NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
13 reportsClear category filterMileage unknown · Aug 18, 2026
Electrical SystemUnknown Or OtherVisibility/wiper
The rearview/360-degree camera system on my 2023 Ford Transit 350 continues to fail, resulting in the rearview camera image and/or other camera views becoming unavailable. The vehicle is available for inspection upon request. This is a large passenger van with significant blind areas, and the loss of the rearview camera creates…
Read full complaint
The rearview/360-degree camera system on my 2023 Ford Transit 350 continues to fail, resulting in the rearview camera image and/or other camera views becoming unavailable. The vehicle is available for inspection upon request. This is a large passenger van with significant blind areas, and the loss of the rearview camera creates a serious safety concern when backing, parking, or maneuvering around pedestrians, children, vehicles, or other objects. When the system fails, I can place the vehicle in reverse and not have the rear camera image that I depend on to see the area immediately behind the vehicle. This is NOT the first occurrence. The vehicle has been taken to an authorized Ford dealer on three separate occasions related to the camera system. Multiple cameras have been replaced. The vehicle has also been subject to Ford safety recall repairs involving the rearview/360-degree camera system. Most importantly, the applicable recall repair was recently completed by an authorized Ford dealer, and the camera system is STILL failing after completion of the recall remedy. The same safety condition that resulted in the recall continues to occur. Ford and its authorized dealer have therefore had multiple opportunities to inspect and repair this vehicle, including replacement of camera components and completion of the safety recall, but the defect has not been permanently corrected. The failure can occur without adequate warning and results in the rearview/360-degree camera image becoming unavailable or otherwise malfunctioning. The problem has occurred repeatedly rather than as an isolated incident. I am filing this complaint because I am concerned that the recall remedy has not successfully corrected the safety defect on this vehicle. I am requesting that NHTSA document and investigate the continued failure of the rearview/360-degree camera system after Ford's recall remedy was performed, including whether the current recall remedy is adequate for affected Ford Tra
NHTSA ODI #11757625
Mileage unknown · Jun 24, 2026
Electrical System
This is a Ford Palladium Van, year 2024, the secondary alternator charging circuit that Thor has installed has a lot of problems. Specifically, the alternator from Balmar fails and you cannot charge lithium batteries while the van is in motion. The whole point of the secondary alternator is to charge these batteries while in m…
Read full complaint
This is a Ford Palladium Van, year 2024, the secondary alternator charging circuit that Thor has installed has a lot of problems. Specifically, the alternator from Balmar fails and you cannot charge lithium batteries while the van is in motion. The whole point of the secondary alternator is to charge these batteries while in motion. Its a safety issue when traveling with children or pets because battery voltage drops if you have to run AC while in a store or something. You proceed down the road and the battery is not recharged. Next stop you may not be able to run AC at all.
NHTSA ODI #11746224
23,459 miles · Apr 6, 2026
Back Over PreventionElectrical SystemPower Train
The contact owns a 2023 Ford Transit. The contact stated that while in drive, the transmission slammed into fourth gear. The hill assist feature was activated during the failure. The contact believed that the failure was caused by an inoperable back over prevention camera. The local dealer was contacted. The vehicle was not diag…
Read full complaint
The contact owns a 2023 Ford Transit. The contact stated that while in drive, the transmission slammed into fourth gear. The hill assist feature was activated during the failure. The contact believed that the failure was caused by an inoperable back over prevention camera. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and offered a buyback, but no assistance was provided. The failure mileage was approximately 23,459.
NHTSA ODI #11729343
Mileage unknown · Nov 14, 2025
Electrical SystemUnknown Or OtherVisibility/wiper
My cargo van has no rearward windows. It has front/rear/left/right exterior cameras which generate a simulated, 360-degree, overhead view on a monitor. The right camera functions about half of the time. Once it generated an all-orange view. Now it often generates an all-blue view. I know other Ford vehicles are subject to a…
Read full complaint
My cargo van has no rearward windows. It has front/rear/left/right exterior cameras which generate a simulated, 360-degree, overhead view on a monitor. The right camera functions about half of the time. Once it generated an all-orange view. Now it often generates an all-blue view. I know other Ford vehicles are subject to a recall for this software issue and Ford has (or is generating) a fix for the problem. The 2023 Transit is not part of that recall group, but it should be.
