NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
20 reportsClear category filterMileage unknown · Jun 9, 2022
StructureSuspension
The spare tire stabilizing bracket rusted away and fell off. The rear shackles for the springs broke on both sides, and is coming up through the bed. The frame has rusted apart and it’s not possible to bolt a new shackle for the rear springs on. The body is not rusting out. They used inferior steel on the frame and it has rust…
Read full complaint
The spare tire stabilizing bracket rusted away and fell off. The rear shackles for the springs broke on both sides, and is coming up through the bed. The frame has rusted apart and it’s not possible to bolt a new shackle for the rear springs on. The body is not rusting out. They used inferior steel on the frame and it has rusted away. They should do a recall on these like other manufacturers have. This is a serious safety issue. I bought this truck new, and it only has 98000 mikes on it.
NHTSA ODI #11468541
101,823 miles · Dec 18, 2020
SuspensionUnknown Or Other
THE FRAME OF MY RANGER HAS RUSTED BADLY , CAUSING THE REAR SPRING SHACKLES TO NO LONGER BE ATTACHED TO THE FRAME.ALSO THE BED OF THE TRUCK HAS RUSTED AWAY BADLY. I I SPOKE TO A GUY WHO SPECIALIZES IN FRAME / AXLE REPAIR . AFTER INSPECTING IT , HE TOLD ME THAT THE ONLY OPTION TO REPAIR MY TRUCK WAS TO REPLACE THE FRAME , BECAUSE…
Read full complaint
THE FRAME OF MY RANGER HAS RUSTED BADLY , CAUSING THE REAR SPRING SHACKLES TO NO LONGER BE ATTACHED TO THE FRAME.ALSO THE BED OF THE TRUCK HAS RUSTED AWAY BADLY. I I SPOKE TO A GUY WHO SPECIALIZES IN FRAME / AXLE REPAIR . AFTER INSPECTING IT , HE TOLD ME THAT THE ONLY OPTION TO REPAIR MY TRUCK WAS TO REPLACE THE FRAME , BECAUSE THE FRAME IS RUSTED TOO BADLY TO BE ABLE TO BE WELDED , HE SAID THE ONLY OTHER OPTION WAS TO JUNK IT . THE TRUCK HAS 102,000 MILES ON IT AND IS OTHERWISE IN GOOD CONDITION . I HAD PLANNED TO OWN IT FOR YEARS TO COME . NOW I AM AFRAID TO TRUST IT . AND I WOULD NOT FEEL RIGHT ABOUT SELLING IT TO SOMEONE ELSE . I USE THIS TRUCK TO HAUL HAY TO FEED MY LIVESTOCK , BUT NOW I AM AFRAID TO LOAD IT UP AND DRIVE DOWN THE ROAD WITH IT .I HAD THE TIRES REPLACED AND THE SERVICE CENTER NOTED ON THE PAPERWORK THAT THE FRAME WAS BAD AND NEEDED TO HAVE THE SPRING MOUNTINGS FIXED ..,
NHTSA ODI #11384120
90,000 miles · Oct 27, 2020
Suspension
LEFT SIDE REAR FRAME...WHERE THE REAR SPRING SHACKLE ATTACHES TO THE THE FRAME RUSTED AWAY. THE FRAME RUSTED AWAY, NO WHERE ELSE IS THERE RUST THROUGH...THE LEAF SPRING ENDED UP BEING SUPPORTED BY THE BED OF TRUCK. SPRING IS ATTACHED TO THE REAR AXLE. AXLE CAN BECOME FREE WHEELING AT ANY TIME. THE RIGHT SIDE REAR SHACKLE ATT…
Read full complaint
LEFT SIDE REAR FRAME...WHERE THE REAR SPRING SHACKLE ATTACHES TO THE THE FRAME RUSTED AWAY. THE FRAME RUSTED AWAY, NO WHERE ELSE IS THERE RUST THROUGH...THE LEAF SPRING ENDED UP BEING SUPPORTED BY THE BED OF TRUCK. SPRING IS ATTACHED TO THE REAR AXLE. AXLE CAN BECOME FREE WHEELING AT ANY TIME. THE RIGHT SIDE REAR SHACKLE ATTACHMENT LOOKS AS IF THE FRAME IS GOING TO FAIL ANY MOMENT ...I CAN NOT BELIEVE THE FRAME RUSTS AWAY WHILE THE REST OF THE BODY IS OK.....A TEMPORARY REPAIR HAS BEEN MADE WITH A 4 X 4 BOLTED TO THE FRAME AND SPRING.
