NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
9 reportsClear category filterMileage unknown · Oct 13, 2025
Fuel/propulsion SystemPower Train
My 2019 Ford Ranger 4x4 was bought new in April of 2019 and has approxiamatly 73,400 miles. Over time a slight glitch in the transission got to be more frequent. When first starting out within the first mile of operation, the vehicle would hang between gears and act like it ran out of fuel for a few seconds at low speed, as …
Read full complaint
My 2019 Ford Ranger 4x4 was bought new in April of 2019 and has approxiamatly 73,400 miles. Over time a slight glitch in the transission got to be more frequent. When first starting out within the first mile of operation, the vehicle would hang between gears and act like it ran out of fuel for a few seconds at low speed, as in pulling out from a stop sign or accelerating from a dead stop. My guess is inbetween first and second or second and third gear. It just wouldn'd go. Fortunatley I was not involved in any accidents. I can see where this could easily cause a mjor accident. There are several TSB's for this transmission and I believe Ford and General Motors use this same transmission. I have had my truck at the dealer for almost a month after it got scary to drive it got scary to drive. They are repairing this and contributing to the cost. I feel ike they no there is a problem and probably should have done a recall before someone gets killed.
NHTSA ODI #11693113
Mileage unknown · Jan 18, 2025
Fuel/propulsion SystemPower TrainVehicle Speed Control
When turning on to another road and accelerating, engine will suddenly loose all power. releasing accelerator will regain some power until vehicle speed increases. Throttle control is often erratic and transmission shifting is inconsistent resulting in hard clunks during shift. Pulling into traffic with a sudden loss of power le…
Read full complaint
When turning on to another road and accelerating, engine will suddenly loose all power. releasing accelerator will regain some power until vehicle speed increases. Throttle control is often erratic and transmission shifting is inconsistent resulting in hard clunks during shift. Pulling into traffic with a sudden loss of power leaves me vulnerable to a collision.
NHTSA ODI #11636744
Mileage unknown · Jul 23, 2024
EngineFuel/propulsion SystemPower Train
There is insufficient shielding to prevent water from reaching the top of the engine. This results in water dripping on the coil packs and also entering the spark plug wells, causing loss of spark and reduced engine output. Over time, this issue also leads to rust in the engine head, potentially resulting in engine failure. Addi…
Read full complaint
There is insufficient shielding to prevent water from reaching the top of the engine. This results in water dripping on the coil packs and also entering the spark plug wells, causing loss of spark and reduced engine output. Over time, this issue also leads to rust in the engine head, potentially resulting in engine failure. Additionally, water can reach the EGR DPFE sensor, causing the engine to hesitate and shutter at various speeds. Both of these issues together cause a misfire when applying the accelerator and will cause the vehicle to initially hesitate then surge forward. Even with the engine cover, the venting at the base of the windshield allows water to drip down on the engine head, causing the above issues. Ford does recognize that there is an issue and have written several TSBs on the it.
NHTSA ODI #11604011
Mileage unknown · Dec 22, 2023
Fuel/propulsion SystemService BrakesUnknown Or OtherCrash
Unintended Aceleration Veheicle experienced normal stop with no anomaly. Upon release of brakes, experienced reported Wide Open Throttle" Brakes were ineffective. Vehicle accelerate thru intersection striking guardrail with significant damage. WOT stopped by shutting of engine. Vehicle currently in repair. Reported event to loca…
Read full complaint
Unintended Aceleration Veheicle experienced normal stop with no anomaly. Upon release of brakes, experienced reported Wide Open Throttle" Brakes were ineffective. Vehicle accelerate thru intersection striking guardrail with significant damage. WOT stopped by shutting of engine. Vehicle currently in repair. Reported event to local dealer service dept, Insurance Rep and Ford referencing 2010 Class Action Lawsuit for similar events, All claim no knowledge of such an event. Vehicle had no previous reports of similar events
NHTSA ODI #11561429
Mileage unknown · Mar 18, 2022
Fuel/propulsion SystemUnknown Or Other
Unknown, My vehicle seems to stall in low gear. I already informed the dealership several times, and they stated that everything was fine. The stalling appears to be getting more frequent as time goes on, and worried that this could cause further damage to the vehicle. This is a safety concern as well.
NHTSA ODI #11457217
Mileage unknown · Mar 12, 2022
EngineFuel/propulsion SystemUnknown Or Other
Drive truck and park in garage and garage smells like gas. Only happens when parking truck in garage right after driving it. This has happened about 3-4 times now. I don't drive it that often. Just had an oil change at Ford and drove home. Then the next day i took it out and parked it in garage and gas smell again. Smell wi…
Read full complaint
Drive truck and park in garage and garage smells like gas. Only happens when parking truck in garage right after driving it. This has happened about 3-4 times now. I don't drive it that often. Just had an oil change at Ford and drove home. Then the next day i took it out and parked it in garage and gas smell again. Smell will last 2-3 days if truck stays parked. Have an appt. this coming week at Ford.
NHTSA ODI #11456425
8,400 miles · Feb 2, 2021
EngineFuel/propulsion SystemPower Train
I CHANGED MY OIL AT 5,000 MILES, I HAVE APPROXIMATELY 8,400 MILES ON MY TRUCK NOW. I NOTICED EXCESSIVE FUEL BUILT UP IN MY OIL CATCH CAN. AFTER DOING SOME RESEARCH A LOT OF PEOPLE WITH THE 2019 FORD RANGER ARE HAVING THE SAME ISSUE. I CHECKED MY OIL AND MY OIL WAS SATURATED WITH FUEL. FUEL IS GETTING INTO THE ENGINE OIL.
NHTSA ODI #11394340
14,136 miles · Jan 2, 2021
Fuel/propulsion System
CONSISTENT ISSUE WITH FUEL IN OIL. LATEST REPORT FROM THE OIL ANALYSIS HAVE 4.5 PERCENT FUEL IN OIL. DROPPING OIL IGNITION POINT TO 285 DEGREES. ISSUE OCCURS DURING NORMAL VEHICLE USE.
NHTSA ODI #11386201
1,860 miles · Dec 7, 2019
Fuel/propulsion System
EXTREME FUEL DILUTION IN THE OIL. LIKELY FROM LEAKING HIGH PRESSURE FUEL PUMP. I HAVE ATTACHED THE RESULTS FROM OIL ANALYSIS AT 1860 MILES. THE TEST ONLY INDICATES THAT FUEL DILUTION IS ABOVE 5%, WHICH ITSELF LEADS TO SEVERE OIL DEGRADATION. WHEN I CHANGED THE OIL, I DRAINED 7.5 QUARTS OUT OF AN ENGINE WITH A 6.2 QUART CAPACI…
Read full complaint
EXTREME FUEL DILUTION IN THE OIL. LIKELY FROM LEAKING HIGH PRESSURE FUEL PUMP. I HAVE ATTACHED THE RESULTS FROM OIL ANALYSIS AT 1860 MILES. THE TEST ONLY INDICATES THAT FUEL DILUTION IS ABOVE 5%, WHICH ITSELF LEADS TO SEVERE OIL DEGRADATION. WHEN I CHANGED THE OIL, I DRAINED 7.5 QUARTS OUT OF AN ENGINE WITH A 6.2 QUART CAPACITY. THIS WOULD INDICATE A 21% FUEL DILUTION, NOT INCLUDING FUEL THAT HAS EVAPORATED FROM THE CRANKCASE AND RETURNED TO THE COMBUSTION CHAMBER VIA THE PCV SYSTEM. IF I ABIDED BY THE MANUAL'S RECOMMENDED OIL CHANGE INTERVAL, I HAVE LITTLE DOUBT THE ENGINE WOULD EVENTUALLY CATCH FIRE, BASED ON THE RESULTS OF SEVERAL TESTS COMPARING FUEL DILUTION TO AN OIL'S FLASHPOINT. AFTER CHANGING THE OIL, IT SMELLED FINE FOR THE FIRST 20 MILES OR SO. AFTER THAT, THE OIL BEGAN TO FEEL OF GASOLINE AGAIN. AFTER GOING THROUGH FORD'S SERVICE MANUALS, I HAVE ASCERTAINED THAT THE PROBLEM MUST LIE IN THE HIGH PRESSURE FUEL PUMP. IT RUNS OFF THE CAMSHAFT, WHERE LEAKING FUEL COULD THEN MAKE IT INTO THE ENGINE AND MIX WITH OIL. THERE WOULD BE NO WARNING OR INDICATION, BESIDES RISING OIL LEVELS ACCOMPANIED BY THE SMELL OF GASOLINE IN THE OIL. IT DOES NOT MAKE ME HAPPY THAT MY DEALER IS NOT TAKING THIS ISSUE SERIOUSLY, ESPECIALLY BECAUSE A FUEL LEAK OF ANY KIND ALWAYS HAS THE POTENTIAL TO LEAD TO A FIRE OR EXPLOSION IN THE HOT ENGINE BAY. I PAID OVER $40K FOR THIS TRUCK, AND SHOULD NOT HAVE TO CHANGE THE OIL EVERY 500 MILES TO KEEP IT FROM SELF DESTRUCTING. THANK YOU FOR YOUR HELP IN THE RESOLUTION OF THIS ISSUE. I DON'T FEEL SAFE DRIVING MY FAMILY IN THIS VEHICLE, AND FORD HAS REPEATEDLY CHOSEN NOT TO ADDRESS THE ISSUE. I FIRST DETECTED THE ISSUE ON OCTOBER 20TH, BUT I HAVE NO DOUBT THAT IT HAS BEEN GOING ON SINCE THE TRUCK ROLLED OFF THE ASSEMBLY LINE. I PURCHASED THE VEHICLE ON AUGUST 30TH OF THIS YEAR.
NHTSA ODI #11287662
Official recalls
11Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Sep 3, 2025
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
May 26, 2023
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: An overloaded vehicle increases the risk of a crash.
Remedy: Ford will mail a new TREAD label to install over the existing label, free of charge. Owners will also have the option to take their vehicle to a Ford or Lincoln dealer to have the new label installed, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C18.
Oct 15, 2021
Ford Motor Company (Ford) is recalling certain 2019-2021 Ford Ranger Super Cab vehicles. The front passenger outboard seat belt may not have been assembled properly, allowing the seat belt to be misrouted. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection" and 209, "Seat Belt Assemblies."
Consequence & remedy
Consequence: A misrouted seat belt may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will provide owners with instructions to perform a preliminary inspection of their front seat belts. Owners that detect an issue with the driver's seat belt, are unsure of the results, or do not want to perform an inspection, should not drive their vehicles and contact a Ford dealership. Dealers will inspect the front row outboard seat belts and replace them, if necessary, free of charge. Interim owner notification letters were mailed on November 5, 2021. Owner notification letters were mailed December 22, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C25.
Mar 9, 2020
Ford Motor Company (Ford) is recalling certain 2019 Ranger vehicles previously repaired under recall 19V-726. The service replacement Heating, Ventilating and Air Conditioning (HVAC) blower motor that was installed may have an improper clearance between an electrical terminal and the conductive base plate that may result in an resistive electrical short.
Consequence & remedy
Consequence: A resistive electrical short increases the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect and replace the HVAC blower motor, as necessary, free of charge. The recall began April 6, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S12.
Nov 21, 2019
Ford Motor Company (Ford) is recalling certain 2019 Ranger trucks. The inline electrical connector terminals for the rear lights may be misaligned or not properly seated, potentially causing the rear lights to function intermittently or not at all.
Consequence & remedy
Consequence: Intermittent or inoperative tail lamps can result in loss of stop, turn, rear position, and reverse lamp functions, which reduces the vehicle's visibility and may not fully alert other drivers that the vehicle is braking, turning, or reversing, increasing the risk of crash.
Remedy: Ford will notify owners, and dealers will inspect the inline connector for loose terminals and replace the connectors, if necessary, free of charge. The recall began March 5, 2020. A renotification was sent on July 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S43.
Oct 10, 2019
Ford Motor Company (Ford) is recalling certain 2019 Ranger vehicles. The Heating, Ventilating and Air Conditioning (HVAC) blower motor may electrically short.
Consequence & remedy
Consequence: An electrical short can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the HVAC blower motor production date, replacing it as necessary, free of charge. The recall began December 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S34.
Jul 10, 2019
Ford Motor Company (Ford) is recalling certain 2019 Ford Ranger vehicles with a SuperCab body style. The front passenger seat belt may have been improperly assembled.
Consequence & remedy
Consequence: Improperly assembled seat belts may not adequately restrain occupants in a crash, increasing their risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the right front seat belt assembly, free of charge. The recall began July 29, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S23.
May 13, 2019
Ford Motor Company (Ford) is recalling certain 2019 Ranger vehicles. The fasteners that attach the transmission shifter cable bracket to the transmission may loosen allowing the transmission to be in a different gear than indicated by the gear shift lever position.
Consequence & remedy
Consequence: If the gear shift lever position does not match the actual transmission gear, the vehicle may move in an unexpected direction. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of crash or injury.
Remedy: Ford will notify owners, and dealers will inspect and tighten the transmission shift cable bracket fasteners as necessary, and verify the proper transmission shift operation, free of charge. The recall began July 1, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S15.
Feb 1, 2019
Ford Motor Company (Ford) is recalling certain 2019 Ranger vehicles equipped with 10-speed automatic transmissions. In some of these vehicles, the transmission shift lever can be moved from the "Park" position without the key in the starting system and without depressing the brake pedal. As a result, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the vehicle can be shifted out of Park without the brake applied, the vehicle may unexpectedly move. Unintentional vehicle movement can increase the risk of injury or crash.
Remedy: Ford has notified owners, and dealers will inspect and repair the transmission floor shift selector interlock assembly, as necessary, free of charge. The recall began February 22, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C02.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration