NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
75 reportsClear category filter132,950 miles · Aug 4, 2006
SteeringSuspension
1)MY VAN WAS PULLING TO THE RIGHT AND THE TIRES WERE WORN. 2) I TOOK MY 1995 FORD WINDSTAR TO FIRESTONE TO HAVE NEW TIRES PUT ON AND AN ALIGNMENT DONE. THEY INSTALLED THE TIRES AND TOLD ME THEY COULD NOT DO THE ALIGNMENT BECAUSE THE SWAY BAR WAS BROKEN IN TWO. THEY ALSO STATED IT WAS BAD CRAFTSMANSHIP BECAUSE THE BAR IS A HOLLO…
Read full complaint
1)MY VAN WAS PULLING TO THE RIGHT AND THE TIRES WERE WORN. 2) I TOOK MY 1995 FORD WINDSTAR TO FIRESTONE TO HAVE NEW TIRES PUT ON AND AN ALIGNMENT DONE. THEY INSTALLED THE TIRES AND TOLD ME THEY COULD NOT DO THE ALIGNMENT BECAUSE THE SWAY BAR WAS BROKEN IN TWO. THEY ALSO STATED IT WAS BAD CRAFTSMANSHIP BECAUSE THE BAR IS A HOLLOW METAL TUBE INSTEAD OF A SOLID PIECE. THEY ALSO SAID I NEEDED BOTH INNER TIE ROD ENDS REPLACED BECAUSE THE LACK OF CONTROL FROM THE SWAY BAR PUT STRESS ON THEM AND DAMAGED THEM. 3) TIRES WERE REPLACED AND I WAS GIVEN AN ESTIMATE OF $400 FOR THE SWAY BAR AND $300 FOR THE TIE ROD ENDS AND ALIGNMENT. *JB
NHTSA ODI #10164450
Mileage unknown · May 19, 2005
Steering
TIE RODS WERE REPLACED AT 50,000 MILES. THEY NEED REPLACEMENT AGAIN. LOUD SQUEAKY NOISE WHILE TURNING THE STEERING.
NHTSA ODI #10121412
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
BRAKE WORK X2 TRANSMISSION X2 ALL BELTS TIRE & SUSPENSION WORK LUGS ON WHEELS NOT PROPERLY REPLACED ,IT ALMOST FELL OFF STILL PAYING ON VEHICLE WHILE IT SITS IN ASHLEY FORD PARKING LOT W/ DEAD TRANSMISSION I AM UNABLE TO PAY CLOSE TO $2000 FOR REPAIRS
NHTSA ODI #10070357
76,000 miles · Jan 15, 2004
Engine And Engine CoolingService Brakes, HydraulicSteering
THE ENGINE WAS THE MAIN PROBLEM DUE TO THE HEAD GASKET RECALL. IN JULY,2000, WE ARGUED WITH FORD ABOUT A BAD ENGINE RUNNING FOR WHICH WE HAD JUST PAID OVER $300 TO EVALUATE BY AN OUTSIDE REPAIR SHOP. AFTER ABOUT 6 WEEKS WE RECEIVED OUR CAR BACK WITH A NEW LONG BLOCK PAID FOR BY FORD, INCLUDING A RENTAL VAN FOR THE TIME IN THE …
Read full complaint
THE ENGINE WAS THE MAIN PROBLEM DUE TO THE HEAD GASKET RECALL. IN JULY,2000, WE ARGUED WITH FORD ABOUT A BAD ENGINE RUNNING FOR WHICH WE HAD JUST PAID OVER $300 TO EVALUATE BY AN OUTSIDE REPAIR SHOP. AFTER ABOUT 6 WEEKS WE RECEIVED OUR CAR BACK WITH A NEW LONG BLOCK PAID FOR BY FORD, INCLUDING A RENTAL VAN FOR THE TIME IN THE SHOP. IN JANUARY 2001 THE ENGINE WAS RUNNING ROUGH AGAIN AND WE WERE CHARGED $81.45 TO CHECK IT OUT AND REPLACE A WIRE BAD ON CYLINDER 6 WHICH WAS MISFIRING. THREE MONTHS LATER IN APRIL 2001 THE CAR RAN ROUGH AGAIN AND THE ENGINE LIGHT WAS BACK ON (HAPPENED FOR YEARS INTERMITTENTLY SINCE WE OWNED THE CAR). THE NEW LONG-BLOCK HAD ANOTHER BAD HEAD GASKET REINSTALLED PER THE SECOND FORD DEALERSHIP SERVICE CENTER. AFTER NEARLY ANOTHER MONTH WE HAD THE SECOND NEW LONG-BLOCK IN LESS THAN ONE YEAR. NOW LESS THAN 2 YEARS AND 40,000 MILES LATER, FOLLOWING THE 110K SERVICE OF RADIATOR FLUSH AND OIL CHANGE AT 113,098 MILES THE ENGINE RAPIDLY LOST OIL AND IS MISFIRING AND BURNING OIL. FORD'S POSITION ONCE AGAIN IS THAT THE WARRANTY WAS ONLY FOR 12 MONTHS OR 12K MILES. ON A SMALLER NOTE, THE BRAKES HAVE GONE OUT NUMEROUS TIMES AND WE HAVE REPLACED ROTORS AND PADS NUMEROUS TIMES WITH NO IMPROVEMENTS. THE POWER STEERING HAS PERFORMED VERY POORLY. WE CHANGED THE FLUID IN 2000 AND THEN THE FORD SERVICE CENTER AND THEY REPLACED THE OUTER TIE RODS AND RESET THE ALIGNMENT. WITHIN MONTHS IT WAS GOING OUT AGAIN INTERMITTENTLY. MOST OFTEN WHEN STARTING OUT THE POWER STEERING GOES OUT AND YOU MUST MANUALLY STEER THE VEHICLE.
NHTSA ODI #10070168
146,000 miles · Jan 15, 2004
Engine And Engine CoolingService Brakes, HydraulicSteering
AT 146,00 MILES I WAS JUST INFORMED THAT I WILL HAVE TO HAVE ANOTHER HEAD GASKET REPAIR DONE (THAT WOULD MAKE IT THE THIRD TIME THIS PART HAS FAILED) TO SAVE THE CAR...I WILL NOT DO IT, AS IN FEBRUARY, I SPENT OVER $750 TO HAVE THE REAR BRAKES REPAIRED FOR BRAKE FLUID COVERING THE SHOES OF THE BRAKES, CAUSE BY BRAKE LINE CORROSI…
Read full complaint
AT 146,00 MILES I WAS JUST INFORMED THAT I WILL HAVE TO HAVE ANOTHER HEAD GASKET REPAIR DONE (THAT WOULD MAKE IT THE THIRD TIME THIS PART HAS FAILED) TO SAVE THE CAR...I WILL NOT DO IT, AS IN FEBRUARY, I SPENT OVER $750 TO HAVE THE REAR BRAKES REPAIRED FOR BRAKE FLUID COVERING THE SHOES OF THE BRAKES, CAUSE BY BRAKE LINE CORROSION (JUST AS IN THE RIGHT FRONT BRAKE LINE CORROSION THAT WAS A NATIONAL RECALL!!!!) BUT THERE WAS NO RECALL FOR THE REARS
NHTSA ODI #10070152
Mileage unknown · Nov 15, 2003
Electrical SystemPower TrainSteering
1995 FORD WINDSTAR, TRANSMISSION FAILURE, ELECTRICAL GREMLINS, POWER STEERING BOX FAILURE, ENGINE FAILURE. *LA
NHTSA ODI #10046957
61,349 miles · Nov 5, 2003
Engine And Engine CoolingPower TrainSteering
ENGINE FAILED TWICE DUE TO A FAULTY HEAD GASKET. ALSO, ORIGINAL AUTOMATIC TRANSMISSION FAILED AND WAS REBUILT. ABOUT TWO YEARS LATER, TRANSMISSION FAILED AND THE DEALER REPLACED IT WITH A NEW TRANSMISSION. ANOTHER TWO YEARS LATER, THE TRANSMISSION FAILED AGAIN AND WAS REBUILT. THE CAUSE OF THE FAILURES WAS NOT DETERMINED. *…
Read full complaint
ENGINE FAILED TWICE DUE TO A FAULTY HEAD GASKET. ALSO, ORIGINAL AUTOMATIC TRANSMISSION FAILED AND WAS REBUILT. ABOUT TWO YEARS LATER, TRANSMISSION FAILED AND THE DEALER REPLACED IT WITH A NEW TRANSMISSION. ANOTHER TWO YEARS LATER, THE TRANSMISSION FAILED AGAIN AND WAS REBUILT. THE CAUSE OF THE FAILURES WAS NOT DETERMINED. *AK THE RECALLED ENGINE BLEW AND THE MANIFOLD GASKET BLEW. WHEN THE CONSUMER CONTACTED FORD THEY STATED THEY COULDN'T DO ANYTHING RIGHT NOW BUT WOULD NOTIFY THEM LATER AND MAYBE THEY COULD HELP. CONSUMER HAD TWO WINDOWS THAT DIDN'T GO UP OR DOWN - REPLACED $412.34. BOTH TIE RODS WERE REPLACED. *PH *JB
NHTSA ODI #10040795
65,000 miles · Sep 2, 2003
Steering
THE VEHICLE LEAKED POWER STEERING FLUID, WHICH RESULTED IN THE RACK AND PINION FAILING. *JB RACK AND PINION HAD TO BE REPLACED. *PH
NHTSA ODI #10018227
65,000 miles · Sep 2, 2003
Engine And Engine CoolingSteering
THE TIE ROD'S BROKE WHILE DRIVING 15 MPH. *JB THE CONSUMER TURNED THE CORNER AND THE HANDLING HAD BECOME IMPOSSIBLE. THE CONSUMER FOUND THAT BOTH FRONT WHEELS WERE POINTING INWARD AS THOUGH THE RIGHT FRONT WERE TURNING LEFT AND THE LEFT FRONT TURNING RIGHT. *SCC. ALSO THE RACK AND PINION WAS REPLACED AS WELL AS THE SERP…
Read full complaint
THE TIE ROD'S BROKE WHILE DRIVING 15 MPH. *JB THE CONSUMER TURNED THE CORNER AND THE HANDLING HAD BECOME IMPOSSIBLE. THE CONSUMER FOUND THAT BOTH FRONT WHEELS WERE POINTING INWARD AS THOUGH THE RIGHT FRONT WERE TURNING LEFT AND THE LEFT FRONT TURNING RIGHT. *SCC. ALSO THE RACK AND PINION WAS REPLACED AS WELL AS THE SERPENTINE BELT. *JB
NHTSA ODI #10018225
Mileage unknown · Sep 17, 2002
Service Brakes, HydraulicSteeringStructure
FRONT STRUTS HAD TO BE REPLACED. FRONT END ALIGNMENT PERFORMED. CASTER AND CAMBER RESET. THERE IS A SQUEALING NOISE FROM FRONT END WHEN TURNING, DEALER REPLACED OUTER TIE RODS AND RIGHT CONTROL ARM. *TT
NHTSA ODI #567485
Official recalls
6Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Apr 4, 2002
ON CERTAIN MINIVANS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. DURING ASSEMBLY, SOME BRAKE LINES WERE INSTALLED IN A TWISTED POSITION, CAUSING CONTACT WITH THE DASH PANEL INSULATOR ABOVE THE CATALYTIC CONVERTER. THIS CONTACT COULD ABRADE THE BRAKE LINE CORROSION PROTECTION, CONSEQUENTLY, SALT OR WATER ABSORBED IN THE DASH PANEL INSULATOR WOULD PROMOTE CORROSION. THIS CORROSION COULD ULTIMATELY LEAD TO A LEAK IN THE BRAKE LINE.
