IllustrationAir bag failure at 35 to 45 mph. All sensors on front end should have been activated to deploy. I am reporting this due to this vehical having prior mvc and has been serviced. I am wondering if air bag system was not repaired from prior incidents
2019 Ford Transit
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2019 Ford Transit do not stand out strongly from the model-year median of 37.
About this comparison →How this year compares
Owner complaints by model year
Compare all Transit years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 17 of 37 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports0 injury reports
Engine complaints
3 reportsSmelling exhaust fumes inside vehicle and not safe to drive with only 46,000 miles on odometer. Took it to Ford Dealer and found two manifold bolts have broken off flush to engine block and manifold is now leaking. This is a very common occurrence with the 3.5 Ecoboost motor.
The contact owns a 2019 Ford Transit. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the catalytic converter had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure t…
Read full complaint
The contact owns a 2019 Ford Transit. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the catalytic converter had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure to an unknown recall. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the safety failure. The failure mileage was approximately 135,000.
Official recalls
925V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:
Dec 17, 2025
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
25V572000 · Back Over Prevention: Sensing System: Camera
Sep 3, 2025
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
21V631000 · Parking Brake:conventional:mechanical:linkage And Cable
Aug 11, 2021
Ford Motor Company (Ford) is recalling certain 2015-2020 Transit vehicles. An incorrect driveshaft torsional damper service kit may have been installed, which can allow the damper shield to contact the parking brake cable, possibly resulting in parking brake failure.
Consequence & remedy
Consequence: Parking brake failure can result in unintended vehicle movement, increasing the risk of a crash.
Remedy: Dealers will replace the passenger side parking brake cable with a cable that provides sufficient clearance to the damper shield, free of charge. Interim owner notification letters were mailed on September 24, 2021. Owner notification letters were mailed on March 14, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S39.
21V324000 · SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly
May 7, 2021
Ford Motor Company (Ford) is recalling certain 2019 Transit T150, T250, T350 vehicles equipped with aluminum alloy wheels. The wheel mounting surface of the axle flange may be warped and cause the wheel studs to fracture.
Consequence & remedy
Consequence: Fractured studs may allow the wheel to detach, increasing the risk of crash.
Remedy: Dealers will inspect and if necessary, replace the rear axle shaft assembly, axle shaft mounting bolts, and rear wheel lug nuts, free of charge. Owner notification letters were mailed on June 28, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S21.
20V250000 · Seat Belts:front:retractor
May 5, 2020
National Van Builders, Inc. (National Van Builders) is recalling certain vehicles based on 2019-2020 Ford Transit and 2019 Ram Promaster vans equipped with Freedman GO-ES foldaway seats. The seat belt retractor block out zone may have not been set correctly, potentially resulting in a seat belt that may not properly secure the occupant. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies."
Consequence & remedy
Consequence: An unsecured occupant has an increased risk of injury in the event of a crash.
Remedy: National Van Builders will notify owners, and dealers will replace the retractors, free of charge. The recall began May 19, 2020. Owners may contact Freedman customer service at 1-800-443-4540 or National Van Builders customer service at 1-800-527-7477.
20V222000 · Seat Belts:front:retractor
Apr 20, 2020
TransitWorks is recalling certain Driverge vehicles based on 2019-2020 Ford Transit vans equipped with Freedman Seating Company (FSC) PT Foldaway and GO-ES 3-point Foldaway seats. The seat belt retractor block out zone may have not been set correctly, potentially resulting in a seat belt that may not properly secure the occupant. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies."
Consequence & remedy
Consequence: An unsecured occupant has an increased risk of injury in the event of a crash.
Remedy: TransitWorks will notify owners, and dealers will replace the retractors, free of charge. The recall began May 13, 2020. Dealers can contact Freedman Seating Company for parts and reimbursement information at 1-800-443-4540.
19V439000 · Structure:emergency:escape/egress/exit
Jun 11, 2019
LA West Inc. (LA West) is recalling certain 2018-2019 Ford Transit vehicles modified to be equipped with glass roof hatches. Temperature and vibration stresses may cause the tempered glass roof hatch to shatter.
Consequence & remedy
Consequence: If the tempered glass roof hatch shatters, glass fragments may fall onto passengers, increasing the risk of an injury.
Remedy: LA West will notify owners, and dealers will replace the hatch lids, free of charge. The recall began July 11, 2019. Owners may contact LA West customer service at 1-704-498-4940.
19V229000 · Seats
Mar 22, 2019
TransitWorks is recalling certain 2015-2018 Ford Transit, 2018 Ford Transit Connect, and 2016 Dodge Ram ProMaster vehicles modified to be equipped with Freedman Seating GO-ES seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: TransitWorks has notified owners and instructed them to contact Freedman seats for a repair kit. The recall began December 19, 2019. Owners may contact Freedman Seating customer service at 1-800-443-4540 or TransitWorks customer service at 1-855-337-9543.
19V103000 · Power Train:driveline:driveshaft; Power Train:driveline:universal Joint
Feb 21, 2019
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence & remedy
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
Additional source detail variants (2)
Power Train:driveline:driveshaft
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
Power Train:driveline:universal Joint
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.