IllustrationI WOULD LIKE FOR THESE PROBLEMS TO BE FIXED. NO SAFETY DEFECT LISTED. *AK
1991 Ford Thunderbird
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Thunderbird years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 8 of 112 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports12 fire reports5 injury reports
What owners actually said
112 reportsANTI-LOCK BRAKES AND BRAKE SYSTEM WARNING LIGHTS ON DASHBOARD COME ON. WHEN CONSUMER ATTEMPTS TO SLOW/STOP VEHICLE, THERE IS NO RESISTANCE BEHIND THE BRAKE PEDAL, AND IT GOES TO THE FLOOR. THIS HAS OCCURRED THREE TIMES; AT 15-20 MPH RANGE/ 20-30 MPH RANGE, AND AT 40-50 MPH RANGE. A PRIVATE MECHANIC STATED THAT ON A PREVI…
Read full complaint
ANTI-LOCK BRAKES AND BRAKE SYSTEM WARNING LIGHTS ON DASHBOARD COME ON. WHEN CONSUMER ATTEMPTS TO SLOW/STOP VEHICLE, THERE IS NO RESISTANCE BEHIND THE BRAKE PEDAL, AND IT GOES TO THE FLOOR. THIS HAS OCCURRED THREE TIMES; AT 15-20 MPH RANGE/ 20-30 MPH RANGE, AND AT 40-50 MPH RANGE. A PRIVATE MECHANIC STATED THAT ON A PREVIOUS VEHICLE WITH SAME DEFECT OCCURRED. THEY RAN A DIAGNOSTIC ON BRAKE SYSTEM AND FOUND NO DEFECTS, BUT REPLACED BRAKE SYSTEM WHICH REPAIRED DEFECT. CONSUMER HAS NOT DETERMINED WHETHER OR NOT HE WILL HAVE THIS DONE. *AK *SLC
ENGINE HEAD GASKETS HAVE BLOWN. DEALER HAS BEEN NOTIFIED.*AK NEW CYLINDER HEAD GASKET WAS INSTALLED AT CONSUMER'S EXPENSE. *YH
MAJOR FUEL LEAK WHEN FILLED. *AK
DRIVER'S SIDE SEATBELT STOPPED WORKING, CONSUMER IS NOT ABLE TO BE PROPERLY RESTRAINED.*AK
THROUGH MOUNTAINOUS REGION IN AR, THROTTLE STUCK WIDE OPEN...FOUND A LITTLE $3 PIECE THAT BROKE ON THE PART THAT HOLDS THE LINKAGE TO THE TRANSMISSION TO THE THROTTLE... CAR KEPT GOING FASTER AND FASTER... BRAKE SYSTEM FAILED. HAD TO PUT CAR IN NEUTRAL, AND GO UP STEEP INCLINE... KEY WOULD NOT COME OUT BECAUSE THE IGNITION SWITC…
Read full complaint
THROUGH MOUNTAINOUS REGION IN AR, THROTTLE STUCK WIDE OPEN...FOUND A LITTLE $3 PIECE THAT BROKE ON THE PART THAT HOLDS THE LINKAGE TO THE TRANSMISSION TO THE THROTTLE... CAR KEPT GOING FASTER AND FASTER... BRAKE SYSTEM FAILED. HAD TO PUT CAR IN NEUTRAL, AND GO UP STEEP INCLINE... KEY WOULD NOT COME OUT BECAUSE THE IGNITION SWITCH IS NOT FUNCTIONING PROPERLY. HAD TO REPLACE THE PIECE THAT BROKE, THE TRANSMISSION, CAR STILL IDLED HIGH.. AND HAD TO REPLACE ANOTHER PART AS WELL. THE BRAKES ARE VERY SPONGY, THEY HAVE BEEN BLED NUMEROUS TIMES, AND THE MASTER CYLANDER REPLACED AND THEY STILL HAVE TO BE PRESSED DOWN 2-3 INCHES (VERY SOFT) BEFORE YOU FEEL ANY SORT OF BRAKAGE. THE CAR STILL DOES NOT RUN CORRECTLY. HAVE SPENT 650.00 + ON AIR CONDITIONER, AND IT STILL DOES NOT WORK RIGHT. APPEARS TO BE A SHORT IN IT, BECAUSE WHEN CAR IS ACCELLERATED, IT WILL START COOLING AGAIN... ONE PART HAS BEEN REPLACED 3 TIMES, SO SOMETHING IS SHORTING IT OUT.
