Power Train. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports1 fire reports3 injury reports

What owners actually said

127 reports

Mileage unknown · Jun 17, 2026

Power Train

Read full complaint

In May of 2025, the transmision of my 2020 Ford Ranger with 35,000 miles jolted and bucked expectadly at traffic lights, I had full loss of engagement of the transmission several times, engine would rev to 4000rpm and no transmission enagement. These issues happened while at traffic stops and while driving in normal conditions. This presented on one occasion with powertrain warning light and the truck going into "limp" mode. This then reverted to no light but the issues continued, with inconsistent jolts, unable to gain speed. The jolting was abrupt and truck "leapt" forward at speed. During loss of power incidents, I was left with no ability to accelerate away from road hazards. This would have been extemely dangerous if I were turning across traffic. Ford refused to acknowledge any issues. An independent mechanic diagnosed this as a full transmission failure.

NHTSA ODI #11744781

91,955 miles · May 14, 2026

Power Train

Read full complaint

The contact owns a 2020 Ford Ranger. The contact stated that while driving, at an undisclosed speed, the vehicle began to shift hard when downshifting and upshifting. The vehicle jerked. The vehicle went into limp mode. There was a reduction of power. No warning lights illuminated. The vehicle was taken to an independent mechanic who determined the transmission needed to be replaced. The vehicle was repaired. The local dealer was contacted regarding parts, but the vehicle was not diagnosed or repaired. The manufacturer was notified. The failure mileage was approximately 91,955.

NHTSA ODI #11737883

Mileage unknown · Apr 29, 2026

EnginePower TrainUnknown Or Other

Read full complaint

Bought 2020 Ford Ranger Lariat in March 2024 with 13k miles. I have had no issues and have kept up maintenance needed. Vehicle currently has 19,128 miles and on 4/17/26 while driving the vehicle lost power. I was able to pull over and immediately called the dealership where vehicle was purchased and had towed to their facility for diagnosis. There we no warning lights prior to losing power. The dealership informed me a new transmission is needed pulling codes P0751 and P2700. The cost they informed me for replacement was $10k +/= indicating the Power Train warranty had expired in 2025. (5 yr/60,000) I find this appalling that at 19k I am responsible to replace something that has clearly had issues in past. Their only option was to replace transmission or they could take apart and overhaul to fix the codes which could be cheaper but also may result in transmission replacement anyways which will cost more in long run.

NHTSA ODI #11734620

Mileage unknown · Apr 27, 2026

Visibility/wiper

Clicking sound coming from under the dash. I traced it to the blend door assy. Defrost intermittently will disengage. Vehicle has 29,600 miles on it

NHTSA ODI #11733994

Mileage unknown · Apr 16, 2026

Engine

Read full complaint

The cylinder #1 spark plug ignition coil. Check engine light came on and the vehicle began to vibrate while traveling 70 mph. The last 30 miles of the drive on an interstate required no speed higher than 50 to prevent the vibrations. Per the independent service center, Ford has issued guidance that water could enter this compartment and rust the part. A repair costing 847.00 was completed by the mechanic, verifying it was completely rusted. Flashing check engine light came on and then steady light.

NHTSA ODI #11731585

Mileage unknown · Mar 26, 2026

Unknown Or Other

Back up camera intermittently fails to operate giving a squiggly picture or a blank black screen. I have seen many articles involving the same issues with Ford Broncos and where recalls have been issued for those vehicles. When will the NTSB be calling for Ford to recall other vehicles models having the same issues?

NHTSA ODI #11727296

Mileage unknown · Mar 21, 2026

Suspension

Read full complaint

2020 Ford Ranger XL: Total failure of both rear leaf spring assemblies (detached from bushing). Discovered during routine maintenance at approximately 47K miles. Both rear leaf spring assemblies failed in the same location where spring meets the bushing at fwd spring attachment leaving the rear of the truck supported by the rear shock assemblies only. Technician assessment showed no damage to associated rear suspension components, minimal corrosion, and no sign of collision or impact causing failure - suspect latent manufacturing defect in original OEM part as OEM has since updated original part number. Local ford service center indicated that this is a known issue however no current recall or extended warranty covered by OEM. I am in possession of all failed parts. Happy to provide info or failed parts upon request for further analysis.

NHTSA ODI #11726096

Mileage unknown · Mar 14, 2026

Power Train

Truck shifts from 1st to 3rd, hard shifting in 4th through 10th gears.

NHTSA ODI #11724318

Mileage unknown · Feb 4, 2026

Air BagsCrash

Hit a tree head-on going 30+mph. Impact point on the vehicle was next to the airbag sensor. Air bags did not deploy

NHTSA ODI #11715693

Mileage unknown · Jan 14, 2026

Power Train

My 10 speed 10r80 transmission is failing and dangerous. Besides slipping bucking and delaying shifting it now revs up without moving. I've almost been hit more than 6 times. My ford dealer changed the fluid road tested and normal all that I'm complaining about is normal.

NHTSA ODI #11710888

Official recalls

25V685000 · Equipment:electrical:engine Block Heater

Oct 10, 2025

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Consequence & remedy

Consequence: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

25V442000 · Back Over Prevention:software

Jun 27, 2025

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Consequence & remedy

Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

23V379000 · Equipment:other:labels

May 26, 2023

Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Consequence & remedy

Consequence: An overloaded vehicle increases the risk of a crash.

Remedy: Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.

21V811000 · Seat Belts:front:webbing

Oct 15, 2021

Ford Motor Company (Ford) is recalling certain 2019-2021 Ford Ranger Super Cab vehicles. The front passenger outboard seat belt may not have been assembled properly, allowing the seat belt to be misrouted. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection" and 209, "Seat Belt Assemblies."

Consequence & remedy

Consequence: A misrouted seat belt may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy: Ford will provide owners with instructions to perform a preliminary inspection of their front seat belts. Owners that detect an issue with the driver's seat belt, are unsure of the results, or do not want to perform an inspection, should not drive their vehicles and contact a Ford dealership. Dealers will inspect the front row outboard seat belts and replace them, if necessary, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed December 22, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C25.

21V765000 · Child Seat:vehicle Latch Anchor; Seats:mid/rear Assembly

Sep 30, 2021

Ford Motor Company (Ford) is recalling certain 2020-2021 Ranger Super Cab vehicles equipped with rear seats containing fixed head restraints. The fixed head restraints may interfere with proper installation of certain types of child seats. Additionally, the child seat may not attach properly to the lower-rear anchors. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child Restraint Anchorage System."

Consequence & remedy

Consequence: An improperly attached child seat can increase the risk of injury in a crash.

Remedy: Dealers will inspect the rear-lower child restraint anchorages for correct alignment and adjust as necessary. Separately, dealers will replace the non-removable head restraints with removable head restraints, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed on March 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C24.

Additional source detail variants (2)

Child Seat:vehicle Latch Anchor

Consequence: An improperly attached child seat can increase the risk of injury in a crash.

Remedy: Dealers will inspect the rear-lower child restraint anchorages for correct alignment and adjust as necessary. Separately, dealers will replace the non-removable head restraints with removable head restraints, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed on March 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C24.

Seats:mid/rear Assembly

Consequence: An improperly attached child seat can increase the risk of injury in a crash.

20V575000 · Back Over Prevention: Sensing System: Camera

Sep 23, 2020

Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Consequence & remedy

Consequence: Reduced rearward visibility can increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.

20V197000 · Power Train:automatic Transmission:gear Position Indication (prndl)

Apr 3, 2020

Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.

Consequence & remedy

Consequence: If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.

Remedy: Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ21002 · Rearview Camera Fmvss 111 Noncompliance

Opened Aug 3, 2021 · No close date supplied

Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera

On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.