IllustrationDRIVER'S WINDOW WAS INSTALLED AT FACTORY USING APLASTIC CLIP TO HOLD WINDOW ON ITS LIFTING MECHANISM. THE MATERIAL USED TO FUSE THE TWO MATERIALS TOGETHER LOSES STRENGTH AFTER SOME USE AND WINDOW NEEDS TO BE REPLACED. ALSO, AIR CONDTIONING FAILED. *AK
1991 Ford Thunderbird
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Thunderbird years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 8 of 112 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports12 fire reports5 injury reports
What owners actually said
112 reportsVEHICLE HAS A DEFECTIVE WINDSHIELD WIPER MOTOR, IT CUTS ON AND OFF WHILE IN USE, CAUSING IMPAIRED VISIBILITY DUE TO INCLEMENT WEATHER. *AK
THE AUTOMATIC SHOULDER BELT ON THE PASSENGER'S SIDE GETS SUCKED IN THE MIDDLE OF THE RETRACTOR AND SOMETIMES THE BELT SHUDDERS IN THE MIDDLE OF THE TRACK BEFORE GOING IN THE OPEN OR CLOSE POSITION . VEHICLE HAS BEEN REPAIRED BY DEALER TWICE FOR THIS PROBLEM, SYSTEM NEEDS REPLACING AGAIN. *AK
WHILE ENTERING A PARKING LOT, NOTICED SMOKE COMING FROM STEERING COLUMN, NEAR IGNITION, PARKED VEHICLE, EVERYONE OUT OF VEHICLE; WENT TO MAKE PHONE CALL, VEHICLE WAS ENGULFED IN FLAMES; CALLED 911; SOMEONE WAS PUTTING FLAMES OUT BEFORE FIRE DEPT. ARRIVED. *AK
DISC BRAKE ROTORS WARPED, CAUSING VEHICLE TO SHAKE UPON BRAKING. *AK
AUTOMATIC SEAT BELT IS STUCK IN POSITION, CANNOT BE USED AT ALL.
TRANSMISSION'S FIRST GEAR FAILED; THREE OUT OF FIVE TAKE-OFFS, VEHICLE STARTS IN SECOND GEAR. *AK
OWNER STATES THAT VEHICLE WAS INVOLVED IN A FRONTAL IMPACT GOING 60MPH AND THERE WAS NO DEPLOYMENT OF THE DRIVER'S AIRBAG. *AK
UPON FILLING VEHICLE WITH GAS OWNER NOTICED A STRONG ODOR OF FUEL, HE STATED THAT THE RING SEAL AROUND FUEL PUMP WAS BAD AND ALSO THE ELECTRICAL CONNECTORS AROUND FUEL PUMP HAD MELTED AWAY. *AK
PADS AND ROTORS REPLACED 3 TIMES.
Official recalls
396V071000 · Electrical System:ignition
Apr 25, 1996
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
91V076000 · Visibility:windshield Wiper/washer:motor
May 6, 1991
THE NUTS WHICH HOLD WINDSHIELD WIPER MOTOR TO THE WIPER MODULE MAY NOT HAVE BEEN SUFFICIENTLY TIGHTENED AND MAY LOOSEN OR COME OFF. THIS CAUSES CHANGED WIPER PATTERNS, OR THE WIPERS MAY JAM IF TWO OF THE THREE NUTS COME OFF.
Consequence & remedy
Consequence: CHANGES IN THE WIPER PATTERN OR JAMMING OF THE WIPERSWOULD RESULT IN REDUCED DRIVER VISIBILTY IN INCLEMENT WEATHER CONDITIONS.
Remedy: APPLY TORQUE RETENTION MATERIAL TO WIPER MOTOR STUDS AND NUTS AND RETORQUE.
91V048000 · Power Train:automatic Transmission
Mar 18, 1991
THE PARK ROD ASSEMBLY CONTAINS A PARK CAM WITH INADEQUATE SURFACE HARDNESS, WHICH COULD LEAD TO PARK DISENGAGEMENT OR NO PARK ENGAGEMENT WHEN THE LEVER IS PLACED IN PARK.
Consequence & remedy
Consequence: IF PARK IS NOT ENGAGED AND THE PARKING BRAKE IS OFF, AVEHICLE ROLL-AWAY COULD RESULT.
Remedy: REPLACE PARK ROD ASSEMBLY ON AUTOMATIC TRANSMISSIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA93033 · Thrttl Vlv Linkage Bushing
Opened Dec 30, 1993 · Closed Dec 30, 1994
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93075 · Thrttl Vlv Linkage Bushing
Opened Aug 30, 1993 · Closed Dec 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available