2019 Ford Ranger

I am submitting this complaint regarding my 2019 Ford Ranger because I discovered what I believe to be a serious safety defect involving the rear leaf spring mounting system. My vehicle has approximately 55,000 miles and has been used primarily as a commuter vehicle for driving to and from work in the city. The truck is originally from Virginia and has very minimal rust exposure. While replacing my rear brake pads, I noticed that the area where the rear leaf spring connects to the body/frame of the truck had broken away and was no longer properly attached. This was completely unexpected. A critical suspension component such as the leaf spring mounting point should not fail on a relatively low-mileage vehicle with only 55,000 miles, especially one that has not been subjected to severe corrosion or extreme use. Had I not been performing brake maintenance myself, I likely would not have discovered this defect. I fear that many other Ford Ranger owners may be driving their vehicles unaware that they could be experiencing the same dangerous condition. A failure involving the leaf spring mounting system has the potential to affect vehicle stability, handling, braking, and overall control. This creates a significant safety risk not only for the driver and passengers of the affected vehicle, but also for everyone sharing the roadway. I respectfully urge your agency to investigate this issue and determine whether a broader defect exists involving the rear leaf spring mounting components on 2019 Ford Rangers. If warranted, I ask that Ford be required to issue a recall to inspect and repair affected vehicles before a catastrophic failure results in serious injury or loss of life. Thank you for your attention to this matter and for your efforts to protect the safety of the driving public.

Rear rear leaf spring broken/cracked completely and disconnected from vehicle. The vehicle was unsafe to drive as the axle was not not connected to the vehicle on one side. The defective component was inspected by Firestone Auto and submitted and approved by SilverRock automotive for warranty replacement and is currently at a Ford Dealership completing repairs because Firestone Auto failed to complete the repair properly. There were no warning lamps or messages and it the problem was only noticeable when the vehicle was on a lift or floor jack. The incident is unknown and it the broken part was poor design/materials.

On friday, march 27th, 2026. My 2019 ford ranger began shaking before the engine stalled. Warning lights for an engine check came on and my vehicle would not go above 20 mph after restarting. When pressing on the accelerator the engine would rev but the vehicle would not accelerate. I took the 2019 ford Ranger to a local Ford Dealership service center and they diagnosed the following problems (listed in full below).The cooling fan was at issue and multiple wires connecting my engine to the rest of the vehicle were melted off. The ford dealership said that this issue is extremely rare and they have never seen it before. After receiving this information from the dealership I discovered that the 2019 ford ranger has had several recalls with the areas at issue in my vehicle. The recalls are under number 25V685000 (Engine block heater), and 20V137000 (Fan). Here is the full diagnosis from the ford dealership attached below: VERIFIED CUSTOMER CONCERN FOUND VEHICLE TO HAVE CEL LIGHT ON, AND MULTIPLE WARNING LIGHTS PERFORMED DIAG AND FOUND SHORT CIRCUIT PRESENT. TRACED SHORT FOUND COOLING FAN CLUTCH FAILED AND HARNESS RUBBING IN CLUCH ASSEMBLY FOR COOLING FAN The fan lowers the temperature of the engine. The cooling fan motor is an electric motor that turns the fan blades. When the vehicle is in traffic or under heavy load, the engine relies on the fan to cool itself. Some vehicles may use multiple electric fans for better control of the cooling system. For the most part, electric cooling fans are controlled by the same computer that controls the engine. However, in some engines, the fans are turned on and off by a temperature-sensitive switch mounted in either the radiator or elsewhere in the cooling system. Spark Plug Replacement 4 Cylinder: 4 Cyl Tune Up The platinum spark plug is a type of spark plug. The platinum is a precious metal that is used in the composition of the spark plug. The center electrode is made of platinum.

both rear springs broken at the front eye mounts. the rear leaf springs hold the rear axle in place need I EXPLAIN MORE? I have not had the truck inspected, I have been in the automotive industry for over forty years. I first heard a noise from the springs when entering a parking lot and drove over a curb. No electronics attached to the springs.

Vehicle has around 50K miles and driver rear leaf spring corroded and broke, review of right rear leaf spring also showed corrosion and metal thinning. Truck has no off road time nor heavy loads in bed. I had to replce both springs at my cost even though Ford is aware of the 2019-2020 Ranger spring issues and refused to replace the springs. This is a serious safety issue that places the occupants and other drivers at risk. The mechanic said he’s replaced over a dozen broken leaf springs on model years 2019 and 2020. The manufacturer is being intentionally negligent and even the dealer parts counter agreed the springs are faulty, saying they sell quite a few regularly.

On November 7th. 2025, I took my Ranger to my mechanic for it's yearly emissions and inspection, to have the tires rotated and brakes changed. He called me later that day and had sent me pictures of BOTH rear leaf springs broken off from the under carriage. He stated that he could not tell how long they were like this and asked if I had any issues driving. I did not notice any noise or driving issues. He stated that he is shocked that I did not wreak the truck by loosing control because it should have caused my rear to be bouncing all over. He contacted FORD and asked if there was a recall on them and was told "No". He then instructed me to file a complaint with you. He ordered the parts and replaced fixed the issue.

The front eyes of both leaf springs were broke. Took truck to local shop to repair a tire leak and they called me to ask me how I drove the truck there as they never saw anything like it before. This is a major component that maintains the rear axle geometry and could have been a safety risk and should never be a concern on a 5 year old vehicle with under 100,000 miles. Vehicle has not been inspected by any other parties than the shop and myself. No symptoms were detected.