Consequence & remedy
Consequence: LEAKAGE OF BRAKE FLUID WILL RESULT IN BRAKE LIGHT ACTIVATION. EXTENDED STOPPING DISTANCE COULD ALSO RESULT, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE BRAKE LINE FOR CORROSION AND CLEARANCE CONDITIONS. A BRAKE LINE THAT IS NOT CORRODED WILL BE REPOSITIONED. A BRAKE LINE THAT IS CORRODED OR LEAKING WILL BE REPLACED WITH A NYLON COATED BRAKE LINE AND SECURED USING THREE RETAINING CLIPS TO ASSURE CLEARANCE FROM THE INSULATOR. OWNER NOTIFICATION BEGAN MAY 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 2, 1999
VEHICLE DESCRIPTION: MINIVANS WHICH WERE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING HOT WEATHER STATES: ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA (10 SOUTHERN COUNTIES), FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA (CLARK COUNTY ONLY), OKLAHOMA, SOUTH CAROLINA AND TEXAS, CAN DEVELOP CRACKS IN THE FUEL TANK IN THE FORWARD STRAP AREA OF THE STANDARD 20 GALLON TANK DUE TO A COMBINATION OF FACTORS THAT ARE PRESENT IN CERTAIN VERY HOT AREAS OF THE COUNTRY.
Consequence & remedy
Consequence: THESE CRACKS COULD RESULT IN FUEL LEAKAGE IF THEY PROPAGATE THROUGH THE WALL OF THE TANK.
Remedy: DEALERS WILL INSTALL A BRACE ASSEMBLY AT THE STRAP BOLT HOLE LOCATION AND REPLACE THE TANK STRAP WITH A REVISED, LONGER STRAP. DEALERS WILL ALSO INSPECT THE TANKS FOR LEAKS. IF A LEAK EXISTS AND IS THE RESULT OF A CRACK IN THE FUEL TANK, THE TANK WILL BE REPLACED IN ADDITION TO THE INSTALLATION OF A SPACER AND LONGER STRAP.
Oct 20, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI VANS. TEARING OF THE BOND BETWEEN THE INNER AND OUTER HOOD PANELS DURING MINOR FRONT END COLLISIONS CAN RESULT IN A GAP AT THE LEADING EDGE OF THE HOOD. AIR FORCED BETWEEN THE INNER AND OUTER PANELS CAN PRODUCE ENOUGH PRESSURE TO FORCE THE OUTER PANEL UPWARD.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN TOTAL SEPARATION OF THE OUTER HOOD PANEL.
Remedy: DEALERS WILL INSPECT THE HOOD AREA FOR ANY DAMAGE ALONG THE LEADING EDGE OF THE HOOD. IF THERE IS ANY EVIDENCE OF BOND SEPARATION, THE HOOD WILL BE REPLACED. IF THERE IS NO EVIDENCE OF BOND SEPARATION, ADDITIONAL ADHESIVE WILL BE APPLIED BETWEEN THE INNER AND OUTER HOOD PANELS.
Nov 4, 1994
THE WIRING HARNESS INSULATION CAN ABRADE ON A BRACE THAT RUNS FROM THE INSTRUMENT PANEL TO THE COWL.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN AN ELECTRICAL SHORT AND POSSIBLY A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A SHIELD ON THE INSTRUMENT PANEL TO COWL BRACE, AND INSTALLATION OF A PIECE OF CONVOLUTE WRAP MATERIAL ON ONE OF THE ADJACENT HARNESSES.
Nov 4, 1994
THE ALTERNATOR OUTPUT WIRE WAS NOT CONNECTED TIGHTLY TO THE POWER DISTRIBUTION BOX.
Consequence & remedy
Consequence: THIS CAN RESULT IN OVERHEATING OF THE CONNECTION AND A POSSIBLE VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT AND TIGHTEN THE CONNECTION. VEHICLES WITH VISIBLE DAMAGE TO THE PLASTIC POWER DISTRIBUTION BOX HOUSING WILL HAVE THE THE UNDERHOOD HARNESS, INCLUDING THE POWER DISTRIBUTION BOX, REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
14EA08021 · Engine Compartment Fires
Opened Sep 17, 2008 · Closed Oct 14, 2009
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Service Brakes, Hydraulic; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip; Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module ; Vehicle Speed Control; Vehicle Speed Control:cruise Control
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Additional source detail variants (7)
Electrical System
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Electrical System:wiring
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Service Brakes, Hydraulic
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Vehicle Speed Control:cruise Control
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
Vehicle Speed Control
EA08-021 IS CLOSED WITH FORD'S ACTIONS IN RECALL 09V-399 RECALLING APPROXIMATELY 4.5 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).WITH THIS RECALL FORD HAS NOW RECALLED ALL OF THE APPROXIMATE 16 MILLION FORD MODEL VEHICLES THAT WERE MANUFACTURED FROM MY 1992 THROUGH 2003 WITH A TEXAS INSTRUMENTS SCDS.NHTSA WILL CONTINUE TO MONITOR THE RECALLED VEHICLES TO ENSURE REMEDIES INSTALLED BY FORD TOMITIGATE THE POTENTIAL FOR SCDS RELATED FIRES ARE EFFECTIVE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR FURTHER DETAILS.
PE08035 · Engine Compartment Fires
Opened May 13, 2008 · Closed Sep 17, 2008
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring; Vehicle Speed Control
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Additional source detail variants (3)
Electrical System
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Electrical System:wiring
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Vehicle Speed Control
ODI HAS RECEIVED 134 CONSUMER COMPLAINTS, 285 MANUFACTURER COMPLAINTS, AND 137 MANUFACTURER WARRANTY CLAIMS ALLEGING INCIDENTS OF ENGINE COMPARTMENT FIRE IN MODEL YEAR (MY) 1995 THRU 2003 FORD WINDSTAR VEHICLES.TWO OF THE ODI COMPLAINTS ALLEGE THE FIRES CAUSED STRUCTURAL DAMAGE TO THE COMPLAINANT'S HOME.OF THE 134 ODI COMPLAINTS, 36 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS PARKED, 72 ALLEGE THE FIRE OCCURRED WHILE THE VEHICLE WAS RUNNING AND 26 OF THE COMPLAINTS DO NOT SPECIFY IF THE VEHICLE WAS RUNNING OR NOT.FURTHER REVIEW OF THE ODI COMPLAINTS SHOWS THAT 72 ALLEGE THAT THE SPEED CONTROL DEACTIVATION SWITCH (SCDS) CAUSED THE FIRE AND 10 ALLEGE THAT THE SCDS LEAKED BRAKE FLUID ON TO THE ABS MODULE RESULTING IN THE FIRE.THERE WERE 52 THAT DID NOT IDENTIFY A CAUSE OR THAT IDENTIFIED MISCELLANEOUS OTHER CAUSES.ODI HAS ALSO RECEIVED 89 COMPLAINTS ( NOT COUNTED IN THIS RESUME) ALLEGING THAT THE SCDS DEVELOPED A BRAKE FLUID LEAK.THIRTEEN OF THESE COMPLAINTS SAY THAT THE LEAK AT THE SCDS RESULTED IN BRAKED FLUID REACHING THE ABS MODULE.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FURTHER EVALUATE THE CAUSE OF THE FIRES AND ASSESS THE SCOPE, FREQUENCY, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
