Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 11 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports0 injury reports
What owners actually said
11 reports
23,000 miles · Feb 10, 2007
Engine And Engine Cooling
WHEN THE WEATHER IS WARM, THE VAN WILL DIE AND NOT START AGAIN UNTIL THE ENGINE HAS COOLED DOWN. YOU ARE STUCK ALONG SIDE THE ROAD UNTIL THEN. THE FIRST TIME THIS HAPPENED I CALLED FOR A TOW AND WAS TOLD THAT THE VAN WAS VAPOR LOCKED. WAS TOWED 35 MILES TO A GARAGE TO HAVE IT FIXED. AFTER LOOKING AT THE VAN THIS IS WHEN WAS TOLD…
Read full complaint
WHEN THE WEATHER IS WARM, THE VAN WILL DIE AND NOT START AGAIN UNTIL THE ENGINE HAS COOLED DOWN. YOU ARE STUCK ALONG SIDE THE ROAD UNTIL THEN. THE FIRST TIME THIS HAPPENED I CALLED FOR A TOW AND WAS TOLD THAT THE VAN WAS VAPOR LOCKED. WAS TOWED 35 MILES TO A GARAGE TO HAVE IT FIXED. AFTER LOOKING AT THE VAN THIS IS WHEN WAS TOLD IT WAS VAPOR LOCKED. *JB
NHTSA ODI #10182203
Mileage unknown · Jan 31, 2005
Wheels
WHILE DRIVING AND COMING TO A COMPLETE STOP ALL FIVE WHEEL STUDS/BOLTS BROKE, AND THE WHEEL DISENGAGED. *AK
NHTSA ODI #10109234
Mileage unknown · May 12, 2001
Engine And Engine CoolingPower Train
TRANSMISSION REBUILT BECAUSE ELECTRONICS FAILED, REPLACED FRONT BANDS, TORQUE CONVERTER AND FRONT SPRAG. IT WAS DISCOVERED THAT WHEN WE HAD THE ENGINE REPLACED AT 50400 MILES THAT THERE HAD BEEN A LEAK THEN AND IT WAS SEALED WITH SILICONE. ENGINE REPLACE
NHTSA ODI #745254
Mileage unknown · Feb 26, 2001
Electrical SystemFire
EARLIER SAME DAY VEHICLE OVERHEATED, IT WAS IMMED. TURNED OFF AND TOWED IN. VEHICLE WAS PARKED AND ENGINE WAS OFF AND KEY REMOVED. IT LATER CAUGHT FIRE. THE PROPER AUTHORITIES WERE CALLED TO EXTINGUISH THE FIRE AND INVESTIGATE THE SCENE. THE "HOT SPOT" OF THE FIRE WAS DETERMINED TO BE AT THE STARTER RELAY. THE VEHICLE IS A T…
Read full complaint
EARLIER SAME DAY VEHICLE OVERHEATED, IT WAS IMMED. TURNED OFF AND TOWED IN. VEHICLE WAS PARKED AND ENGINE WAS OFF AND KEY REMOVED. IT LATER CAUGHT FIRE. THE PROPER AUTHORITIES WERE CALLED TO EXTINGUISH THE FIRE AND INVESTIGATE THE SCENE. THE "HOT SPOT" OF THE FIRE WAS DETERMINED TO BE AT THE STARTER RELAY. THE VEHICLE IS A TOTAL LOSS.THE TIME OF DAY OF THE FIRE WAS APPROX. 4:30 PM. NO ONE WAS NEAR THE VEHICLE AT THE TIME.
NHTSA ODI #741584
Mileage unknown · Jun 12, 1999
Electrical System
POSSIBLE ELECTRICAL PROBLEM CAUSING COURTESY LIGHTS, READING LIGHTS, RADIO AND TELEVISION FAILURE. NLM
NHTSA ODI #546557
Mileage unknown · Feb 2, 1999
Fuel System, Gasoline
THE CONSUMER HAS BEEN EXPERIENCING PROBLEMS WITH AUTOMATIC FUEL PUMP. FUEL PUMP SQUIRTS GAS OUT OF THE FUEL TANK. IN ADDITION, THE CONSUMER SMELLED STRONG FUMES. MANUFACTURER HAS BEEN CONTACTED.
NHTSA ODI #834402
Mileage unknown · Dec 8, 1998
Fuel System, Gasoline
WHILE FILLING MY FUEL TANK, GAS WAS SEEN RUNNING ON THE GROUND FROM UNDER THE CAR. AFTER AN INSPECTION, IT WAS DETERMINED THAT THE FUEL FILLER AND AIR RETURN RUBBER HOSES WERE CRACKED AND CRUMBLING. THIS SHOULD NOT HAPPEN ON A 4 YEAR OLD VEHICLE. THESE PARTS ARE DEFECTIVE ON MY CAR AND PROBABLY MANY OTHER SIMILAR CARS. THIS …
Read full complaint
WHILE FILLING MY FUEL TANK, GAS WAS SEEN RUNNING ON THE GROUND FROM UNDER THE CAR. AFTER AN INSPECTION, IT WAS DETERMINED THAT THE FUEL FILLER AND AIR RETURN RUBBER HOSES WERE CRACKED AND CRUMBLING. THIS SHOULD NOT HAPPEN ON A 4 YEAR OLD VEHICLE. THESE PARTS ARE DEFECTIVE ON MY CAR AND PROBABLY MANY OTHER SIMILAR CARS. THIS IS A SERIOUS FIRE AND POLLUTION HAZARD. IN THE EVENT OF AN ACCIDENT, THE HOSES WILL CRACK OPEN COMPLETLY AND FUEL WILL SPILL OUT. THE CRACKED LOSES CAUSE FUEL VAPORS TO BE RELEASED INTO THE AIR. THE DEALER WANTS TO CHARGE ME FOR THE REPAIR BECAUSE IT IS BEYOND THE WARRANTY. REPORTED IT TO FORD CUSTOMER SERVICE AT 800-392-3673, BUT THEY WERE NOT HELPFUL. I THINK THAT ALL FORD MODELS THAT USED THESE PARTS SHOULD BE RECALLED, INSPECTED AND REPAIRED AT FORDS EXPENSE. *MJS
NHTSA ODI #701196
Mileage unknown · Jan 24, 1998
Unknown Or Other
REQUEST INFORMATION CONCERNINT U-HAUL RENTAL VANS AND TRUCKS.
NHTSA ODI #529745
Mileage unknown · Jan 24, 1998
Unknown Or Other
REQUEST INFORMATION CONCERNINT U-HAUL RENTAL VANS AND TRUCKS.
NHTSA ODI #529744
Mileage unknown · Aug 29, 1997
Suspension
CAMBER BUSHING WEARS OUT, CAUSING INPROPER ALIGNMENT AND EXCESSIVE WEAR ON THE TIRES. *AK
NHTSA ODI #815857
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1994 Ford Van Problems, Complaints & Recalls | Skip That Year
Illustration