMEDIATE SHAFT.
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED STEERING CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM REAR ATTACHING BRACKETS, AND BOTH BODY MOUNT ATTACHMENTS AT THE REAR OF THE FRONT SUBFRAME, AND MAKE THE NECESSARY REPAIRS FREE OF CHARGE. IF REPAIRS CANNOT BE MADE TO A VEHICLE, FORD WILL OFFER TO REPURCHASE THE VEHICLE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 21, 2011. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Aug 26, 2010
FORD IS RECALLING CERTAIN MODEL YEAR 1998-2003 WINDSTAR VEHICLES MANUFACTURED FROM SEPTEMBER 1, 1997 THROUGH FEBRUARY 28, 2003 AND CURRENTLY REGISTERED OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. AFTER MANY YEARS OF VEHICLE SERVICE IN THESE AREAS, CORROSION CAN WEAKEN THE REAR AXLE, MAKING IT SUSCEPTIBLE TO TORSIONAL STRESS. CORROSION AND STRESS CAN LEAD TO CRACKS WHICH IF UNDETECTED CAN PROPAGATE AND RESULT IN A COMPLETE FRACTURE OF THE AXLE.
Consequence & remedy
Consequence: A FRACTURED AXLE CAN AFFECT VEHICLE HANDLING AND INCREASE THE RISK OF A CRASH.
Remedy: AS PARTS BECOME AVAILABLE, DEALERS WILL INSPECT AND IF NECESSARY INSTALL THE REAR AXLE REINFORCEMENT BRACKETS FREE OF CHARGE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 20, 2010. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Nov 6, 2003
CERTAIN MINIVANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." DURING TESTING, A THIRD ROW BENCH FLOOR-TO-SEAT LATCH RELEASED BEFORE THE STRENGTH REQUIREMENT WAS MET. IDENTICAL LATCHES ARE USED IN THE SECOND ROW OF SEATS.
Consequence & remedy
Consequence: IF THE LATCHES ON TH4E SECOND OR THIRD ROW SEATS OF THE VEHICLE RELEASE IN A CRASH, THE POTENTIAL FOR OCCUPANT INJURY IS INCREASED.
Remedy: DEALERS WILL REPLACE THE SEAT-TO-FLOOR LATCHES ON THE SECOND AND THIRD ROW OF SEATS. OWNER NOTIFICATION BEGAN ON NOVEMBER 21, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA10007 · Front Subframe Corrosion Failures
Opened Dec 20, 2010 · Closed Mar 17, 2011
Status: closed (inferred from source dates) · Structure:frame And Members; Suspension
In a January 26, 2011 Defect Information Report, Ford Motor Company (Ford) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address corrosion related fractures in the front lower control arm rear attaching brackets and body mount attachments at the rear of the front subframe in approximately 425,288 model year (MY) 1999 through 2003 Ford Windstar vehicles manufactured from April 1998 to July 2003 and either sold or currently registered in the following high corrosion (Salt-Belt) states:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Utah, Vermont, West Virginia and Wisconsin (NHTSA Recall No. 11V-030, Ford Recall No. 11S16).According to Ford, separation of a front lower control arm rear attaching bracket may result in a lower control arm separation and separations of both front subframe rear body mounts may result in separation of the steering intermediate shaft.Either condition could result in diminished vehicle directional control, increasing the risk of a crash.Dealers will inspect the lower control arm rear attachment flanges and the rear body mount sections of the subframe on the right (passenger) and left (driver) sides of the vehicle.Owners of vehicles that pass the inspection will be notified when to return for installation of reinforcement brackets to extend the durability of the front subframe assembly in affected areas in the presence of corrosion.Owners of vehicles that do not pass inspection, but can be repaired, will be offered transportation until parts become available.Repurchase offers will be extended to owners of vehicles that cannot be repaired with the reinforcement brackets.This investigation is closed.