RQ04003 · Hydraulic Brake Line Failure
Opened May 27, 2004 · Closed Oct 7, 2004
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
ON APRIL 4, 2002, FORD MOTOR COMPANY NOTIFIED ODI OF A DEFECT CONDITION THAT COULD RESULT IN EXTENDED STOPPING DISTANCES IN APPROXIMATELY 250 THOUSAND MODEL YEAR (MY) 1995 AND 1996 WINDSTAR MINIVANS SOLD OR REGISTERED IN SALT BELT STATES (RECALL 02V-101).ACCORDING TO FORD, IMPROPER BRAKE LINE ROUTING IN VEHICLES MANUFACTURED AT THE OAKVILLE ASSEMBLY PLANT FROM JANUARY 14, 1994 THROUGH MAY 21, 1996 RESULTED IN SOME VEHICLES WITH MIS-POSITIONED BRAKE LINES THAT COULD CONTACT A DASH PANEL INSULATOR.SUCH CONTACT COULD ABRADE THE BRAKE LINE PROTECTION COATING AND RESULT IN CORROSIVE FAILURE OF THE BRAKE LINES. ODI OPENED RQ04-003 TO INVESTIGATE COMPLAINTS OF BRAKE LINE FAILURE IN WINDSTAR VEHICLES THAT WERE:(1) LOCATED OUTSIDE THE RECALL REGION; OR (2) BUILT AFTER THE RECALL RANGE.REGARDING THE LATTER GROUP, FORD CHANGED THE ASSEMBLY PROCESS AFTER MAY 21, 1996 TO ELIMINATE THE MIS-BUILD PROBLEM.THE FAILURE RATES IN THE MY 1996 WINDSTAR VEHICLES BUILT AFTER THE PROCESS CHANGE ARE RELATIVELY LOW IN BOTH THE SALT-BELT STATES. WITH RESPECT TO THE MY 1995 AND 1996 VEHICLES BUILT DURING THE PERIOD OF CONCERN THAT WERE NOT SOLD OR REGISTERED IN SALT BELT STATES, THE FAILURE RATE IS ALSO LOW.THE RELATED BRAKE LINE WARRANTY CLAIM RATE FOR THOSE VEHICLES IS ALSO LOW. ACCORDINGLY, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED IN THE MY 1995-96 WINDSTAR VEHICLES THAT WERE NOT INCLUDED IN RECALL 02V-101.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Service Brakes, Hydraulic:fluid
ON APRIL 4, 2002, FORD MOTOR COMPANY NOTIFIED ODI OF A DEFECT CONDITION THAT COULD RESULT IN EXTENDED STOPPING DISTANCES IN APPROXIMATELY 250 THOUSAND MODEL YEAR (MY) 1995 AND 1996 WINDSTAR MINIVANS SOLD OR REGISTERED IN SALT BELT STATES (RECALL 02V-101).ACCORDING TO FORD, IMPROPER BRAKE LINE ROUTING IN VEHICLES MANUFACTURED AT THE OAKVILLE ASSEMBLY PLANT FROM JANUARY 14, 1994 THROUGH MAY 21, 1996 RESULTED IN SOME VEHICLES WITH MIS-POSITIONED BRAKE LINES THAT COULD CONTACT A DASH PANEL INSULATOR.SUCH CONTACT COULD ABRADE THE BRAKE LINE PROTECTION COATING AND RESULT IN CORROSIVE FAILURE OF THE BRAKE LINES. ODI OPENED RQ04-003 TO INVESTIGATE COMPLAINTS OF BRAKE LINE FAILURE IN WINDSTAR VEHICLES THAT WERE:(1) LOCATED OUTSIDE THE RECALL REGION; OR (2) BUILT AFTER THE RECALL RANGE.REGARDING THE LATTER GROUP, FORD CHANGED THE ASSEMBLY PROCESS AFTER MAY 21, 1996 TO ELIMINATE THE MIS-BUILD PROBLEM.THE FAILURE RATES IN THE MY 1996 WINDSTAR VEHICLES BUILT AFTER THE PROCESS CHANGE ARE RELATIVELY LOW IN BOTH THE SALT-BELT STATES. WITH RESPECT TO THE MY 1995 AND 1996 VEHICLES BUILT DURING THE PERIOD OF CONCERN THAT WERE NOT SOLD OR REGISTERED IN SALT BELT STATES, THE FAILURE RATE IS ALSO LOW.THE RELATED BRAKE LINE WARRANTY CLAIM RATE FOR THOSE VEHICLES IS ALSO LOW. ACCORDINGLY, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED IN THE MY 1995-96 WINDSTAR VEHICLES THAT WERE NOT INCLUDED IN RECALL 02V-101.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic
ON APRIL 4, 2002, FORD MOTOR COMPANY NOTIFIED ODI OF A DEFECT CONDITION THAT COULD RESULT IN EXTENDED STOPPING DISTANCES IN APPROXIMATELY 250 THOUSAND MODEL YEAR (MY) 1995 AND 1996 WINDSTAR MINIVANS SOLD OR REGISTERED IN SALT BELT STATES (RECALL 02V-101).ACCORDING TO FORD, IMPROPER BRAKE LINE ROUTING IN VEHICLES MANUFACTURED AT THE OAKVILLE ASSEMBLY PLANT FROM JANUARY 14, 1994 THROUGH MAY 21, 1996 RESULTED IN SOME VEHICLES WITH MIS-POSITIONED BRAKE LINES THAT COULD CONTACT A DASH PANEL INSULATOR.SUCH CONTACT COULD ABRADE THE BRAKE LINE PROTECTION COATING AND RESULT IN CORROSIVE FAILURE OF THE BRAKE LINES. ODI OPENED RQ04-003 TO INVESTIGATE COMPLAINTS OF BRAKE LINE FAILURE IN WINDSTAR VEHICLES THAT WERE:(1) LOCATED OUTSIDE THE RECALL REGION; OR (2) BUILT AFTER THE RECALL RANGE.REGARDING THE LATTER GROUP, FORD CHANGED THE ASSEMBLY PROCESS AFTER MAY 21, 1996 TO ELIMINATE THE MIS-BUILD PROBLEM.THE FAILURE RATES IN THE MY 1996 WINDSTAR VEHICLES BUILT AFTER THE PROCESS CHANGE ARE RELATIVELY LOW IN BOTH THE SALT-BELT STATES. WITH RESPECT TO THE MY 1995 AND 1996 VEHICLES BUILT DURING THE PERIOD OF CONCERN THAT WERE NOT SOLD OR REGISTERED IN SALT BELT STATES, THE FAILURE RATE IS ALSO LOW.THE RELATED BRAKE LINE WARRANTY CLAIM RATE FOR THOSE VEHICLES IS ALSO LOW. ACCORDINGLY, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED IN THE MY 1995-96 WINDSTAR VEHICLES THAT WERE NOT INCLUDED IN RECALL 02V-101.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
ON APRIL 4, 2002, FORD MOTOR COMPANY NOTIFIED ODI OF A DEFECT CONDITION THAT COULD RESULT IN EXTENDED STOPPING DISTANCES IN APPROXIMATELY 250 THOUSAND MODEL YEAR (MY) 1995 AND 1996 WINDSTAR MINIVANS SOLD OR REGISTERED IN SALT BELT STATES (RECALL 02V-101).ACCORDING TO FORD, IMPROPER BRAKE LINE ROUTING IN VEHICLES MANUFACTURED AT THE OAKVILLE ASSEMBLY PLANT FROM JANUARY 14, 1994 THROUGH MAY 21, 1996 RESULTED IN SOME VEHICLES WITH MIS-POSITIONED BRAKE LINES THAT COULD CONTACT A DASH PANEL INSULATOR.SUCH CONTACT COULD ABRADE THE BRAKE LINE PROTECTION COATING AND RESULT IN CORROSIVE FAILURE OF THE BRAKE LINES. ODI OPENED RQ04-003 TO INVESTIGATE COMPLAINTS OF BRAKE LINE FAILURE IN WINDSTAR VEHICLES THAT WERE:(1) LOCATED OUTSIDE THE RECALL REGION; OR (2) BUILT AFTER THE RECALL RANGE.REGARDING THE LATTER GROUP, FORD CHANGED THE ASSEMBLY PROCESS AFTER MAY 21, 1996 TO ELIMINATE THE MIS-BUILD PROBLEM.THE FAILURE RATES IN THE MY 1996 WINDSTAR VEHICLES BUILT AFTER THE PROCESS CHANGE ARE RELATIVELY LOW IN BOTH THE SALT-BELT STATES. WITH RESPECT TO THE MY 1995 AND 1996 VEHICLES BUILT DURING THE PERIOD OF CONCERN THAT WERE NOT SOLD OR REGISTERED IN SALT BELT STATES, THE FAILURE RATE IS ALSO LOW.THE RELATED BRAKE LINE WARRANTY CLAIM RATE FOR THOSE VEHICLES IS ALSO LOW. ACCORDINGLY, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED IN THE MY 1995-96 WINDSTAR VEHICLES THAT WERE NOT INCLUDED IN RECALL 02V-101.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
RQ02011 · Fuel Tank Fatigue Cracking
Opened Aug 29, 2002 · Closed Mar 14, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
SEE ATTACHED REPORT.
EA00027 · Suspension Coil Spring Breakage
Opened Dec 8, 2000 · Closed Jul 31, 2001
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
Additional source detail variants (2)
Suspension
There is no summary currently available
Suspension
There is no summary currently available
PE00024 · Suspension Coil Spring Breakage
Opened Jun 23, 2000 · Closed Dec 8, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA99020 · Fuel Tank Cracks
Opened Jul 26, 1999 · Closed Dec 16, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline
There is no summary currently available
PE99025 · Fuel Tank Cracks
Opened Apr 15, 1999 · Closed Jul 26, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline
There is no summary currently available
PE98056 · Rear Axle Trailing Arm
Opened Oct 28, 1998 · Closed Feb 24, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
DP98004 · Automatic Transmission Failure
Opened May 18, 1998 · Closed Jul 2, 1998
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
EA97018 · Outer Hood Panel Detachment
Opened Sep 30, 1997 · Closed Oct 22, 1997
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE97011 · Outer Hood Panel Detachment
Opened Mar 13, 1997 · Closed Sep 30, 1997
Status: closed (inferred from source dates) · Structure
THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED 6 REPORTS INDICATING THE OUTER HOOD PANEL SEPARATED FROM THE VEHICLES AS THEY WERE BEING DRIVEN.FORD HAS PROVIDE 39 ADDITIONAL REPORTS THAT ARE CONSISTENT WITH ODI REPORTS.FORD INDICATES THAT THE LIKELY CAUSE IS PRIOR COLLISION DAMAGE.THIS INVESTIGATION IS BEING UPGRADED TO FURTHER STUDY THIS ISSUE.
EA96026 · Brake Pedal Fade/extended Stop Distance
Opened Oct 31, 1996 · Closed Feb 18, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE96042 · Brake Pedal Fade/extended Stopping
Opened Jun 13, 1996 · Closed Oct 31, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
ODI HAS RECEIVED SIXTY-EIGHT (68) CONSUMER REPORTS OF ALLEGED FAILURES OR MALFUNCTIONS IN THE BRAKE SYSTEM ON CERTAIN 1995 AND 1996 FORD WINDSTARS, WHICH RESULTED IN BRAKE PEDAL FADE AND IN EXTENDED STOPPING DISTANCES DURING BRAKINGTHESE ALLEGED FAILURES OR MALFUNCTIONS ARE REPORTED TO HAVE CAUSED TWELVE (12) ACCIDENTS THAT RESULTED FROM VEHICLE LOSS OF BRAKING.THE CONPLAINANTS REPORT THAT THE LOSS OF BRAKING OCCURRED DURINGBRAKING SITUATIONS ON DRY ROADS AS WELL AS ON WET OR SLIPPERY ROADS.IN RESPONSE TO ODI'S INFORMATION REQUES (IR) CONCERNING THE LONG STOPPING DISTANCE COMPLAINTS ON THE 1995 WINDSTAR, FORD REPORTED RECEIVING 259 REPORT (FIELD REPORTS, OWNER COMPLAINTS, AND SUBROGATION CLAIMS) OF LONG STOPPING DISTANCE ON THE 1995 FORD WINDSTAR, ALONG WITH 64 REPORTS OF ACCIDENTS.IN ADDITION, FORD REPORTED RECEIVING SOME 64,000 WARRANTY CLAIMS THAT COULD RELATE TO THE ALLEGED DEFECT OF LONG STOPPING DISTANCE PERFORMANCE ON THE SUBJECT VEHICLES.SINCE APRELIMINARY EVALUATION WAS OPENED, ODI HAS RECEIVED ADDITIONAL COMPLAINTS OF THE ALLEGED FAILURE ON THE 1996 MODELS, WHICH WERE NOT INCLUDED INITIALLY IN THIS INVESTIGATION.ODI BELIEVES THAT AN ENGINEERING ANALYSIS ON THE 1995 AND 1996 FORD WINDSTAR VEHICES IN WARRANTED TO DETERMINE THE SCOPE OF THE PROBLEM.
Illustration