ACCELERATOR PEDAL WAS STUCK IN A WIDE OPEN POSITION WHILE CONSUMER WAS DRIVING. CONSUMER HAD TO TAKE KEY OUT OF IGNITION AND REAPPLY PEDAL TO GET IT UNSTUCK. DEFECT DUE TO A PLASTIC BUSHING CONNECTED TO A THROTTLE VALVE CABLE BECAME DISINTEGRATED, CAUSING CABLE TO TO BECOME LODGED AGAINST THE ACCELERATOR.*AK
NO SUMMARY
3.8 V6S SINCE 1988 HAVE HEAD GASKET PROBLEMS. FORD SHOULD COVER THIS PROBLEM WHEN VEHICLES HAVE SUCH LOW MILEAGE (LESS THAN 100,000 MILE RANGE) AND NOT JUST COVER THE 94-95 MODELS.
HEADLIGHTS FLICKER AT NIGHT, MAKING IT VERY HARD TO SEE. CONSUMER IS HAVING THE SAME PROBLEM AS DISCUSSED IN A MANUFACTURER'S RECALL CONCERNING HEADLAMP SWITCH. HOWEVER, THIS VEHICLE IS NOT INCLUDED. *AK THE HEAD LIGHT SWITCH HAD BEEN REPLACED TWICE. THE CONSUMER HAD ENCOUNTERED CLOSE CALLS DUE TO HEAD LIGHT FAILURES AND…
Read full complaint
HEADLIGHTS FLICKER AT NIGHT, MAKING IT VERY HARD TO SEE. CONSUMER IS HAVING THE SAME PROBLEM AS DISCUSSED IN A MANUFACTURER'S RECALL CONCERNING HEADLAMP SWITCH. HOWEVER, THIS VEHICLE IS NOT INCLUDED. *AK THE HEAD LIGHT SWITCH HAD BEEN REPLACED TWICE. THE CONSUMER HAD ENCOUNTERED CLOSE CALLS DUE TO HEAD LIGHT FAILURES AND INDICATED THE CONDITON TO BE DANGEROUS. *YH
Official recalls
396V071000 · Electrical System:ignition
Apr 25, 1996
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
91V076000 · Visibility:windshield Wiper/washer:motor
May 6, 1991
THE NUTS WHICH HOLD WINDSHIELD WIPER MOTOR TO THE WIPER MODULE MAY NOT HAVE BEEN SUFFICIENTLY TIGHTENED AND MAY LOOSEN OR COME OFF. THIS CAUSES CHANGED WIPER PATTERNS, OR THE WIPERS MAY JAM IF TWO OF THE THREE NUTS COME OFF.
Consequence & remedy
Consequence: CHANGES IN THE WIPER PATTERN OR JAMMING OF THE WIPERSWOULD RESULT IN REDUCED DRIVER VISIBILTY IN INCLEMENT WEATHER CONDITIONS.
Remedy: APPLY TORQUE RETENTION MATERIAL TO WIPER MOTOR STUDS AND NUTS AND RETORQUE.
91V048000 · Power Train:automatic Transmission
Mar 18, 1991
THE PARK ROD ASSEMBLY CONTAINS A PARK CAM WITH INADEQUATE SURFACE HARDNESS, WHICH COULD LEAD TO PARK DISENGAGEMENT OR NO PARK ENGAGEMENT WHEN THE LEVER IS PLACED IN PARK.
Consequence & remedy
Consequence: IF PARK IS NOT ENGAGED AND THE PARKING BRAKE IS OFF, AVEHICLE ROLL-AWAY COULD RESULT.
Remedy: REPLACE PARK ROD ASSEMBLY ON AUTOMATIC TRANSMISSIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA93033 · Thrttl Vlv Linkage Bushing
Opened Dec 30, 1993 · Closed Dec 30, 1994
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93075 · Thrttl Vlv Linkage Bushing
Opened Aug 30, 1993 · Closed Dec 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available