Additional source detail variants (2)
Structure:frame And Members
In a January 26, 2011 Defect Information Report, Ford Motor Company (Ford) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address corrosion related fractures in the front lower control arm rear attaching brackets and body mount attachments at the rear of the front subframe in approximately 425,288 model year (MY) 1999 through 2003 Ford Windstar vehicles manufactured from April 1998 to July 2003 and either sold or currently registered in the following high corrosion (Salt-Belt) states:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Utah, Vermont, West Virginia and Wisconsin (NHTSA Recall No. 11V-030, Ford Recall No. 11S16).According to Ford, separation of a front lower control arm rear attaching bracket may result in a lower control arm separation and separations of both front subframe rear body mounts may result in separation of the steering intermediate shaft.Either condition could result in diminished vehicle directional control, increasing the risk of a crash.Dealers will inspect the lower control arm rear attachment flanges and the rear body mount sections of the subframe on the right (passenger) and left (driver) sides of the vehicle.Owners of vehicles that pass the inspection will be notified when to return for installation of reinforcement brackets to extend the durability of the front subframe assembly in affected areas in the presence of corrosion.Owners of vehicles that do not pass inspection, but can be repaired, will be offered transportation until parts become available.Repurchase offers will be extended to owners of vehicles that cannot be repaired with the reinforcement brackets.This investigation is closed.
Suspension
In a January 26, 2011 Defect Information Report, Ford Motor Company (Ford) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address corrosion related fractures in the front lower control arm rear attaching brackets and body mount attachments at the rear of the front subframe in approximately 425,288 model year (MY) 1999 through 2003 Ford Windstar vehicles manufactured from April 1998 to July 2003 and either sold or currently registered in the following high corrosion (Salt-Belt) states:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Utah, Vermont, West Virginia and Wisconsin (NHTSA Recall No. 11V-030, Ford Recall No. 11S16).According to Ford, separation of a front lower control arm rear attaching bracket may result in a lower control arm separation and separations of both front subframe rear body mounts may result in separation of the steering intermediate shaft.Either condition could result in diminished vehicle directional control, increasing the risk of a crash.Dealers will inspect the lower control arm rear attachment flanges and the rear body mount sections of the subframe on the right (passenger) and left (driver) sides of the vehicle.Owners of vehicles that pass the inspection will be notified when to return for installation of reinforcement brackets to extend the durability of the front subframe assembly in affected areas in the presence of corrosion.Owners of vehicles that do not pass inspection, but can be repaired, will be offered transportation until parts become available.Repurchase offers will be extended to owners of vehicles that cannot be repaired with the reinforcement brackets.This investigation is closed.
PE10026 · Front Subframe Corrosion Failures
Opened Jul 20, 2010 · Closed Dec 20, 2010
Status: closed (inferred from source dates) · Structure:frame And Members; Suspension
