MY MECHANIC HAS INFORMED ME OF A DANGEROUS SITUATION WITH MY AUTOMOBILE THAT COULD LEAD TO AN ACCIDENT. ALL THE BALL JOINTS IN THE FRONT END ARE WORN EXCESSIVELY. HE SAYS THE EXCESSIVE WEAR IS A RESULT OF THE DUST SEALS DISINTEGRATING ALLOWING DIRT AND WATER TO ENTER THE BALL JOINTS. HE INDICATED THAT THIS IS PROBABLY A RESULT…
Read full complaint
MY MECHANIC HAS INFORMED ME OF A DANGEROUS SITUATION WITH MY AUTOMOBILE THAT COULD LEAD TO AN ACCIDENT. ALL THE BALL JOINTS IN THE FRONT END ARE WORN EXCESSIVELY. HE SAYS THE EXCESSIVE WEAR IS A RESULT OF THE DUST SEALS DISINTEGRATING ALLOWING DIRT AND WATER TO ENTER THE BALL JOINTS. HE INDICATED THAT THIS IS PROBABLY A RESULT OF THE USE OF INAPPROPRIATE OR DEFECTIVE MATERIALS FOR THE SEALS. I AM GOING TO HAVE THE BALL JOINTS REPLACED. I WILL ASK THE MECHANIC TO KEEP THE OLD PARTS FOR ME. *NM
NHTSA ODI #10172453
58,000 miles · Oct 13, 2006
Suspension
DT*: THE CONTACT STATED WHILE PERFORMING GENERAL MAINTENANCE ON THE VEHICLE, IT WAS DETERMINED THE PLASTIC SEALS ON ALL FOUR UPPER AND LOWER BALL JOINTS AS WELL AS THE SEALS ON THE STABILIZER BAR WERE FRACTURED AND DETERIORATING. THE MANUFACTURER WAS ALERTED.
NHTSA ODI #10170731
33,573 miles · Jul 30, 2005
Engine And Engine CoolingSuspension
TO WHOM IT MAY CONCERN! MY 1997 FORD THUNDERBIRD IS NOT LISTED WHY? I HAVE A LOT OF PROBLEMS WITH THE SMOG STUFF EVERY YEAR I PAY A LOT OF MONEY. WHEN TEMPERATURES ARE HOT OUTSIDE OVER 90 THE ENGINE LIGHT COMES ON AND SAYS SERVICE ENGINE, OR WHEN I GO UP A LONG HILL AND MY CAR OVERHEATS THE ENGINE LIGHT COMES ON AND SAYS SE…
Read full complaint
TO WHOM IT MAY CONCERN! MY 1997 FORD THUNDERBIRD IS NOT LISTED WHY? I HAVE A LOT OF PROBLEMS WITH THE SMOG STUFF EVERY YEAR I PAY A LOT OF MONEY. WHEN TEMPERATURES ARE HOT OUTSIDE OVER 90 THE ENGINE LIGHT COMES ON AND SAYS SERVICE ENGINE, OR WHEN I GO UP A LONG HILL AND MY CAR OVERHEATS THE ENGINE LIGHT COMES ON AND SAYS SERVICE ENGINE AND IT IS ALWAYS ABOUT AN OXYGEN SENSOR OR OTHER SMOG RELATED ITEMS THAT ALWAYS COST $300 TO $650 I AM GOING B BROKE BEING ON A FIXED INCOME. FORD CAN'T FIX MY FRONT END VIBRATION I HAD ALL ALIGNMENTS DONE WHEEL BALANCING 4 TIMES NOTHING HELPS. MY STEERING WHEEL VIBRATES ALSO. PLEASE HELP! MANFRED GAUER . *JB
NHTSA ODI #10130641
71,568 miles · May 30, 2003
EquipmentPower TrainSuspension
I BOUGHT MY 1997 THUNDERBIRD 4-15-2003 W/70000 MILES, AFTER READING ALL THE COMPLAINTS ON THIS PAGE I CAN ONLY RELATE TO 2 OF THEM, THE VIBERATION IN THE TRANSMISSION ON UPSHIFT,AND THE FRONT END SHAKING ABOVE 50 MPH.BUT I'M SO GLAD. *AK I BOUGHT A 2 YR.EXTENTED WARRENTY,BECAUSE IT LOOKS LIKE I'M IN FOR SOME PROBLENS. I CAN B…
Read full complaint
I BOUGHT MY 1997 THUNDERBIRD 4-15-2003 W/70000 MILES, AFTER READING ALL THE COMPLAINTS ON THIS PAGE I CAN ONLY RELATE TO 2 OF THEM, THE VIBERATION IN THE TRANSMISSION ON UPSHIFT,AND THE FRONT END SHAKING ABOVE 50 MPH.BUT I'M SO GLAD. *AK I BOUGHT A 2 YR.EXTENTED WARRENTY,BECAUSE IT LOOKS LIKE I'M IN FOR SOME PROBLENS. I CAN BE CONTACTED AT TBIRD97@INTERGATE.COM
NHTSA ODI #10020735
79,000 miles · Jan 6, 2003
Suspension
