NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
81 reportsClear category filterMileage unknown · Oct 14, 2005
Engine And Engine Cooling
CONSUMER VEHICLE MADE A LOUD SCREECHING NOISE AND THEN DIED. *TS*** NAR RECEIVED 10-12-05*** WHEN THE VEHICLE WENT THROUGH PUDDLES THE CONSUMER HEARD A LOUD NOISE ON THE PASSENGER SIDE WHICH WAS FOLLOWED BY THE POWER STEERING LOCKING UP AND STALLING. THE DEALER CONCLUDED THAT THE PROBLEM WAS THE CRANK PULLEY, TENSIONER OR IDL…
Read full complaint
CONSUMER VEHICLE MADE A LOUD SCREECHING NOISE AND THEN DIED. *TS*** NAR RECEIVED 10-12-05*** WHEN THE VEHICLE WENT THROUGH PUDDLES THE CONSUMER HEARD A LOUD NOISE ON THE PASSENGER SIDE WHICH WAS FOLLOWED BY THE POWER STEERING LOCKING UP AND STALLING. THE DEALER CONCLUDED THAT THE PROBLEM WAS THE CRANK PULLEY, TENSIONER OR IDLER PULLEY. THE DEALER ALSO REPLACED THE SERPENTINE BELT. THE CONSUMER REQUESTED REIMBURSEMENT FROM THE MANUFACTURER. *NM
NHTSA ODI #10141021
1,000 miles · Oct 6, 2005
Electrical SystemEngine And Engine CoolingExterior Lighting
DT: THE CONTACT HAS A 1999 FORD TAURUS AND HAS HAD CONSISTENT PROBLEMS WITH THE CAR SINCE IT WAS BOUGHT NEW. SHE HAS BEEN COMPLAINING FOR THE LAST 48,000 MILES FOR THE SAME THINGS. MOST RECENTLY LAST WEEK SHE TOOK VEHICLE TO THE DEALER FOR A LEAK IN THE MASTER CYLINDER, WHICH THEY REPAIRED. . THEY CLEANED THE HUBS. SHE HAD …
Read full complaint
DT: THE CONTACT HAS A 1999 FORD TAURUS AND HAS HAD CONSISTENT PROBLEMS WITH THE CAR SINCE IT WAS BOUGHT NEW. SHE HAS BEEN COMPLAINING FOR THE LAST 48,000 MILES FOR THE SAME THINGS. MOST RECENTLY LAST WEEK SHE TOOK VEHICLE TO THE DEALER FOR A LEAK IN THE MASTER CYLINDER, WHICH THEY REPAIRED. . THEY CLEANED THE HUBS. SHE HAD TO PUSH THE BRAKES ALL THE WAY TO GET THE CAR TO STOP. THEY REPLACED BRAKE BOOSTER, MACHINED ROTORS, AND PUT NEW BRAKE PADS ON. AT 1,700 MILES HAD TO TAKE VEHICLE TO DEALER FOR A NOISE SHE FROM THE BRAKES. THEY CLEANED THE HUBS. AT 22,466 BRAKES AND SERPENTINE BELT WERE CHECKED. THEY PUT A NEW SERPENTINE BELT ON AT 22,500 MILES. ALSO, HAD MULTIPLE ELECTRICAL PROBLEMS WITH THE CAR. 4 MULTIFUNCTION SWITCHES WERE REPLACED. IN ADDITION, A HEAD LAMP CONTROL SWITCH WAS REPLACED AT 17,000 MILE, AND A NEW RADIO PUT IN.*AK THE A/C HAD ALO BEE WORKED ON TWICE. *NM
NHTSA ODI #10132429
64,000 miles · Aug 19, 2005
Engine And Engine Cooling
I NOTICED PROBLEMS WITH MY AIR AND HEAT IN MY 1999 FORD TAURUS. WHEN I TOOK IT TO A MECHANIC, I WAS TOLD THAT A FREEZE PLUG ON MY ENGINE HAD RUSTED THROUGH, AND ANTIFREEZE WAS LEAKING OUT OF THE CAR. I SPENT A LITTLE OVER $200 TO REPLACE THE FREEZE PLUG (MOSTLY LABOR CHARGES). TWO MONTHS LATER, MY AIR CONDITIONER STOPPED WORK…
Read full complaint
I NOTICED PROBLEMS WITH MY AIR AND HEAT IN MY 1999 FORD TAURUS. WHEN I TOOK IT TO A MECHANIC, I WAS TOLD THAT A FREEZE PLUG ON MY ENGINE HAD RUSTED THROUGH, AND ANTIFREEZE WAS LEAKING OUT OF THE CAR. I SPENT A LITTLE OVER $200 TO REPLACE THE FREEZE PLUG (MOSTLY LABOR CHARGES). TWO MONTHS LATER, MY AIR CONDITIONER STOPPED WORKING AGAIN, SO I CHECKED ON THE ANTIFREEZE LEVEL, AND IT WAS AGAIN EMPTY. THE MECHANIC TOLD ME THAT ANOTHER FREEZE PLUG HAD FAILED, AND HE ESTIMATED IT WOULD BE BETWEEN $250 AND $450 TO REPLACE IT. I DO HAVE THE FIRST FREEZE PLUG; THE SECOND HAS NOT BEEN REPLACED YET.
NHTSA ODI #10133572
Mileage unknown · Jan 25, 2005
Engine And Engine Cooling
COOLING SYSTEM BROKEN, REPLACED FAULTY OIL PAN GASKET AND HEATER SUPPLY HOSE. *BF *JB
NHTSA ODI #10109724
76,000 miles · Jan 11, 2005
Engine And Engine Cooling
ALTERNATOR BELTS BREAKING. NEW ALTERNATOR BELT LASTING FOR ONLY 1 MILE, THEN SHREDDING AGAIN. HAD TO GET ENTIRE PULLEY SYSTEM REPLACED. *AK
NHTSA ODI #10106108
Mileage unknown · Oct 7, 2004
Engine And Engine Cooling
WHEN STARTING VEHICLE IT BEGAN TO SHAKE, AND THEN THE CHECK ENGINE LIGHT CAME ON. DROVE THE VEHICLE HOME BUT AT A VERY SLOW PACE. SHE VEHICLE ACTED AS IF IT DID NOT WANT TO GO. CONSUMER STATED LAST WEEK THE VEHICLE WOULD NOT START AT ALL. SHE HAD THE VEHICLE TOWED TO A MECHANIC, WHO DETERMINED THAT VEHICLE NEEDED A TIMING BE…
Read full complaint
WHEN STARTING VEHICLE IT BEGAN TO SHAKE, AND THEN THE CHECK ENGINE LIGHT CAME ON. DROVE THE VEHICLE HOME BUT AT A VERY SLOW PACE. SHE VEHICLE ACTED AS IF IT DID NOT WANT TO GO. CONSUMER STATED LAST WEEK THE VEHICLE WOULD NOT START AT ALL. SHE HAD THE VEHICLE TOWED TO A MECHANIC, WHO DETERMINED THAT VEHICLE NEEDED A TIMING BELT, WHICH SHE HAD PUT ON. *AK
NHTSA ODI #10095434
78,000 miles · Sep 24, 2004
Engine And Engine CoolingService Brakes, Hydraulic
A NEW OIL PUMP WAS REPLACED AND THE ENGINE WAS STILL KNOCKING. DEALER STATED THAT THE LIFTERS WERE BAD. ALSO, BRAKES WERE REPLACED FOUR TIMES.*AK
NHTSA ODI #10094298
Mileage unknown · Sep 23, 2004
Engine And Engine Cooling
WHILE DRIVING, THE VEHICLE STALLED WITHOUT WARNING. THE CONSUMER TRIED TO RESTART THE VEHICLE BUT WAS UNABLE TO DO SO. THE CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE CONSUMER THAT THE HEAD GASKET BLEW AND NEEDED REPLACEMENT. PLEASE FILL IN ADDITIONAL INFORMATION. *JB
NHTSA ODI #10094215
Mileage unknown · Sep 14, 2004
Engine And Engine Cooling
VEHICLE WAS TAKEN TO THE DEALER FOR A ROUTINE CHECK UP, AND MECHANIC DETERMINED THAT OIL WAS LEAKING FROM UNDERNEATH THE VEHICLE, AND THAT THE OIL GASKET NEEDED TO BE REPLACED. *AK THE CONSUMER WROTE THAT HE SHOULD BE REFUNDED MONEY PAID FOR THE WORK THAT HAD TO BE DONE *TC
NHTSA ODI #10087737
Mileage unknown · Aug 18, 2004
Engine And Engine Cooling
CONSUMER STATED THAT FORD CHANGED THE GASKET IN THE FORD TAURUS. THE GASKET MELTED, AND WATER ENTERED INTO THE ENGINE, WHICH MADE THE VEHICLE INOPERABLE. *AK
NHTSA ODI #10089211
Official recalls
5Jul 15, 2004
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSION ASSOCIATED WITH SALT USED ON THE ROADWAYS DURING THE WINTER. A FRACTURED SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL REPLACE BOTH FRONT SPRINGS AT NO CHARGE TO THE OWNER. AN INTERIM NOTICE WAS SENT TO OWNERS ON AUGUST 2, 2004. PARTS ARE NOW AVAILABLE FOR THE 2000-2001 MY VEHICLES AND OWNERS WERE SENT A LETTER ON JANUARY 10, 2005, ADVISING THEM TO BRING IN THEIR VEHICLES FOR REPAIR PARTS ARE EXPECTED TO BE AVAILABLE FOR THE 1999 MY VEHICLES BY THE END OF FEBRUARY 2005 AND OWNERS OF THESE VEHICLES WILL BE NOTIFIED THEN. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Sep 20, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.
Consequence & remedy
Consequence: IF THE MECHANISM MALFUNCTIONS AND DOES NOT ALLOW THE WEBBING TO BE EXTRACTED, THE LAP AND SHOULDER BELT COULD NOT BE WORN BY A VEHICLE OCCUPANT. IN THE EVENT THAT THE MECHANISM DOES NOT ALLOW THE ALR MODE TO BE ENGAGED, THE OPERATOR MAY BE UNABLE TO PROPERLY INSTALL A CHILD SEAT IN THAT SEATING POSITION.
Remedy: DEALERS WILL INSPECT THE LAP AND SHOULDER BELT ASSEMBLIES. ASSEMBLIES WITH JULIAN DATE CODES OF 200 THROUGH 223 ARE SUSPECT AND WILL BE REPLACED.
Nov 9, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUPPED WITH THE "CALIFORNIA" EMISSIONS PACKAGE. AN INCORRECT TRANSMISSION OIL COOLER LINE WAS INSTALLED. THE LINE CONTACTS THE ANTI-LOCK BRAKING SYSTEM MODULE SUPPORT BRACKET AND OVER TIME, CAN WEAR AND DEVELOP A LEAK.
Consequence & remedy
Consequence: TRANSMISSION FLUID LEAKAGE ONTO THE EXHAUST MANIFOLD OR CATALYTIC CONVERTER CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL THE APPROPRIATE TRANSMISSION OIL COOLER LINE.
Sep 1, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DASH INSULATOR RETAINER CLIP WAS NOT FULLY ASSEMBLED TO THE ACCELERATOR CABLE DASH FITTING. THE CLIP CAN DISENGAGE FROM THE ACCELERATOR CABLE AND FALL INTO THE ACCELERATOR PEDAL ARM PIVOT AREA.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE ENGINE MAY NOT FULLY RETURN TO IDLE. ALSO, THE INSULATOR MAY NOT STAY IN THE INTENDED LOCATION AND COULD INTERFERE WITH THE ACCELERATOR CABLE.
Remedy: DEALERS WILL INSPECT THESE VEHICLES TO ENSURE PROPER INSTALLATION OF THE ACCELERATOR CABLE CLIP, AND RE-INSTALL IF NEEDED.
Aug 25, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL SEAT TRACKS. THE FRONT SEAT BELT BUCKLE ATTACHING STUD MAY HAVE BEEN IMPROPERLY HEAT TREATED. THIS HEAT TREATMENT MAY HAVE RESULTED IN CRACKS DEVELOPING IN THE STUD.
Consequence & remedy
Consequence: IF THE STUD IS CRACKED, IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE SEAT BELT BUCKLE MOUNTING BRACKET AND STUD ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE04044 · Front Suspension Coil Spring Fracture
Opened May 24, 2004 · Closed Aug 16, 2004
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Additional source detail variants (2)
Suspension:front
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
PE02080 · Front Suspension Coil Spring Fracture
Opened Oct 22, 2002 · Closed Apr 29, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (2)
Suspension
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Illustration