The Office of Defects Investigation (ODI) has identified 346 complaints to ODI and Ford alleging fracture, cracking and or excessive corrosion of the front subframes in model year (MY) 1999 through 2003 Ford Windstar vehicles.Approximately 97 percent of these complaints (334) involve vehicles that have been operated in Salt Belt states, which make up approximately 60 percent of the subject vehicle sales in the United States.The front subframe, sometimes referred to as the engine cradle, is a structural component of the Windstar vehicles that carries the engine, transaxle, steering rack and certain front suspension components (e.g., lower control arm).For complaints with sufficient information to identify the location of the failure, most describe problems with the rear mounting bracket for the front passenger-side lower control arm with some related to the rear body mount attachment located in the same general area of the subframe (right-rear section near the front passenger wheel).The remainder of the reports allege fracture of the front subframe at other or, most often, unspecified locations.Almost all of the complaints that specified the side of the vehicle indicated that the problem occurred on the right/passenger side (106), with only a few indicating the left/driver side (2) or both sides (3) were affected.Ford and several complainants attributed the right-side failures to the routing of the air-conditioning lines above the front subframe on that side of the vehicle, further noting that condensation has been observed dripping onto the front subframe in the area of the affected components (the A/C drain tube is also located on the right side, near the front subframe).ODI has identified 93 complaints related to lower control arm attachments, including 80 that appear to involve complete separations.All but one of these involved vehicles from Salt Belt states.All three crash incidents appear to be related to lower control arm separations, including one road departure into a road-side sign resulting in a totalled vehicle and a lane departure into another vehicle.Almost half of the ODI complaints related to control arm separation occurred at speeds greater than 20 mph and about a quarter occurred at highway speeds.Three-quarters of these complaints allege experiencing difficulty controlling the vehicle and about 40 percent appear to have resulted in departures from the intended lane of travel.Testing by both Ford and NHTSA have demonstrated that lower control arm separation from the rear attachment bracket results in significant toe out of the affected wheel, which affects the driver's ability to control vehicle direction.According to Ford, moderate braking improved vehicle controllability by reducing the amount of toe out, possibly explaining incidents that did not allege a loss of control.ODI's analysis of complaints related to the rear body mount identified 41 complaints (ODI only).These complaints generally report experiencing progressively worsening noise concerns when turning, accelerating or braking.Although, some of the complaints that appeared to involve a complete separation of the body mount alleged difficulty steering, the effects on vehicle control from this failure mode do not appear to be as great as those resulting from control arm separation.However, ODI is seeking more information regarding two complaints which alleged that body mount failure resulted in disconnection of the steering wheel from the steering rack (one occurred during vehicle service).This investigation has been upgraded to an Engineering Analysis (EA10-007) for subject vehicles sold or currently re
Additional source detail variants (2)
Structure:frame And Members
The Office of Defects Investigation (ODI) has identified 346 complaints to ODI and Ford alleging fracture, cracking and or excessive corrosion of the front subframes in model year (MY) 1999 through 2003 Ford Windstar vehicles.Approximately 97 percent of these complaints (334) involve vehicles that have been operated in Salt Belt states, which make up approximately 60 percent of the subject vehicle sales in the United States.The front subframe, sometimes referred to as the engine cradle, is a structural component of the Windstar vehicles that carries the engine, transaxle, steering rack and certain front suspension components (e.g., lower control arm).For complaints with sufficient information to identify the location of the failure, most describe problems with the rear mounting bracket for the front passenger-side lower control arm with some related to the rear body mount attachment located in the same general area of the subframe (right-rear section near the front passenger wheel).The remainder of the reports allege fracture of the front subframe at other or, most often, unspecified locations.Almost all of the complaints that specified the side of the vehicle indicated that the problem occurred on the right/passenger side (106), with only a few indicating the left/driver side (2) or both sides (3) were affected.Ford and several complainants attributed the right-side failures to the routing of the air-conditioning lines above the front subframe on that side of the vehicle, further noting that condensation has been observed dripping onto the front subframe in the area of the affected components (the A/C drain tube is also located on the right side, near the front subframe).ODI has identified 93 complaints related to lower control arm attachments, including 80 that appear to involve complete separations.All but one of these involved vehicles from Salt Belt states.All three crash incidents appear to be related to lower control arm separations, including one road departure into a road-side sign resulting in a totalled vehicle and a lane departure into another vehicle.Almost half of the ODI complaints related to control arm separation occurred at speeds greater than 20 mph and about a quarter occurred at highway speeds.Three-quarters of these complaints allege experiencing difficulty controlling the vehicle and about 40 percent appear to have resulted in departures from the intended lane of travel.Testing by both Ford and NHTSA have demonstrated that lower control arm separation from the rear attachment bracket results in significant toe out of the affected wheel, which affects the driver's ability to control vehicle direction.According to Ford, moderate braking improved vehicle controllability by reducing the amount of toe out, possibly explaining incidents that did not allege a loss of control.ODI's analysis of complaints related to the rear body mount identified 41 complaints (ODI only).These complaints generally report experiencing progressively worsening noise concerns when turning, accelerating or braking.Although, some of the complaints that appeared to involve a complete separation of the body mount alleged difficulty steering, the effects on vehicle control from this failure mode do not appear to be as great as those resulting from control arm separation.However, ODI is seeking more information regarding two complaints which alleged that body mount failure resulted in disconnection of the steering wheel from the steering rack (one occurred during vehicle service).This investigation has been upgraded to an Engineering Analysis (EA10-007) for subject vehicles sold or currently re
Suspension
The Office of Defects Investigation (ODI) has identified 346 complaints to ODI and Ford alleging fracture, cracking and or excessive corrosion of the front subframes in model year (MY) 1999 through 2003 Ford Windstar vehicles.Approximately 97 percent of these complaints (334) involve vehicles that have been operated in Salt Belt states, which make up approximately 60 percent of the subject vehicle sales in the United States.The front subframe, sometimes referred to as the engine cradle, is a structural component of the Windstar vehicles that carries the engine, transaxle, steering rack and certain front suspension components (e.g., lower control arm).For complaints with sufficient information to identify the location of the failure, most describe problems with the rear mounting bracket for the front passenger-side lower control arm with some related to the rear body mount attachment located in the same general area of the subframe (right-rear section near the front passenger wheel).The remainder of the reports allege fracture of the front subframe at other or, most often, unspecified locations.Almost all of the complaints that specified the side of the vehicle indicated that the problem occurred on the right/passenger side (106), with only a few indicating the left/driver side (2) or both sides (3) were affected.Ford and several complainants attributed the right-side failures to the routing of the air-conditioning lines above the front subframe on that side of the vehicle, further noting that condensation has been observed dripping onto the front subframe in the area of the affected components (the A/C drain tube is also located on the right side, near the front subframe).ODI has identified 93 complaints related to lower control arm attachments, including 80 that appear to involve complete separations.All but one of these involved vehicles from Salt Belt states.All three crash incidents appear to be related to lower control arm separations, including one road departure into a road-side sign resulting in a totalled vehicle and a lane departure into another vehicle.Almost half of the ODI complaints related to control arm separation occurred at speeds greater than 20 mph and about a quarter occurred at highway speeds.Three-quarters of these complaints allege experiencing difficulty controlling the vehicle and about 40 percent appear to have resulted in departures from the intended lane of travel.Testing by both Ford and NHTSA have demonstrated that lower control arm separation from the rear attachment bracket results in significant toe out of the affected wheel, which affects the driver's ability to control vehicle direction.According to Ford, moderate braking improved vehicle controllability by reducing the amount of toe out, possibly explaining incidents that did not allege a loss of control.ODI's analysis of complaints related to the rear body mount identified 41 complaints (ODI only).These complaints generally report experiencing progressively worsening noise concerns when turning, accelerating or braking.Although, some of the complaints that appeared to involve a complete separation of the body mount alleged difficulty steering, the effects on vehicle control from this failure mode do not appear to be as great as those resulting from control arm separation.However, ODI is seeking more information regarding two complaints which alleged that body mount failure resulted in disconnection of the steering wheel from the steering rack (one occurred during vehicle service).This investigation has been upgraded to an Engineering Analysis (EA10-007) for subject vehicles sold or currently re
PE10016 · Rear Axle Cracking
Opened May 13, 2010 · Closed Sep 22, 2010
Status: closed (inferred from source dates) · Suspension
In a letter dated August 26, 2010, Ford Motor Company (Ford) submitted a Defect Information Report notifying NHTSA that it will conduct a safety recall (NHTSA Recall No. 10V-385) to address a rear axle defect in model year (MY) 1998 through 2003 Ford Windstar vehicles built at the Oakville assembly plant from September 1, 1997 through February 28, 2003 and either sold or currently registered in high corrosion (Salt-Belt) states where the use of salt and other corrosive chemicals may be used to treat snow/ice covered roads.The following states are included in Ford's recall:Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. The subject vehicles utilize a Stamped/Formed axle assembly manufactured by Benteler automotive Corporation of Galesburg, MI.According to Ford, after many years of vehicle service in the Salt-Belt states, corrosion can weaken the rear axle, making it susceptible to torsional stress.There is a risk that the combined effects of corrosion and stress can lead to cracks which, if undetected, can propagate and result in a complete fracture of the axle.A completely fractured axle can affect vehicle handling and increase the risk of a crash.To correct the safety defect, Ford will initially inspect all of the subject vehicles brought into Ford/Lincoln-Mercury dealerships for possible cracked axles.Owners of vehicles without cracked axles will be notified when to return for the installation of reinforcement brackets to extend the axle durability in the presence of corrosion.Owners who have vehicles with cracked axles will either be offered a repair or alternative transportation until parts become available. On May 13, 2010, the Office of Defects Investigation (ODI) opened PE10-016 to investigate complaints of rear axle cracking in MY 1999 through 2003 Ford Windstar minivans.Combining ODI and Ford complaint data, ODI is aware of a total 891 complaints alleging rear axle cracking in the subject vehicles.Over a third of the complaints (334) allege that the cracking progressed to a complete fracture of the rear axle, including 8 allegations of crashes resulting in 3 injuries. Approximately 57 percent of the subject vehicles (524,661) were sold in Salt-Belt states covered by Ford's recall and Ford estimates that approximately 463,000 of these remain in service.Ninety-six percent of the complaints (858) and all of the complaints alleging complete fracture were from the recall region.The action taken by Ford is sufficient to resolve the issues raised by this investigation.Accordingly, this investigation is closed.
EA08021 · Engine Compartment Fires
Opened Sep 17, 2008 · Closed Oct 14, 2009
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Vehicle Speed Control; Vehicle Speed Control:cruise Control
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Additional source detail variants (7)
Electrical System
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Electrical System:wiring
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Service Brakes, Hydraulic
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Vehicle Speed Control:cruise Control
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Vehicle Speed Control
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
PE08035 · Engine Compartment Fires
Opened May 13, 2008 · Closed Sep 17, 2008
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Vehicle Speed Control
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Additional source detail variants (3)
Electrical System
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Electrical System:wiring
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Vehicle Speed Control
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
PE04022 · Power Sliding Door Opening
Opened Mar 3, 2004 · Closed Jul 1, 2004
Status: closed (inferred from source dates) · Structure:body:door ; Structure:body:door:hinge And Attachments