NHTSA ODI #11366707
62,000 miles · Aug 9, 2018
StructureSuspension
I WAS GOING DOWN THE HIGHWAY SPARE TIRE DROPPED DOWN ON THE ROAD CAUSING ME TO LOSE CONTROL OF MY TRUCK GOT THE TRUCK HOME AND FOUND THE FRAME ROTTED ONLY HAS 62,000 MILES
NHTSA ODI #11118843
107,000 miles · Dec 22, 2017
SuspensionUnknown Or Other
THE ENTIRE FRAME IS RUSTED, THE RUST ON THE FRAME AROUND THE REAR SPRING SHACKLE RUSTED ENOUGH THAT THE SHACKLE IS BROKEN FREE. THIS WAS NOTICED DUE TO THE NOISES THE SHACKLE MAKES WHEN MOVING. THE VEHICLE HAS LESS THAN 108,000 MILES. IN ADDITION THE SIDE STEPS RUSTED THROUGH AND WERE HANGING DOWN, I HAD TO REMOVE THEM TO PREV…
Read full complaint
THE ENTIRE FRAME IS RUSTED, THE RUST ON THE FRAME AROUND THE REAR SPRING SHACKLE RUSTED ENOUGH THAT THE SHACKLE IS BROKEN FREE. THIS WAS NOTICED DUE TO THE NOISES THE SHACKLE MAKES WHEN MOVING. THE VEHICLE HAS LESS THAN 108,000 MILES. IN ADDITION THE SIDE STEPS RUSTED THROUGH AND WERE HANGING DOWN, I HAD TO REMOVE THEM TO PREVENT THEM FROM FALLING OFF.
NHTSA ODI #11056143
100,000 miles · Oct 8, 2017
StructureSuspensionUnknown Or Other
SEVERE RUST ENTIRE BACK HALF OF TRUCK. FIRST THE SPARE TIRE FELL OFF WHILE DRIVING AND THE EVAP CANISTER WAS BROKEN. THE BED ROTTED OUT AND MY GAS TANK WAS IN DANGER OF FALLING OFF. THE CROSS MEMBERS BROKE WHILE DRIVING ON A TOWN DIRT ROAD CAUSING THE CROSS MEMBER TO RUB AGAINST THE DRIVE SHAFT. I HAD TO USE A CARGO STRAP TO HOL…
Read full complaint
SEVERE RUST ENTIRE BACK HALF OF TRUCK. FIRST THE SPARE TIRE FELL OFF WHILE DRIVING AND THE EVAP CANISTER WAS BROKEN. THE BED ROTTED OUT AND MY GAS TANK WAS IN DANGER OF FALLING OFF. THE CROSS MEMBERS BROKE WHILE DRIVING ON A TOWN DIRT ROAD CAUSING THE CROSS MEMBER TO RUB AGAINST THE DRIVE SHAFT. I HAD TO USE A CARGO STRAP TO HOLD UP THE GAS TANK SO I COULD GET HOME WHICH LUCKILY WAS ONLY ABOUT A MILE.
NHTSA ODI #11032230
90,000 miles · Sep 8, 2017
Suspension
THE REAR SHACKLES RUSTED THROUGH AND BROKE OFF FROM THE LEAF SPRINGS. THIS HAPPENED WHILE DRIVING HOME FROM WORK ON CITY STREETS. WHEN TURNING CORNERS THE SOUND OF THE BROKEN SHACKLE ROLLING BACK AND FORTH ON THE BACK OF THE BUMPER ALERTED ME TO THE SITUATION. I AM THIRD OWNER AND THIS TRUCK HAS BEEN TAKEN CARE OF VERY WELL
NHTSA ODI #11022395
245,000 miles · Oct 24, 2016
SteeringStructureSuspension
REAR LEAF-SPRING SHACKLES AND HANGERS ON MY 2006 FORD RANGER ARE RUSTED OUT, ONE OF THE SHACKLES BROKE FREE FROM THE FRAME WHILE I WAS DRIVING, MADE IT HARDER TO STEER BECAUSE THE TRUCK FELT NOWHERE NEAR AS STABLE AS IT WAS BEFORE IT BROKE, IT CAUSED ME TO SWERVE INTO THE LANE BESIDE ME WHICH VERY WELL COULD HAVE CAUSED A SERIOU…
Read full complaint
REAR LEAF-SPRING SHACKLES AND HANGERS ON MY 2006 FORD RANGER ARE RUSTED OUT, ONE OF THE SHACKLES BROKE FREE FROM THE FRAME WHILE I WAS DRIVING, MADE IT HARDER TO STEER BECAUSE THE TRUCK FELT NOWHERE NEAR AS STABLE AS IT WAS BEFORE IT BROKE, IT CAUSED ME TO SWERVE INTO THE LANE BESIDE ME WHICH VERY WELL COULD HAVE CAUSED A SERIOUS ACCIDENT IF SOMEONE WERE TO BE THERE. THE REST OF MY FRAME SEEMS TO HAVE EXCESSIVE RUST WHICH IS NOT TO BE EXPECTED FROM A 10 YEAR OLD TRUCK, ESPECIALLY BY THE SHACKLES AND HANGERS FOR THE LEAF SPRINGS, AND ALSO ALL AROUND THE SPARE TIRE MOUNT WHICH I COULD SEE TO BECOME A VERY SERIOUS SAFETY CONCERN WHILE DRIVING. I MEAN WHO WANTS A SPARE TIRE IN THEIR WINDSHIELD WHILE FOLLOWING SOMEONE DOWN THE ROAD? MY VEHICLE WAS IN MOTION ON THE HIGHWAY WHEN ALL OF THIS HAPPENED IM VERY CERTAIN THAT CHEAP FRAME METAL WAS THE CAUSE OF IT BREAKING, BECAUSE IM GENERALLY PRETTY EASY ON MY TRUCK. *TR
NHTSA ODI #10918444
191,353 miles · Aug 28, 2016
SuspensionUnknown Or Other
ON MY 2006 FORD RANGER 4X4, I HAVE HAD BOTH LEFT AND RIGHT REAR LEAF SPRING BRACKETS AND SHACKLES REPLACED, ALSO NOTICED THE FRAME AND UNDER CARRIAGE RUSTED, TRUCK BED RUSTING THROUGH.
NHTSA ODI #10902005
129,183 miles · Aug 14, 2016
Suspension
FRAME AND UNDERCARRIAGE SEEMS TO HAVE EXCESSIVE RUST, ESPECIALLY REAR AXLE SPRING HANGERS.
NHTSA ODI #10895823
Official recalls
12Apr 28, 2023
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that received replacement front passenger air bag inflators under a previous recall. The replacement front passenger air bag inflators may have been installed incorrectly.
Consequence & remedy
Consequence: An incorrectly installed inflator may not properly inflate the passenger air bag, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and reinstall the front passenger air bag inflator, as necessary, free of charge. Owner notification letters were mailed May 22, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S08. This recall expands and replaces previous recall number 23V-125.
Feb 24, 2023
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that received replacement front passenger air bag inflators under a previous recall. The replacement frontal passenger air bag inflators may have been installed incorrectly.
Consequence & remedy
Consequence: An incorrectly installed inflator may not properly inflate the passenger air bag, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and reinstall the front passenger air bag inflator, as necessary, free of charge. Owner notification letters were mailed April 5, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S08. This recall has been fully superseded by recall 23V-306.
Feb 17, 2021
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Additional source detail variants (3)
Air Bags:frontal:passenger Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal:driver Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal
Ford Motor Company (Ford) is recalling certain 2004-2006 Ranger vehicles that may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Feb 16, 2021
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Additional source detail variants (3)
Air Bags:frontal:passenger Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal:driver Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Jan 11, 2018
Ford Motor Company (Ford) is recalling certain 2006 Ford Ranger trucks. Ford is requesting owners NOT TO DRIVE these vehicles until they have been repaired. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to explode. On January 11, 2018, Ford Motor Company (Ford) notified NHTSA that they are recalling 2,700 model year 2006 Ranger vehicles built with passenger-side air bag inflators. As of February 9, 2018, Ford is expanding the recall to a total of 33,310 model year 2006 Ranger vehicles built with passenger-side air bag inflators. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could explode with sharp metal fragments striking the vehicle occupants, potentially resulting in serious injury or death.
Remedy: Ford will notify owners instructing them to not drive their vehicles, and dealers will replace the passenger side air bag inflator with an alternate inflator, free of charge. The recall for the original population began on January 16, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S02.
Jan 11, 2018
Ford Motor Company (Ford) is recalling certain 2006 Ford Ranger trucks. Ford is requesting owners NOT TO DRIVE these vehicles until they have been repaired. On January 11, 2018, Ford Motor Company (Ford) notified NHTSA that they are recalling 2,700 model year 2006 Ranger vehicles built with driver-side air bag inflators . As of February 9, 2018, Ford is expanding the recall to a total of 33,310 model year 2006 Ranger vehicles. Upon deployment of the driver side frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with sharp metal fragments striking the vehicle occupants, potentially resulting in serious injury or death.
Remedy: Ford will notify owners instructing them to not drive their vehicles, and dealers will replace the front driver side air bag inflator with an alternate inflator, free of charge. The recall for the original population began on January 16, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S02.
Dec 11, 2017
Ford Motor Company (Ford) is superseding a previous recall for certain 2004-2006 Ford Ranger trucks to implement a final repair. Upon deployment of the driver side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternate inflator, free of charge. The recall began January 16, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S42. Note: This recall supersedes recall 16V-036 which was an interim repair. Vehicles that received a replacement air bag inflator under the previous campaign need to return to a dealer to have an alternate inflator installed.
Dec 11, 2017
Ford Motor Company (Ford) is superseding a previous recall for certain 2004-2006 Ford Ranger trucks to implement a final repair. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants, potentially resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger's frontal air bag inflator with an alternate inflator, free of charge. The recall began January 16, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S42. Note: This recall supersedes recall 15V322 which was an interim repair. Vehicles that received a replacement air bag inflator under the previous campaign need to return to a dealer to have an alternate inflator installed. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S42.
Jan 25, 2016
Ford Motor Company (Ford) is recalling certain model year 2004-2006 Ranger vehicles manufactured March 24, 2003, to May 4, 2006. Upon deployment of the driver side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will replace the air bag inflators, free of charge. The recall began February 26, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S03. Note: This recall supersedes 14V-343 and only applies to Rangers manufactured in North America.
May 28, 2015
Ford Motor Company (Ford) is recalling certain model year 2004-2006 Ranger trucks manufactured March 24, 2003, to May 4, 2006. The affected vehicles are equipped with a passenger side frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began on December 4, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S22. Note: This recall partially supersedes recall 14V-787.
Jul 13, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence & remedy
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:brake Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Exterior Lighting:tail Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Nov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
Consequence & remedy
Consequence: AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration