IllustrationRAIN CAUSES A LEAK IN THE CABIN OF MY 1999 FORD TAURUS. I HAVE HAD TO REPLACE THE BLOWER MOTOR AND FIX THE AC. ALSO CAUSES DAMAGE TO THE INTERIOR CARPET. THE LEAK IS ALWAYS ON THE PASSENGER SIDE AFTER RAIN. *JB
1999 Ford Taurus
Owner reports · Recalls · Investigations
More warning signs than most Taurus years
Owner complaints for the 1999 Ford Taurus are substantially higher than the model-year median of 318.
About this comparison →How this year compares
Owner complaints by model year
Compare all Taurus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
220–25K
6925–50K
8650–75K
7475–100K
64100–150K
22150K+
337 reports with mileage · 537 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 180 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
61 crash reports16 fire reports46 injury reports
What owners actually said
874 reportsTL*THE CONTACT OWNS A 1999 FORD TAURUS. WHILE DRIVING 1 MPH, THE PASSENGER SIDE FRONT TIRE BLEW OUT. THE CONTACT NOTICED THAT THE COIL SPRING PUNCTURED THE TIRE AND CAUSED IT TO FLATTEN. THE VEHICLE WAS TOWED TO A GAS STATION. HE SPOKE WITH THE LOCAL FORD DEALER AND THEY ADVISED HIM TO BRING THE VEHICLE IN FOR REPAIR. THE D…
Read full complaint
TL*THE CONTACT OWNS A 1999 FORD TAURUS. WHILE DRIVING 1 MPH, THE PASSENGER SIDE FRONT TIRE BLEW OUT. THE CONTACT NOTICED THAT THE COIL SPRING PUNCTURED THE TIRE AND CAUSED IT TO FLATTEN. THE VEHICLE WAS TOWED TO A GAS STATION. HE SPOKE WITH THE LOCAL FORD DEALER AND THEY ADVISED HIM TO BRING THE VEHICLE IN FOR REPAIR. THE DEALER REPLACED THE PARTS FOR FREE, HOWEVER, THEY WOULD NOT REIMBURSE HIM FOR THE TOW AND THE NEW TIRE. THE CONTACT BELIEVES THAT HIS VEHICLE SHOULD BE INCLUDED IN RECALL NUMBER 04V332000 (SUSPENSION:FRONT:SPRINGS:COIL SPRINGS). THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 152,000.
MY 1999 FORD TAURUS BRAKE LINE CORRODED AND FELL INTO PIECES. THIS METAL LINE SHOULD NOT HAVE HAD THIS PROBLEM. THE METAL ALLOY IN THIS LINE IS AT FAULT AND SHOULD BE RECALLED OR WARRANTY DUE TO THE SEVERELY DANGEROUS OUTCOME. MY 16 YEAR OLD PULLED THE CAR INTO THE DRIVEWAY WHEN THE LINE LITERALLY BLEW AND ALL OF THE FLUID BL…
Read full complaint
MY 1999 FORD TAURUS BRAKE LINE CORRODED AND FELL INTO PIECES. THIS METAL LINE SHOULD NOT HAVE HAD THIS PROBLEM. THE METAL ALLOY IN THIS LINE IS AT FAULT AND SHOULD BE RECALLED OR WARRANTY DUE TO THE SEVERELY DANGEROUS OUTCOME. MY 16 YEAR OLD PULLED THE CAR INTO THE DRIVEWAY WHEN THE LINE LITERALLY BLEW AND ALL OF THE FLUID BLEW OUT. IT WAS A MIRACLE THAT THIS DID NOT OCCUR ANY OTHER TIME WHILE DRIVING BECAUSE THERE IS NO PEDAL BRAKING AT ALL! *TR
TL*THE CONTACT OWNS A 1999 FORD TAURUS. WHILE DRIVING 25 MPH, THE SERVICE ENGINE LIGHT ILLUMINATED. THE DEALER STATED THAT COOLANT WAS LEAKING FROM THE HEAD GASKET AND THERE WAS CORROSION IN THE COOLANT. THE DEALER REPLACED THE HEAD GASKET. THERE IS SERVICE BULLETIN # 622646 FOR THE COOLING SYSTEM. THE CURRENT MILEAGE IS 90…
Read full complaint
TL*THE CONTACT OWNS A 1999 FORD TAURUS. WHILE DRIVING 25 MPH, THE SERVICE ENGINE LIGHT ILLUMINATED. THE DEALER STATED THAT COOLANT WAS LEAKING FROM THE HEAD GASKET AND THERE WAS CORROSION IN THE COOLANT. THE DEALER REPLACED THE HEAD GASKET. THERE IS SERVICE BULLETIN # 622646 FOR THE COOLING SYSTEM. THE CURRENT MILEAGE IS 90,000 AND FAILURE MILEAGE WAS 84,000.
TL*THE CONTACT OWNS A 1999 FORD TAURUS. THE CONTACT STATED THAT THE PASSENGER SIDE SEAT BELT FAILS TO RETRACT. THE FORD DEALER DIAGNOSED THE VEHICLE AS NEEDING A NEW RETRACTOR. THE DEALER WILL NOT REPAIR IT FOR FREE. THE VEHICLE HAS NOT BEEN REPAIRED. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE IS 108,000 AND FAILUR…
Read full complaint
TL*THE CONTACT OWNS A 1999 FORD TAURUS. THE CONTACT STATED THAT THE PASSENGER SIDE SEAT BELT FAILS TO RETRACT. THE FORD DEALER DIAGNOSED THE VEHICLE AS NEEDING A NEW RETRACTOR. THE DEALER WILL NOT REPAIR IT FOR FREE. THE VEHICLE HAS NOT BEEN REPAIRED. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE IS 108,000 AND FAILURE MILEAGE WAS 96,000.
TL*THE CONTACT OWNS A 1999 FORD TAURUS SPORT. THE CONTACT STATED THAT THE VEHICLE'S HEADLIGHTS BLINK INTERMITTENTLY, DAY AND NIGHT. SHE COULD DRIVE 20 MILES AND THE HEADLIGHTS WOULD BLINK FOR APPROXIMATELY THREE TO FOUR MINUTES BEFORE DIMMING. THE FORD DEALER KEPT THE VEHICLE FOR FIVE DAYS AND WAS UNABLE TO DETERMINE THE CAUS…
Read full complaint
TL*THE CONTACT OWNS A 1999 FORD TAURUS SPORT. THE CONTACT STATED THAT THE VEHICLE'S HEADLIGHTS BLINK INTERMITTENTLY, DAY AND NIGHT. SHE COULD DRIVE 20 MILES AND THE HEADLIGHTS WOULD BLINK FOR APPROXIMATELY THREE TO FOUR MINUTES BEFORE DIMMING. THE FORD DEALER KEPT THE VEHICLE FOR FIVE DAYS AND WAS UNABLE TO DETERMINE THE CAUSE OF FAILURE. SHE STATED THAT THE FAILURE IS EMBARRASSING BECAUSE IT GIVES MIXED SIGNALS TO ONCOMING TRAFFIC. THE CURRENT MILEAGE IS 29,000 AND FAILURE MILEAGE WAS 15,000. UPDATED 02-01-08. *KB
TL*THE CONTACT OWNS A 1999 FORD TAURUS. THE CONTACT TOOK THE VEHICLE IN FOR INSPECTION AND WAS TOLD THAT SHE HAD TO HAVE THE HEADLIGHTS REPLACED. THE HEADLIGHTS HAD OXIDIZED AND PREVENTED THE PROPER AMOUNT OF LIGHT FROM SHINING THROUGH. THE PURCHASE DATE OF THE VEHICLE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 120,0…
Read full complaint
TL*THE CONTACT OWNS A 1999 FORD TAURUS. THE CONTACT TOOK THE VEHICLE IN FOR INSPECTION AND WAS TOLD THAT SHE HAD TO HAVE THE HEADLIGHTS REPLACED. THE HEADLIGHTS HAD OXIDIZED AND PREVENTED THE PROPER AMOUNT OF LIGHT FROM SHINING THROUGH. THE PURCHASE DATE OF THE VEHICLE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 120,000. UPDATED 06/13/07 *TR
DRIVING OUR 99 FORD TAURUS WHEN WE HAD A SUDDEN BLOWOUT AND SAGGING ON THE LEFT FRONT. THE STRUT SPRING HAD RUPTURED, ALSO PUNCTURING THE TIRE. NEW FRONT STRUTS AND TIRES TOTALLED OVER $1100. LUCKILY, WE WERE TRAVELING AT LOW SPEED WHEN THIS OCCURED. ONE MONTH LATER I DISCOVER THAT FORD HAD RECALLED VEHICLES INCLUDING OUR TYPE F…
Read full complaint
DRIVING OUR 99 FORD TAURUS WHEN WE HAD A SUDDEN BLOWOUT AND SAGGING ON THE LEFT FRONT. THE STRUT SPRING HAD RUPTURED, ALSO PUNCTURING THE TIRE. NEW FRONT STRUTS AND TIRES TOTALLED OVER $1100. LUCKILY, WE WERE TRAVELING AT LOW SPEED WHEN THIS OCCURED. ONE MONTH LATER I DISCOVER THAT FORD HAD RECALLED VEHICLES INCLUDING OUR TYPE FOR THAT VERY PROBLEM. WE WERE NEVER NOTIFIED. THE FORD CUSTOMER RELATIONS PERSON (JASMINE) SAID THAT BECAUSE THEY DID NOT HAVE A 'PROFILE' ON US, WE WERE NOT NOTIFIED. WE HAVE LIVED AT THE SAME ADDRESS SINCE 1991 AND HAVE OWNED THIS CAR FOR YEARS. ANY SECRETARY OF STATE OFFICE WOULD HAVE HAD OUR INFO, YET NO GENUINE NOTIFICATION ATTEMPT WAS MADE. I LEARNED THAT FORD EXTENDED WARRANTY COVERAGE FOR THAT PROBLEM BUT THE TIME AND/OR MILEAGE ON OUR CAR NOW SLIGHTLY EXCEEDED THE LIMIT. I PHONED THE NHTSA ROUGHLY 3 WEEKS AGO. A LADY TOOK DOWN MY COMPLAINT AND STATED THAT SOMEONE WOULD CONTACT ME BY PHONE OR EMAIL. I HAVE RECEIVED NEITHER. I EMAILED FORD CUSTOMER SERVICE AND MY REPLY WAS THAT THERE WAS NO PENDING ACTIONS OR ADJUSTMENTS REGARDING MY VEHICLE. WHEN THIS PROBLEM FIRST SURFACED FORD APPARENTLY TOOK THE EAST WAY OUT AND ONLY NOTIFIED PEOPLE THEY HAD ON RECORD AS OWNERS. IF NOTIFIED, I WOULD HAVE IMMEDIATELY HAD THEM REPAIR THE CAR. NO NOTIFICATION, NO REPAIR AND OUR WELL- BEING WAS PUT IN DANGER AS A RESULT. WE WERE NOT HURT BUT I WOULD LIKE FORD TO LIVE-UP TO THEIR RESPONSIBILITY AND COVER THE DAMAGE COST AS SHOULD HAVE BEEN THE CASE ANYWAY. I WOULD LIKE YOUR INPUT ON THIS BEFORE I PROCEED FURTHUR. PLEASE ADVISE. THANK YOU. AL MANENTE.
1999 FORD TAURUS CUSTOMER STATES THAT THEY REPLACED THE WIRING HARNESS THREE TIMES DUE TO IT BURNING OUT **CC *JB
TL*- THE CONTACT STATED THAT WHILE DRIVING THE 1999 FORD TAURUS AT 40 MPH IT CRASHED INTO THE BACK OF ANOTHER VEHICLE, AND THE DRIVER'S SIDE AIRBAG DID NOT DEPLOY. THE CONTACT HAS NOT HAD THE VEHICLE INSPECTED TO DETERMINE THE REASON FOR THE CRASH. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE HOME. THE VEHICLE CURRENTLY HAD A…
Read full complaint
TL*- THE CONTACT STATED THAT WHILE DRIVING THE 1999 FORD TAURUS AT 40 MPH IT CRASHED INTO THE BACK OF ANOTHER VEHICLE, AND THE DRIVER'S SIDE AIRBAG DID NOT DEPLOY. THE CONTACT HAS NOT HAD THE VEHICLE INSPECTED TO DETERMINE THE REASON FOR THE CRASH. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE HOME. THE VEHICLE CURRENTLY HAD AN ODOMETER READING OF 100,000. MILES. *AK
Official recalls
504V332000 · Suspension:front:springs:coil Springs
Jul 15, 2004
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSION ASSOCIATED WITH SALT USED ON THE ROADWAYS DURING THE WINTER. A FRACTURED SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL REPLACE BOTH FRONT SPRINGS AT NO CHARGE TO THE OWNER. AN INTERIM NOTICE WAS SENT TO OWNERS ON AUGUST 2, 2004. PARTS ARE NOW AVAILABLE FOR THE 2000-2001 MY VEHICLES AND OWNERS WERE SENT A LETTER ON JANUARY 10, 2005, ADVISING THEM TO BRING IN THEIR VEHICLES FOR REPAIR PARTS ARE EXPECTED TO BE AVAILABLE FOR THE 1999 MY VEHICLES BY THE END OF FEBRUARY 2005 AND OWNERS OF THESE VEHICLES WILL BE NOTIFIED THEN. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
99V250000 · Seat Belts:front:anchorage
Sep 20, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.
Consequence & remedy
Consequence: IF THE MECHANISM MALFUNCTIONS AND DOES NOT ALLOW THE WEBBING TO BE EXTRACTED, THE LAP AND SHOULDER BELT COULD NOT BE WORN BY A VEHICLE OCCUPANT. IN THE EVENT THAT THE MECHANISM DOES NOT ALLOW THE ALR MODE TO BE ENGAGED, THE OPERATOR MAY BE UNABLE TO PROPERLY INSTALL A CHILD SEAT IN THAT SEATING POSITION.
Remedy: DEALERS WILL INSPECT THE LAP AND SHOULDER BELT ASSEMBLIES. ASSEMBLIES WITH JULIAN DATE CODES OF 200 THROUGH 223 ARE SUSPECT AND WILL BE REPLACED.
98V288000 · Power Train:automatic Transmission:cooling Unit And Lines
Nov 9, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUPPED WITH THE "CALIFORNIA" EMISSIONS PACKAGE. AN INCORRECT TRANSMISSION OIL COOLER LINE WAS INSTALLED. THE LINE CONTACTS THE ANTI-LOCK BRAKING SYSTEM MODULE SUPPORT BRACKET AND OVER TIME, CAN WEAR AND DEVELOP A LEAK.
Consequence & remedy
Consequence: TRANSMISSION FLUID LEAKAGE ONTO THE EXHAUST MANIFOLD OR CATALYTIC CONVERTER CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL THE APPROPRIATE TRANSMISSION OIL COOLER LINE.
98V204000 · Vehicle Speed Control
Sep 1, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DASH INSULATOR RETAINER CLIP WAS NOT FULLY ASSEMBLED TO THE ACCELERATOR CABLE DASH FITTING. THE CLIP CAN DISENGAGE FROM THE ACCELERATOR CABLE AND FALL INTO THE ACCELERATOR PEDAL ARM PIVOT AREA.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE ENGINE MAY NOT FULLY RETURN TO IDLE. ALSO, THE INSULATOR MAY NOT STAY IN THE INTENDED LOCATION AND COULD INTERFERE WITH THE ACCELERATOR CABLE.
Remedy: DEALERS WILL INSPECT THESE VEHICLES TO ENSURE PROPER INSTALLATION OF THE ACCELERATOR CABLE CLIP, AND RE-INSTALL IF NEEDED.
98V198000 · Seat Belts:front:anchorage
Aug 25, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL SEAT TRACKS. THE FRONT SEAT BELT BUCKLE ATTACHING STUD MAY HAVE BEEN IMPROPERLY HEAT TREATED. THIS HEAT TREATMENT MAY HAVE RESULTED IN CRACKS DEVELOPING IN THE STUD.
Consequence & remedy
Consequence: IF THE STUD IS CRACKED, IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE SEAT BELT BUCKLE MOUNTING BRACKET AND STUD ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE04044 · Front Suspension Coil Spring Fracture
Opened May 24, 2004 · Closed Aug 16, 2004
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Additional source detail variants (2)
Suspension:front
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
PE02080 · Front Suspension Coil Spring Fracture
Opened Oct 22, 2002 · Closed Apr 29, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (2)
Suspension
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.