NHTSA ODI #11699408
Mileage unknown · Sep 9, 2025
Electrical System
This will be our second Balmar alternator that failed. The original alternator was replaced in March 2025 after the alternator basically melted. In April the new alternator was no longer charging the battery. It was finally serviced in July 2025. The dealership replaced a sensor and the recall to reduce the alternator output…
Read full complaint
This will be our second Balmar alternator that failed. The original alternator was replaced in March 2025 after the alternator basically melted. In April the new alternator was no longer charging the battery. It was finally serviced in July 2025. The dealership replaced a sensor and the recall to reduce the alternator output was performed. The recall was supposed to prevent the alternator from failing,however, two days later the alternator was no longer working. August 2025, the dealership has been discussing the issue with Winnebago and Balmar. September 2025 it was confirmed that the alternator needs to be replaced. This is a huge safety issue since the alternator will create a fire under the hood which was the case in our first incidence. This is also a continuos problem with the Winnebago Ekko’s and a solution should not be to keep replacing the alternator with the same exact make and model.
NHTSA ODI #11686053
75,000 miles · Aug 25, 2025
Electrical SystemPower Train
The contact owns a 2023 Ford Transit. The contact stated that while driving at various speeds, the vehicle failed to accelerate properly while depressing the accelerator pedal. The contact stated that the vehicle eventually accelerated after repeatedly depressing the accelerator pedal. There was no warning light illuminated duri…
Read full complaint
The contact owns a 2023 Ford Transit. The contact stated that while driving at various speeds, the vehicle failed to accelerate properly while depressing the accelerator pedal. The contact stated that the vehicle eventually accelerated after repeatedly depressing the accelerator pedal. There was no warning light illuminated during the failure. The vehicle was taken to a dealer, where a diagnostic test was performed; however, no cause for the failure was found. The contact was informed by the mechanic that the failure was likely related to the computer system. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 75,000.
NHTSA ODI #11682813
125,055 miles · Jun 6, 2025
Electrical System
Odometer Fraud. The contact purchased a 2023 Ford Transit. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 20,813 and at the time of registration, it was discovered that the mi…
Read full complaint
Odometer Fraud. The contact purchased a 2023 Ford Transit. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 20,813 and at the time of registration, it was discovered that the mileage was 125,055.
NHTSA ODI #11665368
Mileage unknown · Apr 1, 2025
Electrical SystemEngine
Vehicle shuts off completely off while driving intermittently. This issue has happened several times starting at 15000 miles. Vehicle has been back to dealership more than once regarding this issue. No codes are detected during diagnostics. UNSAFE
NHTSA ODI #11652187
Mileage unknown · Mar 19, 2025
Electrical System
After the recalll to fix the Balmer alternator and changing system. The Balmer alternator has failed. 21k miles. Recall repairs/fix did not resolve the issue.
NHTSA ODI #11649166
Mileage unknown · May 30, 2024
Electrical System
The alternator and regulator failed. Parts are available for inspection. Safety was at risk as vehicle could stop or loose nighttime electrical lighting at highway speeds without any prior warning due to sudden loss of electric power. Selling dealer has inspected and confirmed failure of above parts. Components have not been …
Read full complaint
The alternator and regulator failed. Parts are available for inspection. Safety was at risk as vehicle could stop or loose nighttime electrical lighting at highway speeds without any prior warning due to sudden loss of electric power. Selling dealer has inspected and confirmed failure of above parts. Components have not been otherwise inspected.The only symptom of imminent failure was a "whineing" noise form the engine compartment audible only when vehicle was not moving. There were no warning lamps, messages,or other signals . This failure occurred at 230 engine hours total and 7000 road miles on unit.
NHTSA ODI #11591496
Official recalls
18Feb 3, 2026
Ford Motor Company (Ford) is recalling certain 2023-2024 Transit vehicles. The engine crossmember may not be secured properly, which can cause the engine to shift and possibly result in a loss of drive power or brake failure.
Consequence & remedy
Consequence: A loss of drive power or brake failure increases the risk of a crash.
Remedy: Dealers will replace the cross member fasteners, free of charge. Owner notification letters were mailed May 22, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S04. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 4, 2026.
Dec 17, 2025
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
Sep 18, 2025
Ford Motor Company (Ford) is recalling certain 2023-2024 Transit vehicles repaired incorrectly under recall numbers 24V226 and 24V591. An incorrect steering coupler cover and tires that were not designed for the vehicle may have been installed during a previous repair.
Consequence & remedy
Consequence: Incorrect tires and an incorrect steering coupler cover can cause a loss of brake function, loss of steering control, or damage to tires, increasing the risk of a crash.
Remedy: Dealers will inspect and if necessary, replace the tires, tire placard, and certification label, and also recalibrate the vehicle. Additionally, dealers will remove the steering coupler cover. Repairs will be performed free of charge. Owner notification letters were mailed April 10, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S95. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 24, 2025.
Additional source detail variants (2)
Steering
Ford Motor Company (Ford) is recalling certain 2023-2024 Transit vehicles repaired incorrectly under recall numbers 24V226 and 24V591. An incorrect steering coupler cover and tires that were not designed for the vehicle may have been installed during a previous repair.
Consequence: Incorrect tires and an incorrect steering coupler cover can cause a loss of brake function, loss of steering control, or damage to tires, increasing the risk of a crash.
Remedy: Dealers will inspect and if necessary, replace the tires, tire placard, and certification label, and also recalibrate the vehicle. Additionally, dealers will remove the steering coupler cover. Repairs will be performed free of charge. Owner notification letters were mailed April 10, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S95. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 24, 2025.
Tires
Ford Motor Company (Ford) is recalling certain 2023-2024 Transit vehicles repaired incorrectly under recall numbers 24V226 and 24V591. An incorrect steering coupler cover and tires that were not designed for the vehicle may have been installed during a previous repair.
Consequence: Incorrect tires and an incorrect steering coupler cover can cause a loss of brake function, loss of steering control, or damage to tires, increasing the risk of a crash.
Remedy: Dealers will inspect and if necessary, replace the tires, tire placard, and certification label, and also recalibrate the vehicle. Additionally, dealers will remove the steering coupler cover. Repairs will be performed free of charge. Owner notification letters were mailed April 10, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S95. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 24, 2025.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
May 23, 2025
Ford Motor Company (Ford) is recalling certain 2022-2023 Transit vehicles previously repaired incorrectly under recall number 22V415. The Instrument Panel Cluster may not properly illuminate warning lights or gauges. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
Consequence & remedy
Consequence: An instrument panel that does not illuminate critical safety information, such as the speedometer or warning lights, can increase the risk of a crash.
Remedy: Dealers will update the instrument panel cluster software, free of charge. Owner notification letters were mailed June 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C19.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.
Consequence & remedy
Consequence: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.
Apr 11, 2025
Ford Motor Company (Ford) is recalling certain 2022-2023 Transit vehicles previously repaired incorrectly under recall number 23V-598. The rearview camera, or 360-degree view camera if equipped, may not display a rearview image when the vehicle is placed in reverse.
Consequence & remedy
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed May 23, 2025. Ford's number for this recall is 25S38.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2022-2023 Transit vehicles previously repaired incorrectly under recall number 22V-791. The heating, ventilation, and air-conditioning (HVAC) system's controls, including those for defog and defrost, may become inoperative.
Consequence & remedy
Consequence: Loss of the ability to control the defrost or defog function decreases the driver's visibility under certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will update the remote climate control module software, free of charge. Owner notification letters were mailed April 21, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S23.
Oct 25, 2024
Ford Motor Company (Ford) is recalling certain 2023-2024 Ford Transit vehicles previously repaired under recall number 24V-102. Incorrect bolts may have been used to attach the rear axle shaft, which can lead to the rear wheel locking up or separating from the axle.
Consequence & remedy
Consequence: Rear wheel lock-up or separation of the wheel from the axle shaft can result in loss of vehicle control or loss of drive power. In addition, the vehicle may roll in park if the parking brake is not applied. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect the rear axle shaft bolts, replace incorrect bolts as necessary, and fill the differential fluid if needed, free of charge. Owner notification letters were mailed December 13, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S67.
Aug 9, 2024
Ford Motor Company (Ford) is recalling certain 2023-2024 Transit vehicles. The steering column intermediate shaft may have been secured to the steering gear pinion shaft with an incorrect bolt, which can result in the separation of steering components and cause a loss of steering control.
Consequence & remedy
Consequence: A loss of steering control can increase the risk of a crash.
Remedy: Dealers will replace the steering column intermediate shaft bolt, free of charge. Owner notification letters were mailed on February 14, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S48.
Jul 19, 2024
Ford Motor Company (Ford) is recalling certain 2023-2024 Transit vehicles equipped with a Transit Trail package. The electronic power assist steering (EPAS) ground eyelet joint may experience corrosion, which can result in a loss of power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist can increase the risk of a crash.
Remedy: Dealers will install a new EPAS ground pigtail kit, free of charge. Owner notification letters were mailed on January 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S46.
Mar 22, 2024
Ford Motor Company (Ford) is recalling certain 2023-2024 Transit vehicles equipped with the Transit Trail package. The tires may contact the front wheel arch liner and body flange, causing damage to the tires.
Consequence & remedy
Consequence: Damaged tires may experience a sudden loss of air pressure or tread separation, causing a loss of vehicle control and increasing the risk of a crash.
Remedy: Dealers will replace the tires, tire placard, and certification label, and also recalibrate the vehicle, free of charge. Owner notification letters were mailed on March 26, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S21.
Feb 9, 2024
Ford Motor Company (Ford) is recalling certain 2023-2024 Ford Transit vehicles. An inadequate amount of rear axle lubricant may cause rear axle tail bearing damage and seizure, which can result in wheel lock-up or driveshaft separation.
Consequence & remedy
Consequence: Wheel lock-up or driveshaft separation can result in a loss of drive power. A disconnected driveshaft can also result in a roll away when the vehicle is in park without the parking brake applied. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect the rear axle, and replace the axle bearings or axle assembly as necessary, free of charge. Owner notification letters were mailed March 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S05.
Aug 25, 2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator, 2018-2021 Lincoln Navigator, 2022-2023 Ford Transit, and 2021 Ford Bronco vehicles. The rearview camera, or 360-degree view camera if equipped, may not display a rearview image when the vehicle is placed in reverse.
Consequence & remedy
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, and update the software and wiring as necessary, free of charge. Owner notification letters were mailed November 20, 2023 to Lincoln owners. Ford vehicle owners notification letters were mailed March 4, 2024. Ford remedy parts are anticipated 2nd Quarter 2024. Ford's number for this recall is 23S48.
Jul 19, 2023
Quality Vans (Quality Vans) is recalling certain 2020-2023 Ford Transit vans equipped with Onan QG 2800i EVAP generators, part number 2.8HGLAA-8303A. The fuel hose between the inline fuel filter and the Injection Pump Module (IPM) may not be properly secured, which can cause a gas leak.
Consequence & remedy
Consequence: A gasoline leak in the presence of an ignition source may increase the risk of fire.
Remedy: Dealers will inspect and replace the fuel hose and clamps as necessary, free of charge. Owner notification letters were mailed August 4, 2023. Owners may contact Quality Vans customer service at 1-480-464-7007.
Feb 24, 2023
Ford Motor Company (Ford) is recalling certain 2023 Transit vehicles equipped with the Special Vehicle Operations Accessory Service Kit #1 or #2 with a High Specification Vehicle Interface Connector. When the accessory kit is installed, the auxiliary wire harness will disable the heating, air-conditioning, and ventilation (HVAC) including the defrost and defog systems. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."
Consequence & remedy
Consequence: An inoperative windshield defrosting and defogging system may decrease the driver's visibility under certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will repair the auxiliary wire harness by modifying the wire harness to include the necessary twisted loop, free of charge. Owner notification letters were mailed April 20, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C02.
Feb 10, 2023
Ford Motor Company (Ford) is recalling certain 2023 Transit vehicles. The fuel tank grade vent valve may not be properly welded to the fuel tank shell, which can result in a fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the fuel tank, free of charge. Owner notification letters were mailed March 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S04.
Oct 20, 2022
Ford Motor Company (Ford) is recalling certain 2022-2023 Transit vehicles. The heating, ventilation, and air-conditioning (HVAC) system's controls, including those for defog and defrost, may become inoperative.
Consequence & remedy
Consequence: Loss of the ability to control the defrost or defog function decreases the driver's visibility under certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will update the remote climate control module software, free of charge. Owner notification letters were mailed on November 11, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S65.
Additional source detail variants (2)
Electrical System: Instrument Cluster/panel
Ford Motor Company (Ford) is recalling certain 2022-2023 Transit vehicles. The heating, ventilation, and air-conditioning (HVAC) system's controls, including those for defog and defrost, may become inoperative.
Consequence: Loss of the ability to control the defrost or defog function decreases the driver's visibility under certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will update the remote climate control module software, free of charge. Owner notification letters were mailed on November 11, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S65.
Visibility:defroster/defogger/hvac System
Ford Motor Company (Ford) is recalling certain 2022-2023 Transit vehicles. The heating, ventilation, and air-conditioning (HVAC) system's controls, including those for defog and defrost, may become inoperative.
Consequence: Loss of the ability to control the defrost or defog function decreases the driver's visibility under certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will update the remote climate control module software, free of charge. Owner notification letters were mailed on November 11, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S65.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration