NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
67 reportsClear category filterMileage unknown · Aug 31, 2000
Engine And Engine Cooling
CAR STALLS WITHOUT WARNING. WE HAVE LIMITED OUR USE OF THIS VEHICLE BECAUSE OF THE PROBLEM WITH IT STALLING UNEXPECTANTLY DURING TRIPS OF ANY LONG DURATION. THE CAR IS USED ONLY ON VERY SHORT TRIPS OF LESS THAN 10 MILES. CAR HAS STALLED IN THE MIDDLE OF TRAFFIC NUMEROUS TIMES AND HAD TO BE PUSHED TO THE SIDE OF THE ROAD IN HEAVY…
Read full complaint
CAR STALLS WITHOUT WARNING. WE HAVE LIMITED OUR USE OF THIS VEHICLE BECAUSE OF THE PROBLEM WITH IT STALLING UNEXPECTANTLY DURING TRIPS OF ANY LONG DURATION. THE CAR IS USED ONLY ON VERY SHORT TRIPS OF LESS THAN 10 MILES. CAR HAS STALLED IN THE MIDDLE OF TRAFFIC NUMEROUS TIMES AND HAD TO BE PUSHED TO THE SIDE OF THE ROAD IN HEAVY TRAFFIC SO THEREFORE DID NOT DRIVE IT ON FREEWAY TRAFFIC. IF THE CAR SET FOR A HALF HOUR OR MORE IT WOULD START AGAIN BUT STALL AGAIN IF TRIP WAS OF ANY LONG DURATION. STALLED ON A FAMILY VACATION IN HEAVY TRAFFIC ALMOST CAUSING A REAR END ACCIDENT. DURING ONE TRIP OF 30 MILES CAR STALLED AND TRIP ENDED UP TAKING 2 HOURS TO TRY AND DRIVE THE CAR HOME WHEN THE USUAL TRIP WOULD HAVE TAKEN 30-40 MINUTES. CAR GUAGES WOULD NOT SHOW ANY OVER HEATING OR PROBLEM.
NHTSA ODI #729663
Mileage unknown · Mar 22, 2000
Engine And Engine Cooling
TEMPERATURE WENT UP, AND LARGE AMOUNT OF WHITE VAPOR CAME FROM OUT OF TAIL PIPE. DEALER SAID WARRANTY DID NOT EXTEND BACK THAT FOR BECAUSE OF THE YEAR OF VEHICLE. *AK
NHTSA ODI #859003
Mileage unknown · Mar 8, 2000
Engine And Engine Cooling
HEAD GASKET FAILURE DESTROYED THE ENGINE. THIS CAUSED VEHICLE TO BREAKDOWN IN THE MIDDLE OF THE ROAD, AND HAD TO BE TOWED. CONSUMER HAD TO REPLACE 2 WATER PUMPS, RADIATOR, OIL PUMP AND HEAD SEALS IN ADDITION TO ENGINE WORK. *AK *ML
NHTSA ODI #858112
Mileage unknown · Feb 4, 2000
Engine And Engine Cooling
WHILE DRIVING ON THE HIGHWAY AND CHANGING LANES VEHICLE ENGINE COMPLETELY SHUTS DOWN WITHOUT WARNING, CAUSE UNKNOWN. DEALER CANNOT IDENTIFY THE CAUSE OF THE PROBLEM. PLEASE GIVE ANY FURTHER DETAILS. *AK
NHTSA ODI #856263
Mileage unknown · Aug 10, 1999
Electrical SystemEngine And Engine Cooling
WHILE DRIVING DOWN HIGHWAY VEHICLE STALLS. WHEN THE CAR OVERHEATS, THE WIRING HARNESS SITUATED BY THE AIR CONDITIONING AND RIGHT REAR OF THE ENGINE COMPARMENT THE CONDENSOR, HEATS UP ALSO.THIS HAPPENS DURING HOT WEATHER. *AK
NHTSA ODI #844790
Mileage unknown · Jul 8, 1999
Engine And Engine CoolingExterior LightingSteering
I HAVE SERVICE RECORDS DOCUMENTING ALL FAILURES AND I SEE FROM NUMEROUS WEBSITES THAT OTHER TAURUS CUSTOMERS ARE FURIOUS AT MANY PROBLEMS OF THIS CAR. ADVERTISING BY FORD SEEMS ALMOST FRAUDULENT AND BASED ON NUMEROUS COMPLAINTS REPORTED TO THEM I BELIEVE THIS CONSTITUTES DELIBERATE FRAUD. THOSE OF US WHO HAVE INTEGRITY HAVEN'T P…
Read full complaint
I HAVE SERVICE RECORDS DOCUMENTING ALL FAILURES AND I SEE FROM NUMEROUS WEBSITES THAT OTHER TAURUS CUSTOMERS ARE FURIOUS AT MANY PROBLEMS OF THIS CAR. ADVERTISING BY FORD SEEMS ALMOST FRAUDULENT AND BASED ON NUMEROUS COMPLAINTS REPORTED TO THEM I BELIEVE THIS CONSTITUTES DELIBERATE FRAUD. THOSE OF US WHO HAVE INTEGRITY HAVEN'T PASSED OUR LEMON CARS ON TO OTHER POOR IGNORANT SOULS BUT THE ENTIRE OWNERSHIP PERIOD OF THIS FORD TAURUS HAS CAUSED ME TO SUFFER SEVERE DEPRESSION AND STRESS AND HAS CAUSED INJURY ON AT LEAST TWO OCCASIONS. I'M AT THE POINT OF JUST DONATING THE CAR TO CHARITY FOR PARTS BUT I INTEND TO BECOME VOCIFEROUSLY INVOLVED IN LAWSUIT AGAINST FORD. NO WONDER THE TAURUS IS NO LONGER THE BEST SELLING CAR IN AMERICA. BUT I THINK IT'S YOUR RESPONSIBILITY TO GET FORD FOR THIS. THEIR BEHAVIOR IS UNACCEPTABLE. NO SAFETY DEFECT MENTIONED. *AK
NHTSA ODI #708365
Mileage unknown · Jul 8, 1999
Engine And Engine CoolingPower TrainService Brakes, HydraulicCrash
LEMON SINCE THE DAY I GOT IT. FORD WON'T HONOR HERTZ RESALES. AT 31K ENGINE AND TRANSMISSION BLEW; MULTIPLE TRANSMISSION PROBLEMS, LIST OF DEFECTS WOULD BE TWO PAGES LONG--SOME MAY STEM FROM SEVERE CORROSION ON UNDERSIDE BUT CAR WAS ONLY ON EAST COAST FOR 1 YEAR. FORD NONRESPONSIVE. *AK
NHTSA ODI #708363
Mileage unknown · Jun 16, 1999
Engine And Engine Cooling
FOUR TIMES WITHIN THE LAST 2 MONTHS WHEN THE WEATHER WAS VERY HOT, VEHICLE STALLED. DEALER IS NOT ABLE TO FIND A REASON FOR THE PROBLEM. PLEASE PROVIDE ANY FURTHER DETAILS. *AK
NHTSA ODI #840100
Mileage unknown · Jun 9, 1999
Engine And Engine Cooling
CONSUMER TOOK VEHICLE TO DEALERSHIP FOR THE SUBFRAME CORROSION RECALL, WHEN SHE TOOK VEHICLE TO MECHANIC FOR CHECK UP, MECHANIC NOTICED THAT THE FRONT MOTOR MOUNTS WERE MISSING, DEALERSHIP DID NOT TELL CONSUMER HER ENGINE MOUNTS WERE MISSING, WHEN SHE BEGAN TO DRIVE THE ENGINE WAS MOVING AROUND.
NHTSA ODI #839158
Mileage unknown · Jun 3, 1999
Engine And Engine CoolingPower Train
FORD TAURUS - HISTORY OF MULTIPLE FAILURES EVEN ON THIS INDIVIDUAL VEHICLE. AXLE FAILED TWICE, CYLINDER HEAD CRACKED TWICE (DIFFERENT UNITS), FRONT DRIVE AXLE SUFFERED COMPLETE FAILURE, PLASTIC RADIATOR FATIGUED AT MOUNTING POINT AND CRACKED. I WANTED TO ADD THIS INFO FOR YOUR HISTORICAL RECORDS. *AK
NHTSA ODI #707166
Official recalls
5Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
Jun 23, 1993
VEHICLE DESCRIPTION: TAURUS AND SABLES BUILT FROM 10-14-85 THROUGH 8-19-88, AND LINCOLN CONTINENTALS BUILT FROM 11-4-87 THROUGH 9-30-88 (EXCEPT 1989 - 1991 2.5L TAURUS AND 1989 - 1992 SHO). THE AFFECTED CARS WERE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WISCONSIN. THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, MAY BECOME DETACHED DUE TO CORROSION OF THE SUBFRAME MOUNT RETAINING PLATE. THIS WOULD ALLOW THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF ONE OF THE REAR CORNERS DROPS, ONLY MINOR INDICATIONS OF A MALFUNCTION SUCH AS A CLUNKING NOISE OR SLIGHT CHANGE IN STEERING WHEEL ALIGNMENT ARE NOTICEABLE. HOWEVER, IF BOTH REAR CORNERS OF THE SUBFRAME DROP, STEERING BECOMES VERY DIFFICULT, WHICH COULD ADVERSELY AFFECT VEHICLE CONTROL AND POSSIBLY RESULT IN AN ACCIDENT.
Remedy: INSTALL A CORROSION-RESISTANT REINFORCING PLATE AND A NEW BOLT ON BOTH REAR SUBFRAME MOUNTS. THIS RECALL CAMPAIGN HAS BEEN SUPERSEDED BY RECALL 98V-323.
May 11, 1992
CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.
Consequence & remedy
Consequence: THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.
Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.
Aug 6, 1991
FRONT DISC BRAKE ROTORS OF THE SUBJECT VEHICLES MAY EXPERIENCE SEVERE CORROSION IF OPERATED IN AREAS WHERE CALCIUM CHLORIDE AND SODIUM CHLORIDE ARE USED EXTENSIVELY.
Consequence & remedy
Consequence: SEVERELY CORRODED ROTORS MAY FRACTURE OR SEPARATE NEARTHE INNER EDGES OF THE BRAKE DISCS RESULTING IN REDUCED BRAKING EFFECTIVENESS,HIGHER THAN NORMAL PEDAL EFFORTS, LOUD GRINDING NOISES, AND MODERATE PULLS WHENTHE BRAKES ARE APPLIED. REDUCED BRAKING EFFECTIVENESS MAY INCREASE MINIMUMSTOPPING DISTANCES, POSSIBLY RESULTING IN AN ACCIDENT.
Remedy: REPLACE FRONT BRAKE ROTORS WITH FULL CAST FRONT BRAKE ROTORS.
Mar 4, 1991
THE POWER SEAT SWITCH WIRING IS ROUTED OVER RATHER THAN UNDER THE FRONT SEAT SUPPORT BRACE, ALLOWING DAMAGE BY SEAT CUSHION SPRING ENDS WHEN SEAT IS OCCUPIED.
Consequence & remedy
Consequence: POWER SEAT SWITCH WIRING INSULATION MAY BECOME ABRADED,OR PUNCTURED, AND AN ELECTRICAL SHORT COULD OCCUR THAT COULD RESULT IN A FIREIN THE SEAT CUSHION MATERIAL.
Remedy: REVISE ROUTING OF POWER SEAT WIRING TO PREVENT DAMAGE FROM SEAT CUSHION SPRING CONTACT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
23RQ97009 · Rear Lower Subframe Assembly
Opened Aug 29, 1997 · Closed Feb 16, 1999
Status: closed (inferred from source dates) · Structure:frame And Members
TO DETERMINE WHETHER THE CARS THAT WERE NOT INCLUDED IN THE SAFETY RECALL 93V-106 SHOULD BE RECALLED DUE TO THE SAME FAILURE PHENOMENON, AND TO DETERMINE IF THERE IS REMEDY FAILURE ISSUE
Additional source detail variants (2)
Structure:frame And Members
TO DETERMINE WHETHER THE CARS THAT WERE NOT INCLUDED IN THE SAFETY RECALL 93V-106 SHOULD BE RECALLED DUE TO THE SAME FAILURE PHENOMENON, AND TO DETERMINE IF THERE IS REMEDY FAILURE ISSUE
Structure:frame And Members
TO DETERMINE WHETHER THE CARS THAT WERE NOT INCLUDED IN THE SAFETY RECALL 93V-106 SHOULD BE RECALLED DUE TO THE SAME FAILURE PHENOMENON, AND TO DETERMINE IF THERE IS REMEDY FAILURE ISSUE
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93099 · Steering LCK-UP/IMPEDIMENT
Opened Nov 30, 1993 · Closed Mar 28, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93065 · Underbody Fuel Line Fails
Opened Jul 15, 1993 · Closed Nov 30, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
EA92040 · SUB-FRM/UNIBODY Absor.fail
Opened Nov 30, 1992 · Closed Jun 30, 1993
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE92056 · SUB-FRM/UNIBODY Absor.fail
Opened Jul 1, 1992 · Closed Nov 30, 1992
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE92044 · Power Steering Leaks/fires
Opened Apr 27, 1992 · Closed Aug 31, 1992
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE92014 · Engine Mount Failure
Opened Feb 4, 1992 · Closed Jun 25, 1992
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA91042 · Storage Compar Suffocation
Opened Oct 28, 1991 · Closed May 21, 1992
Status: closed (inferred from source dates) · Structure
===
PE91128 · Fires In Ignition Switch
Opened Sep 17, 1991 · Closed Jan 27, 1992
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE91108 · Storage Compar Suffocation
Opened Aug 1, 1991 · Closed Oct 28, 1991
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE91036 · Door Handles Breakage
Opened Jan 22, 1991 · Closed May 22, 1991
Status: closed (inferred from source dates) · Structure
There is no summary currently available
EA90045 · Brake Disc Hub Separations
Opened Sep 28, 1990 · Closed Sep 12, 1991
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
===
Additional source detail variants (2)
Service Brakes, Hydraulic
===
Service Brakes, Hydraulic
===
EA90042 · Throttle Sticking
Opened Aug 31, 1990 · Closed Dec 31, 1991
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE90071 · Brake Disc Hub Failure
Opened Apr 2, 1990 · Closed Jun 28, 1990
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE90066 · Throttle Sticking
Opened Mar 27, 1990 · Closed Aug 31, 1990
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE90019 · Speed Control Failure
Opened Nov 27, 1989 · Closed Mar 27, 1990
Status: closed (inferred from source dates) · Vehicle Speed Control
There is no summary currently available
EA90005 · Power Seat Malfunc/fire
Opened Oct 31, 1989 · Closed Mar 12, 1991
Status: closed (inferred from source dates) · Seats
There is no summary currently available
PE89125 · Pwr Seat Malfunc - Fire
Opened Jun 1, 1989 · Closed Oct 31, 1989
Status: closed (inferred from source dates) · Electrical System
===
PE89006 · Head Rest Drops
Opened Oct 19, 1988 · Closed Jun 26, 1989
Status: closed (inferred from source dates) · Seats:front Assembly:head Restraint
===
Illustration