NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
81 reportsClear category filterMileage unknown · Oct 31, 2001
Engine And Engine CoolingFuel System, Gasoline
MY TAURUS LEAKS FUEL AFTER FILLING THE TANK. THE DEALER REPLACED THE ROLLOVER VALVE, VAPOR CANISTER AND EVAPORATOR SOLENOID AND A HOSE CLIP ON MARCH 1, 01. IN OCTOBER 2001 I AGAIN NOTICED FUEL DRIPPING FROM THE TANK AREA AFTER REFUELLING. THE DEALER IS ORDERING A NEW TANK. FORD TECH HOTLINE SAYS THERE MAY BE ANOTHER DEFECTIV…
Read full complaint
MY TAURUS LEAKS FUEL AFTER FILLING THE TANK. THE DEALER REPLACED THE ROLLOVER VALVE, VAPOR CANISTER AND EVAPORATOR SOLENOID AND A HOSE CLIP ON MARCH 1, 01. IN OCTOBER 2001 I AGAIN NOTICED FUEL DRIPPING FROM THE TANK AREA AFTER REFUELLING. THE DEALER IS ORDERING A NEW TANK. FORD TECH HOTLINE SAYS THERE MAY BE ANOTHER DEFECTIVE ROLLOVER VALVE INSIDE THE TANK. THIS POSES A SAFETY HAZARD WHICH I BELIEVE SHOULD BE REPORTED.
NHTSA ODI #753940
Mileage unknown · Oct 4, 2001
Engine And Engine Cooling
WHILE DRIVING 55 MPH VEHICLE WILL COMPLETELY SHUTDOWN WITHOUT WARNING, CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS.*AK
NHTSA ODI #897373
Mileage unknown · Sep 2, 2001
Engine And Engine CoolingPower TrainVisibility
THE VEHICLE HAD SMELLY EXHAUST.*YH
NHTSA ODI #563037
Mileage unknown · Aug 22, 2001
Engine And Engine CoolingFuel System, GasolinePower Train
I COMPLAINED ABOUT THIS CAR THE DAY I BOUGHT IT. I TOLD THEM IT WAS A LEMON AND I WANTED MY MONEY BACK. THE DEALER REFUSED. FROM THE DAY I BOUGHT THE CAR (ONE YEAR AGO) IT IS HAS BEEN IN THE SHOP FOR A TOTAL OF OVER 8 WEEKS. IT HAS HAD REPLACEMENT TRANSMISSION, CATALYTIC CONVERTERS, GASKETS, PUMPS, HOSES, FILTERS AND IT STILL…
Read full complaint
I COMPLAINED ABOUT THIS CAR THE DAY I BOUGHT IT. I TOLD THEM IT WAS A LEMON AND I WANTED MY MONEY BACK. THE DEALER REFUSED. FROM THE DAY I BOUGHT THE CAR (ONE YEAR AGO) IT IS HAS BEEN IN THE SHOP FOR A TOTAL OF OVER 8 WEEKS. IT HAS HAD REPLACEMENT TRANSMISSION, CATALYTIC CONVERTERS, GASKETS, PUMPS, HOSES, FILTERS AND IT STILL DOES NOT RUN. IT DOESN'T START PROPERLY, IF IT STARTS AT ALL. IT STALLS IN REVERSE AND INITITAL SHIFT INTO DRIVE DOES NOT RUN SMOOTH. THE WIPER FLUID DOES NOT COME OUT. THE CAR RATTLES AND SOUNDS AWFUL . THE CAR IS UNDER MANUFACTURER WARRANTY AND THEY WON'T FIX IT. THE CAR IS A LEMON THERE IS SOMETHING FUNDAMENTALLY WRONG WITH IT AND IT CAN'T BE FIXED. FORD KNOWS THIS AND THEY WON'T TAKE IT BACK.
NHTSA ODI #750906
Mileage unknown · Jul 26, 2001
Engine And Engine Cooling
A BLOCK IN THE ENGINE SHOULDNT CRACK WITHIN 3 MONTHS OF BUYING A VEHICLE UNLESS THERE WAS A PROBLEM WITH IT EARLIER, IM RUNNING A BACKGROUND CHECK WITH LAWYER. PLEASE HELP. *AK
NHTSA ODI #749213
Mileage unknown · Jun 5, 2001
Engine And Engine CoolingService Brakes, HydraulicSuspension
FOUL ODOR IN PSGR COMPARTMENT AFTER ENG GETS HOT (20 MIN); RETD TO DLR 3X, DLR=NO PROB FOUND;BRAKES=PULSATE,TURNED ROTORS;INTERMITTENT WASHER SPRAY WHEN WIPERS ON(WASHER FLUID NOT ACTIVATED) =TURN SIGNAL SW RPLCD;BROKEN MO MOUNT FOUND, DLR REPLCD; SWAY BAR BRKN, DLR REPLCD; DLR BOUGHT VEHL BACK DUE TO ODOR PROBLEM-SLSMAN & UV MG…
Read full complaint
FOUL ODOR IN PSGR COMPARTMENT AFTER ENG GETS HOT (20 MIN); RETD TO DLR 3X, DLR=NO PROB FOUND;BRAKES=PULSATE,TURNED ROTORS;INTERMITTENT WASHER SPRAY WHEN WIPERS ON(WASHER FLUID NOT ACTIVATED) =TURN SIGNAL SW RPLCD;BROKEN MO MOUNT FOUND, DLR REPLCD; SWAY BAR BRKN, DLR REPLCD; DLR BOUGHT VEHL BACK DUE TO ODOR PROBLEM-SLSMAN & UV MGR WERE WONDERFUL, SERV DEPT =DEPENDS ON TECH INVOLVED; BOUGHT 2000 TAU SES FR BD FORD. *AK
NHTSA ODI #746459
Mileage unknown · Apr 10, 2001
Electrical SystemEngine And Engine Cooling
WHEN THE FAN FOR THE RADIATOR TURNS ON THE ALL THE LIGHTS DIM FOR A FEW SECONDS WHEN SHUTS OFF IT GOES BACK UP I TOOK IT TO FORD DEALER AND THEY SAID IT WAS THE ALTERNATER AND THEY REPLACED IT WITH A USED ALTERNATER WICH THE CAR IS STILL UNDER WARRENT WHEN I GOT THE CAR AT NORMAL TEMP AND THE FAN KICKS ON IT STILLS DOES IT EVEN …
Read full complaint
WHEN THE FAN FOR THE RADIATOR TURNS ON THE ALL THE LIGHTS DIM FOR A FEW SECONDS WHEN SHUTS OFF IT GOES BACK UP I TOOK IT TO FORD DEALER AND THEY SAID IT WAS THE ALTERNATER AND THEY REPLACED IT WITH A USED ALTERNATER WICH THE CAR IS STILL UNDER WARRENT WHEN I GOT THE CAR AT NORMAL TEMP AND THE FAN KICKS ON IT STILLS DOES IT EVEN AFTER THEY REPLACE THE ALTERNATER SO I CALLED THEM BACK AND NOW THEY ARE SAYING IT IS NORMAL FOR THE LIGHT TO DIM BUT ALL THE OTHER CARS I HAVE DRIVEN HAVE DONE THIS. *AK
NHTSA ODI #743804
Mileage unknown · Mar 13, 2001
Engine And Engine Cooling
NOTICED A FOUL ODOR COMING THROUGH VENTS. HAD OIL CHANGE, ASKED DEALER TO CHECK COOLANT. DEALER FOUND THAT OIL HAD LEAKED INTO THE COOLANT. DEALER RECOMMENDS REPLACING ENGINE.*AK
NHTSA ODI #742380
Mileage unknown · Feb 23, 2001
Engine And Engine Cooling
EGR VALVE MALFUNCTIONED. *AK
NHTSA ODI #881317
Mileage unknown · Jan 8, 2001
Engine And Engine Cooling
EXCELLENT SVC HISTORY, ENGINE BLEW AFTER WARRANTY, FORD MOTOR COMPANY AND DEALER WOULDN'T COVER AND I DEFENITELY COULD NOT AFFORD A NEW ENGINE/REPLACEMENT , SURRENDERED VEHICLE UNDER BANKRUPTSY, QUITE SURPRISED VEHICLE ENGINE EXPIRED AT SUCH LOW MILEAGE. I WILL BE HAPPY TO PROVIDE ANY PRIOR SERVICE REPORTS, FROM OIL CHANGES TO A…
Read full complaint
EXCELLENT SVC HISTORY, ENGINE BLEW AFTER WARRANTY, FORD MOTOR COMPANY AND DEALER WOULDN'T COVER AND I DEFENITELY COULD NOT AFFORD A NEW ENGINE/REPLACEMENT , SURRENDERED VEHICLE UNDER BANKRUPTSY, QUITE SURPRISED VEHICLE ENGINE EXPIRED AT SUCH LOW MILEAGE. I WILL BE HAPPY TO PROVIDE ANY PRIOR SERVICE REPORTS, FROM OIL CHANGES TO ANYTHING. THANKS.*AK
NHTSA ODI #739028
Official recalls
5Jul 15, 2004
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSION ASSOCIATED WITH SALT USED ON THE ROADWAYS DURING THE WINTER. A FRACTURED SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL REPLACE BOTH FRONT SPRINGS AT NO CHARGE TO THE OWNER. AN INTERIM NOTICE WAS SENT TO OWNERS ON AUGUST 2, 2004. PARTS ARE NOW AVAILABLE FOR THE 2000-2001 MY VEHICLES AND OWNERS WERE SENT A LETTER ON JANUARY 10, 2005, ADVISING THEM TO BRING IN THEIR VEHICLES FOR REPAIR PARTS ARE EXPECTED TO BE AVAILABLE FOR THE 1999 MY VEHICLES BY THE END OF FEBRUARY 2005 AND OWNERS OF THESE VEHICLES WILL BE NOTIFIED THEN. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Sep 20, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.
Consequence & remedy
Consequence: IF THE MECHANISM MALFUNCTIONS AND DOES NOT ALLOW THE WEBBING TO BE EXTRACTED, THE LAP AND SHOULDER BELT COULD NOT BE WORN BY A VEHICLE OCCUPANT. IN THE EVENT THAT THE MECHANISM DOES NOT ALLOW THE ALR MODE TO BE ENGAGED, THE OPERATOR MAY BE UNABLE TO PROPERLY INSTALL A CHILD SEAT IN THAT SEATING POSITION.
Remedy: DEALERS WILL INSPECT THE LAP AND SHOULDER BELT ASSEMBLIES. ASSEMBLIES WITH JULIAN DATE CODES OF 200 THROUGH 223 ARE SUSPECT AND WILL BE REPLACED.
Nov 9, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUPPED WITH THE "CALIFORNIA" EMISSIONS PACKAGE. AN INCORRECT TRANSMISSION OIL COOLER LINE WAS INSTALLED. THE LINE CONTACTS THE ANTI-LOCK BRAKING SYSTEM MODULE SUPPORT BRACKET AND OVER TIME, CAN WEAR AND DEVELOP A LEAK.
Consequence & remedy
Consequence: TRANSMISSION FLUID LEAKAGE ONTO THE EXHAUST MANIFOLD OR CATALYTIC CONVERTER CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL THE APPROPRIATE TRANSMISSION OIL COOLER LINE.
Sep 1, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DASH INSULATOR RETAINER CLIP WAS NOT FULLY ASSEMBLED TO THE ACCELERATOR CABLE DASH FITTING. THE CLIP CAN DISENGAGE FROM THE ACCELERATOR CABLE AND FALL INTO THE ACCELERATOR PEDAL ARM PIVOT AREA.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE ENGINE MAY NOT FULLY RETURN TO IDLE. ALSO, THE INSULATOR MAY NOT STAY IN THE INTENDED LOCATION AND COULD INTERFERE WITH THE ACCELERATOR CABLE.
Remedy: DEALERS WILL INSPECT THESE VEHICLES TO ENSURE PROPER INSTALLATION OF THE ACCELERATOR CABLE CLIP, AND RE-INSTALL IF NEEDED.
Aug 25, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL SEAT TRACKS. THE FRONT SEAT BELT BUCKLE ATTACHING STUD MAY HAVE BEEN IMPROPERLY HEAT TREATED. THIS HEAT TREATMENT MAY HAVE RESULTED IN CRACKS DEVELOPING IN THE STUD.
Consequence & remedy
Consequence: IF THE STUD IS CRACKED, IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE SEAT BELT BUCKLE MOUNTING BRACKET AND STUD ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE04044 · Front Suspension Coil Spring Fracture
Opened May 24, 2004 · Closed Aug 16, 2004
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Additional source detail variants (2)
Suspension:front
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
PE02080 · Front Suspension Coil Spring Fracture
Opened Oct 22, 2002 · Closed Apr 29, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (2)
Suspension
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Illustration