THE SUBJECT VEHICLES ARE EQUIPPED WITH SINGLE OR DUAL POWER SLIDING DOORS (PSD).APPROXIMATELY 111,000 VEHICLES HAVE DUAL POWER SLIDING DOORS.THE PSD IS OPENED BY ANY OF 5 METHODS, THE INSIDE OR OUTSIDE MANUAL DOOR HANDLE, THE KEY FOB, THE OVERHEAD CONSOLE SWITCH AND THE B-PILLAR SWITCH.THE DOOR MAY BE OPENED ONLY UNDER THESE CONDITIONS: IGNITION KEY IS IN OFF/ACCESSORIES/ON/START POSITION, GEAR SELECTOR IN PARK, VEHICLE SPEED LESS THAN 6 MPH, AND DOOR UNLOCKED.THE PSD LATCH IS LOCATED AT THE REAR OF THE DOOR AND HAS A SECONDARY AND PRIMARY LATCH POSITION.FULL AND PROPER CLOSURE ENGAGES BOTH THE SECONDARY AND PRIMARY LATCH.WITH THE IGNITION IN THE ON POSITION, AS THE GEAR SELECTOR IS MOVED OUT OF PARK THE DOOR AUTOMATICALLY LOCKS AND THAT ACTION MECHANICALLY ISOLATES THE LATCH, SECONDARY AND PRIMARY, FROM ALL LATCH RELEASE CONNECTIONS.IN ADDITION TO THE REPORTS ALLEGING DOOR OPENING WHILE DRIVING, FORD HAS RECEIVED APPROXIMATELY 5,700 REPORTS THAT ALLEGE THE DOOR DOES NOT CLOSE PROPERLY OR POPS OPEN WITH NO MENTION OF WHILE DRIVING.FORD'S INVESTIGATION INTO THESE REPORT INCLUDED OWNER INTERVIEWS, VEHICLE BY-BACKS AND TESTING OF CONSUMER VEHICLES.IT FOUND THAT ALLEGATIONS OF DOOR OPENING WHILE DRIVING WERE IN FACT REPORTS OF DOORS NOT BEING PROPERLY CLOSED INITIALLY AND SUBSEQUENTLY OPENING TO THE SECONDARY LATCH POSITION AS A RESULT OF VEHICLE VIBRATIONS OR DRIVING MANEUVERS.FORD'S TESTING OF CONSUMER VEHICLES DID NOT RESULT IN ANY RECURRENCE OF PSD OPENING WHILE BEING DRIVEN.ODI INTERVIEWS WITH OWNERS AFFIRMED THE ALLEGATIONS OF PSD OPENING WHILE DRIVING; HOWEVER OWNERS INDICATED THE EVENT IS NOT A REGULAR OCCURRENCE (I.E.,IT OCCURRED ONLY ONCE OR HAS NOT OCCURRED RECENTLY) AND THAT THE UNINTENDED PSD OPENING MAY NOT BE ABLE TO BE DUPLICATED.IN CONTRAST, THE IMPROPER CLOSING OF THE PSD (LATCHING ON THE SECONDARY BUT NOT THE PRIMARY LATCH) CAN BE DUPLICATED, AND ODI VERIFIED THIS DURING AN INSPECTION OF A CONSUMER VEHICLE.IN THIS CONDITION (SECONDARY BUT NO PRIMARY LATCH), WHEN THE VEHICLE'S GEAR SELECTOR IS MOVED OUT OF PARK POSITION, A WARNING CHIME SOUNDS AND WARNING MESSAGE APPEARS ON THE INSTRUMENT PANEL.MOST REPORTS AND WARRANTY CLAIMS WERE FILED IN THE EARLY SERVICE-LIFE OF THE VEHICLE AND PEAKED AROUND THE 18-MONTH IN-SERVICE TIME PERIOD.ODI AND MFR COMPLAINT TRENDS ARE DECLINING OVER THE LAST 8 QUARTERS.THERE IS NO ALLEGED INJURY ASSOCIATED WITH OCCUPANT FALLING OUT WHILE THE VEHICLE IS IN MOTION.NO FAILURE MODE CAUSING FULL DOOR OPENING WHILE VEHICLE IS IN MOTION HAS BEEN VERIFIED (REPRODUCED BY ODI OR BY TRAINED SERVICE TECHNICIANS AT DEALERSHIPS) DURING THIS INVESTIGATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Structure:body:door
THE SUBJECT VEHICLES ARE EQUIPPED WITH SINGLE OR DUAL POWER SLIDING DOORS (PSD).APPROXIMATELY 111,000 VEHICLES HAVE DUAL POWER SLIDING DOORS.THE PSD IS OPENED BY ANY OF 5 METHODS, THE INSIDE OR OUTSIDE MANUAL DOOR HANDLE, THE KEY FOB, THE OVERHEAD CONSOLE SWITCH AND THE B-PILLAR SWITCH.THE DOOR MAY BE OPENED ONLY UNDER THESE CONDITIONS: IGNITION KEY IS IN OFF/ACCESSORIES/ON/START POSITION, GEAR SELECTOR IN PARK, VEHICLE SPEED LESS THAN 6 MPH, AND DOOR UNLOCKED.THE PSD LATCH IS LOCATED AT THE REAR OF THE DOOR AND HAS A SECONDARY AND PRIMARY LATCH POSITION.FULL AND PROPER CLOSURE ENGAGES BOTH THE SECONDARY AND PRIMARY LATCH.WITH THE IGNITION IN THE ON POSITION, AS THE GEAR SELECTOR IS MOVED OUT OF PARK THE DOOR AUTOMATICALLY LOCKS AND THAT ACTION MECHANICALLY ISOLATES THE LATCH, SECONDARY AND PRIMARY, FROM ALL LATCH RELEASE CONNECTIONS.IN ADDITION TO THE REPORTS ALLEGING DOOR OPENING WHILE DRIVING, FORD HAS RECEIVED APPROXIMATELY 5,700 REPORTS THAT ALLEGE THE DOOR DOES NOT CLOSE PROPERLY OR POPS OPEN WITH NO MENTION OF WHILE DRIVING.FORD'S INVESTIGATION INTO THESE REPORT INCLUDED OWNER INTERVIEWS, VEHICLE BY-BACKS AND TESTING OF CONSUMER VEHICLES.IT FOUND THAT ALLEGATIONS OF DOOR OPENING WHILE DRIVING WERE IN FACT REPORTS OF DOORS NOT BEING PROPERLY CLOSED INITIALLY AND SUBSEQUENTLY OPENING TO THE SECONDARY LATCH POSITION AS A RESULT OF VEHICLE VIBRATIONS OR DRIVING MANEUVERS.FORD'S TESTING OF CONSUMER VEHICLES DID NOT RESULT IN ANY RECURRENCE OF PSD OPENING WHILE BEING DRIVEN.ODI INTERVIEWS WITH OWNERS AFFIRMED THE ALLEGATIONS OF PSD OPENING WHILE DRIVING; HOWEVER OWNERS INDICATED THE EVENT IS NOT A REGULAR OCCURRENCE (I.E.,IT OCCURRED ONLY ONCE OR HAS NOT OCCURRED RECENTLY) AND THAT THE UNINTENDED PSD OPENING MAY NOT BE ABLE TO BE DUPLICATED.IN CONTRAST, THE IMPROPER CLOSING OF THE PSD (LATCHING ON THE SECONDARY BUT NOT THE PRIMARY LATCH) CAN BE DUPLICATED, AND ODI VERIFIED THIS DURING AN INSPECTION OF A CONSUMER VEHICLE.IN THIS CONDITION (SECONDARY BUT NO PRIMARY LATCH), WHEN THE VEHICLE'S GEAR SELECTOR IS MOVED OUT OF PARK POSITION, A WARNING CHIME SOUNDS AND WARNING MESSAGE APPEARS ON THE INSTRUMENT PANEL.MOST REPORTS AND WARRANTY CLAIMS WERE FILED IN THE EARLY SERVICE-LIFE OF THE VEHICLE AND PEAKED AROUND THE 18-MONTH IN-SERVICE TIME PERIOD.ODI AND MFR COMPLAINT TRENDS ARE DECLINING OVER THE LAST 8 QUARTERS.THERE IS NO ALLEGED INJURY ASSOCIATED WITH OCCUPANT FALLING OUT WHILE THE VEHICLE IS IN MOTION.NO FAILURE MODE CAUSING FULL DOOR OPENING WHILE VEHICLE IS IN MOTION HAS BEEN VERIFIED (REPRODUCED BY ODI OR BY TRAINED SERVICE TECHNICIANS AT DEALERSHIPS) DURING THIS INVESTIGATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Structure:body:door:hinge And Attachments
THE SUBJECT VEHICLES ARE EQUIPPED WITH SINGLE OR DUAL POWER SLIDING DOORS (PSD).APPROXIMATELY 111,000 VEHICLES HAVE DUAL POWER SLIDING DOORS.THE PSD IS OPENED BY ANY OF 5 METHODS, THE INSIDE OR OUTSIDE MANUAL DOOR HANDLE, THE KEY FOB, THE OVERHEAD CONSOLE SWITCH AND THE B-PILLAR SWITCH.THE DOOR MAY BE OPENED ONLY UNDER THESE CONDITIONS: IGNITION KEY IS IN OFF/ACCESSORIES/ON/START POSITION, GEAR SELECTOR IN PARK, VEHICLE SPEED LESS THAN 6 MPH, AND DOOR UNLOCKED.THE PSD LATCH IS LOCATED AT THE REAR OF THE DOOR AND HAS A SECONDARY AND PRIMARY LATCH POSITION.FULL AND PROPER CLOSURE ENGAGES BOTH THE SECONDARY AND PRIMARY LATCH.WITH THE IGNITION IN THE ON POSITION, AS THE GEAR SELECTOR IS MOVED OUT OF PARK THE DOOR AUTOMATICALLY LOCKS AND THAT ACTION MECHANICALLY ISOLATES THE LATCH, SECONDARY AND PRIMARY, FROM ALL LATCH RELEASE CONNECTIONS.IN ADDITION TO THE REPORTS ALLEGING DOOR OPENING WHILE DRIVING, FORD HAS RECEIVED APPROXIMATELY 5,700 REPORTS THAT ALLEGE THE DOOR DOES NOT CLOSE PROPERLY OR POPS OPEN WITH NO MENTION OF WHILE DRIVING.FORD'S INVESTIGATION INTO THESE REPORT INCLUDED OWNER INTERVIEWS, VEHICLE BY-BACKS AND TESTING OF CONSUMER VEHICLES.IT FOUND THAT ALLEGATIONS OF DOOR OPENING WHILE DRIVING WERE IN FACT REPORTS OF DOORS NOT BEING PROPERLY CLOSED INITIALLY AND SUBSEQUENTLY OPENING TO THE SECONDARY LATCH POSITION AS A RESULT OF VEHICLE VIBRATIONS OR DRIVING MANEUVERS.FORD'S TESTING OF CONSUMER VEHICLES DID NOT RESULT IN ANY RECURRENCE OF PSD OPENING WHILE BEING DRIVEN.ODI INTERVIEWS WITH OWNERS AFFIRMED THE ALLEGATIONS OF PSD OPENING WHILE DRIVING; HOWEVER OWNERS INDICATED THE EVENT IS NOT A REGULAR OCCURRENCE (I.E.,IT OCCURRED ONLY ONCE OR HAS NOT OCCURRED RECENTLY) AND THAT THE UNINTENDED PSD OPENING MAY NOT BE ABLE TO BE DUPLICATED.IN CONTRAST, THE IMPROPER CLOSING OF THE PSD (LATCHING ON THE SECONDARY BUT NOT THE PRIMARY LATCH) CAN BE DUPLICATED, AND ODI VERIFIED THIS DURING AN INSPECTION OF A CONSUMER VEHICLE.IN THIS CONDITION (SECONDARY BUT NO PRIMARY LATCH), WHEN THE VEHICLE'S GEAR SELECTOR IS MOVED OUT OF PARK POSITION, A WARNING CHIME SOUNDS AND WARNING MESSAGE APPEARS ON THE INSTRUMENT PANEL.MOST REPORTS AND WARRANTY CLAIMS WERE FILED IN THE EARLY SERVICE-LIFE OF THE VEHICLE AND PEAKED AROUND THE 18-MONTH IN-SERVICE TIME PERIOD.ODI AND MFR COMPLAINT TRENDS ARE DECLINING OVER THE LAST 8 QUARTERS.THERE IS NO ALLEGED INJURY ASSOCIATED WITH OCCUPANT FALLING OUT WHILE THE VEHICLE IS IN MOTION.NO FAILURE MODE CAUSING FULL DOOR OPENING WHILE VEHICLE IS IN MOTION HAS BEEN VERIFIED (REPRODUCED BY ODI OR BY TRAINED SERVICE TECHNICIANS AT DEALERSHIPS) DURING THIS INVESTIGATION.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration