IllustrationCRUISE CONTROL STOPPED WORKING. *TR
1991 Ford Thunderbird
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
Counts are not adjusted for sales, age, mileage exposure or reporting. A lower count does not establish that a car is problem-free.
About this comparison →112Owner complaints
Model-year median: 3
3Recall campaignsView recall details →
2InvestigationsView investigation details →
Check a VIN with NHTSA ↗ Model-level counts do not show whether a particular VIN is affected or repaired.
Inspection summary
1991 Ford Thunderbird
NHTSA snapshot: September 18, 2026. 112 owner complaints · 3 recall campaigns · 2 investigations.
Counts are not failure probabilities and are not adjusted for sales, age, mileage exposure or reporting. One report may name several categories. Comparison method and limitations.
Top reported categories (up to 5)
- Service Brakes, Hydraulic: 18 reports
- Seat Belts: 15 reports
- Engine And Engine Cooling: 14 reports
- Electrical System: 13 reports
- Exterior Lighting: 10 reports
Full reported-category list and vehicle report
Recall links
- 96V071000 — Electrical System:ignition
- 91V076000 — Visibility:windshield Wiper/washer:motor
- 91V048000 — Power Train:automatic Transmission
Check a VIN with NHTSA. Model-level history does not establish whether a particular VIN is affected or repaired.
Print the top reported categories, recall links, snapshot date and comparison limits.
How this year compares
Owner complaints by model year
Compare all Thunderbird years →Counts vary with age, sales, mileage exposure and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 8 of 112 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports12 fire reports5 injury reports
Vehicle Speed Control complaints
10 reportsWHILE THE CONSUMER WAS DRIVING ON THE HIGHWAY THE ACCELERATOR BECAME STRUCK. AS A RESULT THE VEHICLE CONTINUED TO ACCELERATE UNTIL THE BRAKE PEDAL AND EMERGENCY BRAKE WERE APPLIED. *AK *NM
PART TO REPAIR NOT AVAILABLE. DT
I WOULD LIKE FOR THESE PROBLEMS TO BE FIXED. NO SAFETY DEFECT LISTED. *AK
THROUGH MOUNTAINOUS REGION IN AR, THROTTLE STUCK WIDE OPEN...FOUND A LITTLE $3 PIECE THAT BROKE ON THE PART THAT HOLDS THE LINKAGE TO THE TRANSMISSION TO THE THROTTLE... CAR KEPT GOING FASTER AND FASTER... BRAKE SYSTEM FAILED. HAD TO PUT CAR IN NEUTRAL, AND GO UP STEEP INCLINE... KEY WOULD NOT COME OUT BECAUSE THE IGNITION SWITC…
Read full complaint
THROUGH MOUNTAINOUS REGION IN AR, THROTTLE STUCK WIDE OPEN...FOUND A LITTLE $3 PIECE THAT BROKE ON THE PART THAT HOLDS THE LINKAGE TO THE TRANSMISSION TO THE THROTTLE... CAR KEPT GOING FASTER AND FASTER... BRAKE SYSTEM FAILED. HAD TO PUT CAR IN NEUTRAL, AND GO UP STEEP INCLINE... KEY WOULD NOT COME OUT BECAUSE THE IGNITION SWITCH IS NOT FUNCTIONING PROPERLY. HAD TO REPLACE THE PIECE THAT BROKE, THE TRANSMISSION, CAR STILL IDLED HIGH.. AND HAD TO REPLACE ANOTHER PART AS WELL. THE BRAKES ARE VERY SPONGY, THEY HAVE BEEN BLED NUMEROUS TIMES, AND THE MASTER CYLANDER REPLACED AND THEY STILL HAVE TO BE PRESSED DOWN 2-3 INCHES (VERY SOFT) BEFORE YOU FEEL ANY SORT OF BRAKAGE. THE CAR STILL DOES NOT RUN CORRECTLY. HAVE SPENT 650.00 + ON AIR CONDITIONER, AND IT STILL DOES NOT WORK RIGHT. APPEARS TO BE A SHORT IN IT, BECAUSE WHEN CAR IS ACCELLERATED, IT WILL START COOLING AGAIN... ONE PART HAS BEEN REPLACED 3 TIMES, SO SOMETHING IS SHORTING IT OUT.
ACCELERATOR PEDAL WAS STUCK IN A WIDE OPEN POSITION WHILE CONSUMER WAS DRIVING. CONSUMER HAD TO TAKE KEY OUT OF IGNITION AND REAPPLY PEDAL TO GET IT UNSTUCK. DEFECT DUE TO A PLASTIC BUSHING CONNECTED TO A THROTTLE VALVE CABLE BECAME DISINTEGRATED, CAUSING CABLE TO TO BECOME LODGED AGAINST THE ACCELERATOR.*AK
VEHICLE RAPIDLY ACCELERATED ON ITS OWN AS WE WERE LEAVING A REST STOP, AND WE WERE FORCED TO ULTIMATELY TURN OFF THE IGNITION BEFORE IT COULD BE BROUGHT TO A STOP. SPEEDS EXCEEDED 100 MPH - BRAKES WERE APPLIED, AND WERE HEATED TO THE POINT THAT ONE OF THE FRONT STRUTS ACTUALLY "BLEW OUT". MY WIFE WAS DRIVING AT THE TIME, AND S…
Read full complaint
VEHICLE RAPIDLY ACCELERATED ON ITS OWN AS WE WERE LEAVING A REST STOP, AND WE WERE FORCED TO ULTIMATELY TURN OFF THE IGNITION BEFORE IT COULD BE BROUGHT TO A STOP. SPEEDS EXCEEDED 100 MPH - BRAKES WERE APPLIED, AND WERE HEATED TO THE POINT THAT ONE OF THE FRONT STRUTS ACTUALLY "BLEW OUT". MY WIFE WAS DRIVING AT THE TIME, AND SHE QUICKLY REACHED A STATE OF PANIC, NOT REALIZING THAT THE IGNITION COULD BE SWITCHED OFF AND THE STEERING WOULD BE MAINTAINED - IF I HAD NOT BEEN WITH HER, THIS MAY WELL HAVE BEEN AN INCIDENT INVOLVING SERIOUS INJURY OR DEATH. I SPOKE TO FORD ABOUT THIS, BUT THEY STATE "IT DOESN'T HAPPEN" AND REFUSED TO PROVIDE ME WITH A WRITTEN DENIAL OF MY REQUEST FOR AN INSPECTION OF THE VEHICLE.
BRAKES: PULLED OUT OF DIRVEWAY INTO INTERSECTION, MAKING A LEFT TURN, ACCELERATOR STUCK APPLIED THE BRAKES AND THE BRAKES DID NOT CATCH. *AK
ENGINE SURGED, CAUSING ACCIDENT. *DSH
SUDDEN ACCELERATION, CAUSED LOSS OF CONTROL/ACCIDENT/INJURY. *SKD
Recall campaigns
396V071000 · Electrical System:ignition
Apr 25, 1996
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
91V076000 · Visibility:windshield Wiper/washer:motor
May 6, 1991
THE NUTS WHICH HOLD WINDSHIELD WIPER MOTOR TO THE WIPER MODULE MAY NOT HAVE BEEN SUFFICIENTLY TIGHTENED AND MAY LOOSEN OR COME OFF. THIS CAUSES CHANGED WIPER PATTERNS, OR THE WIPERS MAY JAM IF TWO OF THE THREE NUTS COME OFF.
Consequence & remedy
Consequence: CHANGES IN THE WIPER PATTERN OR JAMMING OF THE WIPERSWOULD RESULT IN REDUCED DRIVER VISIBILTY IN INCLEMENT WEATHER CONDITIONS.
Remedy: APPLY TORQUE RETENTION MATERIAL TO WIPER MOTOR STUDS AND NUTS AND RETORQUE.
91V048000 · Power Train:automatic Transmission
Mar 18, 1991
THE PARK ROD ASSEMBLY CONTAINS A PARK CAM WITH INADEQUATE SURFACE HARDNESS, WHICH COULD LEAD TO PARK DISENGAGEMENT OR NO PARK ENGAGEMENT WHEN THE LEVER IS PLACED IN PARK.
Consequence & remedy
Consequence: IF PARK IS NOT ENGAGED AND THE PARKING BRAKE IS OFF, AVEHICLE ROLL-AWAY COULD RESULT.
Remedy: REPLACE PARK ROD ASSEMBLY ON AUTOMATIC TRANSMISSIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Defect investigations
2EA93033 · Thrttl Vlv Linkage Bushing
Opened Dec 30, 1993 · Closed Dec 30, 1994
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93075 · Thrttl Vlv Linkage Bushing
Opened Aug 30, 1993 · Closed Dec 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.