NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
5 reportsClear category filter45,000 miles · Feb 24, 2026
EngineStructure
The contact owns a 2023 Ford Transit. The contact stated that while driving approximately 25 - 60 MPH, the check engine warning light illuminated, and the vehicle started to decelerate. During the most recent failure, the contact was able to drive to the dealer before the vehicle lost power. The vehicle was diagnosed, and the co…
Read full complaint
The contact owns a 2023 Ford Transit. The contact stated that while driving approximately 25 - 60 MPH, the check engine warning light illuminated, and the vehicle started to decelerate. During the most recent failure, the contact was able to drive to the dealer before the vehicle lost power. The vehicle was diagnosed, and the contact was informed that water was leaking into the engine, causing a shortage with the spark plugs and other electrical systems. The #4 spark plug was replaced. The contact researched and became aware of an issue with the cowl allowing water and debris to enter the engine and causing the #4 spark plug to be short-circuited. The manufacturer was made aware of the failure and opened a case. The failure mileage was approximately 45,000.
NHTSA ODI #11720126
Mileage unknown · Apr 1, 2025
Electrical SystemEngine
Vehicle shuts off completely off while driving intermittently. This issue has happened several times starting at 15000 miles. Vehicle has been back to dealership more than once regarding this issue. No codes are detected during diagnostics. UNSAFE
NHTSA ODI #11652187
Mileage unknown · Sep 6, 2024
EnginePower Train
Power train malfunction and loss of power in vehicle may cause accident due to sudden loss of speed. Vehicle makes noises and kicks when accelerating. Turbo doesn’t work properly and hesitates when engaging. The wrench light comes and goes off when turning the car back on. Vehicle often looses power while driving either due to t…
Read full complaint
Power train malfunction and loss of power in vehicle may cause accident due to sudden loss of speed. Vehicle makes noises and kicks when accelerating. Turbo doesn’t work properly and hesitates when engaging. The wrench light comes and goes off when turning the car back on. Vehicle often looses power while driving either due to the turbo or the power train. May cause accidents, we have had to pull over because of the power loss and for the pulling/kicking of the car.
NHTSA ODI #11613095
Mileage unknown · Jul 6, 2024
EnginePower TrainSteering
Vehicle struggles and kicks to catch speed. At times in freeway/ street it will “jerk”/ hesitate to speed up. We have had to pull over in the middle of the freeway because it was not catching speed. No warning lights have turned on in the vehicle. It is dangerous to drive and vehicle looses speed or hesitates to pick up on speed…
Read full complaint
Vehicle struggles and kicks to catch speed. At times in freeway/ street it will “jerk”/ hesitate to speed up. We have had to pull over in the middle of the freeway because it was not catching speed. No warning lights have turned on in the vehicle. It is dangerous to drive and vehicle looses speed or hesitates to pick up on speed, could cause an accident. Please help get vehicle fully checked, vehicle was made during Covid and chip shortage, I believe they rushed this vans out and did not make them properly. Other vehicles have had recalls for the problems I am experiencing with this vehicle, but mine has not been recalled. I strongly believe my vehicle is part of those recalls. Attached are the recalls made to similar vehicles, I believe mine should be included in this recalls.
NHTSA ODI #11599586
Mileage unknown · Jul 6, 2024
EngineFuel/propulsion System
A very strong gas smell was detected on the vehicle cabin. It lingers for a long time when it seems to be going away, it comes back strong again. This began July 2nd 2024. I have not taken my vehicle to get checked out because I cannot afford it, but i did ask around and everyone including some that know about cars said the car …
Read full complaint
A very strong gas smell was detected on the vehicle cabin. It lingers for a long time when it seems to be going away, it comes back strong again. This began July 2nd 2024. I have not taken my vehicle to get checked out because I cannot afford it, but i did ask around and everyone including some that know about cars said the car is too new and it is not normal, it is bad for our health since we are inhaling those nasty fumes everyday. This vehicle has never been hit or has had any type of damage to it in any way. It has been driven 85k miles and it is still in perfect condition. Honestly since I purchased this vehicle it has been nothing but problems. This is not the only issue this vehicle came with since day 1. I reached out to dealer at first but had no luck. Please help with this vehicle, I really believe this vehicle was not made correctly in so many ways.
NHTSA ODI #11599583
Official recalls
18Feb 3, 2026
Ford Motor Company (Ford) is recalling certain 2023-2024 Transit vehicles. The engine crossmember may not be secured properly, which can cause the engine to shift and possibly result in a loss of drive power or brake failure.
Consequence & remedy
Consequence: A loss of drive power or brake failure increases the risk of a crash.
Remedy: Dealers will replace the cross member fasteners, free of charge. Owner notification letters were mailed May 22, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S04. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 4, 2026.
Dec 17, 2025
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
Sep 18, 2025
Ford Motor Company (Ford) is recalling certain 2023-2024 Transit vehicles repaired incorrectly under recall numbers 24V226 and 24V591. An incorrect steering coupler cover and tires that were not designed for the vehicle may have been installed during a previous repair.
Consequence & remedy
Consequence: Incorrect tires and an incorrect steering coupler cover can cause a loss of brake function, loss of steering control, or damage to tires, increasing the risk of a crash.
Remedy: Dealers will inspect and if necessary, replace the tires, tire placard, and certification label, and also recalibrate the vehicle. Additionally, dealers will remove the steering coupler cover. Repairs will be performed free of charge. Owner notification letters were mailed April 10, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S95. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 24, 2025.
Additional source detail variants (2)
Steering
Ford Motor Company (Ford) is recalling certain 2023-2024 Transit vehicles repaired incorrectly under recall numbers 24V226 and 24V591. An incorrect steering coupler cover and tires that were not designed for the vehicle may have been installed during a previous repair.
Consequence: Incorrect tires and an incorrect steering coupler cover can cause a loss of brake function, loss of steering control, or damage to tires, increasing the risk of a crash.
Remedy: Dealers will inspect and if necessary, replace the tires, tire placard, and certification label, and also recalibrate the vehicle. Additionally, dealers will remove the steering coupler cover. Repairs will be performed free of charge. Owner notification letters were mailed April 10, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S95. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 24, 2025.
Tires
Ford Motor Company (Ford) is recalling certain 2023-2024 Transit vehicles repaired incorrectly under recall numbers 24V226 and 24V591. An incorrect steering coupler cover and tires that were not designed for the vehicle may have been installed during a previous repair.
Consequence: Incorrect tires and an incorrect steering coupler cover can cause a loss of brake function, loss of steering control, or damage to tires, increasing the risk of a crash.
Remedy: Dealers will inspect and if necessary, replace the tires, tire placard, and certification label, and also recalibrate the vehicle. Additionally, dealers will remove the steering coupler cover. Repairs will be performed free of charge. Owner notification letters were mailed April 10, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S95. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 24, 2025.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
May 23, 2025
Ford Motor Company (Ford) is recalling certain 2022-2023 Transit vehicles previously repaired incorrectly under recall number 22V415. The Instrument Panel Cluster may not properly illuminate warning lights or gauges. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
Consequence & remedy
Consequence: An instrument panel that does not illuminate critical safety information, such as the speedometer or warning lights, can increase the risk of a crash.
Remedy: Dealers will update the instrument panel cluster software, free of charge. Owner notification letters were mailed June 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C19.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.
Consequence & remedy
Consequence: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.
Apr 11, 2025
Ford Motor Company (Ford) is recalling certain 2022-2023 Transit vehicles previously repaired incorrectly under recall number 23V-598. The rearview camera, or 360-degree view camera if equipped, may not display a rearview image when the vehicle is placed in reverse.
Consequence & remedy
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed May 23, 2025. Ford's number for this recall is 25S38.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2022-2023 Transit vehicles previously repaired incorrectly under recall number 22V-791. The heating, ventilation, and air-conditioning (HVAC) system's controls, including those for defog and defrost, may become inoperative.
Consequence & remedy
Consequence: Loss of the ability to control the defrost or defog function decreases the driver's visibility under certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will update the remote climate control module software, free of charge. Owner notification letters were mailed April 21, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S23.
Oct 25, 2024
Ford Motor Company (Ford) is recalling certain 2023-2024 Ford Transit vehicles previously repaired under recall number 24V-102. Incorrect bolts may have been used to attach the rear axle shaft, which can lead to the rear wheel locking up or separating from the axle.
Consequence & remedy
Consequence: Rear wheel lock-up or separation of the wheel from the axle shaft can result in loss of vehicle control or loss of drive power. In addition, the vehicle may roll in park if the parking brake is not applied. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect the rear axle shaft bolts, replace incorrect bolts as necessary, and fill the differential fluid if needed, free of charge. Owner notification letters were mailed December 13, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S67.
Aug 9, 2024
Ford Motor Company (Ford) is recalling certain 2023-2024 Transit vehicles. The steering column intermediate shaft may have been secured to the steering gear pinion shaft with an incorrect bolt, which can result in the separation of steering components and cause a loss of steering control.
Consequence & remedy
Consequence: A loss of steering control can increase the risk of a crash.
Remedy: Dealers will replace the steering column intermediate shaft bolt, free of charge. Owner notification letters were mailed on February 14, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S48.
Jul 19, 2024
Ford Motor Company (Ford) is recalling certain 2023-2024 Transit vehicles equipped with a Transit Trail package. The electronic power assist steering (EPAS) ground eyelet joint may experience corrosion, which can result in a loss of power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist can increase the risk of a crash.
Remedy: Dealers will install a new EPAS ground pigtail kit, free of charge. Owner notification letters were mailed on January 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S46.
Mar 22, 2024
Ford Motor Company (Ford) is recalling certain 2023-2024 Transit vehicles equipped with the Transit Trail package. The tires may contact the front wheel arch liner and body flange, causing damage to the tires.
Consequence & remedy
Consequence: Damaged tires may experience a sudden loss of air pressure or tread separation, causing a loss of vehicle control and increasing the risk of a crash.
Remedy: Dealers will replace the tires, tire placard, and certification label, and also recalibrate the vehicle, free of charge. Owner notification letters were mailed on March 26, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S21.
Feb 9, 2024
Ford Motor Company (Ford) is recalling certain 2023-2024 Ford Transit vehicles. An inadequate amount of rear axle lubricant may cause rear axle tail bearing damage and seizure, which can result in wheel lock-up or driveshaft separation.
Consequence & remedy
Consequence: Wheel lock-up or driveshaft separation can result in a loss of drive power. A disconnected driveshaft can also result in a roll away when the vehicle is in park without the parking brake applied. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect the rear axle, and replace the axle bearings or axle assembly as necessary, free of charge. Owner notification letters were mailed March 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S05.
Aug 25, 2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator, 2018-2021 Lincoln Navigator, 2022-2023 Ford Transit, and 2021 Ford Bronco vehicles. The rearview camera, or 360-degree view camera if equipped, may not display a rearview image when the vehicle is placed in reverse.
Consequence & remedy
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, and update the software and wiring as necessary, free of charge. Owner notification letters were mailed November 20, 2023 to Lincoln owners. Ford vehicle owners notification letters were mailed March 4, 2024. Ford remedy parts are anticipated 2nd Quarter 2024. Ford's number for this recall is 23S48.
Jul 19, 2023
Quality Vans (Quality Vans) is recalling certain 2020-2023 Ford Transit vans equipped with Onan QG 2800i EVAP generators, part number 2.8HGLAA-8303A. The fuel hose between the inline fuel filter and the Injection Pump Module (IPM) may not be properly secured, which can cause a gas leak.
Consequence & remedy
Consequence: A gasoline leak in the presence of an ignition source may increase the risk of fire.
Remedy: Dealers will inspect and replace the fuel hose and clamps as necessary, free of charge. Owner notification letters were mailed August 4, 2023. Owners may contact Quality Vans customer service at 1-480-464-7007.
Feb 24, 2023
Ford Motor Company (Ford) is recalling certain 2023 Transit vehicles equipped with the Special Vehicle Operations Accessory Service Kit #1 or #2 with a High Specification Vehicle Interface Connector. When the accessory kit is installed, the auxiliary wire harness will disable the heating, air-conditioning, and ventilation (HVAC) including the defrost and defog systems. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."
Consequence & remedy
Consequence: An inoperative windshield defrosting and defogging system may decrease the driver's visibility under certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will repair the auxiliary wire harness by modifying the wire harness to include the necessary twisted loop, free of charge. Owner notification letters were mailed April 20, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C02.
Feb 10, 2023
Ford Motor Company (Ford) is recalling certain 2023 Transit vehicles. The fuel tank grade vent valve may not be properly welded to the fuel tank shell, which can result in a fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the fuel tank, free of charge. Owner notification letters were mailed March 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S04.
Oct 20, 2022
Ford Motor Company (Ford) is recalling certain 2022-2023 Transit vehicles. The heating, ventilation, and air-conditioning (HVAC) system's controls, including those for defog and defrost, may become inoperative.
Consequence & remedy
Consequence: Loss of the ability to control the defrost or defog function decreases the driver's visibility under certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will update the remote climate control module software, free of charge. Owner notification letters were mailed on November 11, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S65.
Additional source detail variants (2)
Electrical System: Instrument Cluster/panel
Ford Motor Company (Ford) is recalling certain 2022-2023 Transit vehicles. The heating, ventilation, and air-conditioning (HVAC) system's controls, including those for defog and defrost, may become inoperative.
Consequence: Loss of the ability to control the defrost or defog function decreases the driver's visibility under certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will update the remote climate control module software, free of charge. Owner notification letters were mailed on November 11, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S65.
Visibility:defroster/defogger/hvac System
Ford Motor Company (Ford) is recalling certain 2022-2023 Transit vehicles. The heating, ventilation, and air-conditioning (HVAC) system's controls, including those for defog and defrost, may become inoperative.
Consequence: Loss of the ability to control the defrost or defog function decreases the driver's visibility under certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will update the remote climate control module software, free of charge. Owner notification letters were mailed on November 11, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S65.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration