Power Train. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports1 fire reports3 injury reports

Visibility complaints

5 reports

Clear category filter

86,000 miles · Jan 9, 2025

Visibility

The contact owns a 2020 Ford Ranger. The contact stated while starting the vehicle, the heating system became inoperable. The contact stated that the heater would not function properly. The vehicle was taken to the dealer where it was diagnosed that the HVAC blower motor failed and needed to be replaced. The vehicle was not repa…

Read full complaint

NHTSA ODI #11635073

Mileage unknown · Dec 18, 2023

Visibility

Vehicle has 51,532 miles and a blend door actuator needs to be replaced - inconsistent air flow coming in. The desired air wanted whether it be hot or cold, is being diverted incorrectly, so we are not getting a consistent temperature out of the A/C system. This item was recalled previously In the 2019 Ford Ranger.

NHTSA ODI #11560748

Mileage unknown · Dec 13, 2023

Visibility

Read full complaint

At one point, the heat/ac would blow air but would not heat or cool. This was about a month and a half ago., There was an electrical burning smell, and at that point the system would not heat or cool. The burning smell has since subsided. I took the truck to Santa Maria Ford to have it looked at and have my oil changed. I was told that it would cost 3500.00 to repair the issue. I looked the issue up and I found that the 2019 Ford Ranger had been recalled for this exacted issue. I felt that it was just a matter of time before the 2020 Ford Ranger would be recalled for this item. I decided to I should submit this form to be on the safe side.

NHTSA ODI #11559859

Mileage unknown · Feb 25, 2023

Visibility

This is the second time I'm hearing the climate control system click before i can adjust the temperature gauge. It was replaced less than 1,000 miles ago and it already broke again. You already put notice on the issue, SSM 49264, but it needs to be recalled with better parts. Im afraid ill be having to pay out of pocket if it ke…

Read full complaint

NHTSA ODI #11509027

Mileage unknown · Feb 2, 2023

Visibility

Read full complaint

There is a known issue with 2019 and some 2020 model year Ford Rangers. The Ford SSM is #50629. I have been waiting for a Ford service center to fix this issue for 3 months. This issue does not allow for the heater to work properly. Because of that, the defroster and defog doesn't work. This allows for limited or zero visibility through the windshield and side windows in winter conditions that require defrost or defog. I have to had to pull over and scrape ice off my windshield on short trips. Also, this winter has had some of the coldest days on record. Reaching in the -20F range. Having no heat at a time like this could possibly result in frostbite or hypothermia. I use my vehicle as sparingly as possible this winter, but there are times I absolutely need to drive around.

NHTSA ODI #11505233

Official recalls

25V685000 · Equipment:electrical:engine Block Heater

Oct 10, 2025

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Consequence & remedy

Consequence: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

25V442000 · Back Over Prevention:software

Jun 27, 2025

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Consequence & remedy

Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

23V379000 · Equipment:other:labels

May 26, 2023

Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Consequence & remedy

Consequence: An overloaded vehicle increases the risk of a crash.

Remedy: Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.

21V811000 · Seat Belts:front:webbing

Oct 15, 2021

Ford Motor Company (Ford) is recalling certain 2019-2021 Ford Ranger Super Cab vehicles. The front passenger outboard seat belt may not have been assembled properly, allowing the seat belt to be misrouted. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection" and 209, "Seat Belt Assemblies."

Consequence & remedy

Consequence: A misrouted seat belt may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy: Ford will provide owners with instructions to perform a preliminary inspection of their front seat belts. Owners that detect an issue with the driver's seat belt, are unsure of the results, or do not want to perform an inspection, should not drive their vehicles and contact a Ford dealership. Dealers will inspect the front row outboard seat belts and replace them, if necessary, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed December 22, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C25.

21V765000 · Child Seat:vehicle Latch Anchor; Seats:mid/rear Assembly

Sep 30, 2021

Ford Motor Company (Ford) is recalling certain 2020-2021 Ranger Super Cab vehicles equipped with rear seats containing fixed head restraints. The fixed head restraints may interfere with proper installation of certain types of child seats. Additionally, the child seat may not attach properly to the lower-rear anchors. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child Restraint Anchorage System."

Consequence & remedy

Consequence: An improperly attached child seat can increase the risk of injury in a crash.

Remedy: Dealers will inspect the rear-lower child restraint anchorages for correct alignment and adjust as necessary. Separately, dealers will replace the non-removable head restraints with removable head restraints, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed on March 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C24.

Additional source detail variants (2)

Child Seat:vehicle Latch Anchor

Consequence: An improperly attached child seat can increase the risk of injury in a crash.

Remedy: Dealers will inspect the rear-lower child restraint anchorages for correct alignment and adjust as necessary. Separately, dealers will replace the non-removable head restraints with removable head restraints, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed on March 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C24.

Seats:mid/rear Assembly

Consequence: An improperly attached child seat can increase the risk of injury in a crash.

20V575000 · Back Over Prevention: Sensing System: Camera

Sep 23, 2020

Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Consequence & remedy

Consequence: Reduced rearward visibility can increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.

20V197000 · Power Train:automatic Transmission:gear Position Indication (prndl)

Apr 3, 2020

Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.

Consequence & remedy

Consequence: If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.

Remedy: Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ21002 · Rearview Camera Fmvss 111 Noncompliance

Opened Aug 3, 2021 · No close date supplied

Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera

On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.