NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
874 reports80,000 miles · Sep 22, 2004
Power Train
SINCE WE PURCHASED THE CAR NEW IT HAS LURCHED FORWARD WHEN BEING STARTED. THE TRANSMISSION HAS HAD A HARD TIME SHIFTING, REVING THE ENGINE UP, THEN JUMPING INTO GEAR. WE HAVE HAD IT BACK TO THE DEALER SEVERAL TIMES FOR VARIOUS PROBLEMS. RECENTLY THE TRANSMISSION HAS BEEN MAKING NOISE AND SHIFTING BADLY. ON A TRIP WE FOUND THAT I…
Read full complaint
SINCE WE PURCHASED THE CAR NEW IT HAS LURCHED FORWARD WHEN BEING STARTED. THE TRANSMISSION HAS HAD A HARD TIME SHIFTING, REVING THE ENGINE UP, THEN JUMPING INTO GEAR. WE HAVE HAD IT BACK TO THE DEALER SEVERAL TIMES FOR VARIOUS PROBLEMS. RECENTLY THE TRANSMISSION HAS BEEN MAKING NOISE AND SHIFTING BADLY. ON A TRIP WE FOUND THAT IT WAS LOW ON TRANSMISSION FLUID ALTHOUGH IT HADN'T LEAKED. WE REPLACED THE FLUID AND STARTED DRIVING HOME, CHECKING THE FLUID SEVERAL TIMES. WE LOOKED IN THE REAARVIEW MIRROR AT ONE POINT AND SAW SMOKE COMING OUT THE BACK. FLUID HAD LEAKED ON THE ENGINE AND EXHAUST. WE ALSO DISCOVERED SMALL DROPS OF FLUID ON THE BACK BUMPER OF THE CAR. WHEN WE GOT HOME, WE PARKED THE CAR, STILL NO LEAK WHEN SITTING STILL. I BACKED THE CAR UP TO TAKE IT TO THE DEALER TO BE CHECKED BUT WHEN I PUT IT IN DRIVE IT WON'T ENGAGE IN ANY FORWARD GEARS. I THEN TRIED GOING BACKWARD AGAIN, NOTHING. I T HAS DIED. I CALLED THE DEALER AND STATED I BELIEVE THIS IS A FORD DEFECT, ESPECIALLY AFTER READING ALL THE PROBLEMS THEY HAVE HAD WITH TRANSMISSIONS. I HAVE BEEN TOLD TOO BAD. THEY WILL BE HAPPY TO REPLACE IT AT MY COST. WHY WOULD I WANT ANOTHER BAD TRANSMISSION. *AK
NHTSA ODI #10093024
40,000 miles · Sep 22, 2004
Seat Belts
PASSENGER SAFETY BELT, IN BACK SEAT WILL NOT RETRACT. WENT TO MY FORD DEALER TO HAVE THEM REPLACE IT UNDER MY EXTENDED WARRANTY, BUT THEY SAID "NORMAL". THIS BELT NEVER RETRACTS LIKE THE OTHERS AND OFTEN THE DOOR GETS SHUT ON IT. DISCOVERED LATER THAT THERE WAS A RECALL FOR THESE BACK SEAT BELTS, BUT THE BELT'S DATE OF MANUFA…
Read full complaint
PASSENGER SAFETY BELT, IN BACK SEAT WILL NOT RETRACT. WENT TO MY FORD DEALER TO HAVE THEM REPLACE IT UNDER MY EXTENDED WARRANTY, BUT THEY SAID "NORMAL". THIS BELT NEVER RETRACTS LIKE THE OTHERS AND OFTEN THE DOOR GETS SHUT ON IT. DISCOVERED LATER THAT THERE WAS A RECALL FOR THESE BACK SEAT BELTS, BUT THE BELT'S DATE OF MANUFACTURE NOT IN THE RANGE FOR THE RECALL. *AK
NHTSA ODI #10093011
85,000 miles · Sep 20, 2004
Power Train
REAR AXLE ON THE PASSENGER'S SIDE BROKE WHILE DRIVING 30 MPH. DEALER/ANUFACTURER WERE NOTIFIED. *AK
NHTSA ODI #10092849
Mileage unknown · Sep 17, 2004
Structure
1999 FORD TAURUS WARNING.*MR WHILE DRIVING THE WIND FROM OTHER VEHICLE'S MADE THE CONSUMER'S VEHICLE SHAKE VIOLENTLY ALMOST TO THE POINT OF LOSING CONTROL. *NM
NHTSA ODI #10092783
Mileage unknown · Sep 14, 2004
Engine And Engine Cooling
VEHICLE WAS TAKEN TO THE DEALER FOR A ROUTINE CHECK UP, AND MECHANIC DETERMINED THAT OIL WAS LEAKING FROM UNDERNEATH THE VEHICLE, AND THAT THE OIL GASKET NEEDED TO BE REPLACED. *AK THE CONSUMER WROTE THAT HE SHOULD BE REFUNDED MONEY PAID FOR THE WORK THAT HAD TO BE DONE *TC
NHTSA ODI #10087737
101,842 miles · Sep 8, 2004
Suspension
WHILE DRIVING 35 MPH FRONT PASSENGER COIL SPRING CUT INTO THE TIRE, CAUSING A BLOW OUT. CONSUMER PULLED OVER AND CHANGED THE TIRE. DEALERSHIP WAS NOTIFIED AND REPLACED THE SPRING. THE CONSUMER REQUEST REIMBURSEMENT. *AK *NM
NHTSA ODI #10083683
82,719 miles · Aug 31, 2004
Power Train
A;RIL 2002 PURCHASE USED 1999 FORD TARUS (ODOMETER READING 70198. APRIL 2003 TRANSMISSION FAILED (ODOMETER READING 82,719). REPLACED WITH COST PAID BY ME (TOTAL COST $2,085, WARRANTY $1,238, I PAID $847). QUESTIONING SERVICE RECALL FOR POSSIBLE FAILED TRANSMISSIONS AND WHY DEALERSHIPS DID NOT REPAIR WHEN SERVICE RECALL BULLETI…
Read full complaint
A;RIL 2002 PURCHASE USED 1999 FORD TARUS (ODOMETER READING 70198. APRIL 2003 TRANSMISSION FAILED (ODOMETER READING 82,719). REPLACED WITH COST PAID BY ME (TOTAL COST $2,085, WARRANTY $1,238, I PAID $847). QUESTIONING SERVICE RECALL FOR POSSIBLE FAILED TRANSMISSIONS AND WHY DEALERSHIPS DID NOT REPAIR WHEN SERVICE RECALL BULLETINS WERE DISTRIBUTED.*AK
NHTSA ODI #10088886
75,000 miles · Aug 30, 2004
Steering
1999 FORD TAURUS SE: WHILE TURNING, STARTED HEARING GRINDING, SQEALING NOISES. POWER STEERING FLUID LEVEL WAS FINE. BROUGHT IT TO MECHANIC, SAID THE POWER STEERING RACK AND POWER STEERING PUMP HAD TO BE REPLACED. VEHICLE HAS 65000 HIGHWAY MILES. PER MECHANIC AND FORD DEALER, THIS IS A VERY COMMON PROBLEM IN THE 1999 FORD TA…
Read full complaint
1999 FORD TAURUS SE: WHILE TURNING, STARTED HEARING GRINDING, SQEALING NOISES. POWER STEERING FLUID LEVEL WAS FINE. BROUGHT IT TO MECHANIC, SAID THE POWER STEERING RACK AND POWER STEERING PUMP HAD TO BE REPLACED. VEHICLE HAS 65000 HIGHWAY MILES. PER MECHANIC AND FORD DEALER, THIS IS A VERY COMMON PROBLEM IN THE 1999 FORD TAURUS. COST: OVER $900.00 USD. PLANNING ON FILING COMPLAINTS WITH FORD AND TAKING THEM TO COURT, IF NECESSARY, TO GET REIMBURSED. THIS SHOULD NOT HAPPEN ON A 5 YEAR OLD VEHICLE THAT HAS BEEN MAINTAINED BY THE BOOK! I'VE DONE SOME SEARCHES ON THE INTERNET, AND THERE ARE TONS OF PEOPLE OUT THERE WITH THIS SAME PROBLEM...PLEASE LOOK INTO ASAP...*AK
NHTSA ODI #10088856
Mileage unknown · Aug 26, 2004
Suspension
REQUEST FOR REFUND FOR REPAIRS PERFORMED TO 1999 FORD TAURUS.*MR (RECALL #04V332000) *JB
NHTSA ODI #10091776
Mileage unknown · Aug 18, 2004
Engine And Engine Cooling
CONSUMER STATED THAT FORD CHANGED THE GASKET IN THE FORD TAURUS. THE GASKET MELTED, AND WATER ENTERED INTO THE ENGINE, WHICH MADE THE VEHICLE INOPERABLE. *AK
NHTSA ODI #10089211
Official recalls
5Jul 15, 2004
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSION ASSOCIATED WITH SALT USED ON THE ROADWAYS DURING THE WINTER. A FRACTURED SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL REPLACE BOTH FRONT SPRINGS AT NO CHARGE TO THE OWNER. AN INTERIM NOTICE WAS SENT TO OWNERS ON AUGUST 2, 2004. PARTS ARE NOW AVAILABLE FOR THE 2000-2001 MY VEHICLES AND OWNERS WERE SENT A LETTER ON JANUARY 10, 2005, ADVISING THEM TO BRING IN THEIR VEHICLES FOR REPAIR PARTS ARE EXPECTED TO BE AVAILABLE FOR THE 1999 MY VEHICLES BY THE END OF FEBRUARY 2005 AND OWNERS OF THESE VEHICLES WILL BE NOTIFIED THEN. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Sep 20, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.
Consequence & remedy
Consequence: IF THE MECHANISM MALFUNCTIONS AND DOES NOT ALLOW THE WEBBING TO BE EXTRACTED, THE LAP AND SHOULDER BELT COULD NOT BE WORN BY A VEHICLE OCCUPANT. IN THE EVENT THAT THE MECHANISM DOES NOT ALLOW THE ALR MODE TO BE ENGAGED, THE OPERATOR MAY BE UNABLE TO PROPERLY INSTALL A CHILD SEAT IN THAT SEATING POSITION.
Remedy: DEALERS WILL INSPECT THE LAP AND SHOULDER BELT ASSEMBLIES. ASSEMBLIES WITH JULIAN DATE CODES OF 200 THROUGH 223 ARE SUSPECT AND WILL BE REPLACED.
Nov 9, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUPPED WITH THE "CALIFORNIA" EMISSIONS PACKAGE. AN INCORRECT TRANSMISSION OIL COOLER LINE WAS INSTALLED. THE LINE CONTACTS THE ANTI-LOCK BRAKING SYSTEM MODULE SUPPORT BRACKET AND OVER TIME, CAN WEAR AND DEVELOP A LEAK.
Consequence & remedy
Consequence: TRANSMISSION FLUID LEAKAGE ONTO THE EXHAUST MANIFOLD OR CATALYTIC CONVERTER CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL THE APPROPRIATE TRANSMISSION OIL COOLER LINE.
Sep 1, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DASH INSULATOR RETAINER CLIP WAS NOT FULLY ASSEMBLED TO THE ACCELERATOR CABLE DASH FITTING. THE CLIP CAN DISENGAGE FROM THE ACCELERATOR CABLE AND FALL INTO THE ACCELERATOR PEDAL ARM PIVOT AREA.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE ENGINE MAY NOT FULLY RETURN TO IDLE. ALSO, THE INSULATOR MAY NOT STAY IN THE INTENDED LOCATION AND COULD INTERFERE WITH THE ACCELERATOR CABLE.
Remedy: DEALERS WILL INSPECT THESE VEHICLES TO ENSURE PROPER INSTALLATION OF THE ACCELERATOR CABLE CLIP, AND RE-INSTALL IF NEEDED.
Aug 25, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL SEAT TRACKS. THE FRONT SEAT BELT BUCKLE ATTACHING STUD MAY HAVE BEEN IMPROPERLY HEAT TREATED. THIS HEAT TREATMENT MAY HAVE RESULTED IN CRACKS DEVELOPING IN THE STUD.
Consequence & remedy
Consequence: IF THE STUD IS CRACKED, IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE SEAT BELT BUCKLE MOUNTING BRACKET AND STUD ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE04044 · Front Suspension Coil Spring Fracture
Opened May 24, 2004 · Closed Aug 16, 2004
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Additional source detail variants (2)
Suspension:front
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
PE02080 · Front Suspension Coil Spring Fracture
Opened Oct 22, 2002 · Closed Apr 29, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (2)
Suspension
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Illustration