WHILE DRIVING 40 MPH, THE FRONT LOWER BALL JOINT SNAPPED, CAUSING THE CONSUMER TO LOSE STEERING CONTROL. THE CONSUMER MANAGED TO PULL OVER. *AK THE INCIDENT OCCURRED WITHOUT WARNING WHILE IN MOTION. THE REPAIR DEPARTMENT SUGGESTED THAT THE CONSUMER SHOULD EXPECT THIS AT 70K MILES. FORD HAD NOT RESPONDED TO THE CONSUMER. …
Read full complaint
WHILE DRIVING 40 MPH, THE FRONT LOWER BALL JOINT SNAPPED, CAUSING THE CONSUMER TO LOSE STEERING CONTROL. THE CONSUMER MANAGED TO PULL OVER. *AK THE INCIDENT OCCURRED WITHOUT WARNING WHILE IN MOTION. THE REPAIR DEPARTMENT SUGGESTED THAT THE CONSUMER SHOULD EXPECT THIS AT 70K MILES. FORD HAD NOT RESPONDED TO THE CONSUMER. *SC *JB
NHTSA ODI #10040248
Mileage unknown · Sep 4, 2001
SuspensionWheels
VEHICLE WAS GOING 20MPH AND THE CONSUMER LOST CONTROL. FRONT PASSENGER WHEEL BENT, AND BALL JOINT CAME APART, DEALER AND MANUFACTURER WILL BE CONTACTED. *AK
NHTSA ODI #895663
Mileage unknown · Nov 15, 2000
Suspension
FRONT BALL JOINT POPPED OUT OF SOCKET WHILE DRIVING. DEALER HAS REPLACED CONTROL ARM AND BALL JOINT TWICE, AND PROBLEM REOCCURRED.*AK THE FRONT SUSPENSION COLLAPSED COMPLETLY AND THE REAR LOWER BALL JOINT BROKE. TENSION ARM BUSHING AND LOWER CONTROL ARM ON RIGHT SIDE FAILED CAUSING THE VEHICLE TO PULL WHEN APPLYING BRAK…
Read full complaint
FRONT BALL JOINT POPPED OUT OF SOCKET WHILE DRIVING. DEALER HAS REPLACED CONTROL ARM AND BALL JOINT TWICE, AND PROBLEM REOCCURRED.*AK THE FRONT SUSPENSION COLLAPSED COMPLETLY AND THE REAR LOWER BALL JOINT BROKE. TENSION ARM BUSHING AND LOWER CONTROL ARM ON RIGHT SIDE FAILED CAUSING THE VEHICLE TO PULL WHEN APPLYING BRAKES. THE LEFT FRONT SWAYBAR FAILED. THE LEFT FRONT WHEEL BEARING FAILED. *YH
NHTSA ODI #875038
Mileage unknown · Nov 13, 2000
Suspension
BOTH INCIDENTS COULD HAVE CAUSED SERIOUS INJURY OR DEATH. THIS IS NOW THE SECOND TIME THIS PART HAS BEEN REPLACED. ON THE FIRST OCCASION I WAS IN A PARKING LOT AND THE WHOLE FRONT END OF THE CAR COLLAPSED. FROM WHAT THE DEALER SAY FORD ENGINEERS LOOKED AT IT AND COULDN'T BELIEVE THE BALL JOUINT POPPED OUT OF THE SOCKET. AGAIN TH…
Read full complaint
BOTH INCIDENTS COULD HAVE CAUSED SERIOUS INJURY OR DEATH. THIS IS NOW THE SECOND TIME THIS PART HAS BEEN REPLACED. ON THE FIRST OCCASION I WAS IN A PARKING LOT AND THE WHOLE FRONT END OF THE CAR COLLAPSED. FROM WHAT THE DEALER SAY FORD ENGINEERS LOOKED AT IT AND COULDN'T BELIEVE THE BALL JOUINT POPPED OUT OF THE SOCKET. AGAIN THIS IS THE SECOND TIME THEY HAD TO REPLACE IT WITHIN 10 MONTHS. FEEL FREE TO CONTACT ME FOR FURTHER INFORMATION AND LET ME KNOW IF I CAN TAKE FURTHER ACTION WITH REGARDS TO THE SAFETY OF THIS CAR. THANKS , TOM. *AK
NHTSA ODI #736254
Mileage unknown · Oct 2, 2000
SuspensionVehicle Speed Control
UNSAFE UNINTENDED ACCELERATION ON MORE THAN ONE OCCASION/STEERING SHAKES CONSISTANTLY. *AK
NHTSA ODI #733282
Mileage unknown · Aug 28, 2000
SuspensionTires
PE00 020;VEHICLE BEGAN TO WOBBLE,AND PULLED TO LEFT/ RIGHT INTERMITTENTLY. TOOKVEHICLE TO THE THE DEALERSHIP. MECHANIC TOLD HER THAT TIRES WERE SEPARATED. SHE HAD ALL FOUR TIRES REPLACED AT HER EXPENSE. TIRES WERE FIRESTONE 205/70R15 FR710. *AK
NHTSA ODI #868939
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1997 Ford Thunderbird Problems, Complaints & Recalls | Skip That Year
Illustration