2019 Ford Ranger

The automatic transmission and related transmission control system malfunctioned. The vehicle experienced improper shifting and loss of gears, including a condition in which 4th gear is disabled due to a failsafe logic triggered by the transmission control module. The vehicle and all affected components are currently available for inspection upon request and are at a Ford-authorized dealership. This malfunction posed a safety risk because the vehicle was unable to shift normally or maintain consistent acceleration. The unpredictable shifting and loss of gears could create hazardous situations when merging, accelerating, or driving at highway speeds, potentially endangering the driver and others. The problem has been reproduced and confirmed by a Ford dealership. After inspection and diagnostic testing, the dealership advised that the transmission requires replacement. The vehicle has been inspected by a Ford-authorized dealer. It has not been inspected by the manufacturer directly, police, or insurance representatives (UNKNOWN). Prior to the failure, warning messages and drivability symptoms were present. Specifically, the transmission control module detected an issue when attempting to shift into 4th gear, triggering a failsafe mode that disabled 4th gear for the remainder of the key cycle. These symptoms appeared before the full transmission failure and progressively worsened over time.

2019 ford ranger, 74,000 miles On way to pick up girlfriends engagement ring…. The truck started jerking, loosing power, no engine light came on. Turned around to go home and drive about 8 miles under 45 mph.Then truck started jerking again , like transmission issue. Engine light and tool wrench came on. As I was pulling in driveway, truck went into “limp” mode. Had it towed to Gullo Ford Conroe. Now they are saying need new transmission due to Internal transmission failure! Shouldn’t Ford. Over this! Only 60,000 mile warranty.

The climate control system on my 2019 Ford Ranger has a recurring failure that prevents the vehicle from properly adjusting temperature or directing air through the vents. The failure causes a constant clicking/snapping noise behind the dashboard, and the blend door does not move when the temperature is changed. This malfunction matches Ford’s published SSM 49264, which identifies a known defect in 2019–2020 Rangers built on or before 7/30/2020 and states that the entire HVAC housing assembly must be replaced. This issue creates a safety hazard because the truck cannot reliably defrost the windshield in cold or wet weather. Loss of defrosting capability severely limits visibility and makes safe operation of the vehicle difficult. The issue is reproducible every time the temperature is adjusted. The problem began when the vehicle was still within the original mileage window of the factory warranty, but the dealership did not repair it. Ford has confirmed the malfunction is caused by the blend door system, yet they have refused goodwill coverage for a repair that requires full dash removal and replacement of a known defective part. There were no warning lights, but the clicking noise and loss of temperature control began well before the warranty expired. The vehicle continues to experience the defect, and it poses an ongoing visibility and safety risk. Ford has acknowledged this exact failure mode in writing (SSM 49264), but has not issued a recall or safety campaign.

Truck looses gear when pulling into traffic. It will shift out of gear and only allow coasting. At speeds of 40 MPH and higher it will down shift causing dramatic reduced speed with no brake warning to other drivers behind. It will also randomly loose power. It will have delayed shifts squealing tires upon shifting and excessive jerking that is uncontrollable.

I have had my 2019 Ford Ranger in for service to address issues with the transmission on 3 different occasions starting in Fall of 2023. Each time paying $106 for the deductible on the warranty to service a "Technical Service Bulletin" (TSB). Each time, being told of a different TSB that they would be addressing. Never addressing them all at the same time. In May of 2025, still experiencing the same/similar issues, I brought in in again only to be told that there was a TSB that they did not service, that my warranty had expired. Upon searching the internet, there are many people reporting similar issues with a similar response from Ford. I have spoken to multiple dealerships as well as reached out to Ford car with little to no response.

On November 7th. 2025, I took my Ranger to my mechanic for it's yearly emissions and inspection, to have the tires rotated and brakes changed. He called me later that day and had sent me pictures of BOTH rear leaf springs broken off from the under carriage. He stated that he could not tell how long they were like this and asked if I had any issues driving. I did not notice any noise or driving issues. He stated that he is shocked that I did not wreak the truck by loosing control because it should have caused my rear to be bouncing all over. He contacted FORD and asked if there was a recall on them and was told "No". He then instructed me to file a complaint with you. He ordered the parts and replaced fixed the issue.

Repeated failure of HVAC system, even after repairs, leads to not only a very cold truck in January in Maine, but inability to defrost the windshield and keep it defrosted. Repairs have been made in January 2025, April 2025, and now has to be repaired again in December 2025. My independent service provider who subscribes to OEM Ford subscriptions, was not made aware of an "internal" service memo until now. Neither from the subscription services or from contacts at a Ford dealer where he resourced parts and repair info. SSM 51313 indicates a different repair than was made on the previous two attempts. These repairs require the disassembly and reassembly of the instrument panel and are very expensive - especially when not apprised of correct. Now the SSM indicates a complete housing replacement to correct the defective part. See attached forms.