IllustrationFUEL LEAK FROM FUEL TANK WHEN FULL . DANGEROUS , COULD CAUSE A FIRE . AUTO IS PARKED IN A GARAGE INSIDE OF MY HOUSE . UNABLE TO FILL TANK BECAUSE OF CONDITION . FORD WILL NOT REPAIR . AROUND 45,000 MILES , NEVER IN ACCIDENT & FUEL SYSTEM NEVER WORKED ON . I THINK THIS IS VERY NEGLIGENT ON FORD'S PART .*AK
1990 Ford Thunderbird
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Thunderbird years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 9 of 140 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports19 fire reports6 injury reports
Fuel System, Gasoline complaints
5 reportsAFTER ALL THE PROBLEMS THAT I HAVE EXPERIENCED WITH MY FORD THUNDERBIRD, I NOW REFUSE TO PURCHASE ANOTHER FORD CAR AND I WOULD NEVER RECOMMEND A FORD VEHICLE TO ANYONE. BETWEEN THE POWER WINDOW FAILURES, TRANSMISSION FAILURE, AIR COMPRESSOR FAILURE, BATTER FAILURE, FUEL PUMP FAILURE, THROTTLE FAILURE, ETC... I COULD KEEP GOING…
Read full complaint
AFTER ALL THE PROBLEMS THAT I HAVE EXPERIENCED WITH MY FORD THUNDERBIRD, I NOW REFUSE TO PURCHASE ANOTHER FORD CAR AND I WOULD NEVER RECOMMEND A FORD VEHICLE TO ANYONE. BETWEEN THE POWER WINDOW FAILURES, TRANSMISSION FAILURE, AIR COMPRESSOR FAILURE, BATTER FAILURE, FUEL PUMP FAILURE, THROTTLE FAILURE, ETC... I COULD KEEP GOING ON HOW MUCH TROUBLE IT HAS PUT ME THROUGH AND WASTE OF MONEY THAT THIS CAR HAS COST ME. I AM COMPLETELY DISSATISFIED. I WANTED TO PURCHASE AN AMERICAN MADE VEHICLE FOR CERTAIN ASPECTS OF KNOWING I AM HELPING OUT THE US(JOB WISE), BUT MY VIEWS HAVE SINCE CHANGED. BESIDES THE FACT THAT I REFUSE TO BUY ANOTHER FORD CAR, I REALIZE THAT QUALITY AND SAFETY ARE NOT FORD'S STRENGTH AND MAY LEAVE TO PURCHASE A FOREIGN CAR TO WHICH I MAY FIND SOME HAPPINESS. IT HAS GOTTEN TO THE POINT WHERE THE CAR IS IN THE SHOP EVER OTHER WEEK. IF IT'S NOT ONE PROBLEM, IT IS ANOTHER. I AM TRULY FED UP. AND BY THE WAY, I KNOW FOR A FACT THAT I AM NOT THE ONLY PERSON WITH THESE PROBLEMS. I KNOW OTHERS, WHO THROUGH BAD EXPERIENCES ALSO REFUSE TO BUY FORD VEHICLES. *AK
FUEL LEAKS FROM TANK WHEN FULL.
WAS DRIVING AT ABOUT 40 MPH WHEN HIT DIVIDER LEFT SIDE. CAR ALSO HIT RIGHT/FRONT THEN STOPPED AND WAS HIT IN REAR. FUEL CUTOFF SYSTEM DID NOT CUT OFF WHILE INVOLVED IN CRASH. *AK
PLASTIC GAS TANK IS COMING APART AT THE SEAMS FORD OFFERS NO HELP. TT
Official recalls
396V071000 · Electrical System:ignition
Apr 25, 1996
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
91V076000 · Visibility:windshield Wiper/washer:motor
May 6, 1991
THE NUTS WHICH HOLD WINDSHIELD WIPER MOTOR TO THE WIPER MODULE MAY NOT HAVE BEEN SUFFICIENTLY TIGHTENED AND MAY LOOSEN OR COME OFF. THIS CAUSES CHANGED WIPER PATTERNS, OR THE WIPERS MAY JAM IF TWO OF THE THREE NUTS COME OFF.
Consequence & remedy
Consequence: CHANGES IN THE WIPER PATTERN OR JAMMING OF THE WIPERSWOULD RESULT IN REDUCED DRIVER VISIBILTY IN INCLEMENT WEATHER CONDITIONS.
Remedy: APPLY TORQUE RETENTION MATERIAL TO WIPER MOTOR STUDS AND NUTS AND RETORQUE.
90V026000 · Electrical SYSTEM:12V/24V/48V Battery:cables
Feb 12, 1990
BATTERY TO STARTER CABLES ARE LONGER THAN SPECIFIED; EXCESSIVE CABLE LENGTH COULD CONTACT ENGINE DAMPER PULLEY.
Consequence & remedy
Consequence: CABLE PROTECTIVE COVERING AND INSULATION COULD WEAR THROUGH AND CAUSE A DIRECT SHORT TO GROUND, RESULTING IN OVERHEATING OF THE CABLE INSULATION AND POSSIBLY A UNDERHOOD FIRE.
Remedy: REPLACE BATTERY TO STARTER CABLE WITH CORRECT LENGTH CABLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE95019 · Faulty Seatbelt Buckles
Opened Mar 27, 1995 · Closed Jul 31, 1995
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
There is no summary currently available
EA93033 · Thrttl Vlv Linkage Bushing
Opened Dec 30, 1993 · Closed Dec 30, 1994
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93075 · Thrttl Vlv Linkage Bushing
Opened Aug 30, 1993 · Closed Dec 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA90034 · Hood Latches Fail
Opened Jun 26, 1990 · Closed Feb 25, 1992
Status: closed (inferred from source dates) · Structure
There is no summary currently available