Power Train. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports1 fire reports3 injury reports

What owners actually said

127 reports

Mileage unknown · Jul 19, 2021

Seat Belts

The right front seat belt pulled out of its anchor in the rear door. It’s clear the webbing did not go through the mounting eye. The belt was held in place only by the plastic housing until it pulled out today. This is the same problem covered by Ford recall 19S23 for 2019 Ranger Super Cab up to June 19, 2019 build date. Mine i…

Read full complaint

NHTSA ODI #11425590

1,242 miles · Jul 13, 2021

Service Brakes

Read full complaint

The contact owns a 2020 Ford Ranger. The contact stated while driving 45 mph, he had to depress the brake pedal to the floor to stop the vehicle. The contact stated no warning light was illuminated. The contact stated he had experienced the failure on two different occasions. The contact called the local dealer and the dealer was made aware of the failure. The vehicle was not diagnosed nor repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 1,242.

NHTSA ODI #11424628

Mileage unknown · Jul 1, 2021

Air Bags

Read full complaint

Truck continues to have airbag lights on even after repairs at ford dealership. The first time it happened it would only come on when cold and would go off after 30-45 minutes. When airbag light was on gauges, heat and air and stereo would not work. That was November 2020. The dealership replaced Body Control Module and other electrical components. June 2021 the airbag light is on again. The code it’s giving is short in passenger airbag circuit. The truck is also saying that rear driver door is open when shut and continually tries to lock and unlock doors. Interior lights stay on because the truck thinks the door is open. Dealership keeps putting off seeing truck for diagnosing. Will not answer if the truck is safe to drive or if airbags will function if the truck is involved in an accident.

NHTSA ODI #11423070

24 miles · Feb 7, 2021

Exterior LightingStructure

Read full complaint

REAR PASSENGER SIDE DOOR IS HARD TO OPEN AND CLOSE. MY SEVEN YEAR OLD CAN'T OPEN IT WITHOUT HELP ON THAT SIDE. WARNING LIGHT COMES ON WHILE DRIVING SOMETIMES WHEN IT IS CLOSED. AFTER PARKING THE PROBLEM CAUSES THE REAR TAILGATE TO STAY ON TO DRAIN BATTERY BECAUSE TRUCK REGISTERS THE DOOR AS AJAR. HAVE TO SLAM AND RELOCK SEVERAL TIMES TO GET WARNING AND LIGHTS TO TURN OFF. WHEN AN OBJECT IS IN THAT DOOR'S POCKET THE PROBLEM IS WORSE AND IT MAY MAKE THE ALARM GO OFF HOURS AFTER PARKING. OFTEN TAKES SEVERAL ATTEMPTS OF OPENING AND CLOSING DOORS AND TURNING INTERIOR LIGHTS ON AND OFF TO GET THE TRUCK LOCKED WITH ALL THE LIGHTS OFF.

NHTSA ODI #11395113

Mileage unknown · Feb 6, 2021

Power Train

WHEN YOU MAKE THE CHANGES OR YOU'RE STOPPING, YOU HIT THE TRANSMISSION. TALK TO OTHER OWNERS. THEY HAVE THE SAME PROBLEM, AND THE DEALER SAYS THAT EVERYTHING IS FINE

NHTSA ODI #11395011

100 miles · Jan 28, 2021

Electrical SystemStructure

EXTENDED CAB MODEL, REAR DRIVER DOOR INTERMITTENTLY INDICATES DOOR AJAR. ALERT APPEARS WHILE IN MOTION, USUALLY AFTER A BUMP IN THE ROAD. THIS HAPPENS AFTER THE DOOR IS CLOSED BY GRIPPING MIDWAY DOWN THE FRAME. THIS WARNING CAN BE PREVENTED IF THE DOOR IS CLOSED BY GRIPPING THE TOP OF THE DOOR FRAME. THIS DOES NOT OCCUR ON THE R…

Read full complaint

NHTSA ODI #11390453

1,400 miles · Jan 26, 2021

Service Brakes

Read full complaint

TL* THE CONTACT OWNS A 2020 FORD RANGER. THE CONTACT STATED THAT ON THREE SEPARATE OCCASIONS WHILE DEPRESSING THE BRAKE PEDAL, THE VEHICLE ACCELERATED FORWARD UNINTENDEDLY WITHOUT WARNING. THE CONTACT WAS FORCED TO TURN OFF THE VEHICLE TO PREVENT THE UNINTENDED ACCELERATION FROM CONTINUING. THE CONTACT HAD TAKEN THE VEHICLE TO JACK KAIN FORD INC. (3405 LEXINGTON RD, VERSAILLES, KY 403830) THREE TIMES AND EACH TIME THE DEALER WAS UNABLE TO DUPLICATE OR DIAGNOSE THE FAILURE. THE MANUFACTURER WAS ALSO NOTIFIED OF THE FAILURE AND A CASE WAS FILED. THE VEHICLE HAD YET TO BE REPAIRED AND REMAINED IN THE POSSESSION OF THE DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 1,400.

NHTSA ODI #11390045

10 miles · Jan 25, 2021

Structure

BRAND NEW 2020 RANGER SUPERCAB (EXTENDED CAB) REAR DOOR AJAR LIGHTS STAY ON CONSTANTLY. KNOWN ISSUE WITH THESE TRUCKS AND BODY STYLE, FORD SHOULD RECALL THEM AND REPLACE THE DOOR SENSORS. COULD BE A SAFETY ISSUE.

NHTSA ODI #11389874

860 miles · Dec 31, 2020

Engine

Read full complaint

MY TRUCK(2020 FORD RANGER) HAS FUEL CONTAMINATION IN THE ENGINE OIL. I CHANGED THE OIL FOR THE FIRST TIME WHEN THE TRUCK HAD 860 MILES ON IT. THE OIL REEKED OF GASOLINE WHEN I CHANGED IT. I SENT THE OIL INTO BLACKSTONE FOR ANALYSIS AND THE RESULTS SHOWED A 4.3% FUEL DILUTION OF THE OIL, WHICH ACCORDING TO THE COMPANY IS A CAUTIONARY LEVEL. THEY ALSO STATED THE OIL VISCOSITY WAS LOW AND PROBABLY DUE TO FUEL DILUTION. I OPENED A FORD CUSTOMER COMPLAINT (CAS-29025613) AND TOOK IT TO DEALER. THE DEALER INSPECTED THE VEHICLE AND SAID NOTHING IS NEEDING REPAIR AT THIS TIME. NO TSB'S ARE LISTED FOR THIS COMPLAINT. THE DEALER SAID THEY TRIED CALLING FORD TO UPDATE THE COMPLAINT CLAIM WITH THEIR FINDINGS BUT COULDN'T DO SO BECAUSE WAS ALREADY CLOSED! VERY FRUSTRATING. THERE ARE SEVERAL OTHER FORD RANGER OWNERS (ON RANGER5.COM FORUMS) WHO ALSO COMPLAIN OF HAVING FUEL DILUTION IN THEIR OIL AND FORD HAS YET TO TAKE THEM SERIOUSLY AND INVESTIGATE THE ROOT CAUSE.

NHTSA ODI #11385771

23 miles · Dec 24, 2020

Service Brakes

BRAKE PEDAL TRAVEL IS LONG, SOFT AND INCONSISTENT. FEELS LIKE AS IF THERE IS AIR IN THE LINE.

NHTSA ODI #11384831

Official recalls

25V685000 · Equipment:electrical:engine Block Heater

Oct 10, 2025

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Consequence & remedy

Consequence: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

25V442000 · Back Over Prevention:software

Jun 27, 2025

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Consequence & remedy

Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

23V379000 · Equipment:other:labels

May 26, 2023

Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Consequence & remedy

Consequence: An overloaded vehicle increases the risk of a crash.

Remedy: Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.

21V811000 · Seat Belts:front:webbing

Oct 15, 2021

Ford Motor Company (Ford) is recalling certain 2019-2021 Ford Ranger Super Cab vehicles. The front passenger outboard seat belt may not have been assembled properly, allowing the seat belt to be misrouted. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection" and 209, "Seat Belt Assemblies."

Consequence & remedy

Consequence: A misrouted seat belt may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy: Ford will provide owners with instructions to perform a preliminary inspection of their front seat belts. Owners that detect an issue with the driver's seat belt, are unsure of the results, or do not want to perform an inspection, should not drive their vehicles and contact a Ford dealership. Dealers will inspect the front row outboard seat belts and replace them, if necessary, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed December 22, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C25.

21V765000 · Child Seat:vehicle Latch Anchor; Seats:mid/rear Assembly

Sep 30, 2021

Ford Motor Company (Ford) is recalling certain 2020-2021 Ranger Super Cab vehicles equipped with rear seats containing fixed head restraints. The fixed head restraints may interfere with proper installation of certain types of child seats. Additionally, the child seat may not attach properly to the lower-rear anchors. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child Restraint Anchorage System."

Consequence & remedy

Consequence: An improperly attached child seat can increase the risk of injury in a crash.

Remedy: Dealers will inspect the rear-lower child restraint anchorages for correct alignment and adjust as necessary. Separately, dealers will replace the non-removable head restraints with removable head restraints, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed on March 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C24.

Additional source detail variants (2)

Child Seat:vehicle Latch Anchor

Consequence: An improperly attached child seat can increase the risk of injury in a crash.

Remedy: Dealers will inspect the rear-lower child restraint anchorages for correct alignment and adjust as necessary. Separately, dealers will replace the non-removable head restraints with removable head restraints, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed on March 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C24.

Seats:mid/rear Assembly

Consequence: An improperly attached child seat can increase the risk of injury in a crash.

20V575000 · Back Over Prevention: Sensing System: Camera

Sep 23, 2020

Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Consequence & remedy

Consequence: Reduced rearward visibility can increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.

20V197000 · Power Train:automatic Transmission:gear Position Indication (prndl)

Apr 3, 2020

Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.

Consequence & remedy

Consequence: If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.

Remedy: Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ21002 · Rearview Camera Fmvss 111 Noncompliance

Opened Aug 3, 2021 · No close date supplied

Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera

On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.